2001 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,790 owner complaints filed for this model year. This is the 5th highest complaint count among 19 Focus model years with reports.
Of the 2001 reports, 173 involved a crash and 49 involved a fire. 136 people were injured and 8 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerMar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V108000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Representative owner complaints
1,790 reports, newest first.
Power train, Dec 13, 2016
THE CAR JERKS WHEN I PUT IT INTO REVERSE. THE CARS STALLS WHEN I PUT IT INTO DRIVE. I HAVE TO TAKE OFF IN 2ND GEAR. THEN I CAN PUT IT INTO DRIVE AND IT TAKES OFF JUST FINE.
Structure, Fuel/propulsion system, Dec 1, 2016
CAR WILL NOT IDLE WHEN STOPPED AT A LIGHT IN THE CITY, WHEN SHIFTING INTO DRIVE FROM PARK, RUNS ROUGH AT LOW SPEEDS WHILE IN TRAFFIC AND GOING THOUGH PARKING LOTS. STARTED ONE MORNING, RAN HORRIBLY, STALLED AND HASN'T STARTED SINCE. THE BACK DOOR DOESN'T STAY LATCHED WHEN SHUT.
Electrical system, Nov 10, 2016
IGNITION KEY GETS STUCK AND WILL NOT TURN. FORD HAS KNOWN OF THIS PROBLEM SHOULD HAVE TO PAY FOR REPAIRS AND REIMBURSEMENT.
Other or unspecified, Jul 12, 2016
I BOUGHT THE CAR DROVE IT OFF THE LOT ABOUT 3 HOURS I HAD TO GET IT TOWED. THE DEALER GOT IT BACK FOR 6 MONTHS AN FINALLY I GOT IT BACK. NOW IT IS DOING THE SAME THING. BATTERY CABLES HAVE DAMAGE. CRANKS BUT WON'T START.
Air bags, Seats, May 17, 2016
THE FRONT PASSENGER SIDE AIRBAG MALFUNCTIONED IN THAT IT DEPLOYED WITHOUT REASON. I WAS DRIVING (IN MOTION) STRAIGHT DOWN A CITY ROAD. IT MADE AN EXTREMELY LOUD NOISE THAT AFFECTED MY HEARING, EXPELLED A LOT OF WHITE POWDER THAT SMELLED BAD, AND TORE UP THE SIDE OF THE PASSENGER SEAT. THE AIRBAG WARNING LIGHT WENT ON.
Engine, Apr 12, 2016
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING BELT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 105,000.
Fuel/propulsion system, Mar 8, 2016
HAD GOOD TUNE UP,CAR WAS DOING GOOD AND NOW JUST AS I HAVE READ PROBLEMS WITH THE FUEL SYSTEM,IS EXACTLY WHAT HAPPENED OUT OF NOWHERE STARTS GIVING ME ISSUES STARTING AND STAYING RUNNING.AFTER TESTING I HAVE 90%OF FUEL PRESSURE WHICH SHOULD ONLY BE 40-45 MAX????WAS CHECKED IN SHOP OVER A WEEK AND LOOKING THROUGH RECALLS I BELIEVE IT IS A DEFECT IN THE FUEL SYSTEM THE FUEL IS GOING SOMEWHERE BUT NOT ALLOWING CAR TO RUN.TO TAKE OFF THERE IS NO TAKING OFF ,LIKE THE OEDAL DOES NOTHING JUST FOR LOOKS.WOULD LIKE TO HEAR BACK.
Fuel/propulsion system, Feb 25, 2016
AS DESCRIBED IN NHTSA ACTION NUMBER EA02022, CAR STALLS AT BELOW 1/4 TANK, PARTICULARLY ON RIGHT HAND TURNS.
