2003 Kia Optima
Problems, recalls and owner-reported issues
Latches/locks/linkages is the leading concern among 144 owner complaints filed for this model year. This is the 16th highest complaint count among 20 Optima model years with reports.
Of the 2003 reports, 8 involved a crash and 2 involved a fire. 6 people were injured.
What owners report most often
Recalls and investigations
Suspension, frontMay 27, 2009
KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE STATES DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING, OR ACCELERATED ABNORMAL TIRE WEAR.
CORROSION OF THE FRONT SUBFRAME COULD LEAD TO SEPARATION, POSSIBLY RESULTING IN A VEHICLE CRASH.
KMC WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 15, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Campaign 09V183000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 12, 2004
SOME PASSENGER VEHICLES MAY CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN JUNE 25, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
Campaign 04V180000 on NHTSA.gov
Representative owner complaints
144 reports, newest first.
Service brakes, Hydraulic, May 18, 2012, crash
I HAD PROBLEM WITH BRAKES LOCKING UP ON 2003 KIA OPTIMA, HAD IT AT A DEALERSHIP TO GET FIXED. THEY SAID THEY FIXED IT, BUT HAD SAME PROBLEM. THEY HAD IT TOWED, TOOK IT BACK TO FIX IT AGAIN, THEN PUT A GOVERNOR ON IT, SAID THE BRAKES WERE NOW FIXED. WELL, THIS EVENING, ENROUTE TO PICK MY DAUGHTER FROM THE DAYCARE FACILITY, I SAW TRAFFIC STOPPED, WENT TO SLOW UP BY APPLYING BRAKES AND GUESS WHAT? NO BRAKES! THIS DID NOT HAPPEN ALL THE TIME, BUT INTERMITTENTLY, NOW CAUSED ME TO HAVE AN ACCIDENT BECAUSE THE BRAKES DID NOT WORK! THE REPAIR SHOP AT THE DEALERSHIP IS THE ONE WHO SAID IT WAS ALL TAKEN CARE OF, HOWEVER, AS YOU CAN SEE , IT IS NOT TAKEN CARE OF AS THE BRAKES FAILED!! THE BRAKES DID NOT ENGAGE, I WAS GOING TO TRY TO GO IN THE LEFTHAND LANE OF THE TWO LANE HIGHWAY ON MY SIDE OF THE ROAD, HOWEVER THERE WAS A CAR ALREADY IN POSITION ON THAT SIDE AND THE CURB, GRASS AND THEN A PIZZA HUT ON MY RIGHT, LEAVING ME NO WHERE TO GO BUT UNDER THE BUMPER OF A PICK UP. IT PUSHED THE GRILL INTO THE RADIO, THEREFORE THE HOOD IS BUCKLED, THE BUMPER DESTROYED AND CAR WILL BE TOTALED BY THE INSURANCE COMPANY AS IT IS COST MORE TO REPAIR AS IT ALSO TORE OFF SIDE STRIP AND OTHER PARTS ON THE LEFT HAND SIDE OF THE CAR. THE LEFT HAND TURN SIGNAL BLINKS TWICE AS FAST AS IT SHOULD AS I CHECKED OUT EVERYTHING AS THE POLICE OFFICER SAID IT WAS DRIVABLE. I DROVE IT HOME VERY SLOWLY WITH MY DAD IN A CAR BEHIND ME TO MAKE SURE I DID NOT LEAK ANY FLUID AND ALSO TO MAKE SURE I GOT HOME ALRIGHT WITH MY 8 YEAR OLD DAUGHTER AFTER WE PICKED HER UP AT DAYCARE. THIS SHOULD NOT HAVE HAPPENED SO WHAT IS WRONG WITH THE 2003 BRAKES ON KIA OPTIMAS? IF THERE IS A RECALL ON THEM I NEED TO KNOW AS I AM TRYING TO FIND A WEBSITE FOR THEM AS I HAVE BEEN TOLD THERE HAVE BEEN BRAKE ISSUES ON KIAS FOR SEVERAL YEARS, ONE OF WHICH IS THE 2003 KIA OPTIMA. THANK YOU AHEAD OF TIME FOR YOUR PROMPT RESPONSE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Air bags, Latches/locks/linkages, Mar 26, 2012
