2006 Ford Fusion
Problems, recalls and owner-reported issues
Air bags is the leading concern among 730 owner complaints filed for this model year. This is the 12th highest complaint count among 15 Fusion model years with reports.
Of the 2006 reports, 38 involved a crash and 4 involved a fire. 33 people were injured.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleMar 10, 2021
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.
Campaign 21V158000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleDec 18, 2019
Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.
If the valves do not properly close, additional brake pedal travel may be required to stop the vehicle, increasing the risk of a crash.
Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap. In addition, the HCU will be tested to detect a possible stuck valve condition, replacing the HCU as necessary. All services will be performed free of charge. The recall began April 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S54.
Campaign 19V904000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleDo not drive until repairedJan 10, 2017
Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
Campaign 17V024000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleDo not drive until repairedMay 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
Campaign 16V384000 on NHTSA.gov
EquipmentMay 29, 2014
Ford Motor Company (Ford) is recalling certain all weather driver side accessory floor mats sold for use in model year 2006-2011 Ford Fusion and Mercury Milan, 2006 Lincoln Zephyr, and 2007-2011 Lincoln MKZ vehicles manufactured November 9, 2007, through October 31, 2010. The affected floor mats may move and possibly interfere with the accelerator pedal.
The floor mat could shift such that it could interfere with the accelerator pedal, preventing its return to an idle position, which could result in unintended vehicle speeds, increasing the risk of a crash.
Ford will notify owners, and dealers will install new replacement mats, free of charge. The recall began in July 2014. Owners may contact Ford's customer service at 1-800-392-3673. Ford's number for this recall is 14S07. NOTE: Vehicles built after October 31, 2010, while potentially equipped with the same floor mats, are equipped with a Brake Over Accelerator (BOA) feature that prevents simultaneous accelerator and brake application, allowing the vehicle to be safely stopped by pressing firmly and steadily on the brake pedal.
Campaign 14E028000 on NHTSA.gov
Representative owner complaints: power train
150 reports, newest first. Show all
Power train, Feb 24, 2011
