2011 Ford Fusion
Problems, recalls and owner-reported issues
Steering is the leading concern among 2,786 owner complaints filed for this model year. This is the 2nd highest complaint count among 15 Fusion model years with reports.
Of the 2011 reports, 80 involved a crash and 10 involved a fire. 46 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleMar 10, 2021
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.
Campaign 21V158000 on NHTSA.gov
Air bags, frontalFeb 16, 2021
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Campaign 21V081000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleFeb 16, 2021
Ford Motor Company (Ford) is recalling certain air bag inflator and/or module replacement service parts that may have been used as part of a collision repair. The parts include certain driver-side air bag inflators and/or modules, designed to fit 2005-2014 Ford Mustang and Mustang GT500. It also includes certain passenger-side air bag inflators and/or modules designed to fit 2005-2014 Ford Mustang, 2010-2012 Lincoln MKZ, 2010-2012 Ford Fusion, 2010-2011 Mercury Milan, 2007-2011 Ford Ranger, and 2007-2010 Lincoln MKX vehicles. Please see Ford's recall report for the specific part numbers. These parts may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Ford will notify dealers that purchased the affected parts, and dealers will provide replacement parts to purchasers, free of charge. The recall began March 18, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Campaign 21E013000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleDo not drive until repairedJan 7, 2019
Ford Motor Company (Ford) is recalling certain 2014 Ford Mustang vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Ford is recalling certain 2011 Ford Ranger and Mercury Milan vehicles, 2011-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles and 2011-2014 Ford Mustang vehicles sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Ford is also recalling certain 2010 Ford Edge and Lincoln MKX vehicles, 2010-2011 Ford Ranger and Mercury Milan vehicles, 2010-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles, and 2010-2014 Ford Mustang vehicles sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 13, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall 19S01.
Campaign 19V001000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleDo not drive until repairedMay 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
Campaign 16V384000 on NHTSA.gov
Fuel system, gasoline, storage, auxillary tankNov 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2010-2011 Ford Fusion vehicles manufactured July 21, 2008, to March 4, 2011, and 2010-2011 Mercury Milan vehicles manufactured July 23, 2008, to December 10, 2010. The affected vehicles have fuel vapor canisters whose purge valves may not operate properly resulting in abnormal pressure changes in the fuel tank.
The pressure changes may cause the tank to crack and leak fuel. A fuel leak in the presence of an ignition source increases the risk of a fire.
Ford will notify owners, and dealers will update the vehicle powertrain control modules and inspect the vehicle for any diagnostic trouble codes (DTCs) for this issue and perform a leak test on the Canister Purge Valve (CPV). The fuel tank will be inspected for cracks. The CPV and fuel tank will be replaced as necessary. These repairs will be performed free of charge. The recall began on January 15, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S34.
Campaign 15V793000 on NHTSA.gov
Steering, electric power assist systemJun 2, 2015
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.
Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S18.
Campaign 15V340000 on NHTSA.gov
EquipmentMay 29, 2014
Ford Motor Company (Ford) is recalling certain all weather driver side accessory floor mats sold for use in model year 2006-2011 Ford Fusion and Mercury Milan, 2006 Lincoln Zephyr, and 2007-2011 Lincoln MKZ vehicles manufactured November 9, 2007, through October 31, 2010. The affected floor mats may move and possibly interfere with the accelerator pedal.
The floor mat could shift such that it could interfere with the accelerator pedal, preventing its return to an idle position, which could result in unintended vehicle speeds, increasing the risk of a crash.
Ford will notify owners, and dealers will install new replacement mats, free of charge. The recall began in July 2014. Owners may contact Ford's customer service at 1-800-392-3673. Ford's number for this recall is 14S07. NOTE: Vehicles built after October 31, 2010, while potentially equipped with the same floor mats, are equipped with a Brake Over Accelerator (BOA) feature that prevents simultaneous accelerator and brake application, allowing the vehicle to be safely stopped by pressing firmly and steadily on the brake pedal.
Campaign 14E028000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsDec 7, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2010-2011 FORD FUSION AND MERCURY MILAN VEHICLES EQUIPPED WITH 17 INCH STEEL WHEELS AND BUILT FROM APRIL 1, 2009, THROUGH APRIL 30, 2009, AND FROM DECEMBER 1, 2009, THROUGH NOVEMBER 13, 2010. THE WHEEL STUDS MAY FRACTURE, POTENTIALLY CAUSING A WHEEL TO SEPARATE.
WHILE DRIVING, MULTIPLE STUD FRACTURES COULD OCCUR AT THE WHEEL LOCATION, AND THE OPERATOR MAY EXPERIENCE VEHICLE VIBRATION AND/OR WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.
FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE REAR BRAKE DISC SURFACE FOR FLATNESS AND REPLACE THE DISCS AS NECESSARY. ADDITIONALLY, THE WHEEL LUG NUTS WILL BE REPLACED ON ALL FOUR WHEELS. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JANUARY 24, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V574000 on NHTSA.gov
Representative owner complaints: fuel/propulsion system
176 reports, newest first. Show all
Vehicle speed control, Engine, Fuel/propulsion system, Sep 19, 2013
I WAS DRIVING HOME GOING 45 MPH WHEN MY CAR STALLED WITHOUT WARNING. WHEN I TRIED TO GIVE IT GAS, IT STARTED JUMPING AND JERKING THE WRENCH LIGHT CAME ON. I WAS ABLE INCH BY INCH TO MOVE MY CAR TO THE ADJACENT TURNING LANE, TURN ON MY FLASHERS AND CALL MY HUSBAND ON MY CELL PHONE. HE WAS ON HIS WAY HOME ALSO AND PULLED UP BEHIND ME. HE TRIED TO GIVE IT GAS TOO BUT IT WOULD NOT BUDGE. HE TURNED THE IGNITION OFF AND THEN CRANKED THE CAR. THE WRENCH LIGHT WENT OFF AND THE CAR HAD POWER - JUST LIKE TURNING IT OFF HAD RESET SOMETHING. WE WERE ONLY A COUPLE OF MILES FROM OUR HOUSE, SO HE DROVE BY 2011 FORD FUSION HOME AND I FOLLOWED IN HIS TRUCK. I THEN CALLED MY DEALER, JIM TIDWELL FORD ON BARRETT PARKWAY AND TOLD THEM WHAT HAD HAPPENED. THEY SUGGESTED THAT I CALL A WRECKER AND HAVE IT TOWED TO THEIR LOCATION AS DRIVING THE CAR MIGHT DUE FURTHER DAMAGE OR THE INCIDENT MIGHT RE-OCCUR. SO, THAT'S WHAT I DID. A SERVICE TECHNICIAN CALLED ME FIRST THING THIS MORNING AND I WENT OVER WHAT HAD HAPPENED WITH HIM. HE CALLED ME THIS AFTERNOON AND SAID MY CAR WAS READY FOR PICK UP. THE PROBLEM WAS THE THROTTLE BODY AND MOTOR ASSEMBLY AND SINCE IT WAS UNDER WARRANTY THERE WOULD BE NO CHARGE TO ME. I CAN'T BELIEVE FORD ISN'T DECLARING A RECALL ON THIS PART. IF I HAD BEEN ON THE EXPRESSWAY, I FEEL CERTAIN I WOULD HAVE BEEN REAR ENDED. THIS PROBLEM WILL CAUSE SOMEONE TO GET KILLED. I'M JUST LUCKY NO ONE HIT ME. IT HAPPENED SO SUDDENLY AND WITHOUT WARNING. THIS TYPE OF SITUATION WILL MAKE YOU FALL OUT OF LOVE WITH YOUR FORD PRODUCT. I DON'T BELIEVE I WILL EVER BUY A FORD PRODUCT AGAIN, EVEN THOUGH I PREFER TO BUY AMERICAN PRODUCTS. *TR
Power train, Electrical system, Fuel/propulsion system, Sep 18, 2013
ON SEPTEMBER 15, 2013 I WAS DRIVING ON A MAJOR SURFACE STREET AT APPROXIMATELY 35 MILES PER HOUR WHEN THE CAR JUST STOPPED WORKING. COMPLETELY POWERLESS. I SAW TWO LIGHTS ON THE DASHBOARD: THE BATTERY AND THE OIL. THERE MAY HAVE BEEN MORE BUT I WAS MORE FOCUSED ON SAFETY AND ONCOMING TRAFFIC THAN THE LIGHTS ON THE DASH. I DECIDED NOT TO TAKE A CHANCE OF GETTING REAR ENDED (INJURED OR KILLED) SO AT THE FIRST BIG BREAK IN TRAFFIC I SAFELY EXITED THE VEHICLE AND WALKED OVER TO THE SIDEWALK (ONE LANE OVER). A LOCAL APARTMENT RESIDENT SAW THE INCIDENT AND GRABBED A SAFETY CONE TO PUT BEHIND MY CAR AS A WARNING. THANKFULLY THERE WERE NO ACCIDENTS BUT THERE WERE SOME CLOSE CALLS AND LAST MINUTE LANE CHANGES AS DRIVERS CAME UPON MY CAR. I CALLED FORD ROADSIDE ASSISTANCE AND THEY SENT A TOW TRUCK TO GET THE VEHICLE. IT STARTED UP PERFECTLY FOR THE DRIVER, BUT I HAD IT TOWED ANYWAY. IT HAS BEEN AT THE DEALER FOR TWO DAYS. THEY HAVE BEEN UNABLE TO DUPLICATE THE SITUATION AND HAVE RECEIVED NO "CODES" TO INDICATE A PROBLEM WITH THE VEHICLE. THEY HAVE CALLED FORD TO ASK FOR ASSISTANCE AND FORD HAS ASKED THEM QUESTIONS REGARDING LIGHTS GOING ON, MY SPEED AT THE TIME OF THE INCIDENT, HOW FAR I HAD BEEN DRIVING THE CAR BEFORE THE INCIDENT, ETC. THIS IS THE SECOND TIME I HAVE HAD A PROBLEM WITH MY 2011 FUSION COMPLETELY FAILING. THE FIRST TIME WAS IN SEPTEMBER 2012 WHEN THE THROTTLE FAILED ON THE FREEWAY. IT WAS SUPPOSEDLY FIXED. THIS TIME THE LOST OF POWER DID NOT FEEL LIKE THE THROTTLE. IT JUST STOPPED WORKING. HAD POWER. DIDN'T HAVE POWER. I AM EXTREMELY CONCERNED THAT THE DEALER WILL FIND NOTHING WRONG WITH THE VEHICLE AND IT WILL BE RETURNED TO ME IN AN UNSAFE CONDITION. OTHERS HAVE REPORTED THIS AND SIMILAR ISSUES. PLEASE GET THESE VEHICLES RECALLED BEFORE SOMEONE LOSES A LIFE.