DRIVERS SIDE DOOR LOCK LOCKS UNATTENDED, TRAPS DRIVER INSIDE CAR. CAN NOT OPEN WITH KEY OR SWITCH. SAFETY ISSUE. ALSO; AIR BAG SENSOR LIGHT ACTIVATED FOR THE SECOND TIME, HAS TO BE A DEFECT. *TR
Structure, Feb 26, 2012
THE DOOR HANDLE(S) ARE DEFECTIVE TO POINT WHERE EVEN THOUGH THE DOOR IS UNLOCKED, THE DOOR CANNOT BE OPENED. UPON TAKING IT TO A BODY SHOP, THE WORKERS INFORM ME THAT THIS COULD BE A SAFETY RECALL AND THAT I SHOULD CONTACT THE DEALER BEFORE DOING ANYTHING ELSE. THERE IS EVIDENCE THAT THIS IS NOT AN ISOLATED PROBLEM. A SIMPLE INTERNET SEARCH OF "2003 KIA OPTIMA DOOR STUCK" WILL SHOW THAT MILLIONS OF CONSUMERS ARE HAVING THIS PROBLEM. THIS IS A SERIOUS SAFETY HAZARD, WHEN THINKING IN TERMS OF AN ACCIDENT OR IF A PASSENGER NEEDS TO QUICKLY GET OUT OF THE CAR. I FEEL THAT KIA NEEDS TO ADDRESS THIS SITUATION. *TR
Latches/locks/linkages, Jan 6, 2012
TL* THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT STATED THAT SHE WAS UNABLE TO UNLOCK THE DRIVER SIDE DOOR. THE CONTACT STATED THAT SHE HAD TO EITHER CLIMB OUT THE WINDOW OR THE ONE OF THE OTHER DOORS IN ORDER TO EXIT THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE LOCKING SOLENOID WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 102,000 AND THE CURRENT MILEAGE WAS 106,000.
Structure, Latches/locks/linkages, Dec 26, 2011
PASSENGER SIDE DOOR DID NOT UNLOCK. THIS FORCED PASSENGER TO COME OUT FROM THE DRIVER SIDE DOOR. *TR
Latches/locks/linkages, Nov 5, 2011
PASSENGER SIDE DOOR LOCKS STARTED HAVING PROBLEMS OPENING APROX 6 MO. AGO. IT TAKES ABOUT 3 OR 4 TRIES TO GET THE DOOR TO OPEN IF YOU ARE USING THE KEY. IF YOU ARE JUST THE PASSENGER AND THE DRIVER OPENS THE DOOR FOR YOU WITH THE DRIVER SIDE DOOR LOCK IT MAY TAKE SEVERAL TRIES AS THE DOOR WILL AUTOMATICLY RELOCK BY ITSELF AND YOU WILL BE LOCKED OUT. ON 10/29/11 THE DRIVER SIDE DOOR STARTED TO HAVE ISSUES. I WENT TO GET INTO THE CAR AND IT TOOK ABOUT 20 TRIES TO OPEN THE DOOR. THE LOCK FELT VERY TIGHT AND WAS HARD TO TURN. I HAD TO FIGHT TO GET THE DOOR TO OPEN. I HAVE NEVER HAD A PROBLEM WITH THE DRIVER SIDE LOCKING SYSTEM. ONCE I GET INTO THE CAR, I WAS CONFUSED BUT DIDN'T THINK ANYTHING OF IT AFTER THAT AND DROVE TO MY DESTINATION, WHEN I TRIED TO GET OUT OF THE CAR I COULDN'T. I WAS LOCKED IN THE CAR. IT TOOK TEN MINUTES TO WITH ME FIGHTING WITHT THE LOCKS TO GET OUT OF THE CAR. I ONLY GOT OUT BY MY DAUGHTER GETTING OUT THROUGH THE PASSENGER DOOR AND TAKING THE KEYS TO FIGHT WITH THE DRIVER SIDE LOCK. I HAVE MY CAR NOW SCHEDULED TO BE FIXED AT THE KIA DEALERSHIP ON 11/7/11. *TR
Structure, Nov 4, 2011
TL* THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT STATED THAT WHEN ATTEMPTING TO OPEN THE DRIVER SIDE DOOR, THE VEHICLE WOULD LOCK BEFORE THE DOOR COULD BE OPENED. IN ADDITION, THE DRIVER SIDE DOOR COULD NOT BE OPENED FROM INSIDE THE VEHICLE AND THE CONTACT HAD TO EXIT THE VEHICLE THROUGH THE PASSENGER SIDE DOOR. THE VEHICLE WAS NOT TAKEN TO A DEALER OR A MECHANIC FOR INSPECTION OR REPAIRS. THE FAILURE MILEAGE WAS 136,000.
