2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints
3,738 reports, newest first.
Service brakes, Hydraulic, Aug 15, 2001
NOISY BRAKES- MY CAR HAS BEEN IN THE SHOP 3 TIMES. TWICE THE ROTORS AND PADS HAVE BEEN REPLACED BUT STILL NOISE BRAKES. DEALER ADVISED THAT THERE IS NO RESOLUTION FOR THIS PROBLEM AND THE CAR WAS CREATED IN EUROPE. SO WHY DID YOU PUT YOUR NAME ON IT AND WHY DIDN'T YOU DISCLOSE THE NOISY BRAKES TO ME AT TIME OF PURCHASE? IN GENERAL I AM NOT SATISFIED WITH MY CAR AND THE DEALERSHIP IS NOT WILLING TO TAKE IT AS A TRADE IN FOR ANOTHER VEHICLE.*AK
Power train, Aug 15, 2001
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
Vehicle speed control, Aug 14, 2001
99 V 346 000/CRUISE CONTROL: GOVERNOR ON CRUISE CONTROL WOULD NOT OPERATE WHEN SHIFTING INTO NEURAL FROM DRIVE, CAUSING UNEXPECTED ACCELERATION WHEN IT OCCURS. DEALER / MANUFACTURER WERE NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER.*AK
Suspension, Engine and engine cooling, Fuel system, Gasoline, Electrical system, Exterior lighting, Structure, Tires, Aug 14, 2001
WHILE CONSUMER WAS DRIVING GAS TANK COVER BLEW OFF THE TANK AND GAS WAS SPILLING EVERY WHERE.*AK CONSUMER STATES VEHICLE HAS EXPERIENCED PROBLEMS WITH THE SENDING UNIT AND GAS GAUGE. WHEEL BEARINGS ON THE LEFT REAR FAILED. TRANSMISSION FLUID LEAKS, CONSUMER STATES THIS IS CAUSING SLIPPAGE AND SHIFTING PROBLEMS. VEHICLE EXPERIENCES A BURNING OIL SMELL. WIRING HARNESS FAILURE. LIGHT FAILURE (CONSUMER DID NOT SPECIFY). GAS LEAKS. FAILED SUSPENSION PARTS (CONSUMER DID NOT SPECIFY). TIRES WEAR PREMATURELY (CONSUMER DID NOT GIVE TIRE INFORMATION). SPLASH SHIELDS BROKE. BROCKING WIRES IN CENTRAL LOCKING SYSTEM. *SLC
Seats, Aug 14, 2001
DRIVER'S SIDE SEAT CAN EASILY MOVE FORWARDS AND BACKWARDS, EVEN IF SEAT IS LOCKED IN PLACE OR NOT. HAS NOT CONTACTED DEALER.*AK
Tires, Aug 14, 2001
WHILE THE CONSUMER WAS TRAVELING THE LEFT REAR TIRE BLEW OUT AND THE VEHICLE SWERVED ALL OVER THE ROAD ALSO, THE RIGHT REAR TIRE WAS BADLY WORN OUT, CONSUMER WAS INFORMED THAT THE TIRES WORE OUT DUE TO A DEFAULT IN THE VEHICLE WHICH ALSO MEANT THAT BRAKES WERE NEEDED TO THIS DEFAULT.*YH
Tires, Aug 7, 2001
WHILE ENTERING FREEWAY AT ABOUT 45MPH FRONT DRIVER'S SIDE TIRE TREAD SEPARATED, CAUSING DAMAGE TO FENDER. TIRE DID NOT DEFLATE. FIRESTONE WANTS TO HAVE THE TIRE.*AK
Steering, Engine and engine cooling, Exterior lighting, Aug 6, 2001
WHILE DRIVING VEHICLE WOULD SHUT DOWN WITHOUT PRIOR WARNING. POWER WOULD COMPLETELY GO OUT, NO STEEERING OR HAZARD LIGHTS. CONSUMER WOULD TURN ENGINE OFF, AND START BACK UP. THIS HAS OCCURRED ON NUMEROUS OCCASIONS. DEALER WAS UNABLE TO DUPLICATE, SO WAS NOT ABLE TO PROVIDE REMEDY. *AK
