2004 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 387 owner complaints filed for this model year. This is the 14th highest complaint count among 19 Focus model years with reports.
Of the 2004 reports, 34 involved a crash and 13 involved a fire. 34 people were injured and 1 person died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Representative owner complaints
387 reports, newest first.
Exterior lighting, Visibility, Apr 25, 2010
2004 FOCUS ZWT 1. LOSS OF FRONT WIPER PARK FUNCTION ! 2. LOSS OF HEADLIGHT / AUXILIARY LAMP FUNCTION ! HAPPENED AT 2 SEPARATE INCIDENTS DURING 2009. *TR
Electrical system, Latches/locks/linkages, Apr 24, 2010
MY FORD FOCUS SVT 2004 INGINTION KEY WILL NOT TURN AND THE STEERING WHEEL IS LOCKED. I HAD PROBLEMS STARTING 4 MONTHS AGO AND NOW IT IS WORST. *TR
Power train, Electrical system, Apr 14, 2010
2004 FORD FOCUS. CONSUMER STATES TRANSMISSION GAVE OUT WITH A MILEAGE UNDER 20,000. CONSUMER REQUESTS REIMBURSEMENT. *TGW IN JULY 2009, THE VEHICLE NEEDED A NEW BATTERY. ABOUT A WEEK AFTER THE NEW BATTERY WAS INSTALLED, PERIODICALLY THE CLUSTER LIGHTS WOULD MAKE A SOUND AND THE LIGHTS WOULD BLINK ON AND OFF. IT WOULD HAPPEN TWICE IN A MATTER OF SECONDS, BUT DID NOT HAPPEN EVERYDAY. THE CONSUMER FOLLOWED INSTRUCTION ON WHAT TO DO. THE SITUATION WAS A LITTLE BETTER, BUT THE CLUSTER BLINKING, ETC STILL OCCURRED PERIODICALLY. A WEEK LATER, AS THE CONSUMER BACKED OUT OF HER DRIVEWAY, THERE WERE SOUNDS COMING FROM THE VEHICLE AND THEY SEEMED TO GET WORSE. THE CONSUMER HAD THE VEHICLE TOWED TO A TRANSMISSION SHOP. UPON INSPECTION, THE TRANSMISSION PLATE WHICH WAS LOCATED UNDER THE ENGINE SHOWED TRANSMISSION FLUID AN D EXCESSIVE AMOUNTS OF METAL FILLINGS. THE MECHANIC SHOWED THE CONSUMER THE DAMAGED PARTS WHERE THE TEETH IN THE GEARS WERE NOT WORKING PROPERLY WHICH CAUSED THE METAL FILLINGS IN THE TRANSMISSION PLATE. *JB
Electrical system, Apr 2, 2010
THE IGNITION LOCK CYLINDER FAILED SUDDENLY WITHOUT A GRADUAL INCREASE OF SYMPTOMS. THE CYLINDER WOULD NOT ALLOW THE KEY TO TURN, UNLOCK THE STEERING WHEEL AND ALLOWING THE CAR TO START. A NEW IGNITION LOCK CYLINDER WAS INSTALLED AND REKEYED AT A PRICE OF $171.18 FOR THE PART AND $142.50 FOR THE LABOR.
Latches/locks/linkages, Mar 12, 2010
TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE DRIVING AT SPEEDS OF 25 MPH, THE REAR PASSENGER DOOR WOULD RELEASE WITH THE LOCKS ENGAGED. THE MANUFACTURER WAS CONTACTED AND ALTHOUGH THERE WAS A RECALL FOR THE EXACT FAILURE (NHTSA CAMPAIGN ID NUMBER: 05V030000, LATCHES/LOCKS/ LINKAGES, DOORS) HER VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE CONTACT FELT UNSAFE WITH A VEHICLE OCCUPANT IN THE REAR NEAR THE DEFECTIVE DOOR. THE FAILURE MILEAGE WAS 120,000. THE CURRENT MILEAGE WAS UNKNOWN.
