2015 Ford Fusion
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,061 owner complaints filed for this model year. This is the 10th highest complaint count among 15 Fusion model years with reports.
Of the 2015 reports, 40 involved a crash and 6 involved a fire. 19 people were injured.
What owners report most often
Recalls and investigations
Power train, manual transmissionJun 9, 2026
Ford Motor Company (Ford) is recalling certain 2015-2018 Focus and 2013-2016 Fusion vehicles previously repaired incorrectly under recall numbers 18V169 and 18V845. The clutch may fracture, resulting in damage to the transmission assembly and possibly a transmission fluid leak.
A transmission fluid leak in the presence of an ignition source such as hot engine or exhaust components can increase the risk of a fire.
Dealers will update the software, free of charge. Additionally, dealers will inspect Focus vehicles and replace the clutch assembly as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 5, 2026. Additional letters will be sent once the remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S43. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6,2026.
Campaign 26V376000 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsMar 10, 2023
Ford Motor Company (Ford) is recalling certain 2013-2018 Fusion and Lincoln MKZ vehicles. The front brake hoses may rupture and leak brake fluid.
A brake fluid leak will increase brake pedal travel and extend the distance needed to stop the vehicle, increasing the risk of a crash.
Dealers will replace the front brake hoses, free of charge. Owner notification letters were mailed June 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S12.
Campaign 23V162000 on NHTSA.gov
Power train, automatic transmission, gear position indication (prndl)Jun 10, 2022
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
Campaign 22V413000 on NHTSA.gov
Service brakes, hydraulic, pedals and linkagesJan 13, 2022
Ford Motor Company (Ford) is recalling certain 2014-2015 Fusion, Lincoln MKZ, and 2015 Mustang vehicles originally sold or ever registered, in Texas, Louisiana, Mississippi, Alabama, Florida, Georgia, South Carolina, North Carolina, Virginia and Hawaii. Exposure to certain environmental conditions, such as high temperatures, high humidity, and salt air can cause the brake pedal bumper to corrode and separate from the brake pedal.
A separated brake pedal bumper can cause the brake lights to illuminate continuously, causing confusion to other drivers and increasing the risk of a crash. On automatic transmission vehicles, a missing brake pedal bumper can allow the driver to shift the vehicle out of the "PARK" position without depressing the brake, allowing the vehicle to rollaway, increasing the risk of injury.
Dealers will replace the brake pedal bumpers and clutch pedal bumpers, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed on March 4, 2022. Owner notification letters were mailed on June 13, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S02.
Campaign 22V011000 on NHTSA.gov
Latches/locks/linkages, doors, latchMar 23, 2020
Ford Motor Company (Ford) is recalling certain 2014-2015 Fiesta, 2014-2016 Fusion and Lincoln MKZ vehicles sold, or ever registered in Alabama, Arkansas, Arizona, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, New Mexico, Nevada, Oklahoma, Oregon, South Carolina, Texas, Utah, Washington, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Ford will notify owners, and Ford or Lincoln dealers will replace the side door latches, free of charge. The recall began September 21, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S15.
Campaign 20V177000 on NHTSA.gov
Steering, electric power assist systemAug 29, 2019
Ford Motor Company (Ford) is recalling certain 2013-2016 Ford Fusion and Lincoln MKZ, 2015-2016 Ford Edge, and 2016 Lincoln MKX vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. Road salt or other contaminants may corrode the electric power steering gear motor attachment bolts.
If the bolts corrode, the steering gear motor may detach from the gear housing resulting in a loss of power steering assist, requiring a greater steering effort, especially at lower speeds, and increasing the risk of a crash.
Ford will notify owners, and dealers will replace the steering gear motor bolts and apply a wax sealer. If any of the steering gear motor attachment bolts are broken or missing, a new steering gear will be installed in the vehicle. These repairs will be performed free of charge. The recall began October 18, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S26.
Campaign 19V632000 on NHTSA.gov
Seat belts, frontAug 12, 2019
Ford Motor Company (Ford) is recalling certain 2015 Fusion and Lincoln MKZ vehicles. In the event of a crash, heat from the deployment of a seat belt pretensioner may cause a front seat belt anchor cable to fail.