WHEN DRIVEN IN TOWN CAR WILL STALL FOR ABOUT 10 TO 15 SECOND THEN JERK FORWARD AROUND SPEED BETWEEN 25- 40MPH WITH A SUDDEN INCREASE IN SPEED UP TO 10MPH. WHEN ENTERING HIGHWAY AND MERGED INTO TRAFFIC. I BEGAN SPEEDING UP TO 60 MPH THE TRANSMISSION HESITATEDTHE STALL FOR 10 SECONDS THEN JERKED,LIKE IT FINALLY SHIFTED BUT THEN TURN AROUND AND STALL GAIN. THE CAR WOULD NOT RESPOND TO THE GAS PEDAL AND WAS STUCK IN 2ND OR 3RD GEAR ONE OF THEM. I TOOK THE CAR TO THE DEALER SEVERAL TIMES AND THE DON'T KNOW WHAT THE PROBLEM, THIS SUDDEN INCREASED IN SPEED IS VERY DANGEROUS DURING RUSH HOUR WITH TRAFFIC I NEARLY HIT THE CAR INFRONT OF ME, THE CAR STALLING IS VERY FLIGHTING WHEN ENTERING HIGHWAY. THIS CAN CAUSE A MAJOR HIGHWAY ACCIDENT. *TR
Power train, Feb 18, 2011
ENTERED HIGHWAY AND MERGED INTO TRAFFIC. BEGAN SPEEDING UP TO AROUND 55 MPH AND TRANSMISSION HESITATED AND JERKED, CAUSING ME TO SLOW DOWN TO AROUND 45 MPH. THE CAR WOULD NOT RESPOND TO THE GAS PEDAL BEING PUSHED AND WAS STUCK IN 2ND OR 3RD GEAR. I COASTED TO THE NEXT EXIT WHERE I EXITED THE HIGHWAY AND DROVE TO A SAFE PLACE TO STOP. THE TRASMISSION LIGHT CAME ON AND I HAD THE CAR CHECKED AT A NEARBY AUTOZONE TO SEE IF SAFE TO DRIVE. THEY COULD NOT DUPLICATE PROBLEM BUT AFTER STOPPED AND RESTARTING CAR, IT DID NOT HAPPEN AGAIN AND TRANSMISSION LIGHT WENT OUT. 63,000 MILES ON THE VEHICLE...I HAD MY 3 CHILDREN, ALL UNDER 5 YRS OLD WITH ME...DEFINITELY A SERIOUS SAFETY ISSUE. *LN
Power train, Feb 4, 2011
2006 FORD FUSION. CONSUMER STATES THAT THE TRANSMISSION IS NOT SHIFTING CORRECTLY. MECHANIC INFORMED THE CONSUMER THAT THERE WERE TSB'S OUT FOR THIS ISSUE. *KB THE CONSUMER STATED AFTER PAYING $3,408.45 FOR THE REPLACEMENT TRANSMISSION, A FEW WEEKS LATER SHE STARTED HAVING THE SAME PROBLEM AGAIN. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHERE THEY CONCLUDED A DEFECTIVE VALVE BODY WAS INSTALLED IN THE VEHICLE DURING A PREVIOUS VISIT. *JB
Power train, Jan 18, 2011
2006 FORD FUSION S 2.3 L WITH 5SP AUTOMATIC TRANSMISSION... WITH LESS THAN 20,000 MILES I BROUGHT MY CAR TO A FORD DEALER AND WAS TOLD NOTHING WAS WRONG WITH THE TRANSMISSION... NOW I KNOW IT SOUNDS HUGE, BUT 3 YEARS LATER HARD SHIFTING AND SOMETIMES REFUSING TO SHIFT FOR A CAR WITH AN MSRP OF 19800 AND 100000 MORE MILES OF EXTREMELY IRRITATING SHIFTING (CLUNKING) I AM UP A CREEK WITHOUT A PADDLE FOR A KNOWN FAULTY TRANSMISSION. SO EITHER I PAY ON THIS CAR FOR NEARLY 2 MORE YEARS FOR A YARD ORNAMENT OR PAY OUT 4000 TO FIX IT. THIS IS A KNOWN AND QUITE COMMON PROBLEM. I WAS TOLD IT WAS NORMAL AND NOTHING WAS WRONG... REALLY? I HAVE HAD 10 YR OLD CARS WITH 200,000 MILES THAT SHIFTED BETTER THAN THIS CAR DID AFTER 15000 MILES. RIDICULOUS....... FORD KNOWS OF THIS PROBLEM AND HAS REFUSED SERVICE AND REPLACEMENT DUE TO COST. THEY KNEW OF THIS PROBLEM 4 YEARS AGO AND STILL THOUSANDS ARE PAYING THOUSANDS OF DOLLARS TO REPAIR A FAULTY TRANSMISSION. *TR
Power train, Jan 13, 2011