Latches/locks/linkages, Oct 25, 2011
TL* THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT STATED THAT THE DRIVER SIDE DOOR LOCK WAS INOPERABLE AND THE CONTACT WAS UNABLE TO ENTER OR EXIT THROUGH THE DRIVER SIDE DOOR. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 44,000.
Service brakes, Hydraulic, Sep 20, 2011, fire
TL* THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT STATED THAT SHE SMELLED SMOKE WHEN SHE APPLIED PRESSURE TO THE BRAKES. SHE ATTEMPTED TO ACTIVATE THE EMERGENCY BRAKE SYSTEM, BUT IT FAILED AND DID NOT ACTIVATE. THE DEALER INSPECTED THE VEHICLE AND INFORMED THE CONTACT THAT THE REAR END OF THE VEHICLE WAS RUSTED TO INCLUDE THE BRAKE HOUSING UNIT. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE NOR WAS THE VEHICLE REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 69,000.
Latches/locks/linkages, Sep 8, 2011
THE FRONT DRIVER AND PASSENGER DOOR LOCKS ARE DEFECTED. WHEN I PUSH THE AUTOMATIC SWITCH TO UNLOCK THE DOORS, THE DRIVER SIDE DOOR STAYS LOCKED AND HAVE TO PUSH IT ON AND OFF A FEW TIMES FOR THE PASSENGER SIDE DOOR TO UNLOCK. I TOOK MY CAR TO A KIA DEALER FOR A DIAGNOSIS AND WAS GIVEN AN ESTIMATE OF $807.00 FOR BOTH DOOR LOCK LATCHES. I STILL HAVE NOT HAD IT FIXED, BEING THAT I CANNOT AFFORD IT RIGHT NOW, SO NOW I HAVE TO GET IN AND OUT THROUGH THE PASSENGER SIDE DOOR. I RESEARCHED THIS PROBLEM ONLINE AND DISCOVERED THAT THERE ARE SIMILAR COMPLAINTS WITH THE SAME CAR MAKE AND MODEL. THE DOOR LOCK LATCH SHOULD BE RECALLED AND REPAIRED BY KIA. ARE THERE ANY NEW SOLUTIONS TO THIS PROBLEM? PLEASE LET ME KNOW.... *TR
Electrical system, Latches/locks/linkages, Jul 18, 2011
POWER DOOR LOCKS RE-LOCK AFTER YOU UNLOCK THEM AND PULL ON THE DOOR HANDLE TO OPEN THE DOOR. THIS CAN EITHER TRAP YOU IN YOUR CAR, OR TRAP YOU OUT. YOU HAVE TO GO AROUND TO THE OTHER SIDE, BUT CRAWLING OVER THE CENTER CONSOLE TO THE DRIVER'S SIDE IS ALMOST IMPOSSIBLE. HAD THE SWITCH AND ACTUATOR REPLACED ON THE DRIVER'S SIDE. ABOUT A YEAR LATER, THE SAME THING HAPPENED WITH THE PASSENGER SIDE DOOR. KIA DOESN'T SEEM TO CARE SINCE IT GETS THEM OVER $300 WORTH OF BUSINESS EACH TIME. *KB
Electrical system, Other or unspecified, Jul 11, 2011
POWER LOCKS INSTANTLY LOCK AFTER UNLOCKING,(OVER AND OVER) PROHIBITING ME AND MY PASSENGERS TO ENTER OR EXIT THE VEHICLE. IT SOMETIMES TAKES 5-10 MINUTES OF TRYING TO UNLOCK THAT THEY WILL FINALLY STAY UNLOCKED ALLOWING ACCESS. I HAVE A TODDLER AND A BABY ON THE WAY. IF THERE WERE TO BE AN ACCIDENT OR A FIRE, I COULD ONLY IMAGINE BEING TRAPPED INSIDE.
