2007 Toyota RAV4
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,003 owner complaints filed for this model year. This is the highest complaint count among 26 RAV4 model years with reports.
Of the 2007 reports, 53 involved a crash and 37 involved a fire. 41 people were injured.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Air bagsApr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V245000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: power train
53 reports, newest first. Show all
Power train, Other or unspecified, Visibility/wiper, Oct 21, 2020
MY CAR IS MAKING THE "GROWLING" NOISE DESCRIBED IN TOYOTA'S WARRANTY ENHANCEMENT AND TOYOTA WILL NOT HONOR THE WARRANTY ENHANCEMENT. BECAUSE OF THE DEFECT THE CAR SHAKES AT SPEEDS MORE THAN 40 MPH, SOUNDS LIKE IT HAS A FLAT EVEN THOUGH IT DOESN'T (LOUDER WHEN MAKING TURNS AND SWITCHING LANES), AND MAKES A BANGING NOISE IN THE REAR (SOUNDS LIKE A CAR DOOR SLAMMING) WHEN DRIVING. VISOR ON DRIVER'S SIDE WILL NOT STAY UP--FALLS AND OBSTRUCTS VIEW WHILE DRIVING.
Suspension, Power train, Wheels, Aug 17, 2019
77000 MILE LOWER CONTROL ARMS WITH BUSHINGS WENT BAD ,LOWER BALL JOINTS BAD INNER & OUTER TIE RODS BAD , SWAY BAR END LINKS BALL JOINTS BAD.ALIGNMENT & RE-BALANCED TIRES AFTER REPLACEMENT .BEGAN SWAYING IN ROAD FIGHTING STEERING ON EVERY BUMP WITH DIPPING OF FRONT END & VIBRATION BADLY OF CAR ESPECIALLY STEERING WHEEL , WORN NEW TIRES ON OUTSIDES .COMPLETE RECORDS IN TOYOTA VEHICLE REPAIR SERVICE SITE.TOTAL COST SO FAR FOR THE ABOVE IS 158.00 PLUS 44.95 PLUS 1 WEEK DOWN TIME, DUE TO ALL JOINTS BAD AND VIBRATIONS AND SWAYING AROUND HAS CAUSED THE CV SHAFTS TO GET LOOSE GOOD SHAKE AND NOT IN TO OUT SIDEWAYS DIRECTION - UP TO DOWN THEY HAVE SLIGHT PLAY AND HEAR A CLUNK BOTH WAYS (TO BE REPLACED WHEN HAVE MONEY WILL BE ANOTHER 150 TO 195 BUCKS AND ANOTHER DAY OR 2 DOWN TIME, NOT SURE OF FRONT WHEEL BEARINGS YET OR THE REAR SWAY BAR ALL THEM LINKS , THIS IS HOW BAD THE SWAYING GOT SO NEEDS CHECKED ANY BACK PARTS WILL COST ME APPROX 240.00 -- REPLACED PARTS LOWER CONTROL ARMS WITH BALL JOINTS AND BUSHINGS ALONG WITH INNER PLUS OUTER TIE RODS ALONG WITH SWAY BAR LINKS WERE BOUGHT THROUGH AMAZON FROM DETROIT AXEL SELLER SO MAY BE ABLE TO GET RECEIPT IF NEEDED-- THE TIRE RE-BALANCED WAS DONE AT LYNN LAYTON FORD OF DECATUR ALABAMA 256-350-2120 CUSTOMER [XXX] INVOICE [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT
Power train, Jul 10, 2019
TAKATA RECALL CAR RUMBLES WHEN IN MOTION GOING OVER 55 MPH SOUND COMES FROM MIDDLE OF CAR HAPPENS WHEN TURNING OR GOING STRAIGHT SOUNDS LIKE CAR RUNNING OVER JESUS LINES
Power train, Electronic stability control (ESC), Engine, Jan 22, 2019
I OWN A 2007 RAV 4, 110,000 MILES AND I BACKED OUT OF MY DRIVE WAY BEGAN TO DRIVE AND THE TRANSMISSION FAILED. I WANT TO KNOW IF I CAN FILE A CLASS ACTION LAWSUIT AGAINST TOYOTA.. I JUST READ IN THE PAST TOYOTA KNEW ABOUT EARLIER MODELS THAT THE ECM RUINED THE TRAN MISSION IN RAV 4S..