WHILE DRIVING MY 2006 FORD FUSION SE V6 WITH 6 SPEED TRANSMISSION, THE TRANSMISSION STARTED SLIPPING AT 40MPH IN A SNOW STORM AND I ALMOST LOST CONTROL OF MY VEHICLE FROM THE LOSS IN POWER. IT NOW RANDOMLY SLIPS OUT OF GEAR AT ALL SPEEDS AND DOWNSHIFTS HARD LURCHING THE CAR OUT OF THE LANE. *TR
Power train, Jan 12, 2011
WHEN ACCELERATING, MERGING INTO TRAFFIC, THE TRANSMISSION POPS OUT OF GEAR AND THE ENGINE WILL CONTINUE TO ACCELERATE WHILE THE CAR COASTS, AND SLOWS. THE TRANSMISSION WILL EVENTUALLY ENGAGE A LOWER GEAR WHEN IT HAS SLOWED DOWN, BUT ONLY IF YOU ARE PATIENT AND IGNORE THE URGE TO ACCELERATE AS TRAFFIC BEARS DOWN ON YOU FROM BEHIND. THIS IS TERRIBLY FRIGHTENING AND DANGEROUS AS THE VEHICLES WHICH REQUIRE THE MOST ROOM TO STOP, USUALLY TRAVEL IN THE SAME LANE ONE IS MERGING ON TO. THIS OCCURS NOT ONLY ON FREEWAY ENTRANCES, BUT ON LONG UPHILLS AND ANYTIME ONE LETS OFF THE THROTTLE AND THEN TRIES TO ACCELERATE AGAIN QUICKLY. A DIAGNOSTIC FROM AN AUTO REPAIR SHOP REVEALS NOTHING. I HAVE CONTACTED ABOUT 30 OTHER SAME MODEL CAR OWNERS WHO DESCRIBE THE SAME PROBLEM. THE FORTUNATE FEW WHO HAVE BEEN ABLE TO GET TO THE ROOT OF THE PROBLEM HAVE SAID THAT THE DEFECT IS IN THE "VALVE BODY". MOST HAVE THIS PROBLEM AFTER THE 50,000 MILE MARK. MANY, LIKE MYSELF, HAVE HAD THIS PROBLEM FOR A LONG TIME. IT IS A MATTER OF TIME BEFORE ONE OF US GETS REAR ENDED AND CRASH, OR WORSE! *TR
Power train, Jan 6, 2011
MY 2006 FORD FUSION TRANSMISSION STARTED SLIPPING AT 34,000 MILES. DEALER SAID THERE WAS NOTHING THEY COULD DO SINCE MY CAR WAS MADE IN THE FIRST PART OF 2006, NO ADDITIONAL WARRANTIES WERE AVAILABLE. I BOUGHT THE CAR UNDER THE ASSUMPTION THAT THERE WAS A WARRANTY STILL AVAILABLE. NOW MY TRANSMISSION IS GOING OUT, I STILL OWE 11,000 ON MY CAR. AFTER TALKING TO ALOT OF FUSION PEOPLE, THIS APPEARS TO BE A VERY VERY COMMON PROBLEM. IT'S ALSO VERY DANGEROUS, THE CAR SLIPS OUT OF GEAR REVS UP AND THEN POPS BACK INTO GEAR JUST AS YOU ARE TRYING TO GET INTO A LANE. VERY DANGEROUS, I HAVE ALMOST WRECKED SEVERAL TIMES AND HAD TO PULL OVER. *TR
Power train, Dec 8, 2010
2006 FORD FUSION FAILING TO SHIFT DURING ACCELERATION, SHIFTING SUDDENLY AND VIOLENTLY, FAILING TO DOWNSHIFT AND RUNNING EXTREMELY HIGH RPM CREATING VERY DANGEROUS CONDITIONS WHEN PASSING, MERGING AND SLOWING. DEALER FAILED TO RESOLVE THE ISSUE DURING 3 SEPARATE REPAIR VISITS 2008 TO 2009. SEVERAL ATTEMPTS TO REPROGRAM TCM & PCM WERE UNSUCCESSFUL. PCM REPLACED IN 2009 BUT HAS NOT RESOLVED THE ISSUE. RESEARCH INDICATES THAT FORD IS AWARE OF DEFECTIVE TRANSMISSION VALVE BODY CAUSING THE ISSUE BUT HAS NOT DONE A RECALL. *TR
Engine and engine cooling, Power train, Dec 7, 2010