Latches/locks/linkages, Jul 1, 2011
POWER DOOR LOCKS INSTANTLY LOCK AFTER UNLOCKING CONTINUOUSLY, PROHIBITING ENTRY OR EXIT TO THE VEHICLE. THIS POSES A SAFETY HAZARD IF THERE WERE TO BE AN ACCIDENT LOCKING ME AND MY CHILDREN INSIDE THE VEHICLE. SOMETIMES IT TAKES 5-10 MINUTES TO GET IN OR OUT OF THE CAR TRYING TO CATCH THE DOOR HANDLE AT JUST THE RIGHT TIME TO BE ABLE TO OPEN IT. *TR
Latches/locks/linkages, Jun 17, 2011
ONCE YOU LOCK THE DOORS ON A 2003 KIA OPTIMA, YOU CANNOT UNLOCK FROM EITHER THE INSIDE OR OUTSIDE FOR LONG PERIODS OF TIME. IF YOU KEEP LOCKING AND UNLOCKING FROM INSIDE, THEY WILL EVENTUALLY STAY UNLOCKED. VERY UNSAFE IF YOU NEED TO GET OUT OF CAR QUICKLY. *TR
Structure, Latches/locks/linkages, Jun 16, 2011
OWNER OF 2003 KIA OPTIMA - DRIVER DOOR WON'T OPEN FROM INSIDE OUR OUTSIDE. OWNER MUST USE PASSENGER DOOR TO GAIN ACCESS TO VEHICLE. EXTERIOR DOOR HANDLE SEEMS LOOSE. UNABLE TO OPEN DOOR TO REMOVE DOOR PANEL. *TR
Structure, Mar 15, 2011
TL*THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT STATED THAT THE DRIVERS SIDE DOOR WOULD NOT OPEN OR CLOSE. THE DEALER INFORMED THE CONTACT THAT SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY THAT THEY WOULD NOT BE ABLE TO PROVIDE HER WITH ANY ASSISTANCE. THE MANUFACTURER ADVISED THE CONTACT THAT IF SHE REPAIRED HER VEHICLE AND A RECALL WAS LATER ISSUED THAT SHE WOULD BE ENTITLED TO A REFUND. THE VEHICLE WAS AWAITING REPAIRS. THE CURRENT MILEAGE WAS 127,000. THE FAILURE MILEAGE WAS 126,000. UPDATED 05/03/11*LJ UPDATED 05/11/11
Latches/locks/linkages, Feb 6, 2011
DOOR LOCKS STOP WORKING ,CAN'T OPEN THE CAR. *TR
Latches/locks/linkages, Feb 3, 2011
TL* THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT STATED THAT SHE BECAME LOCKED INSIDE OF THE VEHICLE AND WAS UNABLE TO EXIT. THE LOCKS HAD MALFUNCTIONED AND SHE HAD TO EXIT THE VEHICLE BY CRAWLING OUT OF THE WINDOW. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE PERSISTED FOR TWO YEAR BEFORE THE DEALER WAS CONTACTED. THE DEALER REFERRED HER TO THE MANUFACTURER AND THE MANUFACTURER AGREED TO ASSIST WITH REPAIRING THE LOCKS FOR THE DRIVER SIDE DOOR ONLY. THE CONTACT STATED THAT ALL FOUR DOOR LOCKS WERE AFFECTED BY THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE CURRENT MILEAGE WAS 73,442 AND FAILURE MILEAGE WAS UNKNOWN.