Steering, Service brakes, Hydraulic, Aug 6, 2001
WHILE DRIVING UNDER NORMAL OPERATING CONDITIONS HEARD AN ABNORMAL NOISE COMING FROM VEHICLE WHILE BRAKING. DEALER EXAMINED VEHICLE AND DISCOVERED THAT LEFT FRONT BRAKE PAD WAS LOOSE. SINCE THAT TIME, CONSUMER HAS EXPERIENCED PROBLEMS WITH BRAKE PADS NEEDED TO BE REPLACED OR EXAMINED BECAUSE LEFT SIDE PAD SUPPORT KNUCKLE: SPINDLE ARM WAS BENT, AND CAUSING BRAKE PAD TO WEAR. DEALERSHIP WAS UNWILLING TO ASSIST IN REPAIRS OF BECAUSE VEHICLE WAS NO LONGER UNDER WARRANTY. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS. *AK
Engine and engine cooling, Fuel system, Gasoline, Aug 6, 2001
ENGINE STALLED FOUR TIMES DURING NORMAL OPERATION. DEALERSHIP EXAMINED VEHICLE AND REPLACED FUEL PUMP AND LINES. THEN IN MIDDLE OF JULY, WHILE TRAVELING AT APPROXIMATELY 40 MPH AND ENTERING HIGHWAY, VEHICLE STALLED AGAIN. DEALER STATED THAT PROBLEM WAS NO LONGER COVERED UNDER WARRANTY. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
Air bags, Aug 6, 2001
WHILE DRIVING AT APPROXIMATELY 5 MPH BOTH FRONTAL AIR BAGS DEPLOYED UNEXPECTEDLY. WINDSHIELD WAS SHATTERED WHEN THIS OCCURRED, AND PASSENGER LOST ALL HEARING FOR APPROXIMATELY 30 TO 45 SECONDS. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS/PHOTOGRAPHS. *AK
Service brakes, Hydraulic, Aug 6, 2001
BRAKES NEEDED TO BE COMPLETELY REPLACED AT 15K MILES DUE TO SQUEAKING PROBLEM. PER DEALER, BRAKES WERE COMPLETELY WORN DOWN AND COULD NOT BE REPAIRED.. *AK
Service brakes, Hydraulic, Aug 5, 2001
BRAKENOISE CONTINUES EVEN AFTER DEALER REPLACED REAR BRAKE SHOES. CONDITION PLACES DRIVER AT RISK AS IT IS HARD TO DETERMINE IF BRAKES ARE FAILING DUE TO WEAR.*AK
Service brakes, Hydraulic, Aug 2, 2001
FORD HAS REPLACED MASTER CYLINDER TWICE AND ALL ROTORS AND PADS. STILL NO BRAKES WHEN FIRST USED AFTER SETTING. *AK
Electrical system, Aug 1, 2001
07/11/01 10 MONTH OLD CAR WOULD NOT START. HAD BEEN PARKED FOR 5 1/2 HOURS. HAD VEHICLE TOWED TO DEALERSHIP. THEY INFORMED US THAT THE MAIN WIRING HARNESS(SAID CONSISTED OF 12 WIRES) APPEARED TO HAVE BEEN EATEN BY AN ANIMAL. THAT THE REPAIR, NOT REPLACEMENT, WOULD BE $325. NOT COVERED UNDER WARRENTY. (IT SAYS NOTHING IN OUR WARRENTY ABOUT THIS NOT BEING COVERED), WE OKAYED THE REPAIRS. ON 07/13/01 I CONTACTED THE DEALERSHIP THEY INFORMED ME THAT THEY HAD FIXED THE WIRES AND THE CAR STILL WOULD NOT START. HE TOLD US THAT HE JUMPED IT AND HOOKED