Power train, Engine, Fuel/propulsion system, Sep 18, 2013
WHILE DRIVING IN THE CENTER LANE ON THE SOUTHBOUND I-5 FREEWAY MY 2011 FORD FUSION BEGAN TO FEEL LIKE IT WAS DRIVING THROUGH MUD AND LOST ACCELERATION. WHEN I ATTEMPTED TO COMPENSATE BY ACCELERATING THE CAR, IT RESISTED AND CONTINUED TO SLOW SIGNIFICANTLY. THANKFULLY TRAFFIC WAS NOT EXTREMELY HEAVY AT THE TIME AND I WAS CLOSE TO A FREEWAY EXIT. I PULLED TO THE RIGHT, AVOIDING ONCOMING TRAFFIC (BARELY) AND COASTED DOWN THE OFF RAMP. BY THE TIME I GOT TO THE OFF RAMP (ABOUT 10 SECONDS) THE CAR HAD GONE FROM 65 MPH TO LESS THAN 5 MPH. IF IT WASN'T FOR THE MOMENTUM OF THE VEHICLE I WOULD NOT HAVE BEEN ABLE TO MAKE IT AND WOULD HAVE BEEN AT A DEAD STOP IN THE MIDDLE OF THE FREEWAY WITH ONCOMING TRAFFIC (AND SEMI TRUCKS) GOING BETWEEN 60 AND 75 MPH. THE ENGINE WAS THROBBING, THE CAR WAS SHAKING, AND I HAD NO ACCELERATION CAPABILITY AT ALL. I HAD ENOUGH MOMENTUM ON THE OFF RAMP DOWNSLOPE TO TURN RIGHT AND STOP MY VEHICLE AT THE SIDE OF THE ROAD. I CALLED A TOW TRUCK AND THE CAR WAS TAKEN TO A DEALERSHIP FOR REPAIRS. I WAS TOLD THE THROTTLE WAS THE PROBLEM AND IT WAS REPLACED UNDER WARRANTY. HAD TIMING NOT BEEN EXACTLY RIGHT, THIS PROBLEM COULD HAVE CAUSED A VERY SERIOUS OR EVEN DEADLY ACCIDENT FOR ME AND FOR OTHER DRIVERS ON THE ROAD. I HAVE SINCE LEARNED ABOUT THIS ONGOING ISSUE ONLINE AND WISH I WOULD HAVE KNOWN AT THE TIME THAT IT WAS A PROBLEM AND KNOWN HOW / THAT I COULD SUBMIT A CONCERN TO THE NHTSA.
Power train, Fuel/propulsion system, Sep 16, 2013
I WAS DRIVING 35MPH WHEN THE VEHICLE LURCHED A COUPLE OF TIMES AND DECELERATED ON ITS OWN TO 2MPH. NO MATTER HOW MUCH I PRESSED ON THE GAS OR LET OFF ON THE GAS, THE VEHICLE STAYED AT 2MPH. THE "WRENCH" ICON ILLUMINATED ON THE DASH. THE ENGINE STAYED MID-WAY BETWEEN HOT AND COLD, BUT THE RPM'S NEVER GOT ABOVE 1 & 1/2. TOOK THE CAR TO A DEALER AND FOUND OUT THAT THE THROTTLE BODY IS GOING OUT. I WAS SO THANKFUL I WAS NOT DRIVING ON THE INTERSTATE AT 70MPH (OR TURNING INTO TRAFFIC) WHEN THE DECELERATION SUDDENLY OCCURRED. I WAS POWERLESS. *TR
Electrical system, Vehicle speed control, Fuel/propulsion system, Sep 14, 2013
CAR DIES WHILE DRIVING, SURGES AT TIMES, HAD BEEN HAPPENING ON AND OFF. DIED PART WAY THROUGH A LARGE INTERSECTION ON 7-13-13, LUCKILY I JUST AVOIDED A COLLISION. IT WOULD START AND GO A FEW FEET, THEN SURGE AND DIE. CALLED CRATER LAKE FORD IN MEDFORD, OR, THEY STATED VERY BUSY THAT DAY AND HAD NOT HEARD OF THE SYMPTOMS I DESCRIBED. PLACED A CALL TO DAVE'S IMPORT SERVICE THEY SAID THEY WOULD LOOK AT THE CAR. WITHIN 45 MIN THEY HAD DIAGNOSED FAILED THROTTLE BODY. *TR
Electrical system, Vehicle speed control, Engine, Fuel/propulsion system, Sep 12, 2013
I HAVE BEEN SENSING A SURGE IN ENGINE POWER FOR SEVERAL MONTHS IN MY 2011 FUSION. I SUSPECTED A THROTTLE BODY PROBLEM AND GOOGLED FOR INFORMATION. I FOUND ALL OF THE INFORMATION ON THE NHTSA WEBSITE ABOUT THROTTLE BODY PROBLEMS FOR THIS CAR AS WELL AS INFORMATION IN OTHER FORUMS. IT WAS A GOOD THING AS I WAS PREPARED FOR WHAT HAPPENED TODAY. I HAD JUST LEFT MY HOUSE WHEN THE DREADED (AND EXPECTED) LOSS OF ENGINE POWER WITH THE WRENCH LIGHT BEING ILLUMINATED. I EXPERIENCED THE SAME SYMPTOMS REPORTED BY SO MANY COMPLAINTS LOGGED FOR THIS ISSUE: LOSS OF POWER, ROUGH IDLE, JUST ENOUGH POWER TO BARELY MOVE THE CAR, CERTAINLY NOT ENOUGH TO LIMP ANYWHERE, MUCH LESS HOME, EVEN THOUGH THE ENGINE WAS IN "LIMP HOME" MODE. I HAD MY CODE SCANNER WITH ME AND WAS ABLE TO RETRIEVE THE P2111 (THROTTLE STUCK OPEN) CODE BEFORE I RESTARTED THE CAR TO RESTORE FULL POWER. THIS ONLY WORKED ENOUGH TO GET THE CAR TURNED AROUND WHEN LIMP HOME WAS TRIGGERED AGAIN. I RESTARTED AGAIN AND WAS ABLE TO GET WITHIN A BLOCK OF MY HOUSE WHEN LIMP HOME TRIGGERED ONCE MORE. THE THIRD TIME I WAS ABLE TO GET TO MY HOUSE. I