2016 Kia Optima
Problems, recalls and owner-reported issues
Engine is the leading concern among 756 owner complaints filed for this model year. This is the 4th highest complaint count among 20 Optima model years with reports.
Of the 2016 reports, 27 involved a crash and 19 involved a fire. 21 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Latches/locks/linkages, trunk lid, latchAug 24, 2023
Kia America, Inc. (Kia) is recalling certain 2016-2017 Rio, 2016-2018 Optima, 2017-2018 Optima Hybrid and Optima Plug-in Hybrid vehicles. The trunk latch base may crack, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."
A person inside the trunk compartment may become trapped, increasing their risk of injury.
Dealers will replace the trunk latch base subassembly, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC278.
Campaign 23V594000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleJan 6, 2017
Kia Motors America (Kia) has recalled one 2016 Optima vehicle. In this vehicle, the end seal for the driver's frontal air bag inflator may not have been properly installed, possibly resulting in reduced inflation of the frontal air bag in the event of a crash.
In the event of a crash, an air bag that does not inflate fully increases the risk of injury.
The affected vehicle was remedied on January 10, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC143.
Campaign 17V007000 on NHTSA.gov
Power train, axle assembly, axle shaftOct 3, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 13, 2015, to April 23, 2016 and equipped with a 2.4l engine. The right front axle driveshaft may crack and fail.
If the driveshaft cracks and separates from the vehicle, it will not be able to move forward. Additionally, if the parking brake is not applied upon exiting the vehicle, the vehicle may roll. Either scenario can increase the risk of a crash.
Kia will notify owners, and dealers will replace the front axle driveshaft, free of charge. The recall began November 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC139.
Campaign 16V705000 on NHTSA.gov
Air bags, frontalApr 21, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 10, 2015, to February 12, 2016. In these vehicles, a chemical enhancer required for the for the second stage deployment of the driver's frontal air bag was not loaded, resulting in the second stage not deploying in necessitating crashes.
If the second stage air bag does not deploy it increases the risk of injury or death.
Kia will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began on May 6, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC131.
Campaign 16V231000 on NHTSA.gov
Representative owner complaints
756 reports, newest first.
Power train, Engine, Feb 24, 2019
ENGINE FAILED ON HIGHWAY AND CAR STOPPED ACCELERATING.
Engine, Feb 7, 2019
I CHANGE MY OIL CHANGE IN MY KIA OPTIMA 16 OIL GET LOW BEFORE 3000MILE IT LOSE OIL BEFORE IT REACH 3000 MILES IT LOSE 2 QUART OIL
Air bags, Feb 3, 2019, crash
I WAS INVOLVED UN A REAR END COLLISION. I WAS STRUCK FROM BEHIND WHILE STOPPED @ A TRAFFIC LIGHT. SEVERE DAMAGE TO THE REAR END OF THE CAR. NO AIR BAGS DEPLOYED FROM THE IMPACT. I ENDED UP HITTING MY HEAD VERY HARD ON THE STEERING WHEEL. NO AIR BAGS DEPLOYED @ ALL FROM THE COLLISION.
Structure, Jan 16, 2019
SHARK FIN ANTENNA COVER EASILY COMES LOOSE OR COMPLETELY WHILE HAND WASHING THE VEHICLE. THE VEHICLE WAS STATIONARY IN DRIVEWAY WHILE WASHING.
Engine, Dec 4, 2018
TL* THE CONTACT OWNS A 2016 KIA OPTIMA. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO CHARLIE'S MOTOR MALL (465 WESTERN AVE, AUGUSTA, ME 04330, 207-622-7327) TO BE DIAGNOSED, BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 92793557. THE FAILURE MILEAGE WAS APPROXIMATELY 22,000. *TT*JB
Vehicle speed control, Electronic stability control (ESC), Fuel/propulsion system, Nov 28, 2018
THE CAR STUMBLES TO START AND WHEN I ACCELERATE IT FLUTTERS UNTIL PICKING UP SPEED. THIS HAPPENED ON HIGHWAY 43.
Seats, Nov 20, 2018
TL* THE CONTACT OWNS A 2016 KIA OPTIMA. WHEN THE CONTACT PUSHED THE BUTTON BEHIND THE REAR PASSENGER SEAT TO RELEASE THE SEATS, THE HEADREST DETACHED AND STRUCK THE CONTACT ON THE LEFT EYE. THE CONTACT SUSTAINED AN EYE INJURY, BUT MEDICAL ATTENTION WAS NOT REQUIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 53,400.