A failed seat belt anchor cable cannot properly restrain the front seat occupants, increasing their risk of injury.
Ford will notify owners, and dealers will apply a protective coating to the seat belt cable, free of charge. The recall began September 9, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S25. Note: This recall is an expansion of a recall 16V-875.
Campaign 19V590000 on NHTSA.gov
Power train, automatic transmission, lever and linkage, floor shiftMay 13, 2019
Ford Motor Company (Ford) is recalling certain 2013-2016 Fusion vehicles equipped with 2.5 liter engines. The bushing that attaches the transmission shifter cable to the transmission may degrade over time and cause the bushing to detach from the transmission. The condition could allow the driver to move the shift lever to Park and remove the ignition key, while the transmission may not be in Park, with no warning message or audible chime.
If the vehicle is exited without the transmission being in Park and without the parking brake being applied, the vehicle may unexpectedly move, increasing the risk of a crash.
Ford will notify owners, and dealers will replace the shifter cable bushing, free of charge. The recall began September 10, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S16. Note: Owners are directed to use the parking brake until the recall remedy repairs can be made. This recall is an expansion of 18V471.
Campaign 19V362000 on NHTSA.gov
Power train, automatic transmission, lever and linkage, floor shiftJul 16, 2018
Ford Motor Company (Ford) is recalling certain 2013-2014 Ford Escape, and 2013-2016 Ford Fusion vehicles, equipped with six-speed automatic transmissions. The bushing that attaches the transmission shifter cable to the transmission may degrade over time and cause the bushing to detach from the transmission. The condition could allow the driver to move the shift lever to Park and remove the ignition key, while the transmission may not be in Park, with no warning message or audible chime.
If the vehicle is exited without the transmission being in Park and without the parking brake being applied, the vehicle may unexpectedly move, increasing the risk of a crash.
Ford will notify owners, and dealers will replace the shifter cable bushing, free of charge. The recall began September 20, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S20. Note: Owners are directed to use the parking brake until the recall remedy repairs can be made.
Campaign 18V471000 on NHTSA.gov
Steering, steering wheel/handle barMar 12, 2018
Ford Motor Company (Ford) is recalling certain 2014-2018 Lincoln MKZ and Ford Fusion vehicles. The steering wheel retaining bolt may loosen allowing the steering wheel to detach while driving.
A steering wheel detachment can cause a loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will replace the steering wheel bolt with a longer bolt, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S08.
Campaign 18V167000 on NHTSA.gov
Seat belts, frontDec 5, 2016
Ford Motor Company (Ford) is recalling certain model year 2013-2016 Ford Fusion vehicles manufactured November 2, 2012, to July 31, 2014, and 2013-2015 Lincoln MKZ vehicles manufactured November 14, 2012, to July 31, 2014. In the event of a crash, heat from the deployment of a seat belt pretensioner may cause a front seat belt anchor cable to fail.
If the driver or front passenger seatbelt cables cannot properly restrain the front seat occupants, they would be at an increased risk of injury.
Ford will notify owners, and dealers will apply a protective coating to the seat belt cable, free of charge. The recall began May 16, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S42.
Campaign 16V875000 on NHTSA.gov
Steering, electric power assist systemApr 28, 2015
Ford Motor Company (Ford) is recalling certain model year 2013-2015 Ford Fusion and Lincoln MKZ vehicles manufactured February 3, 2012, to March 20, 2015, and 2015 Ford Edge vehicles manufactured February 26, 2015, to February 28, 2015, and originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, snow or water containing road salt or other contaminants may corrode the electric power steering gear motor attachment bolts.
If the bolts corrode, the steering gear motor may detach from the gear housing resulting in a loss of power steering assist. Loss of power steering assist would require a higher steering effort, especially at lower speeds, which may increase the risk of a crash.
Ford will notify owners, and dealers will apply sealer and replace the steering gear motor bolts as required. If one or more of the steering gear motor attachment bolts are broken or missing, a new steering gear will be installed in the vehicle. These repairs will be performed free of charge. The recall began on June 24, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S14.