Suspension, Feb 4, 2016
2001 FORD FOCUS WITH 146K MILES. ADULT DRIVEN ONE OWNER AND WELL CARED SINCE NEW. NOTICED CLUNKING SOUND SO TOOK IT IN FOR BRAKES TO THE FORD DEALER. WAS TOLD BY DEALER THEY CAN'T FIX AS ENTIRE SUBFRAME IS ROTTED AND "I WAS ONE POTHOLE FROM THE ENGINE FALLING OUT". IT APPEARS THAT DEALERS USE THIS LINE AS I FOUND OTHER COMPLAINTS WITH THE EXACT SAME WORDING. HOW CAN YOU RECALL THE ESCAPE AND WINDSTAR FOR THE SAME PROBLEM AND NOT THE FOCUS? BECAUSE FOCUS OWNERS DON'T HAVE THE SAME MONEY THAT THOSE OTHER HIGHER END CARS HAVE? I WAS DRIVING MY NEW BABY AROUND IN THIS CAR AND THANK GOD I DIDN'T HIT THAT ONE MORE POTHOLE OR BOTH OUR LIVES COULD HAVE BEEN ENDED! ALL IT TAKES IS AN INTERNET SEARCH TO REALIZE THAT THIS IS A COMMON PROBLEM. THE SUBFRAME IS A VERY IMPORTANT COMPONENT TO A CAR THAT SHOULD NOT JUST RUST AWAY IN 14 YEARS! CLEARLY THE DESIGN OR MATERIALS USED WERE AT FAULT FOR THIS. FORD NEEDS TO RECALL THESE CARS BEFORE MORE PEOPLE ARE KILLED OR INJURED!
Air bags, Structure, Jan 27, 2016, crash
TAKATA AIRBAG DEPLOYED AFTER THE CAR HAD COME TO A STOP. ALI STOPPED TO AVOID HITTING A CAR THAT HAD SUDDENLY BRAKED IN FRONT OF HER. THERE WAS NO DAMAGE TO THE CAR IN FRONT HER AS ALI WAS ABLE TO STOP IN TIME, BUT THERE WAS MAJOR DAMAGE TO HER CAR. WHEN THE TAKATA AIRBAG DEPLOYED IT BURNT HER LEFT FOREARM/HAND AND INCURRED $107.00 IN MEDICAL EXPENSES. CALIBER COLLISION SAYS THAT TO REPAIR THE CAR IT WOULD COST ALI $7,639.37.
Steering, Suspension, Dec 15, 2015
TL* THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING, THE VEHICLE PULLED TO THE RIGHT INDEPENDENTLY AND THE CONTACT LOST CONTROL OF THE STEERING WHEEL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE LOWER CONTROL ARM, BALL JOINT ASSEMBLY, AND AXLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT DID NOT KNOW IF THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 02V289000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 165,611.
Air bags, Structure, Engine, Sep 30, 2015, crash
DRIVING FORD FOCUS SLOWLY IN SNOW,A JEEP SPUN OUT OF CONTROL HIT THE DRIVERS SIDE FRONT OF CAR SPUN AROUND AND HIT US AGAIN FROM THE REAR.AIRBAG DEPLOYED AND IT MY PASSENGER FULL IN FACE. DAMAGED HER FACE WITH CHEMICAL BURNS AND CREATED A COROIDITAL TEAR IN HER EYE THAT IS PERMANENT AND PERMANENT VISION LOSS IN ONE EYE. THE IMPACT OF THE AIRBAG JARRED HER BRAIN AND SHE NOW HAS A BRAIN INJURY CALLED CHIARI MALFORMATION,
Air bags, Sep 21, 2015, crash
ON 5/2/15 DURING A COLLISION WHERE MY CLIENT STUCK ANOTHER DRIVER THAT FAILED TO YIELD AND RAN A STOP SIGN, THE AIRBAG INSIDE MY CLIENT'S 2001 FORD FOCUS DEPLOYED. DURING ITS DEPLOYMENT IT BURNED THE RIGHT VOLAR (INSIDE) FOREARM OF MY CLIENT, CAUSING A FULL THICKNESS BURN. SHE HAD TO UNDERGO SURGICAL TANGENTIAL EXCISION OF THE BURN AND SKIN GRAFTING, WHERE THEY HARVESTED THE SKIN FROM HER RIGHT THIGH TO HER RIGHT VOLAR FOREARM. THE AIRBAG IS DANGEROUS AS IT CAUSED FULL THICKNESS BURN TO HER SKIN, FOR WHICH SHE IS STILL RECOVERING.