Other or unspecified, Nov 10, 2018
TAKATA RECALL - MY CAR IS STARTING TO STALL FOR SOME REASON BUT THERE ISN'T A CHECK ENGINE LIGHT ON. MECHANICS CANNOT UNDERSTAND WHAT MIGHT BE CAUSING IT. THIS HAPPENS AS I DRIVE ON STREETS AND ON HIGHWAYS.
Exterior lighting, Nov 4, 2018
HEADLIGHT ASSEMBLY: WIRING HARNESS MELTING, BULBS BURNING OUT EVERY 3 MONTHS OR SO. A SAFETY HAZARD POTENTIALLY A FIRE HAZARD. DRIVING VISIBILITY AT NIGHT WITH LIGHTS ON DIM CREATES A TREMENDOUS SAFETY HAZARD.
Exterior lighting, Oct 23, 2018
HEADLIGHT MALFUNCTION SHUT OFF PROBLEM. AT NIGHT WHEN IN MOTION ON VARIOUS CITY STREETS THE FRONT AND REAR LIGHTS WILL, SUDDENLY AND RANDOMLY, WITH NO DRIVER INPUT WHATSOEVER, SHUT OFF COMPLETELY BOTH IN THE BACK AND IN THE FRONT OF THE CAR! THE HEADLAMPS AND REAR LAMPS WILL, AT THAT POINT STAY COMPLETELY OFF WITH ABSOLUTELY NO EXTERIOR LIGHTING FUNCTION EXCEPT THE BRAKE LIGHTS!! THE ONLY WAY TO GET REAR AND HEAD LAMPS BACK IS TO TURN THE HEADLIGHTS SWITCH OFF AND THEN ON AGAIN. THIS MALFUNCTION SO FAR HAS OCCURRED WHEN HEADLIGHT SWITCH IS IN AUTO MODE. THIS MODE OF LIGHTING DETECTS ENVIRONMENTAL LIGHTING CONDITIONS TO ACTIVATE EITHER DAYTIME RUNNING LIGHTS OR HEADLIGHTS. THIS HAS HAPPENED FIVE TIMES SINCE I PURCHASED THIS CAR BRAND NEW IN 2016. THE DEALER HAS BEEN NOTIFIED AND THE CAR HAS BEEN INSPECTED SEVERAL TIMES BUT THEY HAVE REPEATEDLY INSISTED THAT THE SYSTEM IS WORKING 'AS DESIGNED' OR SHOWS NO PROBLEMS. FORTUNATELY, I HAVE THE FRONT AND REAR CAMERAS INSTALLED WITH VIDEOS TO PROVE IT. MY VEHICLE MOUNTED CAMERAS HAVE CAPTURED THIS MALFUNCTION AS HAS MY IPHONE VIDEO.I WILL NEED A WAY TO SEND YOU THE VIDEO FILES AS THEY ARE TOO LARGE. I BELIEVE THIS IS A VERY DANGEROUS SITUATION. AFTER MANY ATTEMPTS AND COMMUNICATION WITH THE COMPANY, THE CAR WAS KEPT FOR TWO WEEKS AND WAS RETURNED WITH REPAIR TO WHAT THEY ARE CALLING THE "MULTIFUNCTION SWITCH".
Steering, Electrical system, Oct 18, 2018
TL* THE CONTACT OWNS A 2016 KIA OPTIMA. WHILE DRIVING 15 MPH, THE STEERING WHEEL BECAME LOOSE AND THE TRACTION CONTROL AND POWER STEERING WARNING INDICATORS ILLUMINATED. THE CONTACT ALSO MENTIONED THAT WHEN TURNING LEFT OR RIGHT, A CLICKING NOISE WAS DETECTED. IN ADDITION, THE STEERING WHEEL WOULD ONLY ALLOW THE CONTACT TO TURN APPROXIMATELY ONE INCH TO THE LEFT OR RIGHT, AND THE STEERING WHEEL EVENTUALLY SEIZED. THE VEHICLE WAS TAKEN TO SOUTH SHORE KIA (1128 SUNRISE HWY, COPIAGUE, NY 11726, (631) 991-3910) WHERE THE CONTACT WAS INFORMED THAT THE COMPUTER NEEDED TO BE RESET. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 2,843.
