2017 Ford Fusion
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,110 owner complaints filed for this model year. This is the 8th highest complaint count among 15 Fusion model years with reports.
Of the 2017 reports, 37 involved a crash and 8 involved a fire. 30 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsMar 10, 2023
Ford Motor Company (Ford) is recalling certain 2013-2018 Fusion and Lincoln MKZ vehicles. The front brake hoses may rupture and leak brake fluid.
A brake fluid leak will increase brake pedal travel and extend the distance needed to stop the vehicle, increasing the risk of a crash.
Dealers will replace the front brake hoses, free of charge. Owner notification letters were mailed June 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S12.
Campaign 23V162000 on NHTSA.gov
Steering, steering wheel/handle barMar 12, 2018
Ford Motor Company (Ford) is recalling certain 2014-2018 Lincoln MKZ and Ford Fusion vehicles. The steering wheel retaining bolt may loosen allowing the steering wheel to detach while driving.
A steering wheel detachment can cause a loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will replace the steering wheel bolt with a longer bolt, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S08.
Campaign 18V167000 on NHTSA.gov
Power train, automatic transmission, torque converterJul 6, 2017
Ford Motor Company (Ford) is recalling certain 2017 Lincoln MKZ and Ford Edge and Fusion vehicles. On vehicles with 2.0L gas engines and six-speed automatic transmissions, the torque converter weld studs may have been inadequately welded.
If the torque converter weld studs fail, the torque converter will not be connected to the engine flexplate and the vehicle will lose the ability to move, increasing the risk of a crash.
Ford or Lincoln will notify owners, and dealers will replace the torque converters, free of charge. The recall began August 25, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S16.
Campaign 17V427000 on NHTSA.gov
Seats, mid/rear assemblyDec 5, 2016
Ford Motor Company (Ford) is recalling certain 2017 Ford Fusion vehicles manufactured September 27, 2016, to September 28, 2016. The left rear seat backs pivot pins may have been improperly welded.
During a crash, the improper welds may fail, allowing any stowed luggage to move into the passenger compartment, increasing the risk of injury.
Ford will notify owners, and dealers will replace the left hand, second row seat back frame, free of charge. The recall began January 10, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S43.
Campaign 16V874000 on NHTSA.gov
Representative owner complaints: engine
498 reports, newest first. Show all
Engine, Jul 15, 2024
Engine light came on. Took it for repair and found coolant is leaking into the firing chamber resulting in the need for a longblock engine replacement. I was told I could keep driving it but it stranded me on a highway. It has been inspected by the dealership in Louisburg Kansas and two other auto shops.
Engine, Jul 15, 2024
The contact owns a 2017 Ford Fusion. The contact stated that on several occasions while driving at various speeds, the check engine warning light illuminated. The vehicle was taken to an independent mechanic twice to be diagnosed. The contact was made aware of an engine misfire and that there was coolant intrusion into the combustion chamber. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 51,000.
Engine, Jul 9, 2024
2017 Ford Fusion has 52,000 miles and needs an engine. Price of new engine and install 9,000. All service completed by Ford om required basis, but now needs an engine at 52K miles.
Engine, Jul 8, 2024
While driving my Ford Fusion to the Local Ford Dealer (Monday 7.1.2024) for the scheduled Oil change the check engine light came on. I informed the Service writer at the dealership upon arrival. He stated they can complete the oil change but, could not check that problem with the engine light coming on due to the fact you have to make an appointment to have the car serviced. At that time I did make an appointment for that service to have my car inspected for the following Monday (7.8.2024). on my way home the car started to run rough, like it was not running on all cylinders. On Friday 7.5.2024 I contacted an independent service mechanic took my car to an independent service mechanic. He ran a diagnostic test. he determined that coolant was leaking into cylinder #2, he stated it was due to either a broken head gasket or a crack block. The vehicle was taken to the dealer, by a tow truck on the same day. On Monday the Ford dealer diagnosed that coolant was leaking into cylinder #2, and it was determined that the engine needed to be replaced. The car has 119,000 miles. It is out of warranty. The vehicle was not repaired. The Service writer informed me that this is a common problem with the 1.5 Eco boost engine. He also stated that this has been a problem since 2014 engines. The Service writer referred me to the Ford Customer Service Department. I contacted the customer Service Department. The manufacturer was made aware of the failure. The Representative informed me that because the car is out of warranty, they would not do anything to help with replacing the engine.
Power train, Engine, Jul 8, 2024
I took our 2017 Ford Fusion in a couple of weeks ago for a service code showing we had a misfire on #2. We had the repair completed which included new plugs and coils. This past week, the car showed an alert that said the car was overheating. I drove it to the service center and the car gave me an alert that the computer had reduced power to lower the temp of the engine. The mechanic just called me and said that we have coolant in the cylinder. They said this is a known problem and that it is listed under TSB 22-2229 which superseded TSB 22-2133. I have called Ford and Ford dealerships and they sent me to this site to file a complaint. Their answer was that they couldn't fix it until the NHTSA told them to fix it--even though they stated they have seen a lot of these issues.