Engine and engine cooling, Mar 11, 2010
I HAVE A 2004 FORD FOCUS ZX3. I WAS AT A GAS STATION FILLING UP AND WHEN I ATTEMPTED TO START UP MY CAR, THE KEY WOULD NOT TURN. THE IGNITION CYLINDER WAS COMPLETELY LOCKED UP. I WAS STRANDED AT THE GAS STATION FOR 2 HOURS BEFORE AAA CAME AND TOWED MY CAR TO THE DEALERSHIP. I HAVE RESEARCHED THE ISSUE AND FOUND OUT THAT THE IGNITION CYLINDER LOCKING UP AND NOT ALLOWING YOU TO START YOUR CAR IS A VERY COMMON ISSUE WITH THE FORD FOCUS, MOST COMMONLY IN MODELS BETWEEN THE YEARS 2000 AND 2006. I WAS LUCKY TO BE ONLY 5 MILES AWAY FROM THE DEALERSHIP WHERE I HAD TO HAVE IT TOWED. IF I WAS FURTHER AWAY OR OUT OF TOWN, THIS COULD HAVE BEEN A BIG SAFETY HAZARD, AS IT COULD HAVE LEFT ME STRANDED IN A DANGEROUS SITUATION. PLEASE TAKE ACTION BY HELPING THE CONSUMERS OF THE FORD FOCUS RECEIVE A REFUND/RECALL FOR THEIR DEFECTED IGNITION CYLINDER. THANK YOU! *TR
Electrical system, Feb 28, 2010
I OWN A 2004 FORD FOCUS, I'VE HAD AN ISSUE WITH THE IGNITION STICKING FOR ABOUT 4 MONTHS, USUALLY BEING ABLE TO JIGGLE IT AND GET IT TO TURN. NOW IT IS STUCK COMPLETELY, I'VE READ TONS AND TONS OF ARTICLES ABOUT THIS BEING A PROBLEM, MY CAR IS NOW PARKED IN MY DRIVEWAY BECAUSE I DON'T FEEL THIS IS MY RESPONSIBILITY TO FIX. *TR
Exterior lighting, Feb 23, 2010
1) TURNED HEADLIGHT SWITH TO "ON" ON MY 2004 FORD FOCUS ZTW 2) TURNING THE HEADLIGHTS ON CAUSED THE REAR HATCH TO OPEN UNCOMMANDED. 3) I REMOVED THE COVER FROM THE HATCH AND DISCONNECTED THE WIPER MOTOR AND LATCH UNLOCK SOLENOID CONNECTORS. THEN, TO FIND THE POSSIBLE PROBLEM, I INSPECTED THE WIRE BUNDLE IN THE AREA OF THE HATCH HINGE AND FOUND SEVERAL WIRES FRAYED AND BROKEN. SO TURNING ON THE HEADLIGHTS APPARENTLY SENT A SIGNAL (SHORT) TO THE LATCH SOLENOID. A FRIEND HAD A SIMILAR PROBLEM. HIS HATCH WOULD POP OPEN WHEN THE IGNITION WAS TURNED TO START THE CAR. TWO DEALERS TOLD ME THEY WOULD NOT BE OF ANY HELP UNLESS I PAID AT LEAST $350 TO REPAIR THE PROBLEM. THIS IS A SAFETY ISSUE. REMEBER THE CHYSLER MINI VAN HATCH RECALL? I HAVE BEEN WATCHING THE TOYOTA SUA HEARINGS AND DECIDED TO CHALLENGE YOU GUYS AND SEE IF YOU WOULD REVIEW AND CONTACT ME AS MR. LAHOOD SAID YOU WOULD. I KNOW YOU ARE BUSY AND UNDERSTAFFED. I DO NOT BLAME YOU AS SOME ARE INTENT UPON. I SPENT MY LIFE AS AN A&P MECHANIC AT AMERICAN AIRLINES AND KNOW THE IMPORTANCE OF SAFETY. THANKS FOR READING AND HOPE TO HEAR FROM YOU SOON. PS FORD HAS HAD KNOWLEDGE OF THIS PROBLEM IN OTHER MODEL YEARS OF THE FOCUS. *TR
Electrical system, Latches/locks/linkages, Feb 22, 2010
THE ISSUE I WOULD LIKE TO REPORT IS IN REGARD TO FORD FOCUS AUTOMOBILES FROM 2000 TO CURRENT DATE 2010. THERE IS A KNOW DEFECT WITH THE IGNITION SWITCH WHICH IS MADE WITH INFERIOR METAL PARTS IN THE IGNITION LOCK. WHAT HAPPENS IS THAT METAL SHAVINGS ARE PRODUCED INSIDE THE LOCK AND AFTER TIME THESE METAL SHAVINGS CAUSE THE LOCK TO JAM. THOUSANDS OF PEOPLE HAVE BEEN AFFECTED BY THIS PROBLEM AND HAVE BEEN STRANDED BECAUSE THEY CANNOT TURN THE IGNITION KEY. FORD DENIES THIS PROBLEM. JUST GO TO ANY LOCKSMITH OR TOW TRUCK DRIVER OR GOOGLE FORD FOCUS IGNITION ON THE INTERNET. EVERYBODY KNOWS ABOUT THE PROBLEM. EVERYTIME THIS HAPPENS IT COSTS THE OWNER BETWEEN $500 AND $800 TO HAVE THIS FIXED AT A FORD DEALERSHIP. MY 2004 FOR FOCUS CURRENTLY HAS THIS PROBLEM. THIS SHOULD BE A RECALL BY FORD AND I THINK THIS IS THE BIGGEST SCAM SINCE BERNIE MADOFF. PLEASE DO SOMETHING ABOUT THIS. THANKS FRUSTRATED FORD OWNER. *TR