Electrical system, Other or unspecified, Oct 16, 2018
IN AUGUST 2018 I NOTICED THAT THE CAMERA ON THE FRONT GRILLE OF MY 2016 KIA OPTIMA WAS PRODUCING A BLURRY IMAGE. IT DID NOT DO THIS THE NIGHT PRIOR WHEN I USED THE CAMERA TO PARK IN MY GARAGE (WHERE I DID NOT HIT OR BUMP ANYTHING, I WAS NOT EVEN NEAR THE WALL AT THE FRONT OF THE GARAGE). THE LENS HAD A CRACK. SOME CONTEXT: THIS HAPPENED BEFORE IN 2017 AND THE KIA DEALERSHIP IN MCDONOUGH, GA REPAIRED IT AS A WARRANT ITEM. I TOOK THE CAR TO THE DEALERSHIP, WHERE THE SERVICE REPRESENTATIVE NAMED JOSE CAMACHO SAID THEY THEY WOULD COVER IT AS A WARRANT TIME AND THAT I WOULD NOT HAVE TO PAY FOR IT. THEY JUST NEEDED TO ORDER THE PART AND WOULD CALL ME WHEN IT ARRIVED. I NEVER RECEIVED A CALL, SO WHEN I CALLED THE DEALERSHIP IN SEPTEMBER 2018 I WAS TOLD THAT THE CLAIM WAS DENIED AS A NORMAL WEAR AND TEAR PROBLEM AND THAT THEY SHOULD NEVER HAVE REPLACED IT THE FIRST TIME. I WAS TOLD THAT IF I WANTED TO DISPUTED IT, I WOULD NEED TO CALL KIA CONSUMER AFFAIRS. KIA CONSUMER AFFAIRS TOLD ME THAT THEY WOULD CHECK WITH THE DEALERSHIP AND AFTER A FEW WEEKS, I CALLED THEM BACK AND THEY SAID THE DEALERSHIP WANTED MY TO COME BACK. I CALLED THE DEALERSHIP AND THEY ASKED FOR ME TO BRING THE CAR IN SO THEY COULD TAKE PICTURES. WHILE I WAS THERE I ASK WHAT THE ODDS WHERE THAT THE CAMERA LENS WOULD CRACK TWICE WITH NO VISIBLE DAMAGE TO THE CAMERA UNIT, THE GRILLE OR THE BUMPER, THE SERVICE MANAGER JUSTIN, TOLD ME IT WASN'T LIKELY. I NOTIFIED THEM THAT THERE WAS A 3 PAGE FORUM ON THE INTERNET WHERE OTHER KIA OPTIMA OWNERS HAVE REPORTED THE SAME PROBLEM, IN FACT, IF YOU DO A SIMPLE GOOGLE SEARCH FOR KIA OPTIMA CRACKED LENS, IT IS THE FIRST SEARCH RESULT. I ASKED WHY THIS IS NOT A RECALL ITEM, AND THEY SHRUGGED THERE SHOULDERS AND SAID THEY DIDN'T KNOW WHY. THEY THEN SAID THEY WOULD SUBMIT THE PICTURES AND I WOULD GET A CALL BACK FROM KIA CONSUMER AFFAIRS. IT WAS DENIED, NO REASON.
Power train, Oct 14, 2018
THE TRANSMISSION HAS A VERY HARSH DOWNSHIFT UPON COMING TO A STOP. SOMETIMES SO BAD THAT IT WILL PUSH ALL PASSENGERS HEADS FORWARD HARSHLY.
Vehicle speed control, Oct 5, 2018
2016 KIA OPTIMA. CONSUMER WRITES WITH CONCERNS MALFUNCTIONS WITH ADVANCED SMART CRUISE CONTROL. *AS *TR
Seats, Oct 2, 2018
TL* THE CONTACT OWNS A 2016 KIA OPTIMA. WHILE THE VEHICLE WAS COMING TO A COMPLETE STOP, THE FRONT DRIVER AND PASSENGER SEATS UNINTENTIONALLY MOVED IN DIFFERENT DIRECTIONS. THE CONTACT MENTIONED THAT BOTH SEATS BECAME DETACHED FROM THE HINGES. THE CONTACT ALSO STATED THAT THE SEAT COVERS DID NOT HOLD THE SEAT CUSHIONS IN PLACE. DOUG SMITH KIA (495 W MAIN ST, AMERICAN FORK, UT 84003, (801) 692-4390) DIAGNOSED THAT NEW SEAT COVERS WERE NEEDED TO LOCK THE CUSHIONS INTO THE SEATS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.
Exterior lighting, Aug 31, 2018
WHILE DRIVING WITH MY AUTOMATIC HEADLIGHTS ON AT NIGHT, THE LIGHTS HAVE TURNED OFF SEVERAL TIMES WHILE I WAS DRIVING. THE LIGHTS TURNED OFF FOR A FEW SECONDS EACH TIME THEN TURNED ON AGAIN.