Engine, Jul 3, 2024
The contact owns a 2017 Ford Fusion. The contact stated that while her son was driving 55 MPH, the vehicle began to shake and vibrate, prompting the driver to pull over to the shoulder of the road and turn off the vehicle. The vehicle then failed to restart. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who determined that there was no compression in cylinder #2, resulting in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 106,000.
Engine and engine cooling, Jul 2, 2024
The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 29,100.
Power train, Engine, Jul 2, 2024
I was driving the car and it started to overheat so I pulled over. I then drove the car to my home and it had a miss in the engine along with white smoke coming out of the exhaust. After getting home I checked the coolant and it was low so i filled it up and as the car sat there idling you could see the coolant disappear and the white smoke and rough idle. I could not see where the coolant leaked out on the ground. I also had to have the transmission replace at the dealership I bought it from due to transmission complete failure. Time to recall this make and model. 1. Engine, Transmission failure 2. Sitting along the highway in the middle of no where.. a woman, you can guess, not safe!! 3.Yes Transmission replaced by dealership and Engine confirmed by service center to have coolant in cylinders. 4. No warning lights at all for either. Only temp gage for overheating.
Engine and engine cooling, Jul 2, 2024
The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact also stated that the vehicle shuddered abnormally at start-up. The vehicle was taken to an independent mechanic, where it was diagnosed with a misfire in cylinder #4. The vehicle was repaired. The contact stated that the check engine warning light was illuminated and the engine overheated. The vehicle was taken back to the independent mechanic, where it was diagnosed with coolant leaking into the engine and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 101,000.
Engine and engine cooling, Jul 2, 2024
The contact owns a 2017 Ford Fusion. The contact stated while driving 50 MPH, the engine overheated. The check engine warning light was illuminated. The local dealer was not contacted, and the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, who determined that there was coolant intrusion into the engine, causing a misfire in cylinder #3. The manufacturer was contacted and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 180,000.
Engine and engine cooling, Jul 1, 2024
The contact owns a 2017 Ford Fusion. The contact stated while starting the vehicle, the vehicle experienced rough starts, shuddered, and made an abnormal sound. The contact was unsure if a warning light was illuminated. The contact stated that the failure persisted while driving at 65 MPH. The contact pulled to the side of the road, where the contact's husband met the contact and drove the vehicle back to the residence. The vehicle was taken to the dealer, where it was diagnosed that there was coolant intrusion into cylinder #4. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was filed. No further assistance was provided. The failure mileage was approximately 81,571.
Engine, Jun 21, 2024
The check engine light began coming on. I took it to the mechanic to determine what may be going on, but he could not find anything. The check engine light continued to come on. Took it back in for deep-dive diagnostics. Service Charging System came on - randomly and intermittently - took it to two different mechanics. At this time problem was intermittent and not consistent. Three mechanics attempted to dive deep into the situation but could not find it. They ruled out the alternator and other issues they suspected. The coolant and Temperature lamps came on once. I immediately stopped driving and checked the coolant. Then, I had mechanics check the coolant and make sure all was good. I took it to another mechanic, and he said it was now throwing all kinds of codes. Took vehicle to local Ford dealership where I was told I needed a new motor and it was not covered by Ford. The cost would be over $13,000. Upon my own investigation, I found that this is a common and recurring problem with this motor. This vehicle has 94k miles on it. In 2022, we purchased it with 78k miles on it for my son to go to college in. Now, I am being told by Ford that the motor will cost more than the car actually did.
Engine, Jun 18, 2024
Engine light came on while driving on the highway with no other warnings or symptoms that could be noticed during standard operation. Vehicle was taken in to Ford for service the next day and it was discovered that coolant was leaking into cylinder #1 due to the design of the engine long block. Coolant intrusion into the cylinder was causing the cylinder to misfire, as well as engine overheating. If I had not taken the vehicle in for service immediately, overheating would have continued, leading to engine failure while actively driving. THIS IS A KNOWN ISSUE BY FORD AFFECTING SOME OF THEIR 2.0L ECO BOOST ENGINES. Ford issued a technical service bulletin (TSB 19-2346) for its technicians on how to diagnose and fix this defect in December 19th of 2019. Ford service told me the repair would not be covered in any extended coverage or powertrain coverage from the factory.
Engine, Jun 18, 2024
The contact owns a 2017 Ford Fusion. The contact stated that when the vehicle was started, the contact stated there was an abnormal amount of white smoke coming from the exhaust tips. The contact stated that the failure was persistent. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 45,000.