CALLED THE DEALER AND THEN ROADSIDE ASSISTANCE TO GET MY CAR TOWED TO THE LOCAL FORD DEALER AFTER VERIFYING THAT THEY HAD A THROTTLE BODY IN STOCK. THE CAR WAS TOWED THERE AND A DEFECTIVE THROTTLE BODY WAS DIAGNOSED AND REPLACED. THIS IS NOT A CASE OF IF THE FAILURE WILL HAPPEN, BUT RATHER WHEN. I WAS FULLY EXPECTING IT ANY DAY AND SURE ENOUGH, IT HAPPENED. I WAS EXTREMELY FORTUNATE AS I WAS LESS THAN A MILE FROM HOME, KNEW WHAT TO EXPECT AND HOW TO DEAL WITH IT, AND MY CAR WAS STILL IN WARRANTY, BUT ONLY BY 1,806 MILES! ANY OTHER SITUATION WOULD HAVE RESULTED IN ME BEING IN A VERY DANGEROUS PREDICAMENT WITH A CAR THAT WAS BASICALLY DEAD IN THE WATER. I WAS ALMOST TO THE POINT OF PURCHASING A NEW THROTTLE BODY ON MY OWN IN THE INTEREST OF BEING PROACTIVE RATHER THAN BEING STRANDED. *TR
Power train, Fuel/propulsion system, Sep 10, 2013
VEHICLE STALLED OUT DURING HIGHWAY SPEEDS. TOOK CAR TO FORD AND THEY SAID IT WAS THE THROTTLE BODY AND IT WAS NOT COVERED UNDER WARRANTY. *TR
Vehicle speed control, Engine, Fuel/propulsion system, Sep 9, 2013
MY 11 FUSION DIED IN GEAR (LEMP MODE THEY CALL IT) IN THE MIDDLE OF AN INTERSECTION WHERE I WAS ALMOST HIT AND STOPPED TRAFFIC FOR A GOOD AMOUNT OF TIME DUE TO IT BEING IN GEAR AND UNABLE TO MOVE. AFTER BEING TOWED TO A DEALER AND BEING TOLD IT WAS MY BATTERY; I LEFT THE DEALER PAYING FOR THE TOW, DIAGNOSTIC AND A BATTERY. I WENT BACK A WEEK LATER FOR AN OIL CHANGE AND WAS TOLD MY CAR WAS IN GOOD RUNNING CONDITION. AROUND THE CORNER FROM THE DEALERSHIP IS THE ON RAMP TO GO HOME. AS I WAS ACCELERATING UP THE ON RAMP TO HIGHWAY SPEED IT WENT INTO LEMP MODE AGAIN LEAVING ME WITH NO POWER ENTERING ONTO THE HIGHWAY. THANK GOD THE SEMI AND OTHER VEHICLES BEHIND ME WERE PAYING ATTENTION AND AVOIDED REAR ENDING ME AT HIGH SPEED. I WAS AGAIN TOWED AROUND THE BLOCK FROM TO THE DEALER WHERE THEY HAVE INFORMED ME THAT IT IS MY THROTTLE BODY POSITION SENSOR AND IS NOT COVERED UNDER MY EXTENDED WARRANTY, OR THE FEDERAL EMISSIONS WARRANTY. $600.00 LATER; I AM TRADING THIS CAR IN BECAUSE IT IS NOT SAFE TO BE DRIVING WITH THIS POSSIBILITY OF LOSING ALL POWER AT A CRITICAL TIME. SOME ONE NEEDS TO HAVE THEM ACCOUNT FOR THIS ERROR AND GET THESE CARS OFF THE ROAD. I WAS CLOSE TO BEING KILLED BECAUSE OF THIS AND SOONER OR LATER THIS WILL CAUSE A DEATH. *TR
Vehicle speed control, Fuel/propulsion system, Sep 9, 2013
WHILE DRIVING AT LOW SPEED, THE VEHICLE SLOWED AND STOPPED, REQUIRING ME TO PULL OFF THE ROAD. THE ENGINE REMAINED RUNNING, BUT AT A VERY LOW RPM - APPLYING GAS DID NOTHING TO REV THE ENGINE. AFTER TURNING THE VEHICLE OFF, I WAS ABLE TO RESTART IT AND LIMP IT HOME. THE NEXT TIME I DROVE IT, APPROXIMATELY 3 DAYS LATER, IT ACTED SIMILARLY, THREATENING TO CUT OFF WHEN NOT APPLYING GAS. I TOOK IT TO THE FORD DEALER FOR DIAGNOSIS AND WAS IMMEDIATELY TOLD THIS WAS PROBABLY A "THROTTLE BODY" PROBLEM. THE DEALER CONFIRMED THIS THE NEXT DAY AND PLACED AN ORDER FOR THE PART. THE PART IS ON BACK ORDER, I SUPPOSE DUE TO THE DEMAND FOR CORRECTION ON THIS PART. I LEFT THE VEHICLE WITH THE DEALER FOR THE 5-7 BUSINESS DAYS NEEDED TO GET THE PART AS I WAS NOT COMFORTABLE DRIVING THE VEHICLE WITHOUT THE REPAIR. THANKFULLY IT IS STILL UNDER WARRANTY. I UNDERSTAND THIS IS A $500+ PART. *TR
Fuel/propulsion system, Sep 8, 2013
CAR BEGAN ON MULTIPLE OCCASIONS ACTING LIKE IT WAS EITHER NOT GETTING POWER OR FUEL. TAKEN TO A FORD DEALER IN 04/2103 AND THEY DISREGARDED THE SYMPTONS I WAS DESCRIBING AND SAID NOTHING WAS WRONG (STILL UNDER WARRANTY THEN). BY AUGUST 2013 IT WAS HAVING INCIDENTS OF SHUDDERING, LOSING POWER AND WOULD HAVE TO BE TURNED OFF. BY 09/03/2013, IT WAS UNDRIVEABLE. A COMPLAINT WAS FILED WITH FORD IN MID AUGUST. CAR WAS OUT OF WARRANTY AND QUOTED REPAIR WAS $871. FORD AGREED TO REPAIR AT 50% AND WORK WAS COMPLETED ON 09/06/2103.
