2011 Kia Optima
Problems, recalls and owner-reported issues
Engine is the leading concern among 593 owner complaints filed for this model year. This is the 5th highest complaint count among 20 Optima model years with reports.
Of the 2011 reports, 23 involved a crash and 33 involved a fire. 19 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/modulePark outsideSep 25, 2023
Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.
An engine compartment fire while parked or driving can increase the risk of injury.
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed November 14, 2023. Owner notification letters were mailed March 29, 2024 through June 18, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC284.
Campaign 23V652000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Air bags, air bag/restraint control moduleJun 1, 2018
Kia Motors America (Kia) is recalling certain 2010-2013 Kia Forte, Forte Koup, 2011-2013 Kia Optima and 2011-2012 Kia Optima Hybrid and Sedona vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags and seat belt pretensioners from deploying.
If the frontal air bags and seat belt pretensioners are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Kia will notify owners. For model year 2011 Sedona vehicles, Kia will instruct dealers to verify the ACU part number and, if necessary, install an extension wire harness kit between the ACU Connector and the Vehicle Harness Connector. For all other affected vehicles, Kia will instruct dealers to install the extension wire harness kit. The recall began September 28, 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC165.
Campaign 18V363000 on NHTSA.gov
Engine and engine cooling, engineMar 31, 2017
Kia Motor Company (Kia) is recalling certain 2011-2014 Optima, 2012-2014 Sorento and 2011-2013 Sportage vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine.
Bearing wear may result in the engine seizing, increasing the risk of a crash.
Kia will notify owners, and dealers will inspect the engine assembly, and replace the engine if necessary, free of charge. The recall began June 20, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC147.
Campaign 17V224000 on NHTSA.gov
Exterior lighting, brake lights, switchApr 1, 2013
Kia Motors Corporation (Kia) is recalling certain model year 2007-2010 Rondo, model year 2007-2011 Sedona, Sorento and Sportage, model year 2010-2011 Soul, model year 2008-2011 Optima, model year 2010 Forte, model year 2007-2009 Amanti, and model year 2009 Borrego vehicles. Originally, in April 2013, Kia recalled 623,658 model year 2007-2010 Rondo and Sportage, model year 2007-2011 Sorento, model year 2007 Sedona, model year 2010-2011 Soul, and model year 2011 Optima vehicles. In September 2013, Kia informed the agency that it was adding an additional 356,719 vehicles to this campaign. The total number of vehicles being recalled is now 980,377. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake-transmission shift interlock feature preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of PARK without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Kia will send an interim notification to owners in May 2013. When parts are available, owners will receive a second notification and dealers will replace the stop lamp switch, free of charge. Owners may contact Kia at 1-800-333-4542. Kia's recall campaign number is SC098.