Structure, Seats, Aug 23, 2018, crash
I WAS REAR ENDED WHILE STOPPED IN BREAKDOWN LANE OF A SECONDARY HIGHWAY (40 MPH) PROBLEM THAT I WOULD LIKE TO ADDRESS IS THE INADEQUATE CUSHIONING IN THE HEADRESTS OF THIS CAR AND PROBABLY MANY OTHERS. SUFFERED A CONCUSSION THE EFFECTS OF WHICH ARE STILL ONGOING. I THINK THAT THERE NEEDS TO BE STANDARDS APPLIED TO HEADRESTS TO HAVE ENERGY ABSORBING CUSHIONING. *TR
Exterior lighting, Jul 19, 2018
HEADLIGHTS SHINE ONLY ON THE ROAD STRAIGHT AHEAD.SIDE LIGHTING IS SO BAD YOU CAN'T READ THE ROAD SIGNS ON THE SIDE OF THE ROAD. THIS IS THE FIRST TIME THAT I HAVE DRIVEN THE CAR AT NIGHT ON COUNTRY ROADS. THE HEADLIGHTS DO NOT FAN OUT ON THE ROAD AHEAD AT ALL. VISABILITY IS VERY POOR AND THIS IS UNSAFE.
Other or unspecified, Jul 13, 2018
UPON FILLING UP THE CAR THE GAS NOZZLE NEVER SHUTS OFF UNTIL GAS (A LOT OF GAS) IS POURING OUT OF THE TANK. EVEN TRYING TO FILL IT UP ON YOUR OWN HOLDING THE HANDLE IT POURS OUT WHEN FULL. LEAVES GAS EVERY WHERE DOWN THE CAR SPRAYING THE PERSON PUTTING THE GAS IN. RUINING THE PAINT ON THE CAR.
Exterior lighting, Jul 11, 2018
TL* THE CONTACT OWNS A 2016 KIA OPTIMA. WHILE DRIVING 30 MPH, BOTH HEADLIGHTS FLICKERED AND FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO PARKWAY FAMILY KIA (22555 US-59, KIRKWOOD, TX 77339, (281) 312-6200) WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT UNDER WARRANTY AND THE BULBS BURNED OUT BECAUSE OF THE MILEAGE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 67,278.
Power train, Jul 4, 2018
WHEN ACCELERATING FROM A COMPLETE STOP, THE ENGINE SHUDDERS & HESITATES. I MUST ALLOW EXTRA TIME & SPACE FOR ONCOMING TRAFFIC, WHEN PULLING OUT INTO AN INTERSECTION. THIS IS AN ONGOING PROBLEM. KIA SAYS THE VEHICLE IS PERFORMING AS IT WAS DESIGNED TO. I THINK A RECALL SHOULD BE CONSIDERED, AS I HAVE SEEN NUMEROUS, SIMILAR COMPLAINTS ON VARIOUS WEBSITES REGARDING THIS PROBLEM.
Power train, Electrical system, Service brakes, Jul 2, 2018, crash
VEHICLE WAS STATIONARY, STOPPED, IN THE WEST CONSHOHOCKEN MUNICIPAL COMMUNITY BUILDING PARKING LOT, 112 FRONT STREET, WEST CONSHOHOCKEN, PA. THE CAR WAS IN PARK WITH EMERGENCY BRAKE ENGAGED. I WENT TO TURN THE CAR OFF AND WHEN I PRESSED THE IGNITION BUTTON, A LOUD EXPLOSION SOUND CAME FROM UNDER THE HOOD AND THEN A LOUD JACK HAMMER SOUND STARTED. CAR SHOT BACKWARDS IN REVERSE AND ALL THE LIGHTS ON THE DASHBOARD WERE FLASHING AND A BELL RINGING. I PUMPED THE BRAKES TO STOP THE CAR AND IT WOULD NOT STOP. IN HAD JUST BEEN TURNED OFF, AND WAS ALREADY IN PARK AND EMERGENCY BRAKE ON. CAR WENT ON OUT OF NOWHERE, AND WENT IN REVERSE THE LENGTH OF APPROXIMATELY 25 CARS AND CRASHED INTO A PARKED CAR.POLICE WERE CALLED TO THE SCENE. THEY REPORTED THE ACCIDENT AND IT IS UNDER INVESTIGATION. MURRAY KIA WAS WHERE THE CAR WAS TOWED. THEY COULD NOT REPLICATE THE PROBLEM AND TOLD ME IT WAS AN INSURANCE PROBLEM. NOT TRUE!! MY PASSENGER AND I WERE LUCKY NOT TO HAVE ROLLED INTO THE STREET AND ONCOMING TRAFFIC, AND COULD BEEN KILLED OR SERIOUSLY INJURED, OR INJURED OTHERS. THANK GOD THE PARKED CAR WAS THERE AND ONLY THEN DID THE CAR CRASH INTO IT, AND STOP.