Fuel/propulsion system, Sep 7, 2013
DRIVING AT 35 MPH LOST ACCELERATION, ENGINE IDLES BUT WHEN GAS PEDDLE IS PUSHED TO THE FLOOR NO POWER. CALLED DEALERSHIP AND WITHOUT HESITATION I WAS TOLD IT WAS THE THROTTLE BODY AND THAT IT WAS A VERY COMMON PROBLEM. CANT BELIEVE THIS IS NOT A SAFETY RECALL. VERY DANGEROUS AND SCARY!!!! AND OF COURSE CAR IS NO LONGER UNDER WARRANTY. I TRULY HOPE THIS DOES NOT HAPPEN TO SOMEONE DRIVING DOWN A HIGHWAY IN HEAVY TRAFFIC. FORD REALLY, REALLY NEEDS TO CONSIDER A RECALL, PUT MONEY ON IT THERE WILL BE MULTIPLE INCIDENTS IN THE VERY NEAR FUTURE. I HAVE ALSO HEARD THAT FORD IS AWARE OF THE PROBLEM AND CHANGED THE PART NUMBER BUT ARE NOT RECALLING THE ORIGINAL PART.
Fuel/propulsion system, Sep 2, 2013
I AM WRITING IN REGARDS TO AN ISSUE WITH MY 2011 FORD FUSION. ON AUGUST 21, 2013 I WAS DRIVING AT 70 MPH ON A BUSY HWY WHEN IT FELT AS IF MY CAR HAD COMPLETELY SHUT OFF. I HAD ABSOLUTELY NO ACCELERATOR. I FOUND MYSELF COASTING IN TRAFFIC. I MANAGED TO PUT ON THE HAZARDS AND MERGE TO THE SHOULDER WITHOUT BEING HIT, THANKFULLY. ONCE OVER I SHUT OFF THE CAR AND AFTER A MINUTE STARTED IT BACK UP AND IT WAS AS IF NOTHING HAD HAPPENED. THINKING THIS WAS SOME KIND OF FLUKE WE CONTINUED TO DRIVE THE CAR. IT HAPPENED AGAIN 3 DAYS LATER, AGAIN IN VERY HEAVY TRAFFIC ON A MAIN HIGHWAY AT 65 MPH. AGAIN WE WERE FORTUNATE ENOUGH TO BE ABLE TO PULL OFF WITHOUT BEING HIT. INTERNET RESEARCH SHOWED THAT THIS WAS A VERY COMMON PROBLEM WITH THIS CAR AND THE DEALER KNEW EXACTLY WHAT WAS WRONG WITH IT UPON HEARING OUR STORY. A DEFECTIVE THROTTLE BODY. HE SAID OURS WAS THE THIRD ONE BEING DROPPED OFF THAT SAME DAY FOR THE SAME PROBLEM. WE WERE VERY DISAPPOINTED TO HEAR THAT THERE IS NO RECALL ON THIS PART CONSIDERING HOW DANGEROUS THE SITUATION IS. THERE HAVE BEEN NUMEROUS ACCIDENTS DUE TO THIS DEFECTIVE PART, YET STILL NO RECALL. EVEN WORSE IS THAT FORD ISN'T EVEN COVERING THE COST OF REPLACING IT UNDER THE ENGINE WARRANTY, WE HAD TO PAY FOR IT. DOES SOMEONE ACTUALLY HAVE TO DIE IN ONE OF THESE ACCIDENTS BEFORE A RECALL IS DONE?? *JS
Fuel/propulsion system, Aug 30, 2013
I WAS SITTING AT A DRIVE UP WINDOW AND MY RPMS WENT WAY UP AND THE CAR DIED AND WHEN I'M DRIVING I HAVE A LOST OF POWER LIKE IT TRYED TO DIE THEN RECOVERED I,M BEING TOLD THIS IS THE (FUEL INJECTION THROTTLE BODIES) THIS IS BE COMING A BIG PROBLEM WHERE IT STARTING TO DIE MORE I DON'T WANT MY WIFE TO GET IN TO A WRECK AND GET HURT SO I'M GOING TO REPLACE THE THROTTLE BODIE BUT I THINK THIS SHOULD BE A RECALL ASAP, THIS IS A VERY HIGH PRICED PART I WOULD LIKE A REFUND
Fuel/propulsion system, Aug 30, 2013
I WAS DRIVING ON MY WAY TO WORK, DRIVING ABOUT 55-60 MPH AND ALL OF A SUDDEN THE CAR JERKED AND THE THROTTLE WENT OFF AND THE WRENCH LIGHT CAME ON. EVERYTHING STILL WORKED IN THE CAR BUT WHEN I PRESSED ON THE GAS, NOTHING HAPPENED. LUCKILY I WAS NEAR A TURN OFF AND I WAS ABLE TO COAST ONTO THE ROAD AND PULL OFF. I TURNED MY CAR OFF AND BACK ON, AND WAS ABLE TO DRIVE TO A LOCAL DEALERSHIP. THEY KNEW IMMEDIATELY WHAT THE PROBLEM WAS AND SAID THEY COULD ORDER THE PART BUT IT WOULD BE FEW DAYS. IN THE MEAN TIME I AM JUST SUPPOSED TO PULL OVER AND TURN MY CAR OFF AND ON IF IT HAPPENS AGAIN. I HAVE AN HOUR COMMUTE TO WORK IN THE MORNING DRIVING IN SEVERAL LANE INTERSTATE TRAFFIC AND THIS COULD BE REALLY SCARY IF IT WERE TO HAPPEN THEN. ESPECIALLY WITH ALL OF THE SEMI TRUCKS THAT I AM TRAVELING WITH AT HIGH SPEEDS. IT IS ALSO OUR FAMILY CAR SO I AM SCARED TO DRIVE WITH MY FAMILY IN THE CAR.