Campaign 13V114000 on NHTSA.gov
Representative owner complaints
593 reports, newest first.
Exterior lighting, Other or unspecified, Jun 23, 2020
SO ONE OF THE KIA DEALERS IN THE STATE OF MAINE REPLACED THE MOTOR IN OUR 2011 OPTIMA, EVER SINCE THEN OUR AIR CONDITIONING SYSTEM HAS NOT BEEN WORKING. I'VE HAD IT TESTED AND RECHARGED. STILL NO ACC. I HAVE DIAGNOSED NO POWER TO THE AC PUMP. ALSO THE HEADLIGHTS HAVE NEW BULBS IN LOW BEAM AND ARE DIM..?? *TR
Exterior lighting, Jun 21, 2020
2011 KIA OPTIMA WAS PURCHASED IN 2014 WITH LOW HEADLIGHT BEAMS OUTPUT, HAS SINCE DETORIATED TO ALMOST NON EXISTENT. HAVE REPLACED HEADLIGHT BULBS SEVERAL TIMES TRYING TO IMPROVE LIGHT QUALITY AND HAS NOT RESOLVED THIS ISSUE IN ANY WAY. HAD PLANNED ON KEEPING THIS CAR FOREVER AS I HAVE REPLACED THE ENGINE ONCE ALREADY BUT I'M AT A LOSS, U SIMPLY CAN NOT SAFELY DRIVE THIS VEHICLE AT NIGHT! SO UPON RESEARCH I FOUND THIS IS A VERY BIG AND COMMON PROBLEM FOR KIA OWNERS. CLEARLY IT IS A SAFETY ISSUE, BUT THERE HAS BEEN NO SERVICING OR RECALLS OFFERED TO CORRECT THIS FOR US DRIVERS. WITH THE SUGGESTED RESOLUTION FOR THIS PROBLEM BEING A NEW HOUSING/ASSEMBLY AT $1,000 OR MORE THAT IS COMPLETELY NOT A FEASIBLE RESOLUTION TO BE ACHIEVED FINANCIALLY BY WAY OF THE AVERAGE DRIVER AS THOSE REPAIRS ARE WAY TO COSTLY, KIA SHOULD HAVE ALREADY JUMPED IN AND OFFERED SOME SAFETY RECALLS! ALSO WORTH NOTING, I HAVE CHANGED THE HEADLIGHTS MANY TIMES JUST DO TO THEM BURNING OUT, NOT SURE IF THAT IS BECAUSE OF WHATEVER UNDERLYING PROBLEM THERE IS FOR THESE LIGHTS INITIALLY OR MAYBE BECAUSE OF AFTERMARKET LIGHTS, ETC. PLEASE PLEASE ADDRESS THIS ISSUE SOON!! MY REGARDS, *COMPLAINT FORM ASKS IS THERE WAS A CRASH WITH ONLY YES OR NO OPTIONS TO ANSWER AS. THERE NEEDS TO BE AN ADDED FIELD WITH "THERE IS GOING TO BE"!
Steering, Engine, Jun 18, 2020
STEERING WHEEL HAS A CLICKING NOISE AND A PLAY. ALSO ENGINE LIGHT COMES ON AND OFF. *TR
Engine, Jun 15, 2020
THE MOTOR SEIZED UP WHILE DRIVING. NO LIGHTS CAME ON. CHECKED OIL THAT HAD METAL SHAVINGS IN THE OIL. WE HAVE BEEN DOING REGULAR OIL CHANGES ON THE VEHICLE. IT WILL NO LONGER RUN. *TR
Vehicle speed control, Electronic stability control (ESC), Service brakes, May 29, 2020, crash
KIA OPTIMA 2011 TOOK A TURN FOR THE WORST ON JULY 2 2018, MY KIA OPTIMA CAUSED ME TO PLUMMET INTO TRAFFIC AFTER MY BRAKE DIDN'T PERFORM L. THAT'S CAR HAD BEEN TAKEN TO KIA FOR ALL SERVICE NEED AND CAR STILL PERFORM POORLY. HAVE TO RESTART MY CAR MULTIPLE TIME JUST FOR IT TO ACT RIGHT. CAR STOPS ONE ME IN THE MIDDLE OF THE STREET ONE DAY. I HAVE A 3 OLD AND THAT DAY SHE COULD HAVE BEEN WITH ME. I LOST MY LICENSE AND MY MONEY I INVESTED FOR A SAFE CAR FOR ME AND MY CHILD. *TR
Engine, Fuel/propulsion system, May 28, 2020