TRANSMISSION WOULD SHIFT OUT OF A GEAR, CAR WOULD REV UP TO HIGH, THEN TRANSMISSION WOULD SHIFT VIOLENTLY BACK IN JERKING THE CAR AROUND FEELING LIKE YOU HAVE BEEN REAR ENDED. THE TRANSMISSION WILL SLAM SO HARD INTO GEAR WHEN TRYING TO ACCELERATE( I HAVE HAD THIS EXPERIENCE ACCELERATING AT 45MPH AND AT 65MPH) ENGINE LIGHT COMES ON STAYS ON FOR A FEW DAYS GOES OFF PROBLEM COMES BACK A FEW DAYS LATER. ONLY SOLUTION WHEN THIS HAPPENS IS TO PULL OVER AND SHUT THE CAR OFF. ONCE CAR IS TURNED BACK ON THE GEAR SHIFTER (AUTOMATIC) IS VERY TIGHT TO PUT IN REVERSE OR DRIVE. *TR
Power train, Dec 1, 2010
TL*THE CONTACT OWNS A 2006 FORD FUSION. WHILE DRIVING APPROXIMATELY BETWEEN 15-30 MPH, THE CONTACT STATED THAT THE TRANSMISSION SLIPPED IN AND OUT OF GEAR CONTINUOUSLY. IN ADDITION, THE VEHICLE WOULD JERK VIOLENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000. UPDATED 01/11/2011*LJ
Power train, Dec 1, 2010
I OWN A 2006 FORD FUSION SE WITH THE 3.0 V6 ENGINE. AT JUST OVER 55,000 MILES, VEHICLE WOULD COME OUT OF GEAR WHILE SHIFTING BETWEEN 30-60MPH, ROUGHLY 2ND-3RD, OR 3RD-4TH GEAR. VEHICLE WOULD GO INTO A HIGH REV AND NOT MOVE. AFTER LETTING OFF GAS, YOU HAVE TO WAIT 5 SECONDS FOR IT TO "RE-ENGAGE", THEN SOMETIMES IN A HIGH GEAR AT LOW SPEEDS CAUSING VEHICLE TO SHAKE VIOLENTLY. THIS IS A VERY SERIOUS AND DANGEROUS MECHANICAL FLAW WITH THIS TRANSMISSION! IT IS THE AISIN TRANSMISSION USED IN A VARIETY OF FORD, LINCOLN, AND MERCURY VEHICLES. (2005-2006 FORD FIVE HUNDRED, 2006 FORD FUSION, 2006 MERCURY ZEPHYR, 2006 MERCURY MILAN, 2005-2006 MERCURY MONTEGO) THERE ARE 100'S TO 1000'S OF COMPLAINTS ON THESE AND MULTIPLE TSB (TECHNICAL SERVICE BULLETINS) THROUGH FORD MOTOR COMPANY, ETC. (TSB 07-26-9, TSB 08-24-1) CALLING IT AISIN TRANSMISSION HARSH SHIFTING. HARSH BEING AN EASY TERM TO DESCRIBE THIS PROBLEM. AND STILL NO RECALL ON THIS OR COMPENSATION FROM DEALER OR MANUFACTURER. IF YOUR VEHICLE IS OUT OF WARRANTY, YOU ARE ON YOUR OWN WITH THIS $1,500 PLUS REPAIR ON A DEFECTIVE VALVE BODY ACCORDING TO FORD MOTOR CO. THIS IS A TREMENDOUS SAFETY ISSUE ESPECIALLY WHEN NEEDING TO MERGE OR ACCELERATE RAPIDLY TO GET ONTO A FREEWAY SYSTEM OR OVERTAKE AND PASS ON THE HIGHWAY! I GUESS IT WILL TAKE A SERIOUS INJURY OR FATALITY TO CAUSE A LAW SUIT FOR ANYTHING TO BE DONE EXCEPT A TSB! WITH ALL THE DOCUMENTATION AND COMPLAINTS I HAVE SEEN ON THESE, I HOPE THE MANUFACTURERS HAVE A STRONG LEGAL TEAM! I WILL NEVER BUY A FORD, LINCOLN, OR MERCURY AGAIN. AND WE WONDER WHY AMERICANS BUY FOREIGN! IT IS A SAD DAY PEOPLE, BUT THE TRUTH HURTS! OUR US CAR MAKERS NEED TO STAND BEHIND THEIR PRODUCTS BETTER AND IMPROVE THEIR BUSINESS ETHICS OR THEY WILL CONTINUE TO FAIL AND GO BANKRUPT. *TR
Power train, Nov 13, 2010