Power train, Fuel/propulsion system, Aug 29, 2013
WHILE DRIVING THE CAR SHUDDERED, LOST POWER, HAD NO GAS PEDDLE RESPONSE AND RAN VERY ROUGH. PUT CAR IN PARK AND SHUT OFF. TURNED IGNITION, CAR TURNED OVER FOR 10-15 SECONDS AS IF STARVING FOR FUEL. FINALLY CAUGHT AND RAN FOR ABOUT 2 MILES, THEN HAPPENED AGAIN. IN A SPAN OF 4 MILES IT DID THIS THREE TIMES. A FEW DAYS LATER IT DID THE SAME THING 3 TIMES IN A MATTER OF ABOUT 10 MILES. THAT TIME WAS ON THE HIGHWAY DOING 65 MPH.
Vehicle speed control, Engine, Fuel/propulsion system, Aug 27, 2013
MY 2011 FORD FUSION, WHICH I PURCHASED ONLY A FEW MONTHS AGO... LOST SPEED WHILE DRIVING HOME FROM WORK TODAY. I'M STILL SHAKY AND UPSET. I WAS A VERY BUSY 2LANE UP/2LANE DOWN AVENUE WHEN MY VEHICLE LOST SPEED! I WAS IN THE INNER LANE AND HAD TO DECIDE IF I WANTED THE DELIVERY TRUCK TO HIT ME FROM BEHIND OR RISK SIDE SWIPING SOMEONE IN HOPE OF GETTING OFF THE ROAD BEFORE I SLOWED COMPLETED. THROUGH THE GRACE OF GOD I WAS ABLE TO MAKE TWO HARD RIGHTS BEFORE MY FUSION BEGAN TO STOP, SHAKE, AND SPUTTER. THE FIRST HARD RIGHT WAS INTO THE RIGHT LANE IN FRONT OF ANOTHER CAR THEN ONTO THE SIDE STREET. MY GOODNESS NEVER BEEN SO SCARED IN LIFE EXCEPT THE NEXT TWO TIME IT DID WHILE STILL TRYING TO MAKE IT HOME. THIS TIME THOUGH, I KNEW TO STAY IN THE LEFT LANE. I ALSO RELIED ON THE FACT THAT ONCE YOU GET TO A SAFE PLACE AND TURN THE ENGINE OFF AND ON AGAIN IT STARTS BACK UP!!! I'M SCARED OF MY CAR! AND SCARED FOR MY LIFE AND OTHERS THAT THIS VEHICLE MALFUNCTION MAY AFFECT DURING MY COMMUTES. I'M GOING ON THE RECORD AS SAYING IF I DIE IN MY 2011 FORD FUSION DURING AN ACCIDENT SINGLE/MULTI VEHICLE PLEASE DO A FORENSIC CHECK ON THE THROTTLE! *TR
Vehicle speed control, Engine, Fuel/propulsion system, Aug 26, 2013
ON THURSDAY 8/22/13, I WAS DRIVING ABOUT 55 MPH ON THE HIGHWAY AND I EXPERIENCED WHAT SEEMED LIKE AN ENGINE STALL. MY 2011 FUSION WOULD NOT ACCELERATE SO I PULLED OFF THE SIDE AND MY CAR STARTED SHAKING SO I TURNED IT OFF. I WAITED A BIT AND STARTED IT BACK UP AND KEPT DRIVING. I COULD STILL FEEL A LAG WHEN I STEPPED ON THE GAS. I HAD A MECHANIC LOOK AT THE CAR BUT HE COULD NOT FIND ANY ISSUES. ON SATURDAY 8/24/13, THE SAME ISSUE HAPPENED TO ME 3 TIMES WITHIN A 4 HOUR SPAN. I POURED IN SOME SEAFOAM TO RULE OUT ANY MOISTURE THAT MAY BE IN THE ENGINE. I DID SOME RESEARCH ONLINE AND DISCOVERED OTHERS HAVE HAD SIMILAR ISSUES THAT HAVE ALL BEEN LINKED TO A FAULTY THROTTLE BODY. ON SUNDAY 8/25/13, THE ISSUE HAPPENED TWICE DURING THE DAY. TODAY I FINALLY TOOK MY CAR TO THE FORD DEALERSHIP AND TOLD THEM WHAT I WAS EXPERIENCING AND TOLD THEM THAT I THINK IT IS THE THROTTLE BODY. THE GUY TOLD ME THAT THEY WOULD NOT KNOW UNTIL THE COMPUTER DISPLAYED THE ERROR CODE. SEVERAL HOURS LATER I RECEIVED A CALL FROM THE DEALERSHIP TELLING ME IT IS A FAULTY THROTTLE BODY AND THE REPAIR WOULD COST $650. IF THIS IS A KNOWN ISSUE, WHY HASN'T A RECALL BEEN ISSUED? *TR
Power train, Vehicle speed control, Fuel/propulsion system, Aug 26, 2013
THIS IS A KNOWN ISSUE WITH 2011 AND OTHER MODEL FORD FUSIONS AND OTHER MODEL FORD CARS. ACCORDING TO THE MEDIA, ON OCT 2ND 2012 NHTSA CREATED A DEFECT PETITION TO OPEN AN INVESTIGATION ON ESCAPE AND FUSION VEHICLES. I WAS TRAVELING ON OVER THE CHESAPEAKE BAY BRIDGE ON I50 IN MORNING TRAFFIC ATA ~ 60 MPH WHEN ALL OF A SUDDEN MY FUSION LOST COMPLETE POWER. THIS CAUSED A HAZARDOUS SITUATION. I THEN HAD TO 'LIMP' OVER A MILE UP THE TO THE TOP OF THE BRIDGE AT LESS THAN 5 MPH UNTIL I COULD PUT THE VEHICLE IN NEUTRAL AND COAST DOWN THE OTHER SIDE. MYSELF AND