Electrical system, Feb 15, 2010
IGNITION SWITCH IN LOCK POSITION FREEZES AND REFUSES TO UNLOCK WHEN IGNITION KEY IS INSERTED, CAUSING AN INABILITY TO START ENGINE OR UNLOCK STEERING WHEEL TO MOVE VEHICLE. THIS PROBLEM STRANDS MOTORISTS WHEREVER THEY ARE WHEN THE IGNITION KEY WAS SWITCHED OFF AND REMOVED FROM THE IGNITION. *TR
Steering, Electrical system, Feb 10, 2010
FORD FOCUS 2004 IGNITION LOCKED. OPENED CAR AS USUAL, INSERTED KEY IN IGNITION TO TURN AND STEERING WHEEL APPEARED TO BE LOCKED. TRIED TO TURN KEY AND MOVE STEERING WHEEL BUT BOTH WOULDN'T MOVE. CALLED DEALERSHIP AND WAS TOLD THE IGNITION WAS LOCKED AND THAT IT WAS A COMMON PROBLEM. CAR NOW NEEDS TO BE TOWED TO BE FIXED. *TR
Electrical system, Feb 1, 2010
FIRST OCCURRENCE,WITHOUT WARNING,(HAD NEVER HAPPENED BEFORE) CAR SHUT OFF, IGNITION SWITCH WOULD NOT TURN, RESULTING IN VEHICLE NO START CONDITION. (ORIGINAL MANUFACTURERS KEY AND IGNITION SWITCH) CONTACTED AAA AUTO CLUB, TOW TRUCK DISPATCHED, TOW TRUCK DRIVER STATES GARAGE HAS SEEN MANY 2003, 2004,2005 FOCUS WITH THIS PROBLEM. ALSO SHOULD BE NOTED NUMEROUS SIMILAR COMPLAINTS ON FILE WITH ALL MODEL YEARS OF THIS VEHICLE. FORD DEALER THAT SOLD ME THE CAR AND EXTENDED WARRANTY CLAIMS REPAIR NOT COVERED BY WARRANTY. FEEL THIS IS A SERIOUS SAFETY ISSUE AS CAR CAN STALL AND FAIL TO RESTART !!!!!!. ALSO FEEL THAT I WAS SOLD AN OVERPRICED "WARRANTY" WHICH I AM TOLD WILL NOT COVER REPAIR !!! WILL RETAIN OLD PART FOR INVESTIGATION AND POSSIBLE CLASS ACTION. NOTE : VEHICLE MILEAGE AT FAILURE 43,205. *TR
Vehicle speed control, Jan 29, 2010
TL*THE CONTACT OWNS A 2004 FORD FOCUS. THE CONTACT STATED THAT THE ACCELERATOR PEDAL BEGAN TO STICK ON A REGULAR BASIS. WHEN SHE PRESSED DOWN ON THE ACCELERATOR, IT WOULD NOT RESUME THE REGULAR POSITION. THE DEALER REPLACED THE THROTTLE BODY. SHE EXPERIENCED NO ISSUES WITH THE PEDAL SINCE THE VEHICLE WAS REPAIRED. SHE HAD NOT SPOKEN WITH THE MANUFACTURER TO-DATE. THE CURRENT MILEAGE IS APPROXIMATELY 116,000. THE FAILURE MILEAGE WAS APPROXIMATELY 105,500. UPDATED 03/01/10 *BF THE CONSUMER STATED THE ACCELERATOR PEDAL WAS STICKING. UPDATED 06/28/10*JB
Air bags, Jan 23, 2010, crash
MY SON REAR-ENDED ANOTHER CAR IN A SNOWSTORM. HE WAS DRIVING BETWEEN 10-20 MILES PER HOUR AT THE TIME. THE AIR BAG INDICATOR LIGHT ON HIS 2004 FORD FOCUS IS NOW ON, BUT THE AIR BAG DID NOT DEPLOY IN THE ACCIDENT. HE MUST HAVE BEEN JOLTED FORWARD PRETTY ABRUPTLY BECAUSE THE SEAT BELT SPOOL IS BROKEN - THE BELT IS STUCK. HE WAS NOT INJURED, BUT I DO WONDER WHETHER THE AIR BAG SHOULD HAVE INFLATED. *TR
Electrical system, Dec 22, 2009
TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE ATTEMPTING TO START THE VEHICLE THE KEY WOULD NOT TURN IN THE IGNITION. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALERSHIP. THE CURRENT AND FAILURE MILEAGES WERE 86000.
