2001 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,790 owner complaints filed for this model year. This is the 5th highest complaint count among 19 Focus model years with reports.
Of the 2001 reports, 173 involved a crash and 49 involved a fire. 136 people were injured and 8 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerMar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V108000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Representative owner complaints
1,790 reports, newest first.
Electrical system, Seats, Electronic stability control (ESC), Dec 16, 2014
IT START WITH DOOR BUSTING ALL THE TIME ,THEN I SWITCH IT OFF ..NOW IT WANT CRANK ,JUST BUST. *TR
Suspension, Oct 27, 2014
CHECKED YOUR SITE FOR RECALLS. FOUND FIELD SERVICE ACTION NUMBER:03M02 RE: COIL SPRINGS. PREVIOUSLY CHECKED FOR RECALLS TWO YEAR AGO. THIS NOTICE WAS NOT ON YOUR SITE THEN. AS THE ORIGINAL OWNER, I HAVE MADE IT A POINT TO KEEP ABREAST OF ALL RECALLS. I WAS NEVER NOTIFIED OF THIS NOTICE BY FORD. USED THE SAME DEALER FOR REPAIRS FOR THE LAST 5 YEARS. CALLED FORD TODAY. FORD SAID THE DEALER HAD A COPY OF THIS NOTICE. NEVER INFORMED OF THIS BY THE DEALER (AUTO NATION, BELLEVUE DEALERSHIP). YOUR SITE POSTING OF THE NOTICE SAID IT EXPIRED AFTER 10 YEAR OR 150,000 MILES. FORD SAID I WAS OUT OF LUCK AS "WHAT EVER CAME FIRST, YEARS OR MILEAGE". I SUSPECT THAT FORD NEVER NOTIFIED NHTSA OF THIS PROBLEM & I ALSO SUSPECT FORD IS DOING A CYA. *TR
Engine, Fuel/propulsion system, Oct 17, 2014
1.ENGINE FADES OR LOSES POWER RAPIDLY DURING EXECUTION OF FREEWAY- SPEED TURNS (OFF RAMPS FOR EXAMPLE) WITHOUT BRAKING; I HAVE GONE FROM 50 TO 20 MPH WITHIN 1-2 SECONDS WHILE IN FRONT OF ANOTHER VEHICLE AND SEMI (VERY DANGEROUS). THE VEHICLE WAS TUNED AND TYPICAL PARTS REPLACED FOR SMOG CHECK A FEW MONTHS AGO AND PASSED SMOG CHECK WITHOUT COMMENTS. THIS PROBLEM STARTED AROUND 100K AND HAS HAPPENED TO OTHER DRIVERS WHO BORROW MY CAR. THE FORD DEALERSHIP (SERRAMONTE FORD) WAS UNABLE TO RECREATE THE PROBLEM SO I PAID 150 DOLLARS FOR A CAN OF FUEL ADDITIVE AND LOST USE OF THE CAR FOR 8 HOUR EVEN THOUGH I WAS ASKED TO DROP IT OFF START OF MORNING. 2. NOW IT STUTTERS OR HESITATES DURING HIGH ACCELERATION (IE PASSING LANE OR GOING UPHILL) ON HIGHWAY; THE VEHICLE IS NO LONGER RELIABLE ESP. IF YOU SHOULD NEED TO RAPIDLY INCREASE POWER. I HAVE READ OF POSSIBLE CONNECTION RELATED TO EITHER A FUEL PUMP OR DEBRIS FROM THE FUEL TANK INNER COATING/MATERIAL COMPOSITION DEGRADING OVER TIME. *TR
Latches/locks/linkages, Sep 9, 2014
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE REAR PASSENGER DOOR LATCH FAILED TO LATCH AND REMAINED OPENED. THE DOOR WAS FORCED CLOSED BY THE USE OF ROPES AND A SEAT BELT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR DOOR LATCH NEEDED TO BE REPLACED. THE TECHNICIAN INFORMED THE CONTACT OF NHTSA CAMPAIGN NUMBER: 05V030000 (LATCHES/LOCKS/LINKAGES); HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 108,900.