Engine and engine cooling, Engine, Jun 14, 2024
The contact's son owns a 2017 Ford Fusion. The contact stated that while her son was driving at 45 MPH, the check engine warning light was illuminated, and the temperature gauge increased to hot. Additionally, the contact stated that the vehicle lost motive power and failed to accelerate above 35 MPH. The vehicle was taken to a dealer where it was diagnosed and determined that the engine needed to be replaced due to a head gasket leak that caused coolant intrusion in the engine. The vehicle was repaired. The failure mileage was 94,000.
Engine, Jun 7, 2024
The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was shaking and failed to accelerate above 40 MPH. An unknown warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion into cylinder #2, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact was advised to file a complaint with the NHTSA Hotline. The failure mileage was approximately 70,000. The VIN was unavailable.
Other or unspecified, Engine, Fuel/propulsion system, Jun 6, 2024
The antifreeze leaks into the engine due to a KNOWN manufacturer design flaw, is available to inspection upon request and appointment made. Mine and others safety are at risk due to the fact that if the engine seizes up while driving, could lead to a sudden crash. Problem confirmed by a local mechanic. Not been inspected by anyone else other than a different independent mechanic. The first sign of a problem is a check engine light, followed by a sputter in the engine and lack of consistent speed control, first appeared in February, and lead to 2 sets of spark plugs being replaced
Engine and engine cooling, Jun 5, 2024
The contact owns a 2017 Ford Fusion. The contact stated that the vehicle was experiencing excessive coolant consumption. The check engine warning light was illuminated. The vehicle was taken to the local dealer and to a second dealer, Norm Reeves Ford Superstore (18900 Studebaker Rd, Cerritos, CA 90703), where the vehicle was diagnosed with coolant intrusion in cylinder #2, and the failure was related to TSB Number: 22-2229. The dealers determined that the engine assembly needed to be replaced. The vehicle was not repaired and remained with the second dealer. The manufacturer was notified of the failure and a case opened. The failure mileage was approximately 76,900.
Engine and engine cooling, Jun 4, 2024
The contact owns a 2017 Ford Fusion. The contact stated while starting the vehicle, the vehicle was shuddering, with the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was determined that the failure was related to Ford Campaign Number: 21N12. The contact stated that the failure persisted while starting and while driving. The vehicle was taken to the dealer, where it was diagnosed that there was coolant intrusion into the engine. The dealer determined that the engine needed to be replaced and informed the contact that the vehicle was not covered under Ford Campaign Number: 21N12. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 75,000.
Power train, Engine, Jun 3, 2024
The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, it was difficult shifting gear. The contact stated that the vehicle was slow to respond. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, and the contact was informed that the vehicle was experiencing transmission failure. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 17V427000 (Power Train). The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 153,000.
Engine, Jun 1, 2024
The vehicle has started going through coolant and the exhaust has a sweet smell. It has the 1.5 litre ecoboost that has an active recall. I believe this is the issue. We still owe more than its worth and cannot afford to have a known recall issue cost us our transportation. It is only a matter of time before it destroys itself. I previously owned a 2014 fusion 2.0 that blew the motor due to the same issue. I had to put a new motor in that car. We picked the 1.5 engine since there were no reported issues at the time of purchase in 2022.
Engine and engine cooling, May 31, 2024
The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle stalled in the middle of the road and the coolant warning light illuminated. The vehicle was pulled to the side of the road where it was restarted and taken to an independent mechanic where the coolant fluid was inspected and refilled. The contact stated that the next day, the failure reoccurred, and the vehicle was unable to be restarted. The vehicle was towed to a local dealer where it was diagnosed with a water pump failure that caused the engine to malfunction. The vehicle was not repaired. The manufacturer was made aware of the failure however, no assistance was provided. The contact stated that while researching online, the contact became aware of an ongoing failure with similar vehicles. The failure mileage was approximately 67,000.
Engine, May 31, 2024
The contact owns a 2017 Ford Fusion. The contact stated that the vehicle shook abnormally while starting. The check engine warning light was illuminated. The contact stated that the engine had previously been replaced. The vehicle was taken to an independent mechanic, who diagnosed that there was coolant intrusion into cylinder #2 and determined that the engine needed to be replaced for the second time. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 64,000. The repairs were made in August of last year but the mechanic stated an additional $8,200 is need for more repairs.
Engine and engine cooling, May 28, 2024
The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle experienced an engine misfire, shuddered, and then stalled. The check engine warning light was illuminated. The contact was able to restart the vehicle, and the vehicle operated as needed. The vehicle was taken to the dealer, where it was diagnosed with a coolant leak into the cylinder which caused engine damage. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to Customer Satisfaction Programs 21N12 and 19B37. The manufacturer was made aware of the failure and confirmed that the vehicle was not included in the Customer Satisfaction Programs. The failure mileage was approximately 55,800.
Engine, May 25, 2024
Check engine light was activated on my 2017 Fusion Titanium a week ago. Took car to the dealership on 5/25/24 and was informed that a coolant leak had caused a "milkshake" in the engine, which (as many others are reporting) now needs to be replaced--at a cost of $8000. Vehicle went out of warranty in late 2023.