Campaign 15V250000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Nov 18, 2014
Ford Motor Company (Ford) is recalling certain model year 2014-2015 Ford Fusion vehicles manufactured July 27, 2013, to October 31, 2014, 2015 Ford Fusion Hybrid vehicles manufactured February 24, 2014, to October 31, 2014, and 2015 Ford Fusion Energi vehicles manufactured July 14, 2014, to October 31, 2014. In the affected vehicles, the key may be able to be removed even while the transmission is not in Park. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 114, "Theft Protection and Rollaway Prevention."
If the key can be removed despite that the transmission is not in Park, a driver may think the vehicle is safety parked, when it is not, increasing the risk of a vehicle rollaway that could cause the vehicle to strike and injure the driver, other vehicle occupants, or bystanders.
Ford will notify owners, and dealers will repair the vehicles, free of charge. The recall began on December 15, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C11.
Campaign 14V736000 on NHTSA.gov
Representative owner complaints
1,061 reports, newest first.
Exterior lighting, Vehicle speed control, Service brakes, Mar 30, 2021
I FOUND LITTLE LIGHT YELLOW PLASTIC UNDER MY RUG AFTER NOT KNOWING WHAT WAS WRONG WITH MY CAR THE BACK LIGHT BRAKE LIGHT WON'T TURN OFF IT'S A LITTLE BUTTON THAT CONTROL THE BRAKES NOW MY BACK LIGHT WON'T TURN OFFF I HAVE TO TAKE THE FUSE OUT AND MY CAR WON'T GO PAST 45-50 MPH BEFORE IT STARTS STALLING. THE YELLOW PLASTIC I CANNOT FIND ANY WHERE. WHAT KEEPS POPPING UP IS HILL START NOT AVAILABLE AS WELL
Power train, Fuel/propulsion system, Mar 26, 2021
FUEL SYSTEM LOSES PRESSURE SOMETIMES AND THE CAR CUTS OFF COMPLETELY, SOMETIMES AT HIGH SPEEDS. THIS IS VERY DANGEROUS BECAUSE OF LOSS OF POWER STEERING AND BRAKES. THAT TRANSMISSION ALSO SHIFTS ERRATICALLY SOMETIMES WHICH IS ALSO DANGEROUS BECAUSE IF I NEED TO ACCELERATE TO AVOID AN ACCIDENT, IT WONT SHIFT CORRECTLY AND MAKES IT MORE DIFFICULT TO DO SO.
Electrical system, Structure, Mar 26, 2021
TRUNK RANDOMLY OPENS ON ITS OWN. OPENS CONSTANTLY THROUGHOUT DAY EVEN WHEN DRIVING DOWN ROAD. THINGS HAVE BLOWN OUT OF TRUNK WHILE DRIVING AND HAVE CAUSED ME TO HAVE TO PULL OVER ON SIDE OF ROAD AND POTENTIALLY CAUSE ACCIDENTS.
Engine, Mar 23, 2021
TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING COOLANT. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER - JIM BURKE FORD (2001 OAK ST, BAKERSFIELD, CA 93301, (661)328-3600) WHERE IT WAS DIAGNOSED WITH NEEDING THE ENGINE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 93,215.