Engine, Aug 16, 2014
I WAS DRIVING ON INTERSTATE 5 IN PORTLAND OR. MY ENGINE JUST STOPPED!! RIGHT IN THE MIDDLE LANE OF TRAFFIC. LUCKILY IT WAS EARLY RUSH HOUR SO IT WAS STOP AND GO TRAFFIC. BUT, WAS VERY SCARY AND DIFFICULT TO GET MY CAR OFF THE FREEWAY. I WAS TOLD THAT 2001 FORD FOCUS'S HAVE A FUEL LINE PROBLEM THAT HAS BEEN RECALLED. I PURCHASED THIS CAR IN 2008. THERE WAS ONLY 1 PREVIOUS OWNER. THIS RECALL WAS NOT REPAIRED ON THIS CAR. PLEASE HELP. THANKS *TR
Engine, Aug 8, 2014
AS I WAS DRIVING HOME AFTER DROPPING MY DAUGHTER OFF THE CAR JUST STOPPED. I LET IT ROLL TO A COMPLETE STOP AND THEN PUT IT IN PARK. I TRIED TO CRANK THE CAR AND I GOT NOTHING. ALL THE LIGHTS, HORN, AND ALL STILL WORKS BY THE ENGINE DOES NOTHING. *TR
Electrical system, Aug 6, 2014
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE WARNING INDICATORS DID NOT ILLUMINATE ON THE DASHBOARD. THE FAILURE OCCURRED NUMEROUS OF TIMES. THE VEHICLE WAS TAKEN TO THE DEALER AND RECOMMENDED THE REPLACEMENT OF THE FAULTY WIRING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE MILEAGE WAS 162,600.
Fuel system, Gasoline, Jul 31, 2014
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE STALLED AT TEMPERATURES ABOVE 85 DEGREES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE TECHNICIAN REPLACED THE FUEL PUMP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 108,182. UPATED 9/4/14*CN UPDATED 1/8/2015 *JS
Electrical system, Jul 10, 2014
KEY DOES NOT TURN PROPERLY IN IGNITION CYLINDER AND DOOR LOCKS. *TR
Structure, Jul 10, 2014
UNDER NORMAL USE THE EXTERIOR DOOR HANDLES ON THREE OF THE FOUR CAR DOORS BROKE. WITHIN A WEEK'S TIME ALL THREE BROKE AND THE ONLY WAY TO OPEN THE DOORS WAS TO REACH THROUGH AN OPEN WINDOW AND PULL THE INTERIOR HANDLE. AT MY EXPENSE THE FORD SERVICE DEPT. REPLACED THE BROKE HANDLES, HOWEVER THE RIGHT REAR PART COULDN'T BE LOCATED TO REPAIR IT. THIS SHOULD HAVE BEEN A SAFETY RECALL. SHOULD THEIR HAVE BEEN AN ACCIDENT PRIOR TO MY REPLACING THE HANDLES, SOMEONE TRYING TO HELP A PERSON STUCK INSIDE WOULDN'T HAVE BEEN ABLE TO GET THE PASSENGER OUT OF THE VEHICLE. WHEN I LOOKED ONLINE TO READ ABOUT THESE HANDLES I FOUND THAT THIS WAS A BAD DESIGN YEAR FOR DOOR HANDLES AND AFTER ABOUT 3 YEARS IT WAS THEN REDESIGNED. WHY NOT A RECALL THEN? *TR
Fuel/propulsion system, Jul 7, 2014
SLOW ACCELERATION, LOSS OF POWER, SURGING, HESITATION, STALLING. *JS
Steering, Service brakes, Engine, Jun 30, 2014, fire
WAS DRIVING MY CAR AT 55 MPH AT 11:20 PM ON WAY HOME FROM WORK CAR MADE JERK LOST ALL POWER NO BRAKES NO STEERING BLACK SMOKE COMING THROUGH VENTS TO INSIDE OF CAR AND FLAMES COMING FROM UNDER HOOD CAR FULLY ENGULFED IN FLAMES BLEW UP. *TR
Suspension, Apr 15, 2014