THE FUEL INJECTOR REQUIRED REPLACEMENT. THE CAR SPUTTERED AND CAME TO A COMPLETE STOP WITHOUT WARNING. IT SPUTTERED WHILE DRIVING ON THE HIGHWAY; IT CAME TO A COMPLETE STOP AT THE MOMENT THAT I MOVED ONTO THE EXIT RAMP. THE DEALERSHIP PERFORMED A FULL DIAGNOSTIC AND REPORTED THAT THE FUEL INJECTOR REQUIRED REPLACEMENT. WHILE REPAIRING THE INJECTOR, THE MECHANIC REPORTED THAT THE CATALYTIC CONVERTER WAS DAMAGED DUE TO THE INJECTOR LEAKING AND CLOGGING THE CONVERTER. NO CODES ALERTED MYSELF, OR THE MECHANIC TO THESE ISSUES. THE MECHANIC REPORTED THAT NEITHER ISSUE WAS COVERED UNDER THE ENGINE RECALL. *TR
Exterior lighting, May 28, 2020
THE LOW BEAMS ON THIS CAR ARE ALMOST NON EXISTENT. I HAVE TO DRIVE WITH MY HIGH BEAMS ON TO SEE ANYTHING IN FRONT OF THE CAR. IT'S SO BAD THAT WHEN A CAR IS BEHIND ME THERE IS THE SHADOW OF MY CAR FROM THE HEADLIGHTS BEHIND ME. I BROUGHT TO THE GARY ROME KIA IN JANUARY WHO TOLD ME IT WASN'T COVERED UNDER THE LIFETIME HEADLIGHT WARRANTY BECAUSE THE FOIL IN HEADLIGHT HOUSING IS INTACT. IT IS A MAJOR HAZARD AND I DON'T KNOW WHAT TO DO. I HAVE HAD THIS PROBLEM SINCE I BOUGHT THE CAR BUT IS GETTING PROGRESSIVELY WORSE. CAR HAS 109K ON IT.*DT*LN *TR THE CONSUMER SUBMITTED A PHOTO OF THE VEHICLE WITH THE DIM LIGHTS. THE CONSUMER STATED MINIMIZES DRIVING AT NIGHT OR IF DRIVING SHE WOULD HAVE TO USE THE HIGH BEAMS IN ORDER TO SEE AT NIGHT. *TR
Engine and engine cooling, Engine, May 15, 2020
TL* THE CONTACT OWNS A 2011 KIA OPTIMA. THE CONTACT STATED AFTER MAKING A COMPLETE STOP, THE ACCELERATOR PEDAL WAS DEPRESSED AND THE VEHICLE STARTED TO JERK. THE VEHICLE STALLED WITH SEVERAL UNKNOWN WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THEY DIAGNOSED THE VEHICLE WITH COMPLETE ENGINE FAILURE. THE CONTACT SPOKE WITH STOKES KIA (202 S GOOSE CREEK BLVD, GOOSE CREEK, SC 29445) WHERE SHE WAS INFORMED THAT THE VEHICLE WAS INCLUDED IN THE NHTSA CAMPAIGN NUMBER: 17V224000 (ENGINE AND ENGINE COOLING) HOWEVER, THE REMEDY WAS A FOUR STEP PROCESS. SHE WAS INFORMED THAT A DIAGNOSTIC TEST NEEDED TO BE PERFORMED ON VEHICLE TO DETERMINE WHETHER SHE WOULD BE ELIGIBLE FOR AN ENGINE REPLACEMENT UNDER THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 170,000.
Exterior lighting, May 9, 2020
DRIVING AT NIGHT HAS BEEN NEAR IMPOSSIBLE. I HAVE GONE TO TWO DIFFERENT DEALERSHIPS WITH NO RESULTS. THERE WAS A RECALL, BUT THE DEALERSHIP SAID MY CAR DID NOT SHOW SIGNS FOR THE RECALL. *TR
Other or unspecified, May 4, 2020
I WAS ON A CURVY BACK ROAD DOING ABOUT 45MPH APPLYING THE BREAKS NOT TO STOP BUT ONLY TO BREAK MY SPEED DOWN SOME IN ORDER TO GO AROUND THE CURVE. WHILE DOING SO MY STEERING WHEEL LOCKS UP, IT FEEL AS IF MY TIRES ARE SLIDING & IT FEELS LIKE MY BREAKS COULD BE LOCKED UP AS WELL. THE NEXT DAY I WAS GETTING OFF OF THE INTERSTATE ON A RAMP AND AGAIN APPLIED MY BRAKES TO BREAK MY SPEED DOWN AND THE EXACT SAME THING HAPPEN. MY WHEEL LOCKED UP, FELT AS IF MY BRAKES WERE LOCKED UP AS WELL & MY TIRES MAY HAVE SLID. I'M NOT NOTICING OF MY CAR IS SHUTTING OFF BECAUSE WHEN IT IS HAPPENING I'M TOO FOCUSED ON THE ROAD & NOT LOSING CONTROL. BUT I AM NOTICING THAT MY RADIO IS BOOTING UP. WHICH IT ONLY DOES THIS WHEN I START UP MY ENGINE.