Engine, Sep 16, 2015
AFTER A 2~ HOUR DRIVE, ENGINE WAS TURNED OFF AND RESTARTED 5MIN LATER. AN INTAKE VALVE SEAT DROPPED AND IT INSTANTLY SMACKED THE PISTON ON THE FIRST TURN OF THE ENGINE, IT HIT HARD ENUF TO BLOW THE PISTON APART AND THE CONNECTING ROD PUT A HOLE THRU THE PISTON LINER. PUTTING COOLANT IN TO THE CRANK CASE, AS IT WAS NO LONGER CONNECTED TO THE PISTON ANY MORE. NEEDLESS TO SAY IT WAS NOT ABLE TO DRIVE. I REPAIRED THE AUTO WITH A AFTERMARKET HEAD FROM HTTP://CIFICINC.NET/ AND A SHORT BLOCK OUT OF A PARTS CAR. AFTER DOING SOME RESEARCH IM NOT THE ONLY PERSON TO HAVE THIS FAILURE, THERE ARE FOCUS ALL OVER THE NET THAT HAVE HAD THIS FAILURE. I SEEM TO BE LUCKY AS ITS MUCH MORE COMMON FOR IT TO HAPPEN AROUND 110/140K THEN 206K THE ESCORT ALSO HAS THE SAME ENGINE OR ONE OF THE SAME SPI SOHC 1.9/2.0 ENGINE FAMILY AND CAN ALSO HAVE THIS FAILURE. . . I REPAIRED THE AUTO ONLY BECAUSE OF ITS ABOVE AVERAGE MPG, HAD IT NOT GOTTEN HIGH 30S OR BETTER, I WOULD HAVE GOTTEN RID OF IT. AS THE VALUE OF THE AUTO IS AROUND 1,400~ AND THE REPAIR WAS ABOUT HALF THAT, DOING ALL THE WORK MY SELF...TAKING IT TO A SHOP WAS OUT OF THE QUESTION AS THE COST TO REPAIR WOULD HAVE BEEN 2X THE VALUE OF THE AUTO OR WORSE....
Other or unspecified, Sep 5, 2015
MY CAR WILL LOSE SPEED GOING UP HILLS AND START TO ACT LIKE IT'S RUNNING OUT OF GAS. I HAVE HAD IT GO DEAD WHILE GOING DOWN THE ROAD AND THE STEERING BECOME HARD TO MOVE. IT SURGES GOING AT VERY LOW SPEEDS OF ABOUT 10-15 MPH AND JERKS. SOMETIMES THE EVEN GOING ON STRAIGHT ROADS WHERE THERE ARE NO HILLS THE CAR STARTS TO ACT LIKE IT'S RUNNING OUT OF GAS AND DIE. THE ONLY THING THAT SHOWED WHEN I HAD IT CHECKED WAS THE THROTTLE BODY POSITION SENSOR WHICH I REPLACED AND NOW SAYS OUT OF RANGE AND NO ONE KNOWS WHY.
Vehicle speed control, Fuel/propulsion system, Aug 12, 2015
WHEN VEHICLE HAS IDELED OR TRAVELED AT SLOW SPEEDS FOR A LONG PERIOD, THE VEHICLE WILL NOT ACCELERATE. IT WILL ALSO STALL HAS LOST FUEL EFFICIENCY AND DRIVER CAN SMELL FUEL. MECHANIC STATES THE FUEL RAIL PRESSOR SENSOR IS LEAKING. MECHANIC STATES PART IS ON NATIONAL BACK ORDER. ONE CAN ONLY ASSUME THAT BACK ORDER IS CAUSED BY SAME OR SIMILLAR MALFUNCTION.
Engine, Jul 31, 2015
TL* THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY STOP ACCELERATING AND RESPONDING WHEN DEPRESSING THE ACCELERATOR PEDAL.THE SPEED OF THE VEHICLE WOULD NOT INCREASE PAST 30 MPH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE SPARK PLUGS, BUT THE FAILURE CONTINUED TO OCCUR. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.
Fuel/propulsion system, Jul 20, 2015
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE STALLED SPORADICALLY AT VARIOUS SPEEDS. THE FAILURE OCCURRED WHEN MAKING A RIGHT TURN OR WHEN LOW ON FUEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP FAILED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.
Engine, May 29, 2015, fire
TL* THE CONTACT OWNED A 2001 FORD FOCUS. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE CAUGHT FIRE. THE VEHICLE WAS DESTROYED AND TOWED TO THE SALVAGE YARD. THE CAUSE OF THE FAILURE WAS UNKNOWN. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.
Electrical system, Engine, May 14, 2015, fire
TL* THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE STARTED TO JERK AND THE CONTACT SMELLED SMOKE. THE BATTERY WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE WAS STOPPED ON THE SIDE OF THE ROAD AND THE IGNITION WAS TURNED TO THE OFF POSITION AS THE CONTACT EXITED THE VEHICLE. THE CONTACT OBSERVED FLAMES UNDER THE HOOD OF THE VEHICLE. THE VEHICLE RESTARTED WITHOUT BEING PROMPTED AND STARTED ROLLING FORWARD. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO A TOW YARD WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 02V288000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.