TRANSMISSION SLIPS IN AND OUT OF GEAR WHILE DRIVING AT ANY SPEED. THESE ARE VERY HARD GEAR SHIFTS AND THE ENTIRE CAR SHAKES. SOMETIMES IT WON'T GO INTO ANY GEAR AT ALL, INCLUDING REVERSE. THE CAR HAS UNUSUALLY HIGH RPM DURING SOME GEAR SHIFTS...PARTICULARLY WHEN SHIFTING GETS "STUCK" BETWEEN 4TH & 5TH GEARS. MY CAR WAS STUCK IN THE MIDDLE OF AN INTERSECTION BECAUSE THE TRANSMISSION FROZE AND WOULDN'T SHIFT GEARS. THE CAR CANNOT ACCELERATE AT A NORMAL SPEED ANYMORE WHICH DOESN'T ALLOW FOR NORMAL HIGHWAY DRIVING, AND IS DANGEROUS DUE TO THE FACT THAT THE TRANSMISSION IS SLIPPING GEARS OR STICKING IN A GEAR. *TR
Power train, Oct 8, 2010
TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH AND ATTEMPTING A RIGHT TURN WHEN THE TRANSMISSION EXHIBITED A HESITATION AND BEGAN JERKING ABNORMALLY. THE RPM GAUGE DISPLAYED AN EXTREMELY LOW READING. THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD. AFTER WAITING A FEW MOMENTS, THE VEHICLE RESUMED AT A LOW SPEED WITHOUT EXPERIENCING THE PREVIOUS FAILURES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE COMPLETE BRAKE SYSTEM WAS REPLACED. THE FAILURE CONTINUED TO OCCUR. THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR INSPECTION. THE FAILURE WAS RELATED TO THE TRANSMISSION AND THE TECHNICIAN DETECTED THE THAT THE GEARS WERE STICKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT TRANSMISSION SHOP FOR A SECOND OPINION WHERE THEY STATED THE SAME DIAGNOSIS AS MENTIONED BY THE DEALER. THE CONTACT WAS WAITING UPON A RESPONSE FROM THE MANUFACTURER REGARDING THE TRANSMISSION FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 61,000.
Power train, Oct 1, 2010
I OWN A 2006 FORD FUSION, WHEN DRIVING ON THE HIGHWAY WHILE TRYING TO PASS ANOTHER VEHICLE, THE CAR WILL DROP OUT OF GEAR. THE CAR WILL NOT REENGAGE UNTIL THE TACHOMETER RETURNS TO AN IDLE. EVEN THEN THE CAR MAY NOT ENGAGE THE GEAR AGAIN. WITH ONCOMING TRAFFIC OR OTHER CARS BEHIND THIS CAUSES AN UNSAFE CONDITION. *TR
Power train, Sep 23, 2010
ON THE INTERSTATE AND GAVE CAR THE GAS TO GO AROUND A TRUCK AND THE CAR REVVED THE ENGINE AND THE TACHOMETER WENT ALL THE WAY DOWN. LET OFF THE GAS AND THE CAR WAS STUCK IN HIGH GEAR AND WOULD NOT SHIFT TO A LOWER GEAR. HAD TO DRIVE THE CAR THAT WAY IN STOP AND GO TRAFFIC IN ABLE TO PULL OFF THE ROAD. ONCE THE CAR WAS TURNED OFF AND RESTARTED IT RESET ITSELF AND HAD LOWER AND UPPER GEARS IN TRANSMISSION. THE CAR STILL JERKS AND DOESN'T WANT TO GO INTO DIFFERENT GEARS WHEN DRIVING. TOOK CAR TO DEALER SHOP AND WAS TOLD THAT IT HAD A TSB BULLETIN ABOUT THE TRANSMISSION VALVE BODY. THERE IS A PROBLEM WITH THIS AND THEY WOULD NOT ADMIT TO A PROBLEM WITH THE TRANSMISSION. SEARCHING THE INTERNET I AM NOT THE ONLY ONE WITH THIS PROBLEM (100'S OF PEOPLE). *TR
Power train, Sep 20, 2010
TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHEN TRAVELING AT ANY SPEED AND DOWNSHIFTING, THE VEHICLE WOULD BEGIN TO SHAKE AND VIBRATE VIOLENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED FOR THE FAILURE. THE CURRENT MILEAGE WAS 41,000 AND THE FAILURE MILEAGE WAS 38,000.