Exterior lighting, Engine, Fuel/propulsion system, Apr 21, 2020
MY CAR HAVE LOT OF PROBLEMS IN SIDE
Exterior lighting, Apr 7, 2020
DIM HEADLAMPS DUE TO DETERIORATING REFLECTIVE COATING ON LOW BEAM HOUSING. *TR
Engine, Mar 10, 2020
WAS DRIVING TO WORK. DROVE THROUGH THE FRONT GATE ENTRANCE TO MY STATION WHEN AN AWFUL METALLIC KNOCKING NOISE COULD BE HEARD IN THE ENGINE COMPARTMENT. HAD TO HAVE THE VEHICLE TOWED ALL THE WAY HOME THAT DAY. 80+ MILES. TURNS OUT I NEED A NEW ENGINE. TOOK IT TO A KIA DEALER WHO DIAGNOSED THE PROBLEM BEING A FAILURE TO A CRANK BEARING.
Engine, Feb 19, 2020
CAR DRIVING AT HIGHWAY SPEED. SUDDEN LOSS OF POWER. NO CRANK, NO START. MECHANIC SAYS THE ENGINE HAS SEIZED.
Engine, Feb 13, 2020
TL* THE CONTACT OWNS A 2011 KIA OPTIMA. THE ENGINE SEIZED THE VEHICLE NEVER STARTED AGAIN, NOT DIAGNOSED YET CONSEQUENCE VEHICLE MUST BE TOWED AT OWNERS EXPENSE THE CONTACT STATED THAT WHILE ATTEMPTING TO PARK IN A PARKING LOT , TRAVELING APPROXIMATELY 5 MPH, THE VEHICLE ENGINE SEIZED. NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO THE RESIDENCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSIS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A CASE WAS FILED AND WAS ADVISED TO TOW THE VEHICLE TO THE NEAREST AUTHORIZED DEALER. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 174,000.
Structure, Wheels, Feb 5, 2020
WILL PRODUCE PHOTO FROM BODY SHOP WHEN CALLED.
Power train, Feb 4, 2020
TRANSMISSION IS SOMETIME SHIFTING ABRUPTLY, & ALSO SLOW TO UP SHIFT GEARS.
Exterior lighting, Jan 28, 2020
PROBLEM WITH KIA DOOR SENSOR LIGHT STAYING ON WHEN ALL DOORS ARE SHUT TIGHT. I'VE GOTTEN (3) THREE JUMPS AND PURCHASED A NEW BATTERY BECAUSE THIS SENSOR IS DRAINING MY BATTERY. WHEN THE SENSOR IS ON IT WON'T ALLOW ME TO SECURE THE CAR. IF I USE THE CLICKER IT WON'T LOCK BECAUSE THE SENSOR LIGHT IS ON. I NEVER KNOW WHEN I GO TO THE CAR IF IT WILL ACTUALLY START OR NOT. I'M TRYING TO GET THE DEALERSHIP TO UNPLUG THE SENSOR. HAD TO CALL TOW TRUCK ON: JAN 1, JAN 17 AND JAN 19
Exterior lighting, Jan 27, 2020
THE LOW BEAM HEADLIGHTS HAVE CONTINUOUSLY BECOME DIMMER OVER TIME. AFTER REPLACING THE BULBS A SECOND TIME, I DETERMINED THAT IT WAS CLEARLY NOT A BULB ISSUE. THERE WAS ABSOLUTELY NO LIGHT DIRECTLY IN FRONT OF THE CAR, ONLY TO THE SIDES. THE HIGH BEAMS ARE FINE. AFTER READING ON LINE THOUSANDS OF COMPLAINTS, I TOOK MY CAR TO A DEALER. BULLDOG KIA IN ATHENS, GA TOLD ME THAT THERE WAS IN FACT A SERVICE ISSUE (SHE WOULD NOT SAY RECALL), BUT BECAUSE NOTHING IN MY HEADLIGHT ASSEMBLY WAS "BROKEN OR CRACKED" THEY COULDN'T REPLACE IT. AND SINCE I DIDN'T BUY THE BULB FROM KIA, THAT WAS THE PROBLEM. I PURCHASED THE EXACT BULB RECOMMENDED FOR THIS YEAR, MAKE AND MODEL. KIA WAS GOING TO CHARGE ME $1,000 TO