Steering, Wheels, Service brakes, Apr 25, 2015
AS I WAS COMING FROM DR'S APPT. WITH DAUGHTER AND MOM A ROARING SOUND STARTED IN THE REAR. IT KEPT GETTING LOUDER AND LOUDER, CAR'S REAR WOULD SWAY TO THE RIGHT SIDE A LITTLE. BUT AS I WAS DRIVING DOWN THE STREET TRYING TO AT LEAST GET US ALL HOME SAFE. THE REAR DRIVER SIDE WHEEL CAME OFF AND JUST ROLLED DOWN THE STREET ABOUT A HALF-A-BLOCK. A MAN CAME OUT NOTICING THE TIRE ROLL PASS HIM, HELPED ME RETRIEVE IT AND GET IT BACK TO MY CAR. LOOKED AT THE WHEEL AND CAR AXLE I GUESS THAT'S WHAT YOU CALL IT, AND TOLD ME MY WHEEL BEARINGS WERE GONE. *TR
Structure, Apr 10, 2015
WHILE DRIVING A 2001 FORD FOCUS SE AND NAVIGATING A CURVE, THE REAR DRIVERS SIDE DOOR FAILED TO REMAIN SECURE AND SUDDENLY OPENED WHILE VEHICLE WAS IN MOTION. UPON ATTEMPTING TO CLOSE THE DOOR, IT APPEARS THE DOOR LATCH DOES NOT ENGAGE AND THE DOOR CANNOT BE CLOSED SECURE. UPON FURTHER INSPECTION, THERE IS SIGNIFICANT CORROSION AROUND THE LATCH MECHANISM. THE DOOR MUST BE MANUALLY RESTRAINED WITH ROPES TO REMAIN CLOSED. *TR
Electrical system, Engine, Apr 3, 2015
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000.
Suspension, Feb 6, 2015
RIGHT FRONT COIL SPRING BROKE AS I WAS DRIVING TO THE MECHANIC TO HAVE A BALL JOINT ON MY LEFT FRONT TIRE REPLACED. HEARD A CLANGING NOISE WHILE DRIVING. I THOUGHT IT WAS FROM THE BAD BALL JOINT, WHEN MECHANIC CHECKED HE SAID THE COIL SPRING HAD SNAPPED. CALLED FORD ABOUT SAFETY RECALL WHICH CAME UP WHEN I PUT MY VIN NUMBER INTO THEIR WEBSITE. I WAS INFORMED THAT THE WARRANTY PERIOD WAS OVER AND MY CAR WAS NOT COVERED. IT COST ME 600.00 TO HAVE BOTH REPAIRS DONE BY A MECHANIC. I FILED A COMPLAINT WITH FORD WHILE ON THE PHONE WITH THEM AND THEIR ADVICE WAS TO SAVE MY RECEIPT AND IF A RECALL GOES INTO EFFECT FOR THIS PROBLEM, I WILL GET REIMBURSED. I HAVE SEEN HUNDREDS OF COMPLAINTS ABOUT THIS PROBLEM, YET FORD JUST IGNORES THE ISSUE AS IT IS STILL HAPPENING. NOW TODAY MY BACK WINDOW MADE A NOISE AND THE WINDOW FELL DOWN AND WON'T GO BACK UP. I'VE ALREADY HAD A NEW BATTERY, ALTERNATOR, PLUGS AND COIL PACK REPLACED BECAUSE OF SURGING AND STALLING. I AM ALSO GETTING POOR GAS MILEAGE. I WAS TOLD BY FORD THAT THERE ARE NO OPEN RECALLS ON MY CAR YET I HAVE AND AM HAVING THE SAME PROBLEMS THAT MANY OF THE RECALLS IN EFFECT ARE LISTING. VERY POOR CUSTOMER SERVICE BY FORD. *JS
Service brakes, Jan 9, 2015
BRAKES REPLACED AT 48,763 MILES WE ARE NOW AT 77,000. FOR THE LAST 2-3,000 MILES IF FEELS LIKE AIR IN THE LINE WHEN YOU STEP ON THE BRAKE PEDDLE IT DOES NOT IMMEDIATELY ENGAGE, THERE IS A GAP BEFORE THE BRAKES ENGAGE & THE GAP IS GROWING A POTENTIAL SAFETY ISSUE. THERE IS NO NOISE ASSOCIATED WITH THE BRAKE ACTIONS. *TR