Engine, Mar 22, 2021
JUST GOT THIS FORD VEHICLE A COUPLE MONTHS AGO AND FOR SOME REASON MY CAR WOULDN'T START. I RAN A DIAGNOSTIC AND HAD NUMEROUS CODES P0300, P0301, P0302, P0303, P0304, P0030, C0014, P0047, P0141, AND A FEW OTHERS. I LOOKED FOR LOOSE WIRES, CHECKED FUSES, PLUGS ETC. THE ONLY THING AT THIS POINT I NOTICED WAS TWO CRACKED SPARK PLUGS, SO I REPLACED ALL OFF THEM. AFTER THAT THE CAR STARTED SO I THOUGHT IT WAS FIXED. CLOSED THE HOOD TURNED THE CAR TO OFF, THEN TRIED TO START IT AGAIN. IT DID NOT START. SO I CHECKED ALL THE FLUIDS AND SEEN THE ANTIFREEZE DISAPPEARED, I HAD PREVIOUSLY FILLED IT. I LOOKED FOR ANY VISIBLE LEAKS, PUDDLES, AND CHECKED FOR WET CARPET AND FOUND NOTHING. I WENT AND BOUGHT ANOTHER LARGE JUG OF ANTIFREEZE PUT IT IN AND WATCHED IT ALL DISAPPEAR BEFORE MY EYES. I COULD NOT FIGURE IT OUT, BUT I GOT THE CAR STARTED AND STILL CONTINUED TO GET MASSIVE ERROR CODES, WHITE SMOKE, ROUGH SOUND, ETC. THEN SEARCHED MORE AND FOUND IT SOUNDS LIKE BLOWN HEAD GASKET, I CHECKED AND THE OIL HAD A MILKY TINT. THIS I THEN FOUND WAS A RECALL FOR MY VEHICLE, SO I SPOKE WITH SOMEONE FROM FORD ON MARCH 20, 2021 AND THEY SAID THEY NEEDED TO CHECK IF MY LOCAL FORD DEALERSHIP HAD THE PARTS TO GET MY CAR IN OR IF THEY NEEDED TO ORDER THE PARTS. I WAS SUPPOSE TO GET A CALL BACK BUT HAVE NOT HEARD ANYTHING. I HAVE NOT BEEN DRIVING, I DID USE LEAK FIX IT SEEMED TO STOP THE LEAK AND CLEAR THE CODES BUT MY DASH CHECK ENGINE LIGHT KEEPS FLASHING SO I DIDN'T WANT TO CAUSE FURTHER DAMAGE. THE RECALL NUMBER I FOUND WAS NHTSA ID NUMBER: 10174400, MY CAR IS A 2015 FORD FUSION ECOBOOST 1.5L, VIN NUMBER# [XXX], AND MY LOCAL FORD IS IN HEATH, OHIO 43056 AT MATHEWS FORD. I AM GETTING THE IMPRESSION THIS IS GOING TO BE AT MY COST AFTER CONTACTING FORD AGAIN, NOW TELLING ME THAT IT WILL NEED DIAGNOSED AT FORD, AND MAY BE AT MY COST. WHY DOESN'T THE RECALL LIST UNDER MY VIN? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Engine, Mar 21, 2021
MY WARRANTY WITH THE VEHICLE WAS FOR 60,000 MILES, AT 62,000 MILES, THE CHECK ENGINE LIGHT CAME ON. I TOOK IT TO THE DEALERSHIP AND WAS INFORMED IT WAS LEAKING COOLANT INTO THE CYLINDER BLOCK AND THE ENGINE WOULD HAVE TO BE REPLACED. FORD DENIED MY REQUEST FOR ANY ASSISTANCE IN THE REPAIR.
Service brakes, Mar 19, 2021
FLEXIBLE BRAKE LINE RUPTURED AND CAUSED CATASTROPHIC LOSS OF BRAKES (THURS, MAR 18, 2021). SECOND TIME THIS HAPPENED - FIRST TIME WAS ABOUT 15-18 MONTHS AGO - ALSO REPORTED. BOTH TIMES VEHICLE TAKEN TO MAC HAIK FORD DEALERSHIP IN HOUSTON, TX FOR SERVICE. (BOTH TIMES FAILED WHILE IN FAST FOOD WAITING LINE).
Fuel/propulsion system, Mar 17, 2021
CHECK ENGINE LIGHT ON, HONING COMING FROM REAR DRIVER SIDE, AFTER FILLING WITH GAS THE ENGINE FIRES UP PROPERLY BUT THEN SPUTTERS OUT, CODES ARE READING EVAPORATOR PURGE SYSTEM FAILURE
Steering, Mar 5, 2021
2015 FORD FUSION WITH 85,000 MILES HAD STEERING GEAR FAIL. VEHICLE ALREADY HAD RECALL FOR CORROSION ON STEERING BOX BOLTS. STEERING GEARS ARE BUILT FOR 10/12/15 YEARS AND THIS FAILED IN UNDER 6 YEARS. THIS IS UNACCEPTABLE. MY SON WAS DRIVING AND THE POWER STEERING SHUT DOWN AND THE VEHICLE DRIVES AS IF IT DOESN'T HAVE POWER STEERING. THE TSC OFF AND TSC INDICATOR LIGHTS ARE LIT UP ON THE DASH.