Power train, Aug 27, 2010
2006 FORD FUSION, WITH 65000 MILES, TRANSMISSION GETTING STUCK BETWEEN SECOND AND THIRD GEAR. WHEN THE TRANSMISSION IS STUCK, THE CAR WILL REV TO 5-6K RPMS AND DROP SEVERELY IN SPEED. WHEN MOVING FROM A STOP POSITION THE CARE THEN TAKES ABOUT 40-60 SECONDS TO GET UP TO 25MPH (BECAUSE IT IS STILL IN SECOND OR THIRD GEAR). THIS OCCURRED WITH ME ENTERING AN ON RAMP TO A FREEWAY AND DRIVING FROM A STOP LIGHT IN A BUSY BUSINESS DISTRICT. I TOOK THE CAR INTO THE DEALERSHIP WHERE THE CAR WAS PURCHASED AND SERVICED SINCE PURCHASE 12/31/2005. AFTER THE FIRST DAY IN THE SHOP THE DEALER TOLD ME THE TRANSMISSION IS BEYOND REPAIR AND I NEED A NEW (REBUILT) FORD TRANSMISSION. THEY WANTED $80 FREIGHT FOR DELIVERY OF TRANSMISSION AND APPROX. $4500 FRO THE TRANSMISSION AND INSTALLATION. WHEN I BOUGHT OUT MY LEASE LAST YEAR I PURCHASED AN EXTENDED WARRANTY ON MY CAR (THE ORIGINAL ENDED AT 36000 MILES). IT HAS NOW BEEN FIVE DAYS WITH MANY PHONE CALLS, A RENTAL CAR (ONLY COVERED FIVE DAYS UNDER MY WARRANTY), AND A VISIT FROM A PRIVATE INSPECTOR/ADJUSTER. THE WARRANTY COMPANY IS STILL "REVIEW THE CLAIM" AND HAS NOT YET AUTHORIZED THE REPAIR. WITHOUT AUTHORIZATION FROM THE WARRANTY CO I CAN NOT BEGIN REPAIRS. IT WILL TAKE 2-3 DAYS TO GET THE TRANSMISSION SHIPPED AND 2-3 DAYS FOR THE REPAIR. I BELIEVE FORD SHOULD BE RESPONSIBLE AND RECALL THE TRANSMISSIONS. NOT ALL OWNERS HAVE THE EXTENDED WARRANTY LIKE I DO. THE FAILING TRANSMISSIONS ARE A HUGE SAFETY DEFECT AND COULD LEAD TO EXPENSIVE REPAIRS, ACCIDENTS AND DEATH. SIMILAR COMPLAINT CAN BE FOUND ON REPAIR PAL AT: HTTP://REPAIRPAL.COM/TRANSMISSION-PROBLEM-242. *TR
Power train, Aug 24, 2010
MY 2006 FORD FUSION SEL V6 STARTED VIOLENT JERKING WHILE DRIVING. I AM AFRAID TO DRIVE IT BECAUSE I HAVE ALMOST REAR ENDED ANOTHER CAR WHEN ACCELERATING AND THE JERKING HAPPENED. MY HUSBAND THINKS IT IS THE TRANSMISSION BUT IT IS OUT OF WARRANTY AND WE DON'T HAVE THE MONEY TO REPAIR IT. IT SEEMS LIKE THERE ARE MANY OTHER OWNERS OUT THERE (DUE TO THE MASS FORUMS AND THE TSB'S) THAT ARE EXPERIENCING THE SAME PROBLEM. FORD IS DOING NOTHING ABOUT IT EVEN THOUGH THERE ARE PLENTY OF DOCUMENTATIONS THAT IT IS AN ONGOING SITUATION. IT OCCURS EVERYTIME THE VEHICLE IS DRIVEN. I DON'T FEEL SELLING IT TO SOMEONE ELSE IS THE ETHICAL SOLUTION. FOR SHOULD BACK/STAND BEHIND THERE PRODUCT. NOT RUN FROM THE PROBLEM. PEOPLE COULD BE SERIOUSLY HURT, IN FACT, I WOULDN'T BE SURPRISED IF THERE AREN'T REPORTED INJURIES. *TR
