2002 Kia Optima
Problems, recalls and owner-reported issues
Structure is the leading concern among 110 owner complaints filed for this model year. This is the 19th highest complaint count among 20 Optima model years with reports.
Of the 2002 reports, 16 involved a crash and 5 involved a fire. 12 people were injured.
What owners report most often
Recalls and investigations
Suspension, frontMay 27, 2009
KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE STATES DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING, OR ACCELERATED ABNORMAL TIRE WEAR.
CORROSION OF THE FRONT SUBFRAME COULD LEAD TO SEPARATION, POSSIBLY RESULTING IN A VEHICLE CRASH.
KMC WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 15, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Campaign 09V183000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 12, 2004
SOME PASSENGER VEHICLES MAY CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN JUNE 25, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
Campaign 04V180000 on NHTSA.gov
Electrical system, starter assemblyMar 4, 2003
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.5 AND 2.7 LITER V6 ENGINES, THE CRANKSHAFT POSITION SENSOR (CKP) CASES DID NOT MEET DIMENSIONAL SPECIFICATIONS.
INTERNAL GAPS WITHIN THE CASES ALLOWED EPOXY TO CONTACT THE PRINTED CIRCUIT BOARD, WHICH RESULTED IN CRACKING OF THE CIRCUIT BOARD CAPACITOR. A DAMAGED CKP CAPACITOR COULD RESULT IN ENGINE STALLING.
DEALERS WILL REPLACE THE CKP. OWNER NOTIFICATION BEGAN MARCH 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Campaign 03V067000 on NHTSA.gov
Representative owner complaints
110 reports, newest first.
Visibility, Mar 21, 2004
BOTH FRONT WINDOWS WILL NOT GO UP OR DOWN. YOU CAN HERE THE MOTOR BUT NOTHING IS HAPPENING. *JB
Vehicle speed control, Mar 15, 2004
WHEN ACCELERATING FROM A STOP VEHICLE HESITATED BEFORE ACCELERATION. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
Service brakes, Hydraulic, Air bags, Jan 15, 2004, crash
PURCHASED CAR BRAND NEW ON APRIL 30, 2003 - INCIDENT #1: JULY 15, 2003, I WAS TRAVELING ABOUT 30-35 MILES PER HOUR EXITING THE MASS PIKE EXIT AT ROUTE 30. ALL TRAFFIC WAS SLOWING TO EXIT - I APPLIED THE BRAKES - WENT ALL THE WAY DOWN - REALIZED THAT THE BREAKS WERE NOT WORKING - PANICKED - IMPACTED THE VEHICLE IN FRONT OF ME. THE AIRBAGS DID NOT WORK. INCIDENT #2: AUGUST 8, 2003, WHEN VEHICLE WAS REPAIRED THE OWNER OF BUCCI'S AUTO BODY TOOK THE CAR IN THE PARKING LOT FOR A TEST DRIVE. AT ABOUT 15 MILES PER HOUR - WHEN BRAKES WERE APPLIED THE FRONT FREEZED UP AND THE BACK PUSHED FORWARD TO CREATE A LUNGE FORWARD EFFECT. I CONTACTED KIA MOTOR AMERICA IN IRVINE, CA AND HAVE A COMPLAINT FILE NUMBER. AFTER ABOUT 1 MONTH OF DOING NOTHING I DEMANDED, ON AUGUST 8TH, THAT THEY TOW THE CAR FROM THE BODY SHOP TO BOCH KIA (WHERE THE CAR WAS PURCHASED)AND CHECK OUT THE MASTER CYLINDER/PROPORTIONATE VALUE SYSTEM. THEY DID SO AND ON AUGUST 12TH I WAS TOLD THAT AN ENGINEER LOOKED AT THE CAR AND FOUND NOTHING WRONG. KIA REFUSES TO STAND ACCOUNTABLE AND ALLEDGES THAT THE VEHICLE HAS NO PROBLEM. I AM FORCED TO DRIVE A CAR THAT HAS BAD BRAKES UNTIL 2 MORE INCIDENTS HAPPEN IN ORDER TO PROCEED UNDER THE MASSACHUSETTS LEMON LAW. EVERY MODEL OF KIA IN 2002 HAS HAD HYDRAULIC AS WELL AS ABS BREAK FAILURE. SEEMS TO ME THAT KIA NEEDS TO REDESIGN THE BRAKING SYSTEM - OR - PERHAPS TRY THIS NEW TAG LINE IN ADVERTISING: KIA - BUY OUR CAR - JUST DON'T EVER HAVE TO STOP FAST!