IT UP TO THE DIAGNOSTIC CENTER AND IT GAVE HIM A CODE 13, BUT HE DIDNT KNOW WHAT THAT MEANT OR WHY THE CAR WOULNT START. ON 07/17/01 WE WERE TOLD THAT THE COMPUTER WAS DEAD, IT WOULD BE AN ADDITIONAL $950 NOT COVERED.ON 07/20/01 THE MANG. OF DAYTON CALLED ME AND SAID " GET YOUR CAR OFF OUR LOT, RETURN OUR LOANER OR WE WILL REPORT IT STOLEN". WHEN WE GOT THERE ARE CAR WAS NOT PUT BACK TOGETHER, THEY HAD WRITTEN THE WORD "F*CKER" ON THE CARS COMPUTER, AND GAVE US THE. *AK
Steering, Electrical system, Aug 1, 2001
THE STEERING WHEEL AND IGNITION SWITCH LOCKED UP, ON ANOTHER OCCASION THE STEERING WHEEL LOCKED UP IN THE RIGHT POSITION WHILE THE DRIVR WAS BACKING INTO A DRIVEWAY, THE REAR WHEEL BEARINGS HAD TO BE REPLACED DUE TO ROAD NOISE, THE IGNITION SWITCH CAME OUT OF THE STEERING COLUMN WHEN THE DRIVERS ATTEMPTED TO REMOVE THE KEY FROM THE IGNITION. NLM
Latches/locks/linkages, Jul 26, 2001
LEFT REAR DOOR WOULD NOT OPEN. DEALER FIXED AND 5 MONTHS LATER IT WOULD NOT OPEN AGAIN. *AK
Steering, Service brakes, Hydraulic, Jul 25, 2001
ENGINE JUST STALLS EVERY 3 MONTHS WHILE DRIVING. HAVE HAD THE SAME PROBLEM HAPPEN 4 TIMES! THE LAST TIME I WASNT UNDER WARRANTY AND IT COST ME 500+...THEY REPLACED MANY THINGS BUT IT STILL CONTINUES. ALSO AFTER ONLY 23000 MILES MY LEFT CALIPER SLIPPED CAUSING EXTREME WEAR AND TEAR ON THE BRAKES AND ROTORS. COST 300 TO FIX THAT. *AK
Service brakes, Hydraulic, Jul 25, 2001
THE FRONT DISK BRAKES WERE WORN OUT TO THE ROTORS AFTER ONLY 25,000 MILES BECAUSE THEY OVER HEAT AND THE PADS WEAROUT QUICKLY. THE VEHICLE WAS DRIVEN ON EXPRESSWAY 80% OF THE TIME. THE FRONT WHEELS BECOME EXTREMELY DIRTY DUE TO QUICKLY WEARING OUT BRAKE PADS. WHEN THIS WAS BROUGHT TO THE NOTICE OF THE DEALER ABOUT 8 MONTHS BACK HE SAID THE DIRT IS DUE TO THE WHEEL DESIGN, BUT THE REAR WHEELS DO NOT GET DIRTY SINCE THEY DO NOT OVERHEAT AND WEAR OUT AS QUICKLY. THE MANUFACTURER AND THE DEALER SAY IT IS NORMAL TO WEAROUT FRONT BREAKS ANY TIME AFTER 9,000 MILES AND REFUSED TO PAY FOR REPAIRS. THIS IS ABNORMAL, MY BRAKES ALWAYS LAST OVER 55,000 MILES.*AK
Service brakes, Hydraulic, Jul 23, 2001
I ASKED FORD TO LOOK AT MY BRAKES AT 12, 541 MILES BECAUSE THEY WERE SQUEALING. I WAS TOLD THAT THE NOISE WAS NORMAL, SO NO ACTION WAS TAKEN. NOW, AT 24, 643 MILES, MY BRAKE PADS AND ROTORS ARE COMPLETELY WORN, AND FORD WILL NOT TAKE ANY ACTION TO REMEDY THIS SITUATION. *AK
Tires, Jul 23, 2001