REPLACE THE HEADLIGHT ASSEMBLIES. THE NEW ASSEMBLIES WOULD BE EXACTLY THE SAME AS THE ONES THAT ARE CURRENTLY BAD. NOTHING HAS BEEN CHANGED! IF YOU LOOK AT ANY KIA OPTIMA ON THE ROAD THAT IS MORE THAN 3 OR 4 YEARS OLD, YOU WILL SEE THE SAME DARK AREA IN FRONT OF THE CAR, WITH A LOT OF LIGHT SHOOTING OUT TO THE SIDES. SINCE THIS IS MY DAUGHTERS CAR FOR COLLEGE, I PURCHASED NEW HEADLIGHT ASSEMBLIES ON LINE FOR $285 AND REPLACED THEM MYSELF AND USED LED BULBS TO PREVENT THE "BURNING" OF THE CHROME PLATING INSIDE THE ASSEMBLY THAT APPARENTLY CAUSE THE OTHERS TO GO BAD. THIS IS A TREMENDOUS SAFETY HAZARD. ANYONE WHO REPLACES THE BULB THINKS THAT THEY ARE FIXING THE PROBLEM, AND THEREFORE ARE DRIVING IN INADEQUATE LIGHTING. PLEASE, PLEASE DO SOMETHING TO FORCE KIA TO RECALL AND REPLACE THESE HEADLIGHT ASSEMBLIES BEFORE NEEDLESS ACCIDENTS HAPPEN CAUSING INJURY OR DEATH. MY DAUGHTER WAS OVERWHELMED BY THE ADDITIONAL VISION THAT SHE NOW HAS WITH HER NEW LED LIGHTS. SHE ONLY TOLD ME BECAUSE SHE HAD FRIENDS THAT DIDN'T FEEL SAFE RIDING IN HER CAR AT NIGHT. SO SHE BROUGHT IT TO MY ATTENTION. I AM APPALLED THAT KIA IS AVOIDING THIS MAJOR ISSUE. PLEASE TAKE ACTION ASAP. THANK YOU.
Exterior lighting, Jan 22, 2020
HEADLIGHTS ARE TOO DIM. USING LOW BEAM LIGHTS AT NIGHT DOES NOT ILLUMINATE THE ROAD AT ALL. HAVE REPLACED THE HEADLIGHT BULBS 3 TIMES AND IT DOES NOT FIX THE PROBLEM.
Electrical system, Air bags, Fuel/propulsion system, Jan 20, 2020
HI MY CAR HAS LOT OF SAFETY ISSUES.. I TOOK MANY TIMES TO KIA DEALER IN JERSEY CITY MY CAR DOOR GETS UNLOCKED WHILE IT'S IN DRIVING MODE WHICH MAKES ME FEEL UNSAFE I TOLD SO MANY TIMES TO THE DEALERS TO FIX IT THEY DO SOME TEMPORARY THINGS IN MY CAR AND THEY LIVE ME BUT AGAIN AFTER SOME DAYS THAT PROBLEM IS ARISING AGAIN... I AM FED UP WITH THIS SITUATION AS I AM THE SECOND OWNER OF THE CAR...
Engine, Jan 16, 2020
DRIVING IN HEAVIER THAN NORMAL TRAFFIC ABOUT 45 MPH. STOPPED AT A TRAFFIC LIGHT AND ENGINE CUT OFF. WAS ABLE TO RESTART, BUT WAS ONLY ABLE TO DRIVE LESS THAN HALF A MILE BEFORE THE ENGINE CUT OFF AGAIN. I COMPLETELY LOST POWER, BUT WAS ABLE TO COAST INTO A PARKING LOT. I WAITED APPROXIMATELY 10 MINUTES, ATTEMPTED TO RESTART THE CAR (SUCCESSFULLY!) AND DROVE AROUND THE PARKING LOT BEFORE TRAVELING THE REMAINING 20 MINUTES HOME. CALLED AAA AND HAD THE CAR TOWED UPON ARRIVING HOME. THE MECHANIC WAS NOT ABLE TO REPLICATE THE ISSUE AND NOTHING WAS CORRECTED. BATTERY AND ALTERNATOR WERE IN PERFECT CONDITION. CAR HAS OCCASIONALLY BEEN HESITATING WHILE STARTING OR WHILE IDLING AT TRAFFIC LIGHTS SINCE THAT EVENT.
Engine, Jan 15, 2020
WAS DRIVING DOWN AND SUDDENLY THE CAR STARTS TO SLOW DOWN AND EVENTUALLY CUTS OFF. FOUND OUT THE ENGINE LOCKED EVEN THOUGH I GET THE RECOMMENDED MAINTENANCE.