Power train, Aug 16, 2010
06 FORD FUSION TRANSMISSION SLIPS OUT OF GEAR AROUND 25-35 MPH. THIS HAPPENED ON THE HIGHWAY RESULTING IN 4 CARS ALMOST HITTING US & ALMOST CAUSING 2 OTHER ACCIDENTS. IT HAS BEEN GETTING PROGRESSIVELY WORSE FOR A MONTH NOW. IT'S @ THE DEALERSHIP NOW ,THEY SAID THERE IS NOTHING WRONG WITH IT @ 1ST,NOW THEY SAY THEY HAVE DUPLICATED THE PROBLEM & I NEED A NEW TRANSMISSION $4700. THE CAR HAS 54K MILES ON IT. I HAVE READ NUMEROUS OTHER COMPLAINTS ONLINE @REPAIRPAL.COM. SOMETHING NEEDS TO BE DONE,THIS IS A VERY HAZARDOUS PROBLEM. *TR
Power train, Aug 11, 2010
TL*THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT A PLASTIC PIECE OVER THE BUTTON ON THE GEAR SHIFT BROKE INSIDE THE SHIFTER. THE BROKEN PIECE CAUSED THE VEHICLE NOT TO ACKNOWLEDGE THAT THE VEHICLE WAS IS IN PARK AND CAUSED THE KEY TO BECOME STUCK IN THE IGNITION. THE DEALER STATED THAT THE ENTIRE GEAR SHIFT NEEDED TO BE REPLACED. THE CONTACT WAS CONCERNED ABOUT NUMEROUS COMPLAINTS REGARDING THE GEAR SHIFT AND THE KEY FOR HIS YEAR, MAKE AND MODEL VEHICLE. THE CONTACT STATED THAT THIS WAS A SAFETY CONCERN SINCE IT MAY BE DIFFICULT TO DETECT THAT THE BROKEN PIECES WERE DAMAGING THE GEAR SHIFT. THE FAILURE MILEAGE WAS 40,000. UPDATED 11/05/10. *LJ
Power train, Vehicle speed control, Aug 10, 2010
AUTOMATIC TRANSMISSION SLIPS OUT OF GEAR WHEN GOING UP A HILL OR WHEN PASSING ANOTHER VEHICLE. THE CAR MAKE A ROUGH NOISE AND YOU HAVE TO BRAKE IN ORDER TO GET THE CAR TO CHANGE GEARS. WHEN THE CRUISE CONTROL WAS SET AT 65 MPH THE CAR APPROACHED A SMALL HILL AND THE GEAR WOULD NOT CHANGE AND MADE A AWFUL NOISE. I TOOK THE CAR TO A FORD DEALERSHIP FOR DIAGNOSTIC CHECK AND IT REVEALED THAT I NEED A TRANSMISSION. THE COST WAS QUOTED AT 4900.00. THIS STARTED APPROX 2 MONTHS AGO AND IS STILL HAPPENING. *TR
Power train, Aug 10, 2010