Electrical system, Jun 28, 2018, fire
TL* THE CONTACT OWNED A 2016 KIA OPTIMA. APPROXIMATELY TEN MINUTES AFTER THE CONTACT TURNED OFF THE ENGINE AND EXITED THE VEHICLE, FLAMES IGNITED INSIDE THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FLAMES. THE VEHICLE WAS DESTROYED AND TOWED TO AN UNDISCLOSED LOCATION. THE CAUSE OF THE FIRE WAS NOT DETERMINED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 29,000. *JS
Air bags, Jun 10, 2018, crash
A CAR ACCIDENT TOOK PLACE EARLY SUNDAY MORNING OF SEPTEMBER 25, 2016 IN WHICH THE AIR BAG FAILED TO DEPLOY RESULTING IN SEVERE INJURIES. KIA WAS CONTACTED AND INFORMED THAT A ACCIDENT HAD TAKEN PLACE IN A NEW VEHICLE THAT WAS PURCHASED, AND THE AIRBAG DID NOT DEPLOY, ALTHOUGH IT HAD PASSED THE INSPECTION AT THE DEALERSHIP AND SHOULD HAVE BEEN UNDER WARRANTY SINCE THE VEHICLE WAS PURCHASED A FEW MONTHS PRIOR. KIA FAILED TO CORRECT THE ISSUE, ALTHOUGH INDICATING THEY WOULD SEND AN INSPECTOR OUT TO CHECK THE VEHICLE. LATER IT WAS INDICATED THE VEHICLE HAD 2 RECALLS ASSOCIATED WITH IT (#1. 16V7050000 AND #2. 16V231000), HOWEVER, KIA FAILED TO HONOR THE RECALLS OR TAKE RESPONSIBILITY FOR FAILING TO PROPERLY INFORM OF THE DEFECTS. NUMEROUS ATTEMPTS WERE MADE TO REACH SOMEONE AT KIA TO RESOLVE THE MATTER, BUT EACH TIME A DIFFERENT REPRESENTATIVE INDICATED MR. GUSTAVIO VALILA WAS THE PERSON HANDLING THE MATTER AND WOULD RESPOND IN A TIMELY MANNER. VOICE MAILS WERE LEFT UNRETURNED AND EMAILS WERE SENT, HOWEVER, MR. VALILA COULD NOT BE REACHED. A YEAR LATER A REPRESENTATIVE RESPONDED INDICATING THAT THE AIR BAG WAS NOT MEANT TO DEPLOY AND THAT THE COMPANY WAS SORRY FOR THE CIRCUMSTANCE AND SITUATION. THE COMPANY DID NOT ACKNOWLEDGE OR RESPOND TO THE PREVIOUS RECALLS THAT WERE NOT HONORED, NOR DID THE COMPANY CORRECT OR RESOLVE THE CONCERNS OR MAKE AN EFFORT TO ASSIST OR PROVIDE A REMEDY FOR THE INJURIES SUSTAINED DUE TO THE FAILURE OF THE AIRBAG NOT DEPLOYING. DUE TO THE ACCIDENT AND INJURIES SUSTAINED DURING THE ACCIDENT THE DRIVER DIED A WEEK LATER. KIA WAS INFORMED OF EVERYTHING, ALONG WITH RECEIVING PHOTOS AND PAPERWORK ASSOCIATED WITH THE INCIDENT (THAT A REPRESENTATIVE FROM THE COMPANY REQUESTED), AND HAS STILL CHOSEN TO ACCEPT NO RESPONSIBILITY FOR THE SITUATION OR DO ANYTHING TO RESOLVE THE PREVIOUS MATTER / CONCERNS...*BF *TT
Air bags, Apr 10, 2018, crash
ONE CAR HEAD ON CRASH. PASSENGER SIDE CURTAIN DID NOT DEPLOY. PASSENGER HAD MANY INJURIES RIGHT SIDE. HAPPENED IN CONSTRUCTION ZONE ON A HIGHWAY, IN MISSOURI.