Electrical system, Jan 15, 2020
TL* THE CONTACT OWNS A 2011 KIA OPTIMA. THE CONTACT STATED THAT WHILE HER FATHER WAS DRIVING AT 70 MPH, THE VEHICLE SHUT OFF COMPLETELY WITHOUT WARNING. THE CONTACT'S FATHER STATED THAT THE VEHICLE HAD MADE ABNORMAL NOISES PRIOR TO THE FAILURE. THE CONTACT WAS ABLE TO PULL OFF TO SIDE OF THE ROAD AND HAD TO HAVE THE VEHICLE TOWED TO THEIR HOME DUE TO VEHICLE NOT RESTARTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REQUESTED THAT THE CONTACT PAY FOR A TOW TO A LOCAL DEALER TO HAVE THE VEHICLE INSPECTED; THE CONTACT REFUSED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 145,362.
Air bags, Other or unspecified, Engine, Jan 6, 2020
I HAVE A THETA II TURBOCHARGED ENGINE 6 SPEED MANUAL AND I WAS DRIVING DOWN THE STREET TAKING MY SON TO WORK. ALL OF A SUDDEN MY CAR STARTED MAKING A LOUD KNOCKING NOISE AND WOULDN'T GO PAST 2ND GEAR. WE CALLED A TOW TRUCK HAD IT SENT TO MECHANIC THEY DID A DIAGNOSTIC TEST AND 2 P CODES CAME BACK FROM CRANKSHAFT AND CONTROLS AND SEIZED ENGINE. SO I HAD IT TOWED INTO WESTON KIA DEALERSHIP. PLUS I HAD JUST BOUGHT THIS CAR IN APRIL. THE DEALERSHIP SHIP CALLED ME SAYING THEY WERE GOING TO REPLACE MY ENGINE AND WIRING AND COMPUTER AND SENSOR CHIP. ALSO MY PASSENGER AIR BAG LIGHT HAS BEEN BLINKING OFF 3 DAYS AFTER I BOUGHT IT AND STILL IS. MY EMERGENCY BRAKE DOESN'T WORK AND ROLLED WHILE IT WAS PULLED UP IN NEUTRAL AND HIT MY DAUGHTER AS SHE WAS RUNNING AROUND THE FRONT OF THE CAR TO THE PASSENGER SIDE RIGHT IN HER KNEE CAP. I GOT MY CAR BACK FROM WESTON AND IT DIDN'T FEEL RIGHT. SOMEONE PUT 380MILES ON MY CAR IT HAD A 1/2TANK OF GAS AND MY CLUTCH AND CLUTCH PEDAL AND GEAR SHIFT WAS WAY SHORTER AND 1/4 INCH OFF IN SHIFTER BOX. I WAS ON THE FREEWAY DRIVING 60 MPH WITH MY KIDS AND WE WERE LEAVING MY PARENTS HOUSE FROM XMAS. ALL OF A SUDDEN I ALMOST LIST CONTROL OF THE CAR MY CLUTCH PEDAL FELL TO THE FLOOR. I GOT US TO SAFETY ALMOST AVOIDING A HUGE WRECK AND HAD IT TOWED TO MY HOUSE. CALLED DEALERSHIP AND TOLD THEM AND HAD NOTICED ON INVOICE THEIR TECHNICIANS HAD TIGHTENED UP BY BOLTS AND FLYWHEEL. WELL I GO OUTSIDE AND THEIRS FLUID ALL OVER THE PAVEMENT UNDER THE CAR BUT NONE ON INSIDE. THEY PAID FOR A TOW TRUCK AND BY THE WAY SINCE REPLACING THE NEW ENGINE I WENT FROM 34 MILES TO THE GALLON TO 20 AND PASSENGER AIR BAG STILL ILLUMINATED OFF. MY DEFROST ISNT WORKING NOW AND MY ENGINE LIGHT BLINKED 3XS. THEY WANT ME TO PAY 1500 FOR NEW CLUTCH.THEIR TECH ADJUSTED MY FLYWHEEL BOLTS AND CLUTCH CABLE. 65.00 EMERGENCY BRAKE AND 125.00 FOR TEST. IT ALREADY HAD ONE. FUEL LEAK?