Steering, Suspension, Mar 5, 2021
WHEN STEERING THE CAR IN A TURN, SUCH AS ON AND OFF RAMPS, THE STEERING WHEEL WILL JERK IN THE DIRECTION OF STEERING AND THE (TCS) TRACTION CONTROL SYSTEM LIGHT COMES ON. THIS BEGAN HAPPENING AFTER TAKING THE CAR TO THE DEALERSHIP TO HAVE A RECALLED STEERING BOLT REPLACED. I HAVE TAKEN THE CAR TO THREE FORD DEALERSHIPS, AND NONE OF THEM CAN FIND ANYTHING WRONG. I TOOK THE CAR TO THE FORD DEALERSHIP RECENTLY ON 2-26-2121 AND WAS TOLD THAT THE STEERING BALL JOINT NEEDED TO BE REPLACED FOR $610.00 WHICH I FOUND ABSURD.
Engine, Mar 3, 2021
WELL TO START OF I HAVE A 2015 FORD FUSION THAT I BOUGHT IN 2014 AS A 2015 MODEL YEAR PRETTY MUCH IT'S BEEN A GOOD CAR SO FAR. IT HAS BEEN IN A COUPLE OF RECALLS SO FAR NOT SO BIG, BUT AT SAME TIME THEY HAVE TO BE TAKING CARE OF BY MY DEALER WERE I PURCHASED THE VEHICLE. MY CONCERN NOW IS THAT IS LOOSING COOLANT FROM THE RESERVOIR WHEN IS ON PARK OVERNIGHT. I ALWAYS HAVE TO PUT COOLANT EVERY MORNING TO GET IT GOING OTHERWISE A WARNING LIGHT COMES OFF TO WARN ME ABOUT THE COOLANT BEING LOW. IT'S BEEN LIKE THAT FOR A COUPLE OF WEEK NOW AND IS KINDA TIRING GOING TO THE SAME STEP EVERY MORNING. I HAVE BEEN SEARCHING ON THE INTERNET ABOUT THIS TYPE OF VEHICLE AND AFTER SEARCHING FOR AWHILE IT CAME UP THAT A LOT OF PEOPLE ARE EXPERIENCING THE SAME ISSUE AS ME. I READ AN ARTICLE STATING THAT SOME ECOBOOST ENGINES ARE EXPERIENCING LOSS OF ANTIFREEZE AND SOME OF EM EXPERIENCING DIFFERENT KIND OF PROBLEMS WITH THEIR ECOBOOST ENGINES. HONESTLY I DON'T WANT TO GO TO THE SAME PROBLEM LIKE THEY ARE GOING. I'M WONDERING IF FORD IS GOING TO RECALL ALL THE ECOBOOST ENGINES THAT THEY HAVE PROBLEMS WITH IT. MINE IS ALREADY GOING THROUGH THE SAME SYMPTOMS LIKE THE OTHER OWNERS ARE EXPERIENCING. HOPEFULLY THE NHSTA STEPS UP AND DO SOMETHING ABOUT US BUYERS WITH A PROBLEMATIC VEHICLE THAT PEOPLE ARE HOPING TO KEEP IT FOR A LONGTIME TIME LIKE MY SELF. PRETTY MUCH MY WARRANTY EXPIRED A COUPLE OF MONTHS AGO. HONESTLY I DON'T WANT TO PAY OUT OF POCKET IF MY VEHICLE STARTS TO MESSING UP AND TO BE HONEST I'M BEARLY SURVIVING OUT HERE AND WITH THIS PANDEMIC GOING ON IT'S VERY HARD TO COME UP WITH MONEY TO PAY YOUR BILLS AND NOW WITH THIS PROBLEM WITH MY VEHICLE IT'LL BE HARDER IF IT MESSES UP ON ME. IT'LL BE HARD TO COME UP WITH $7 THOUSAND DOLLARS TO REPAIR YOUR VEHICLE IN WHICH YOU RELY ON. THANK YOU VERY MUCH FOR THE OPPORTUNITY TO EXPRESS MY CONCERNS THROUGH OUT THIS WEBSITE.