Air bags, Nov 5, 2003, crash
PROBLEMS WITH AIR BAG EQUIPMENT ON 2002 KIA OPTIMA. *MR A LARGE PIECE OF RUBBER HAD COME OFF THE TIRE OF A SEMI-TRUCK AND WHEN THE CONSUMER TRIED TO AVOID HITTING IT, HE LOST CONTROL OF THE VEHICLE AND HIT A WALL DIVIDER. *SCC *JB
Service brakes, Hydraulic, Sep 1, 2003, crash, fire
FEB. 14, 2003, DRIVING A 2002 OPTIMA KIA AND APPLIED BRAKES HARD ABOUT 70 MPH AND CAR WAS COMPLETLY UNCONTROLLABLE SENDING ME OFF THE ROAD INTO VARIOUS TREES EVENTUALLY HITTING A TREE HEAD ON. CAR CAUGHT FIRE AND COMPLETELY BURNT DOWN. I WAS SENT TO A TRAUMA UNIT AT FOREST GENERAL IN HATTIESBURG MS WITH A PUNCTURED LUNG , SPLEEN REMOVED AND EXTREME DAMAGE TO THE RIBS WHICH I AM PRESENTLY IN PAIN MANAGEMENT FOR AND ON LTD. *AK
Service brakes, Hydraulic, Equipment, Jul 18, 2003, crash
WHILE SLOWING DOWN TO EXIT OFF MASS PIKE, I WAS DOING ABOUT 30-35 AND SO WERE THE OTHER CARS, I BRAKED TO CONTINUE TO SLOW - THE CAR DID NOT STOP AND APPLIED THE BRAKES ALL THE WAY DOWN AND THE CAR STILL DID NOT STOP AND I PANICKED KNOWING THE CAR WAS NOT STOPPING AND FINALLY MADE IMPACT INTO THE VEHICLE IN FRONT OF ME. *JB
Other or unspecified, Apr 22, 2003, crash, fire
JAN. 10TH- BRAKED TO AVOID ACCIDENT ON I-59 AT 70 MPH AND CAR WAS COMPLETELY UNCONTROLLABLE-RAN OFF I-59 AND COLLIDED WITH TREE FEB. 14- BRAKED AGAIN AT HIGH SPEED TO AVOID ACCIDENT AND CAR WAS UNCONTROLLABLE. HIT TREE AND ALMOST LOST LIFE. WOULD HAVE LOST LIFE HAD NOT SOMEONE PULLED ME FROM VEHICLE, VEHICLE CAUGHT FIRE AND BURNED DOWN COMPLETELY. *NLM
Air bags, Mar 10, 2003, crash
THE VEHICLE WAS INVOLVED IN A FRONTAL COLLISION, AND THE AIR BAGS DID NOT DEPLOY.*JB....*AK
Visibility, Nov 29, 2002
NO SUMMARY. DT
Tires, Nov 4, 2002
CONSUMER STATED THAT WHILE DRIVING AT ANY SPEED AND NO WARNING THE FRONT RIGHT TIRE HAVE TREAD SEPARATION CAUSING A TIRE BLOW OUT. DEALER NOTIFIED SIZE#LT26575R16. DOT# UNKNOWN. MR *TT