RIGHT FRONT COIL SPRING BROKE WHILE DRIVING ON THE ROAD. THE BROKEN SPRING PENETRATED THE RIGHT FRONT TIRE AND IMMEDIATELY DISABLED THE VEHICLE. IT HAS BEEN DOCUMENTED THAT THIS IS A COMMON PROBLEM FOR THIS VEHICLE, AND IT WAS DETERMINED THAT THE SPRINGS WERE MANUFACTURED IMPROPERLY AND DO NOT RESIST CORROSION. FORD HAS RECOGNIZED THE PROBELM THROUGH SEVERAL TSBS AND EVEN HAD A CUSTOMER SATISFACTION PROGRAM 03M02 WITH AT LEAST 2 SUPPLEMENTS CONCERNING THE ISSUE AND REPLACEMENT OF THE FAULTY PARTS. I SPOKE WITH A LOCAL FORD DEALER (HONDRU) AND THEY TOLD ME THE PROGRAM EXPIRED AND THE CAR IS NO LONGER COVERED. I THEN SPOKE WITH A FORD REPRESENTATIVE THROUGH DIRECT CUSTOMER SERVICE AND THEY CONFIRMED THIS WAS THE CASE. THEY CONFIRMED THE CONVERSATION WITH NUMBER CAS4271469-Z6W0F2. THE REPRESENTATIVE'S NAME WAS KENDRA. I AM DEEPLY CONCERNED ABOUT THIS BECAUSE IT IS A SIGNIFICANT SAFETY RISK TO ME AN MY FAMILY. THE COIL SPRING IS A SIGNIFICANT COMPONENT OF THE SUSPENSION, AND WHEN IT BRAKES THE DRIVER'S ABILITY TO CONTROL THE CAR IS EXTREMELY COMPROMISED. TO MAKE THINGS WORSE, THE BROKEN SPRING DESTROYS THE TIRE IMMEDIATELY, FURTHER REDUCING THE ABILITY TO CONTROL THE CAR. SINCE IT WAS DOCUMENTED THAT THERE WAS A FAULT IN THE MANUFACTURING PROCESS, AND FORD AND NHTSA KNEW ABOUT THE PROBLEM, THESE PARTS SHOULD HAVE BEEN REPLACED UNDER A RECALL DUE TO THE SAFETY CONCERNS. *TT
Electrical system, Exterior lighting, Latches/locks/linkages, Service brakes, Apr 14, 2014
BOUGHT VEHICLE 2ND HAND, CASH, EVERYTHING WORKED FINE. NOW, I HAVE NO BRAKE LIGHTS, & MY DOOR LOCKS NO LONGER WORK ON THE REMOTE, OR THE "ALL LOCK/UNLOCK" BUTTON, & NOW MY TRUNK LATCH IS NOT WORKING CORRECTLY. THE DOOR LOCKS ARE SELF LOCKING (MEANING THAT THEY LOCK AT ANY GIVEN TIME WHENEVER THEY PLEASE.) THE BRAKE SWITCH HAS BEEN REPLACED, ALL BULBS HAVE BEEN CHECKED & REPLACED, FUSES KEEP GETTING BLOWN. CANNOT LOCATE FUSE FOR THE DOOR LOCKS. FORD HAS A CAMPAIGN FOR THE YEAR 2000 FOR A DOOR LATCH ISSUE, CAMPAIGN #05S27 NHTSA ID# 05V-030. ALSO, CAMPAIGN #05S50 NHTSA ID #00V-411 FOR A TAIL LAMP ISSUE. THERE ARE NO RECALLS ON THIS YET AFTER DOING WEEKS OF RESEARCH I AM FINDING THAT IT IS AN ISSUE WITH THE FORD FOCUS FROM 2000 TO CURRENT. AFTER CALLING SEVERAL DEALERS, NONE OF THEM WOULD TELL ME ANYTHING, & THAT "THEY DIDN'T RECALL ANY PROBLEMS BEFORE FROM ANYONE ELSE". HOW IS IT THAT I CAN FIND THIS ISSUE ON THE INTERNET BUT THE DEALERS "NEVER HEARD OF IT"? WHY IS THERE NO CHANGE IN THE INDICATED ISSUE OF THE WIRING HARNESS TO THE REAR TAIL LIGHT ASSEMBLY? WOULDN'T THIS BE A HAZARD? I DIDN'T KNOW THEY WEREN'T WORKING UNTIL I GOT PULLED OVER BY LAW ENFORCEMENT. SO, THIS ISSUE HAPPENS WHILE THE VEHICLE IS BEING DRIVEN!!! THEREFORE, A DILIGENT OWNER WHO CHECKS THEIR LIGHTS REGULARLY WILL NOT KNOW IT HAPPENS UNTIL (A) SAID PERSON GETS HIT FROM BEHIND, OR (B) GETS PULLED OVER BY LAW ENFORCEMENT. HERE ARE A FEW LINKS FOR YOUR REFERENCE: LINK: HTTP://WWW.CARGURUS.COM/CARS/DISCUSSION-T574_DS546293. LINK: HTTP://WWW.FOCUSFANATICS.COM/FORUM/SHOWTHREAD.PHP?S=2146E9390BE4CC339AE4F6438BAF3812&T=104972. LINK: HTTP://WWW.DIYNOT.COM/FORUMS/VIEWTOPIC.PHP?P=1250643. LINK: HTTP://WWW.FOCUSFANATICS.COM/FORUM/SHOWTHREAD.PHP?T=149053. LINK: HTTP://WWW.FOCUSFANATICS.COM/FORUM/SHOWTHREAD.PHP?T=268411. LINK: HTTP://WWW.FOCUSFANATICS.COM/FORUM/SHOWTHREAD.PHP?T=206427 *JS
Suspension, Seat belts, Structure, Apr 8, 2014
SUBFRAME IS RUSTED THROUGH. *TR