Steering, Feb 27, 2021
SUDDEN LOSS OF POWER STEERING. POWER STEERING ASSIST FAULT MESSAGE ON DASHBOARD SCREEN
Steering, Feb 23, 2021
POWER STEERING MAKES LOUD THUNKING SOUNDS WHENEVER I TURN RIGHT OR LEFT, WHETHER CAR IS MOVING OR STOPPED. IT'S COMING FROM THE STEERING RACK MECHANISM ITSELF.
Steering, Air bags, Forward collision avoidance, Feb 16, 2021
WHILE IAM DRIVING SOME TIME AIR BAGS IMAGE LIGHT UP ON THE SPEEDOMETER, COLLISION WARNING WILL ALSO LIGHT UP AND STEERING GETTING TIGHTER .THIS IS HAPPENING WHILE IAM DRIVING ON THE STREETS AND SOME TIME ITS HAPPENING ON FREEWAY TOO
Steering, Feb 16, 2021
TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT STATED THAT WHILE HIS WIFE WAS DRIVING 5 MPH, THE STEERING ASSIST FAULT, SERVICE REQUIRED AND SERVICE ADVANCE TRAC WARNING LIGHTS FLASHED ON THE INSTRUMENT PANEL AS THE VEHICLE SIMULTANEOUSLY LOSS POWER STEERING FUNCTIONALITY. THE CONTACT'S WIFE RESTARTED THE VEHICLE AND THE VEHICLE RESUMED NORMAL OPERATION. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 15V250000 (STEERING) WHICH HE LINKED TO THE FAILURE. NIELSEN FORD (375 NJ-23, WANTAGE, NJ 07461) WAS CONTACTED ABOUT THE FAILURE AND THE CONTACT WAS INFORMED THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 118,000.
Power train, Fuel/propulsion system, Feb 11, 2021
THE AFFECTED VEHICLE IS A 2015 FORD FUSION ENERGI WITH 80,350 MILES. VIN: 3FA6P0SU1FR I PURCHASED THE VEHICLE FROM KELLER FORD IN HANFORD CALIFORNIA ON 11JAN2021, AT 79,902 MILES. ON MY WAY TO WORK WHILE ON THE HIGHWAY, SYMPTOMS STARTED WITH A HIGH PITCH NOISE, FOLLOWED BY, A BURNING SMELL, MOTOR OVER TEMP WARNING, AND FINALLY A COMPLETE LOSS OF POWER AND A "PULL OVER SAFELY" WARNING. I HAD MY CAR TOWED TO THE DEALERSHIP THE FOLLOWING MORNING TO BE WORKED ON, WHERE THEY FOUND THE TRANSMISSION ASSEMBLY TO BE THE AFFECTED ISSUE. THE TRANSMISSION HAD BEEN REPLACED SOMETIME LAST YEAR PRIOR TO MY OWNERSHIP, WHICH WAS UNDISCLOSED TO ME AT THE TIME OF PURCHASE, SO THIS IS NOW THE SECCOND TIME THIS CAR HAS HAD AN ISSUE WITH THE ECVT ASSEMBLY. (PART NUMBER HM5Z-7000-ARM). THE ORIGINAL REPAIR WAS A COMPLETE TRANSMISSION REPLACEMENT, BUT THIS TIME, FORD IS LOOKING AT HAVING THE DEALERSHIP REBUILD THE TRANSMISSION. I HAVE NOT BEEN ABLE TO FIND MANY OTHER ISSUES WITH THIS TRANSMISSION, ASIDE FOR TWO TSBS. 20-2219 AND 19-2391. THE HYBRID ELECTRICAL SYSTEM, WHICH INCLUDES THE ECVT, IS WARRANTED BY FORD UP TO 8 YEARS OR 100,000 MILES
Engine, Feb 8, 2021
TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT STATED THAT AN UNKNOWN WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO THE LOCAL DEALER PAUL CLARK FORD (464046 STATE RD 200, YULEE, FL 32097) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS DUE TO THE NUMBER 3 CYLINDER MISFIRE, WHICH CAUSED FLUID TO ENTER INTO THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 91,000.