NUMEROUS OTHER VEHICLES WERE SUBJECTED TO A HAZARDOUS CONDITION WHEN THIS OCCURRED. LATER TROUBLESHOOTING REVEALED MY PROBLEM WAS THE WELL KNOWN 'FUSION THROTTLE BODY ISSUE' CURRENTLY UNDER INVESTIGATION. LOCAL FORD DEALER AL PACKARD IN WHITE MARSH MD SERVICE DEPT CONFIRMED THE ISSUE AS THE '2111' FAULT AND PROBLEM. AFTER READING ALL OF THE DETAILS ON THIS PROBLEM ON THE INTERNET, I DISCUSSED THE MATTER AT LENGTH WITH LOCAL AND NATIONAL FORD CUSTOMER SERVICE PEOPLE. ALTHOUGH THIS IS A WELL KNOWN ISSUE, FORD HAS NO CUSTOMER WARRANTY PROGRAM IN PLACE FOR THIS DANGEROUS PROBLEM, NOR IS IT COVERED UNTIL THEIR POWER TRAIN WARRANTY. THERE NEEDS TO BE A RECALL WARRANTY PROGRAM AND HAVE THIS PROBLEM FIXED BEFORE MORE PEOPLE GET HURT. IN MY CASE I WITNESSED NUMEROUS UNSAFE CONDITIONS WHILE I WAS LIMPING UP THE BRIDGE FOR 20 MINUTES. THE SITUATION COULD HAVE CAUSED A TERRIBLE ACCIDENT ON THE CHESAPEAKE BAY BRIDGE. I WORK AS A FLIGHT SAFETY PRODUCT SUPPORT MANAGER FOR A MAJOR AIRCRAFT ENGINE MANUFACTURER. ANY LOSS OF THRUST CONTROL ISSUE IS HANDLED AS A SAFETY ISSUE AND RECALL PROGRAMS ARE PUT IN PLACE. THE SAME NEEDS TO OCCUR HERE. MY BROTHER WHO ALSO OWNS A 2010 FUSION HAD A SIMILAR ISSUE WHERE HE HAS LOST COMPLETE POWER WHILE TRAVELING ~65 MPH IN INTERSTATE TRAFFIC. *TR
Vehicle speed control, Fuel/propulsion system, Aug 25, 2013
IN APRIL 2012 AS I WAS MAKING A RIGHT HAND TURN AT ABOUT 15 MILES PER HOUR THE CAR JUST BASICALLY STOPPED. THE POWER WAS ON BUT THE CAR WOULD NOT GO. AGAIN ON SUNDAY, AUGUST 11, 2013 AS I WAS MAKING A LEFT HAND TURN, THE CAR BASICALLY STOPPED IN THE MIDDLE OF AN INTERSECTION, CAUSING THE DRIVER BEHIND TO HONK AND WONDER IF I WAS MOVING. I PUT THE FLASHERS ON AND THE VEHICLE "LIMPED" THROUGH THE INTERSECTION. I COULD HAVE BEEN IN A SERIOUS ACCIDENT IN THE MIDDLE OF FIVE LANES OF TRAFFIC! I SHUT THE CAR OFF AND RESTARTED SAME PROBLEM. I SHUT THE CAR OFF AGAIN AND WAS ABLE TO DRIVE HOME. I TOOK THE VEHICLE TO THE DEALERSHIP ON MONDAY, AUGUST 12TH AND THEY DIAGNOSED A BAD THROTTLE-BODY. THEY REPLACED THE THROTTLE BODY. I THEN LOOKED ON THE INTERNET TO SEE IF THERE WAS A PROBLEM WITH MY CAR AND I SAW A NEWS ARTICLE POSTED IN FEBRUARY 2013 WITH FORD HAVING FAILURES WITH THE THROTTLE BODY IN MY VEHICLE. *TR
Fuel/propulsion system, Aug 25, 2013
CAR KEEPS DISPLAYING CHECK FUEL FILL INLET, NOW CHECK ENGINE LIGHT IS ON. WHILE FILLING TANK AT LOCAL GAS STATION STRONG SMELL OF FUEL AROUND AND INSIDE OF CAR. THIS HAS HAPPENED ON MORE THAN ONE OCCASION. OBD II READS CODE P0455. THIS IS UNSAFE IN MANY WAYS, EXPLOSIVES ARE TO DANGEROUS TO MESS WITH. NO RESOLUTION FROM FORD MOTOR COMPANY ON THIS ISSUE. *TR
Vehicle speed control, Fuel/propulsion system, Aug 23, 2013
I WAS IN MY 2011 FORD FUSION. I STOPPED AT A RED LIGHT. WHEN IT TURNED GREEN I GAVE IT GAS AND THE CAR STARTED TO SHAKE VIOLENTLY, THE WRENCH LIGHT CAME ON THE DASH AND WOULD NOT GO MORE THAN 2 MPH. A TRUCK ALMOST REAR-ENDED ME IN A 50 MPH ZONE. I WAS REALLY SHAKEN UP AND THOUGHT THAT WAS THE CLOSEST I HAD COME TO DEATH OR SERIOUS INJURY IN MY LIFE. WE TOOK THE CAR TO FORD AND THEY TOLD US THAT IT WAS A BAD THROTTLE BODY AND THAT IT WOULD BE AROUND $500 TO REPLACE. THEY SAID THE PART WAS ON BACK ORDER BUT COULD DO A RUSH SHIPMENT AND HAVE IT WITHIN 10 DAYS. OUR FORD HAS ALWAYS BEEN SERVICED AT THE DEALERSHIP BUT WE DECIDED TO CALL OUR MECHANIC (NON FORD) IN TOWN TO SEE IF HE COULD GET THE PART QUICKER OR CHEAPER. HE CALLED ANOTHER FORD DEALERSHIP AND WAS TOLD THAT THE THROTTLE BODY IS A HUGE PROBLEM AND THEY HAD BEEN BACK ORDERED FOR OVER 6 