Power train, Latches/locks/linkages, Jan 24, 2011
TL*THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT STATED THAT THE DOOR LATCHES ON BOTH THE DRIVER AND PASSENGER SIDE WERE NOT FUNCTIONING PROPERLY; THE CONTACT WAS UNABLE TO OPEN THE DOORS TO GET IN OR OUT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE LATCHES NEEDED TO BE REPLACED. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT SHE WOULD BE RESPONSIBLE FOR REPAIR COSTS. THE CONSUMER ALSO STATED THE CV JOINTS NEEDED TO BE REPLACED, BUT THE PARTS WERE NOT AVAILABLE. UPDATED 02/16/11 UPDATED 3/8/11 *CN
Exterior lighting, Latches/locks/linkages, Jan 3, 2011
TL* THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT STATED THAT THE PASSENGER DOORS WOULD NOT UNLOCK FROM THE INTERIOR OR EXTERIOR OF THE VEHICLE. THE ONLY WAY TO EXIT FROM THE VEHICLE WAS TO CLIMB OUT FROM THE OPPOSITE SIDE. THE CONTACT ALSO STATED THAT THE HEADLIGHTS WOULD FAIL INTERMITTENTLY. THE VEHICLE WAS NOT INSPECTED BY THE DEALER NOR WAS IT REPAIRED FOR THE FAILURES. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 180,000.
Latches/locks/linkages, Dec 15, 2010
TL*THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT STATED THAT THE FRONT PASSENGER AND DRIVER SEAT DOORS REMAINED LOCKED WITHOUT A WARNING. THE DEALER WAS NOTIFIED AND ADVISED HIM THAT THERE WAS AN ELECTRICAL DEFECT. THE CONTACT DID NOT INFORM THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 120,000. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. THE VIN WAS UNAVAILABLE.
Structure, Latches/locks/linkages, Dec 13, 2010
DRIVER'S DOOR WON'T OPEN. FAILED IN SHUT POSITION. *TR
Latches/locks/linkages, Nov 15, 2010
TL* THE CONTACT OWNS 2003 KIA OPTIMA. THE CONTACT STATED THAT THE DRIVER AND PASSENGER DOOR LOCKS FAILED AND THE CONTACT WAS UNABLE TO UNLOCK THE DOORS FROM THE INSIDE OR USE THE KEY TO OPEN THE DOORS FROM THE OUTSIDE OF THE VEHICLE. THE CONTACT HAD TO CLIMB INTO THE DRIVER SEAT FROM THE REAR IN ORDER TO ENTER AND EXIT THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO BE DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 66,196. UPDATED 01/31/11 *BF THE CONSUMER STATED THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS ON NOVEMBER 17, 2010. HOWEVER, THE DOORS WERE STILL LOCKING ON THEIR OWN. UPDATED 03/11/11
Latches/locks/linkages, Oct 11, 2010
2003 KIA OPTIMA DRIVER SIDE DOOR LOCKED AND WON'T UNLOCK. CANNOT OPEN DOOR AND I'M LOCKED IN VEHICLE. MUST CLIMB THROUGH WINDOW OR PASSENGER SIDE. KEY WILL NOT UNLOCK DRIVERS DOOR. I CANNOT LOCK THE REST OF THE DOORS TO VEHICLE IN FEAR I WILL BE LOCKED IN OR OUT FOR GOOD. *TR
Engine and engine cooling, Sep 7, 2010
TL*THE CONTACT OWNS A 2003 KIA OPTIMA. WHENEVER THE CONTACT ATTEMPTED TO USE THE AIR CONDITIONER HE NOTICED THAT THE VEHICLE BEGAN TO RUN HOT WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE RADIATOR AND TUBING WERE REPLACED ; HOWEVER, 2 WEEKS AFTER THE REPAIR THE CONTACT CONTINUED TO EXPERIENCE THE FAILURE. THE FAILURE MILEAGE WAS 89000 AND THE CURRENT MILEAGE WAS 90000.