Electrical system, Latches/locks/linkages, Dec 18, 2009
ON A SATURDAY EVENING I DROVE TO GROCERY STORE. AFTER I HAD FINISHED SHOPPING I TRIED TO START VEHICLE. I COULD NOT TURN KEY IN IGNITION AND THE STEERING COLUMN REMAINED IN THE LOCKED POSITION. THE VEHICLE HAD 67787 MILES. I HAD CAR TOWED TO FORD DEALER AND THEY DRILLED OUT LOCK CYLINDER AND REPLACED WITH A NEW ONE AT A COST OF $385.34. TOW TRUCK DRIVER STATED THAT HE HAD TOWED THE SAME MODEL BEFORE WITH AN IDENTICAL PROBLEM. THE SERVICE MANAGER AT DEALER STATED THAT HE HAD SEVERAL OF THE SAME MODEL WITH IDENTICAL PROBLEM. HE ALSO STATED THAT THE PART HAD BEEN UPDATED A FEW TIMES. I AM 53 AND HAVE DRIVEN MANY VEHICLES, SOME WITH OVER 240,000 MILES AND HAVE NEVER BEFORE HAD THIS PROBLEM. I FEEL IT WAS MANUFACTURED WITH A DEFECT AND IT FAILED PREMATURELY. *TR
Electrical system, Latches/locks/linkages, Dec 12, 2009
I HAVE A 2004 FORD FOCUS. THE IGNITION LOCKS WHENEVER THE CAR IS TURNED OFF. IT IS IMPOSSIBLE TO START THE CAR AGAIN WITHOUT HITTING ON THE KEY ITSELF. THIS HAS RESULTED IN THE KEY BREAKING OFF IN THE LOCK. THE IGNITION LOCK APPEARS TO BE A COMMON PROBLEM WITH THIS MAKE AND MODEL, AND POSES A SIGNIFICANT SAFETY RISK.. I HAVE HAD THIS PROBLEM FOR THE PAST 2 YEARS, BUT IT HAS BECOME MUCH WORSE RECENTLY. THERE WAS NO ACCIDENT OR DAMAGE TO THE CAR PRIOR TO THIS ISSUE. THE LOCAL FORD DEALERS TOLD ME IT WOULD COST BETWEEN $400-500 TO FIX, AND IT SEEMS THAT MANY TIMES, THE NEW PARTS ARE ALSO DEFECTIVE AND THE PROBLEM RETURNS. AS THIS APPEARS TO BE A WIDESPREAD PROBLEM AMONG FOCUS OWNERS, PLEASE CONSIDER ISSUING A SAFETY RECALL FOR THIS MAKE AND MODEL. *TR
Steering, Latches/locks/linkages, Dec 10, 2009
NO EVENTS PULLED INTO PARKING LOT LEFT CAR FOR FEW MINUTES CAME BACK AND THE IGNITION WAS LOCKED SOLID. FROM WHAT I AM TOLD THIS IS A COMMON ISSUE WITH THE FORD FOCUS MINE IS A 2004. THIS IS A SAFETY HAZARD MAYBE NOT TO ME THIS TIME BECAUSE I WAS IN A PARKING LOT AND WAITED FOR OVER AN HOUR FOR A TOW TRUCK HOWEVER IF I WAS BROKEN DOWN ON THE SIDE OF THE ROAD FOR A FLAT TIRE AND THIS HAPPENED WHAT THEN OR IS THIS NOT CONSIDERED A SAFETY HAZARD BECAUSE NO ONE HAS BEEN KILLED THIS SEEMS LIKE SOMETHING THAT SHOULD OF BEEN RECALLED YEARS AGO. PROTECT THE CONSUMER. *TR
Electrical system, Dec 9, 2009
2004 FORD FOCUS IGNITION PROBLEM. COULD NOT PUT MY KEY IN THE IGNITION AND WAS STRANDED. *TR
Electrical system, Nov 30, 2009
2004 FORD FOCUS-- IGNITION KEY WON`T TURN LEAVING THE DRIVER STRANDED. *TR
Seat belts, Nov 20, 2009
TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE SEATING IN A BOOSTER SEAT IN THE DRIVERS SIDE REAR SEAT, THE CHILD WAS ABLE TO TIE THE SEAT BELT AROUND HIS HEAD. THE VEHICLE WAS TAKEN TO THE DEALERSHIP. THEY JUST LOOKED AT THE VEHICLE AND SUGGESTED THE CONSUMER CONTACTED NHTSA. THE CURRENT AND FAILURE MILEAGES WERE 85342. UPDATED 12/22/09.*LJ THE CONSUMER HAD TO CUT THE STRAP. UPDATED 12/29/09.*JB
Exterior lighting, Oct 29, 2009, fire
TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE PREPARING TO MAKE A RIGHT TURN AT APPROXIMATELY 45 MPH, THE RIGHT TURN SIGNAL FAILED TO OPERATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN STATED THE FAILURE WAS CONTRIBUTED TO THE BURNING AND MELTING OF THE TURN SIGNAL BULB SOCKET. THE VEHICLE WAS REPAIRED AT THE COST OF $300.00. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON A THREE SEPARATE OCCASIONS FOR THE IDENTICAL FAILURES. THE MANUFACTURER WAS NOTIFIED AND REIMBURSED FOR THE PRIOR SERVICE REPAIR. ALSO, PERFORMED ONE FREE REMEDY REPAIR ON THE VEHICLE. THE FAILURE MILEAGE WAS 45,000. THE CURRENT MILEAGE WAS 120,000.
Latches/locks/linkages, Oct 12, 2009
KEY WILL NOT TURN ON IGNITION WILL NOT GO INTO GEAR NOR WILL THE STEERING WHEEL TURN AT ALL!!!, COMPLETELY LOCKED IGNITION CAR IS ONLY FIVE YEARS OLD AND NOT DRIVEN VERY MUCH W/ ONLY 68K MILES ON IT!, 2004 FORD FOCUS ZX3. *TR
Electrical system, Structure, Oct 7, 2009
I HAVE TWO ISSUES WITH MY FORD FOCUS (2004) FIRST, I RAN INTO A PROBLEM WITH THE IGNITION SWITCH AND IT WILL NOT TURN. I LEFT THE KEY IN FOR A COUPLE OF MONTHS WHEN THIS INITIALLY HAPPENED BUT, IT WORE OUT MY ALTERNATOR AND I HAD TO HAVE IT REPLACED. I REMOVED THE KEY ONCE THE NEW ALTERNATOR WAS INSTALLED. I HAD SOME MINOR SUCCESS WITH INSERTING THE KEY AND HAD TO BANG ON IT WITH MY HAND TO GET IT TO TURN. THIS WORKED SUCCESSFULLY FOR 2 WEEKS. THE IGNITION SWITCH IS NOW FROZEN. I AM BACK TO SQUARE ONE. SECONDLY, THE TRUNK LATCH DOESN'T CLOSE PROPERLY AND I HAVE TO USE MY REMOTE TO REOPEN THE MECHANISM IN ORDER TO GET IT TO CLOSE. VERY AGGRAVATING. I WILL NOT PURCHASE ANOTHER FORD IF THESE ISSUES ARE NOT RECALLED. *TR
Vehicle speed control, Oct 5, 2009
THE VEHICLE HAS 54,000MI AND DRIVEN WITHIN NORMAL DRIVING LIMITS. THE HINGE PEG THAT CREATES A PIVOT POINT FOR THE ACCELERATOR PEDAL BROKE ON ONE END CAUSING IT TO FALL COMPLETELY OUT OF THE PEDAL AND BRACKET. THE INCIDENT HAPPENED ON A BUSY ROAD DURING RUSH HOUR AND CAUSE COMPLETE LOSS OF CONTROL TO ACCELERATE. THE PROBLEM HAS NOT YET BEEN CORRECTED HAPPENING ONLY HOURS AGO. *TR