Electrical system, Vehicle speed control, Apr 7, 2014, fire
2001 FORD FOCUS. CONSUMER WRITES IN REGARDS TO ELECTRICAL SYSTEM FAILURE. *SMD THE CONSUMER STATED THE VEHICLE WAS A LEMON. OVER THE PAST 2 YEARS ALONE, HE HAS SPENT $2,000 IN NON-ROUTINE REPAIRS. EVERY TIME THERE WAS AN ISSUE, THE VEHICLE WAS TAKEN TO THE REPAIR SHOP FOR THE PROBLEM, BUT WAS NEVER FULLY FIXED. ON ONE OCCASION, THE VEHICLE STARTED SMOKING AND THE WIRING CAUGHT ON FIRE.. THE CONSUMER WAS INFORMED, THE VEHICLE NEEDED ALL NEW WIRING, AFTER THE DASH LIGHTS AND TAIL LIGHTS WENT OUT 3 TIMES. ALSO, THE CRUISE CONTROL AND ALL THE LIGHTS INSIDE THE VEHICLE STOPPED WORKING. *JB
Structure, Mar 18, 2014
ON OUR FORD FOCUS, THE EXTERIOR DOOR HANDLE, ON THE FRONT DRIVER'S SIDE DOES NOT WORK. YOU CAN REACH IN THE WINDOW (OR LEAN OVER CTR CONSOLE) TO PULL THE HANDLE AND OPEN IT. THE HANDLE ON THE OUTSIDE IS STUCK IN THE FULL PULLED OUT POSITION, AND CANNOT BE FORCED IN EVEN. THE BACK DOOR STARTED NOT WORKING PERIODICALLY. I THOUGHT THE PROBLEM ON THE BACK DOOR MAY BE THE CHILD SAFETY LOCKS BEING ON. I OPENED THE REAR DOOR, INSERTED THE KEY, AND ROTATED IT. AS FAR AS I COULD TELL, THERE WAS NO CHANGE. YOU COULD PULL ON THE INSIDE, AND OUTSIDE HANDLE, AND THE MECHANISM SEEMED TO BE WORKING, SO I CLOSED THE DOOR ....BEFORE CHANGING THE ROTATION BACK. NOW, THE DOOR WILL NOT OPEN FROM THE INSIDE OR OUTSIDE. THIS CONCERNS ME IF THERE WERE AN ACCIDENT, OR FIRE, THE PERSON IN THE BACK SEAT MAY NOT BE ABLE TO EXIT. I WOULD LIKE TO KNOW IF THERE IS A WAY TO RESET THE CHILD DOOR LOCKS-WITHOUT OPENING THE DOOR (SINCE THE DOOR WILL NOT OPEN)? *TR
Structure, Mar 18, 2014
ON OUR FORD FOCUS, THE EXTERIOR DOOR HANDLE, ON THE FRONT DRIVER'S SIDE DOES NOT WORK. YOU CAN REACH IN THE WINDOW (OR LEAN OVER CTR CONSOLE) TO PULL THE HANDLE AND OPEN IT. THE HANDLE ON THE OUTSIDE IS STUCK IN THE FULL PULLED OUT POSITION, AND CANNOT BE PUSHED IN. THE BACK DRIVER'S SIDE DOOR STARTED PERIODICALLY STARTED HAVING PROBLEMS OPENING. I THOUGHT THE PROBLEM WITH THE BACK DOOR MAY BE DUE TO THE CHILD SAFETY LOCKS BEING ENGAGED. I OPENED THE REAR DOOR, INSERTED, AND ROTATED THE KEY. AS FAR AS I COULD TELL, THERE WAS NO CHANGE. YOU COULD PULL THE HANDLE ON THE INSIDE, AND OUTSIDE, AND THE MECHANISM SEEMED TO BE WORKING, SO I CLOSED THE DOOR ....BEFORE CHANGING THE ROTATION BACK. NOW, THE DOOR WILL NOT OPEN ANY, FROM THE INSIDE, OR OUTSIDE. THIS IS A GREAT CONCERN BECAUSE IF THERE WAS AN ACCIDENT, OR FIRE, THE PERSON IN THE BACK SEAT MAY NOT BE ABLE TO EXIT THIS VEHICLE. I WOULD LIKE TO KNOW: IS THERE A WAY TO RESET THE CHILD SAFETY LOCKS, WITHOUT OPENING THE DOOR (SINCE THIS DOOR WILL NOT OPEN)? *TR
Fuel/propulsion system, Mar 5, 2014
TL * THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, SHE ATTEMPTED TO MAKE A RIGHT TURN WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT AFTER DRIVING FOR A SEVERAL MINUTES THE FAILURE RECURRED. THE CONTACT STATED THAT THE VEHICLE HAD BEEN REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 03V482000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 162,000.