Engine, Feb 4, 2021
COOLANT LEAK INTO ENGINE FOR 2015 FORD FUSION SE. CAR OVERHEATED ON THE HIGHWAY IN 2020. I TOOK IT TO FORD WHILE UNDER WARRANTY. THEY SAID THE ENGINE WASN'T THE ISSUE AND THAT IT WAS THE COOLANT. THEY BLED IT & PUT NEW. I AM STILL HAVING THE SAME ISSUE. GOT IT FIXED 3 TIMES! TO FIND OUT IT IS THE COOLANT LEAKING INTO THE CYLINDER/ENGINE. MY COOLANT IS EMPTY EVERY 20MILES! MY CAR IS NO LONGER UNDER WARRANTY BUT I ORIGINALLY ASKED FORD WHEN THE ISSUE FIRST HAPPENED !
Engine, Feb 4, 2021
I HAVE A 2015 FORD FUSION MY ENGINE HAS STOPED WORKING.I ONLY HAVE 145000 MILES.I WAS BEEN ADVISED THIS IS A COMMON PROBLEM IN THESE VEHICLES.IF I HAD KNOWN I WOULD HAVE NEVER PURCHASED IT
Engine, Jan 22, 2021
WHILE DRIVING ON THE INTERSTATE MY CONTROL PANEL STARTED THROWING AN ALARM OF ENGINE TEMP HIGH. IT WOULD GO OFF THEN BACK ON SEVERAL TIMES. ABOUT 15-30 MINS HEADING HOME THE ENGINE LIGHT CAME ON AND CUT POWER TO THE ENGINE. THIS IS THE SECOND TIME THIS HAS HAPPENED IN THE LIFE OF THIS CAR. FIRST TIME FORD REPLACED THE ENGINE. THIS TIME THEY SAY THAT ITS NOT UNDER WARRANTY AND WANT ME TO REPLACE IT AGAIN. THE LIFE OF THIS NEW ENGINE IS LESS THAN 2 YEARS OLD AND LESS THAN 12000 MILES ON IT. COOLANT LEAKING INTO THE ENGINE. THIS IS A SERIOUS ISSUE THAT IS GOING TO GET SOMEBODY KILLED IF IT HASN'T ALREADY!
Engine, Jan 22, 2021
IN 2019 I HAD AN OVER TEMP WARNING POP UP. AFTER TAKING TO DEALERSHIP FOUND IT TO BE A COOLANT LEAK IN CYLINDER 2. SINCE IT WAS UNDER WARRANTY FORD REPLACED THE ENGINE. LESS THAN 2 YEARS LATER WITH THE NEW ENGINE THE SAME ISSUE IS HAPPENING AGAIN, BUT IS NO LONGER UNDER WARRANTY AND THEY WANT ME TO PAY TO REPLACE. THIS HAS NOT ONLY HAPPENED TO ME, BUT THERE ARE COUNTLESS OTHERS WITH THE SAME ISSUE. I WAS DRIVING ON THE INTERSTATE GOING ABOUT 65-70MPH WHEN THE POWER WAS SHUT DOWN TO MY ENGINE AND COULD HAVE KILLED ME.
Steering, Jan 19, 2021
TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE LOSS POWER STEERING WHILE PULLING OUT OF THE DRIVEWAY AND BECAME DIFFICULT TO STEER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE STEERING GEAR MOTOR DETACHED FROM THE GEAR HOUSING. THE CONTACT WAS INFORMED THAT THE ELECTRIC POWER STEERING ASSIST SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MECHANIC INFORMED OF NHTSA CAMPAIGN NUMBER: 19V632000 (STEERING) HOWEVER, THE VIN WAS NOT INCLUDED. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. NEITHER THE DEALER NOR THE MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 83,000.