AUTOMATIC TRANSMISSION SLIPS OUT OF GEAR DURING ACCELERATION. WHEN DOWNSHIFTING IT SLIPS AND SOMETIMES SLAMS ITSELF INTO GEAR. STARTING FROM A STOP SOMETIMES THE TRANSMISSION DOESN'T SEEM TO KNOW WHICH GEAR TO START IN AND SLAMS INTO 1ST. THE MOST FREQUENT PROBLEM IS THAT OF THE TRANSMISSION DROPPING OUT OF GEAR UPON ACCELERATION OR TRYING TO TOP A GRADE. IF YOU ARE NOT CAREFUL THE RPMS WILL REACH 5000+ RPMS. THIS ISSUE BEGAN AROUND 50K MILES. FORD DEALERSHIP IN STERLING HEIGHTS MICHIGAN CHECKED THE TRANSMISSION IN APPROX MAY OF 2008 AND THEY ONLY OFFERED A COMPLETE TRANSMISSION REPLACEMENT AT A COST OF 4K+, THEY COULD NOT DETERMINE WHAT THE PROBLEM WAS. *TR
Power train, Aug 9, 2010
TRANSMISSION FAILS TO RESPOND MOSTLY DURING SHIFTS IN THE RANGE FROM 2ND TO 5TH GEAR. THE CAR FAILS TO ACCELERATE, TRANSMISSION/ENGINE WINDS AND BECOME USELESS UNTIL YOU LET THE CAR RETURN TO FIRST GEAR. THIS DOESN'T ALLOW FOR PROPER PASSING MANEUVERS. THE TRANSMISSION ALSO CLANKS WHEN DOWNSHIFTING. *TR
Power train, Aug 4, 2010
PURCHASED 2006 FORD FUSION SEL 6 CYL., WITH ROUGHLY 48K ON IT AND CURRENTLY HAVE 62K ON IT NOW, IN/AROUND OCTOBER OF 2009, AND ABOUT 3 MONTHS AGO STARTING HAVING TRANSMISSION PROBLEMS. UPON ACCELERATING BETWEEN 25-40, THE TRANSMISSION JUMPS IN AND OUT OF GEAR, OFTEN MAKING A LOUD BANGING NOISE AND TAKING AWAY ALL ACCELERATION. IN ORDER FOR IT TO GET BACK INTO GEAR, YOU HAVE TO COMPLETELY LET OF THE GAS AND IT WILL EVENTUALLY GO BACK INTO GEAR. THIS ALLOWS FOR MINIMAL ACCELERATOR AT BEST WHEN TRYING TO SPEED UP. THIS FAILURE OCCURS RANDOMLY EVERYTIME I DRIVE THE VEHICLE. IF NOT FIXED, THE TRANSMISSION IN MY CAR WILL EVENTUALLY GO BAD. I TOOK IT IN TO ADVANCED AUTOMOTIVE IN ANN ARBOR TO HAVE IT FIXED. THEY TOLD ME, AFTER DOING EXTENSIVE RESEARCH DUE TO NO CODES SHOWING UP ON THE COMPUTER, THAT ON THE FORD BULLETIN IT WAS GOING TO NEED A NEW VALVE BODY, TRANSMISSION FLUSH, AND REPROGRAMMING. THIS IS GOING TO COST ROUGHLY $2200. THE VALVE BODY, FROM FORD, WAS $1400. *TR
Power train, Jul 30, 2010
TL*THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THEY WERE UNABLE TO REMOVE THE KEY OUT OF THE IGNITION. THE RING AROUND DRIVE SHIFT WAS BROKEN AND GAVE THE APPEARANCE THAT THE VEHICLE WAS IN PARK WHEN IT WASN'T WHICH ALSO MADE IT IMPOSSIBLE TO REMOVE THE KEY FROM THE IGNITION. WHEN THE BROKEN RING WAS REMOVED, THE CONTACT WAS ABLE TO REMOVE THE KEY FROM THE IGNITION; HOWEVER, THE TRANSMISSION CONTINUED TO MALFUNCTION. THE VEHICLE HAD NOT BEEN INSPECTED AT THE TIME OF THE COMPLAINT. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 50000.