Power train, Jan 14, 2014
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH AND CHANGING GEARS FROM SECOND TO THIRD, THE VEHICLE BEGAN SHAKING UNCONTROLLABLY. THE VEHICLE WAS NOT BEEN TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.
Electrical system, Structure, Engine, Jan 13, 2014, fire
SUNDAY 05 JAN 2014 I HAD RECENTLY PARKED MY CAR, TURNED IT OFF, AND WAS OUTSIDE OF MY VEHICLE (2001 FORD FOCUS) WHEN I BEGAN TO NOTICE SMOKE COMING FROM THE HOOD OF THE VEHICLE. I WAS CONFUSED AT FIRST, AS THE CAR WAS COMPLETELY OFF FOR A FEW MINUTES BEFORE ANY PROBLEMS BEGAN. WITHIN A MATTER OF TWO MINUTES THE SMOKE HAD INCREASED, THICKENED, AND BEGAN TO SMELL. MY FRIEND WAS NEARBY AND HAD NOTICED THAT SOMETHING WAS NOT RIGHT. HE CAME OVER AND WE BOTH TOOK A COUPLE STEPS TOWARD THE FRONT OF THE CAR TO FIGURE OUT WHAT WAS GOING ON. IMMEDIATELY FLAMES BURST UP FROM THE HOOD. AT THIS POINT WE INSTANTLY RAN FROM THE VEHICLE, DIALING 911. THE FLAMES GOT WORSE AS WE WAITED FROM A DISTANCE FOR THE FIRE DEPARTMENT TO ARRIVE. AT THIS POINT I WAS UNSURE AS TO WHETHER THE CAR WOULD COMPLETELY BLOW UP OR NOT, AS THE FLAMES BECAME WORSE WITH EVERY MINUTE. THE FIRE DEPARTMENT ARRIVED WITHIN APPROXIMATELY FIVE MINUTES. THEY WERE ABLE TO PUT THE FIRE OUT IN A FEW MINUTES, BUT HAD TO BREAK THE WINDOW AND THEN PRY THE HOOD OPEN IN ORDER TO DO SO. AFTER THE FIRE WAS COMPLETELY OUT AND THE SCENE WAS SAFE I WAS ABLE TO TALK WITH THE FIREMEN. THEY SHOWED ME UNDER THE HOOD AND SAID THE FIRE SEEMED TO BE SOMETHING ELECTRICAL AND LOOKED AS IF IT HAD STARTED NEAR THE FRONT RIGHT OF THE VEHICLE UNDER THE HOOD (SOMEWHERE CLOSE TO THE PASSENGER HEADLIGHT). THEY ALSO EXPLAINED, AS I HAD ALREADY ASSUMED, THAT THE VEHICLE WAS UNSALVAGEABLE. *TR
Electrical system, Jan 3, 2014
IGNITION SWITCH ON THE VEHICLE IS COMPLETELY LOCKED UP AND WILL NOT TURN. MY WIFE IS A DIABETIC AND HAS NUMEROUS HEALTH COMPLICATIONS DUE TO HER DIABETES. IF WE WERE OUT AND BECAME STRANDED IT COULD HAVE COST US HER LIFE. I AM DISAPPOINTED WITH FORD FOR NOT FIXING THIS ISSUE. *TR
Fuel/propulsion system, Nov 22, 2013
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, THE VEHICLE WAS CONSUMING FAR MORE FUEL THAN RATED. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER OR MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE FAILURE MILEAGE WAS 140,000.
Fuel/propulsion system, Oct 15, 2013
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE FUEL PUMP HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 110,000. THE CURRENT MILEAGE WAS 127,598.
Electrical system, Sep 30, 2013
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE ALTERNATOR FAILED DUE TO CORROSION AND IT WAS CRACKED IN SEVERAL PLACES.. THE CONTACT REPLACED THE ALTERNATOR HIMSELF. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 143,000. ...UPDATED 12-24-13 *BF