Engine, Jan 16, 2021
I PURCHASE A 2015 FORD FUSION SE WITH 119,00 MILES GREAT CONDITION CAR... THE CAR WILL MOT START... I'VE TOWED THE CAR TO MECHANIC SHOPS WHERE THEY INFORMED ME THAT I NEED TO REPLACE MY ENGINE. IN DISBELIEF I TOLD THE CAR TO ELDERLY FORD DEALERSHIP IN TROY, MI WHERE ARE THEY NOTIFIED ME THAT I NEEDED TO REPLACE MY ENGINE BECAUSE COOLANT WAS LEAKING INTO MY ENGINE AND THE REPAIRS WILL COST MEV$7500 THEY'VE DONE TWO DIAGNOSTIC TEST WERE THEY FIND FAULT IN FORD! I NEED TO RESOLVE THIS MATTER
Steering, Electrical system, Jan 14, 2021
MY VEHICLE'S BATTERY DRAINED OUT BECAUSE WE HADN'T BEEN DRIVING THE VEHICLE MUCH DUE TO COVID STAY-HOME ORDERS IN MICHIGAN AND STAYING AT HOME OVER THE HOLIDAYS. WE ROLLED IT OUT OF THE GARAGE AND JUMP STARTED IT IN THE DRIVEWAY, THEN LET IT RUN FOR AN HOUR TO RECHARGE THE BATTERY RATHER THAN DRIVING IT BECAUSE OUR POWER STEERING AND ADVANCE TRAC WERE SHOWING FAULT MESSAGES AND IT WAS VERY DIFFICULT TO STEER THE VEHICLE. THE MESSAGES DIDN'T GO AWAY AFTER WE TURNED IT OFF AND RESTARTED IT. WE EVEN LEFT IT OVERNIGHT AND TRIED THE NEXT MORNING. THE MESSAGES ARE AS FOLLOWS: LOW BATTERY FEATURES TEMPORARILY TURNED OFF STEERING ASSIST FAULT SERVICE REQUIRED SERVICE ADVANCE TRAC THERE ARE ALSO TWO WARNING LIGHTS SHOWING A CAR SKIDDING, ONE WITH THE TEXT "OFF" UNDER IT. I BELIEVE THESE ARE THE TRACTION CONTROL WARNING LIGHTS. LOOKING ON THE INTERNET, I SEE THERE HAVE BEEN RECALLS FOR STEERING PROBLEMS RELATED TO THE ELECTRIC POWER STEERING ASSIST SYSTEMS HTTPS://WWW.CONSUMERREPORTS.ORG/CAR-RECALLS-DEFECTS/FORD-RECALLS-SEDANS-AND-SUVS-STEERING-PROBLEM/ HTTP://WWW.FORDPROBLEMS.COM/EPAS/ I CONTACTED FORD TO SEE IF THEY COULD PROVIDE SOME ADVICE OR ASSISTANCE. THERE DON'T SEEM TO BE ANY RECALLS ASSOCIATED WITH THIS ISSUE FOR MY VEHICLE'S VIN. THEY SUGGESTED I TRY TURNING IT OFF AND TURNING IT ON AGAIN (A "KEY CYCLE") TO SEE IF IT WOULD RESET, WHICH I HAVE DONE A FEW TIMES WITH NO SUCCESS. THEY THEN SUGGESTED TAKING IT TO THE DEALERSHIP TO HAVE IT CHECKED OUT. I DON'T FEEL SAFE DRIVING WITH THE STEERING WHEEL BEING SO DIFFICULT TO TURN, SO WILL NEED TO HAVE IT TOWED. I ALSO I FEAR I COULD BE EXPENSIVE TO GET THIS FIXED IF FORD DOES NOT RECOGNIZE THIS AS A SERVICE ISSUE. I THOUGHT I SHOULD DOCUMENT THIS IN CASE OTHER VEHICLE OWNERS HAVE EXPERIENCED SIMILAR PROBLEMS AND THIS IS IN FACT A SYSTEMATIC ISSUE, NOT AN ISOLATED CASE.
Steering, Jan 13, 2021
MY DAUGHTER WAS DRIVING ON HIGHWAY I-45 WHEN SHE ENCOUNTERED SOME SNOW. THE STEERING ASSIST LIGHT, THE TIRE PRESSURE LIGHT AND ADVANCE TRAC LIGHT CAME ON. POWER WAS LOST TO THE STEERING WHEEL MAKING IT EXTREMELY HARD FOR HERE TO STEER THE VEHICLE. THE FAULT MAYBE A WHEEL SENSOR OR SOME OTHER COMPONENT CAUSING THIS TO HAPPEN. I REALLY DON'T KNOW. LUCKILY NO ONE WAS INJURED AND NO POLICE WAS INVOLVE.