MONTHS BUT MORE WERE EXPECTED IN BY OCTOBER 2013. WE CHECKED ONLINE AND FOUND THAT THERE HAS BEEN PROBLEMS WITH THE FORD THROTTLE BODY FOR YEARS, AND FORD REFUSES TO DO ANYTHING ABOUT IT. I WOULD THINK FORD WOULD STAND BEHIND THEIR PRODUCTS INSTEAD OF WORRYING ABOUT PROFITS WHEN THEIR CUSTOMER'S LIVES ARE IN DANGER FROM AN INFERIOR PART. TO TOP IT OFF WE HAVE ALSO BEEN HEARING A POPPING SOUND IN THE FRONT END. WHEN WE TOOK IT INTO FORD FOR THE THROTTLE BODY PROBLEM THEY ALSO SAID THAT THE BUSHINGS IN THE FRONT END FOR THE TIE RODS AND A ARMS WERE BAD AND THAT THEY NEEDED TO BE REPLACED. WHEN I CALLED FORD THEY SAID THERE WAS NOTHING THEY COULD DO SINCE THERE WERE NOT ANY RECALLS ON THE VEHICLE. I CAN'T UNDERSTAND WHEN YOU TYPE IN FORD THROTTLE BODY IN ANY SEARCH ENGINE, IT COMES UP WITH THOUSANDS OF PEOPLE THAT ARE HAVING PROBLEMS WITH THE FORD THROTTLE BODY. NOW I TRULY KNOW THE MEANING OF FORD, FOUND ON ROAD DEAD. EITHER THE FORD VEHICLE ITSELF OR THE OCCUPANTS OF THE CAR. SHAME ON FORD FOR NOT FIXING THESE SAFETY ISSUES. *TR
Vehicle speed control, Fuel/propulsion system, Aug 20, 2013
THROTTLE BODY STOPPED WORKING WHILE I WAS TRAVELING DOWN THE FREEWAY. SERVICE LIGHT CAME ON AND I HAD NO POWER TO CONTINUE ON. HAD TO GET OVER THREE LANES WHILE CAR SLOWED DOWN. STOPPED OFF AT SIDE OF ROAD AND CAR IDLED VERY ROUGH. TURNED CAR OFF WAITED A MINUTE AND RESTARTED AND IT RAN FINE FOR AWHILE UNIT HAPPENED AGAIN. *TR
Vehicle speed control, Engine, Fuel/propulsion system, Aug 19, 2013
AFTER ACCELERATING TO 30 MY CAR LOST THE ABILITY TO USE THE FOOT PEDAL. THE ENGINE CONTINUED RUNNING BUT WAS UNABLE TO ACCELERATE. I PULLED OFF THE SIDE OF THE ROAD, SHUT THE CAR OFF WAITED A FEW MINUTES AND THEN STARTED THE CAR. IT WORKED FINE UNTIL AUGUST 15TH WHEN THE SAME THING HAPPENED 4 TIMES. ONCE WITH IN 30 MINUTES AT A SPEED US 40 TO 55. THE 3RD AND 4TH TIMES OCCURRED WITHIN MINUTES OF EACH OTHER AT 55 MPH IN A CONSTRUCTION ZONE. ON ALL OCCASIONS THE WRENCH LIGHT CAME ON. ON AUGUST 17TH I TOOK MY CAR TO THE DEALERSHIP AND THEY INFORMED ME THE THROTTLE BODY ASSEMBLY WAS BAD AND NEEDED REPLACED. THAT COST ME $500 OUT OF POCKET SINCE MY CAR IS OUT OF WARRANTY. *TR
Power train, Fuel/propulsion system, Aug 15, 2013
DRIVE OUT OF TOWN ON A SINGLE LANE ROAD GOING 55 MPH AND WITHOUT WARNING THE CAR SHOWED A WRENCH SYMBOL AND LOST ALL THROTTLE RESPONSE AT THE FOOT PEDAL. HAD TO PULL OVER ON A HIGHWAY WITHOUT A SHOULDER AND TURNED OFF THE CAR. RESTARTING THE CAR CLEARED THE WRENCH SYMBOL AND I HAD THROTTLE RESPONSE. TRIED TO DRIVE THE 10 MILES THAT I HAD LEFT TO GET HOME AND THE ISSUE HAPPENED 4 MORE TIMES. INTERNET SEARCH POINTED TO A BAD THROTTLE BODY AND IT LOOKS LIKE A MAJOR ISSUE ON MULTIPLE FORD CARS/SUVS. FORD DEALER SHIP HAS A NEW PART NUMBER FOR THIS THROTTLE BODY WITH A 2 MONTH BACKORDER WITH AROUND 6,534 UNITS ON BACKORDER! ORDERED A NEW PART NUMBER FROM EBAY AND SEEMS TO BE WORKING. I DID THE REPLACEMENT IN 10 MINUTES, BUT HAVE READ ONLINE THAT PEOPLE ARE PAYING AROUND 500 DOLLARS AT THE DEALERSHIP TO REPLACE THIS PART. THAT ALONE SHOULD BE A LAW SUIT! I WAS LUCKY THAT THIS DID NOT CAUSE A CRASH SINCE I HAD MY KIDS IN THE CAR WITH ME WHEN THIS HAPPENED. [XXX] I HAVE THE REMOVED PART IF YOU NEED IT. *TR
Power train, Fuel/propulsion system, Aug 14, 2013
VEHICLE LOST POWER THREE TIMES OVER A 10-MILE STRETCH. CHECK ENGINE LIGHT CAME ON. WE CALLED AAA FOR A TOW TO THE FORD DEALERSHIP SINCE WE FELT LIKE IT WAS TOO UNSAFE TO RISK A TRIP ON THE INTERSTATE TO GET TO THE DEALERSHIP. WAS FOUND TO BE A THROTTLE BODY FAILURE. *TR