NOTIFIED THE DEALER OF THE PROBLEM . THE FIRST PERSON NAMED TOM SAID THAT I HIT A CURB THE PERSON AT THE NEXT DEALER LOCATION SAID HE WOULD REPLACE THE TIRE AND THAT SOMETHING WAS PROBABLY WRONG INSIDE . THE SIDEWALL HAD A LARGE BUBBLE AND APPEAR AND IT GREW FROM THE THREAD TO THE RIM AT THE TIME THER WAS ONLY 9500 MILES ON THE TRUCK . THIS TRUCK IS DRIVEN BY VERY FEW PEOPLE . MY ESTIMATE OF MILEAGE PUT ON FROM OTHERS DRIVING THIS TRUCK IS AROUND 500 MILES THE REST ARE MINE. I DON'T FEEL THAT I SHOULD HAVE BEEN CHARGED FOR A TIRE THAT HAS 90% MORE WEAR LEFT . THERE IS A PROBLEM WITH WITH THE TIRE AND EVEN THOUGH THEY WORKED WITH ME A PROBLEM DOES EXIST AND THIS SHOULD BE LOOKED INTO . PLEASE CALL ME AND LET ME KNOW IF THERE IS ANYTHING ELSE I CAN HELP WITH. THANK YOU. *AK (DOT NUMBER: 038059 TIRESIZE: 22570R15)
Vehicle speed control, Jul 22, 2001
THE THROTTLE CABLE RUNS OVER THE DISTRIBUTOR WIRE'S AND THE THROTTLE CABLE IS WORN THROUGH THE RUBBER DOWN TO EXPOSE THE THROTTLE CABLE WIRES AS WELL AS ONE OF THE DISTRIBUTOR WIRES. FORD SENT A RECALL FOR 2.0L ENGINES WITH A 5-SPEED MANUAL TRANSAXLES, FORD PROGRAM # 00B59 AFTER THAT REPAIR MY CRUISE CONTROL NO LONGER WORKED BECAUSE AS SOON AS THE KEY WAS PUT IN THE IGNITION AND TURNED FORWARD WITH OR WITHOUT TURNING OVER THE ENGINE THE BRAKE LIGHTS COME ON AND REMAIN ON AT ALL TIMES AND AT ALL SPEEDS UNTIL YOU TURN THE IGNITION COMPLETELY OFF. A THIRD PROBLEM ALSO DEALS WITH A RECALL FMVVSS 201. THE NEW A-PILLAR TRIM PANELS THEY REPLACED IN MY CAR DO NOT FIT. FORD MODIFIED THE PILLARS TO MAKE THEM FIT IN PLACE. YOU CAN SEE THE METAL FROM THE OUTSIDE OF THE CAR FROM THE INSIDEOF THE CAR. FORD HAD TO CUT PART OF THE PILLARS TO MAKE THEM FIT AND THEY CONSTANTLY DO NOT STAY IN PLACE OVER THE PASSENGER SIDE DOOR. THE NEW A-PILLARS DO NOT FIT PROPERLY AND FORD MODIFIED THE RECALL PARTS TO FIT THEM INTO PLACE. THEY EVEN CRACKED MY WINDSHIELD ON THE PASSENGER SIDE TRYING TO FIT THEM INTO PLACE.*AK
Tires, Jul 18, 2001
DRIVERS SIDE BACK TIRE BLEW OUT FRO NO APPARENT REASON, TRIED TO GET OFF THE ROAD, TO NO AVAIL DUE TO SPEED. ONCE REACHED 10MPH WAS ABLE TO GET OFF THE FREEWAY SAFELY.
Electrical system, Jul 18, 2001
FAULTY IGNITION SWITCH CAUSED THE KEY TO NOT INSERT OR ONCE INSERT THE KEY COULD NOT BE REMOVED FROM THE IGNITION, THIS PROBLEM ALSO CAUSED THE VEHICLE TO STALL. NLM
Structure, Interior lighting, Jul 16, 2001
DRIVER'S DOOR SENSOR WOULD INDICATE THAT THE DOOR WOULD BE AJAR WHEN ITS NOT. THIS CAUSES INTERIOR LIGHTS TO STAY ON. ITS AN INTERMITTENT PROBLEM. OWNER DISABLED MECHANISM FOR INTERIOR LIGHTS. TOOK VEHICLE TO DEALERSHIP, INFORMED BY MECHANIC THAT PROBLEM COULD NOT BE LOCATED.*AK