Steering, Power train, Sep 20, 2018
STEERING WHEEL FEELS LIKE LOSE AND THERE IS A THUNDER NOISE COMING FROM RACK AND PINION ACCORDING TO MECHANIC, ESPECIALLY WHEN DRIVES IN THE CITY OR OVER A HUMP.NO MATTER HOW SMALL IS, ALSO WHEN DRIVING AND MAKE RIGHT TURN
Power train, Feb 2, 2018
I TOOK MY RAV4 TO THE TOYOTA DEALER FOR ITS REGULAR CHECK-UP. I WAS TOLD THAT THE CARS TRANSMISSION BLOCKS WERE BROKEN AND THAT THEY HAD TO BE REPAIRED OR CAR WOULD SHAKE AND SHUDDER. ALSO THERE WAS A SAFETY ISSUE. THIS CAR, A SPORT TRIM, ONLY HAS A LITTLE OVER 60,000 MILES. HOW COULD THIS HAPPEN UNLESS IT WAS FAULTY QUALITY/WORK WHEN ASSEMBLING. I AM BEING CHARGED $1200.00 TO REPAIR THESE BLOCKS. I HAVE DRIVEN HONDAS FOR 30 YEARS AND THIS IS MY 1ST TOYOTA. I HAVE NEVER HEARD OF THIS. NEVER HAPPENED W/ A HONDA (NO DOCUMENTATION AS YET AS I DO NOT PICK UP THE CAR UNTIL TOMORROW.)
Suspension, Power train, Jan 12, 2018
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING 45 MPH, THERE WAS A LOUD NOISE COMING FROM THE REAR OF THE VEHICLE. THE NOISE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO TOYOTA OF ROCK HILL (640 GALLERIA BLVD, ROCK HILL, SC 29730) WHERE IT WAS DIAGNOSED THAT THE REAR DIFFERENTIAL COUPLING NEEDED TO BE REPLACED. THE DEALER STATED THAT THE WARRANTY WAS EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AT 888-270-9371 AND STATED THAT NOTHING COULD BE DONE. A CASE NUMBER WAS NOT PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 141,203.
Suspension, Power train, Seat belts, Aug 27, 2017
FOUND BY MAIL ABOUT RAKATA AIR BAGS, AND MY SERVICE FOR OIL,FILTER WAS CALLED BY REPAIR SHOP,TIME FOR SERVICE, FINISH THE CAR SERVICE , BEFORE LIVED I ASK A QUESTION ABOUT, THE RECALL AND HE LOOK THE SCREEN,TOOK 30 SECONDS (FLAHS) AND SAYS, YOU CAR, DON'T HAVE ANY RECALL, WHY? NO IM CURIOUS, WHAT ABOUT THE REAR SUSPENSION ARM 1, AND HEARD ABOUT SEAT BELTS,SAFETY RECALL, AND MOST OF INFO.STILL IN CHINESE OR JAPANES, AND SOME ONE PUT NEW BUT COMO N THEY LOOK CHEAP AND HAVE A TACOMA TOTALLY DIF. FOUND 11 RECALLS, NOW TRASMISSION AUT,BURN OUT,AT 100000 MILES, SORRY BUT LOOK LIKE THE REPAIR SHOPS DON'T CARE ABOUT "US" THE WANT TO SELL CARTS, BUT MAKE A OT OF MISTAKES AND WE PAY TO GET KILL IN CAR ACCIDENT,CAUSE DEFECT OF FACTURY,THEY FIXED THE CARS,BUT LIFE AND FEW THURS AND DLLS DON'T RETURN WIFES,SONS,HUSBAND,GONE SO WHY CARS COMPANIES ARE IN SO MUCH IN A HURRY NOT EASY TO PAY A LOAN OF 60,000 IN 5 YEARS, AND 3 YEARS LATER WANT YOU TO LEAVE THE CAR AND AGAIN,AND AGAIN,AAIN BY T M, PAS,CA #1
Power train, Nov 16, 2016
TRANSMISSION SLIPS OR JERKS AFTER VEHICLE SLOWS DOWN AND SPEEDS UP. THIS IS UNSAFE IN TRAFFIC DUE TO VEHICLES FOLLOWING BEHIND AND STOPS WHICH COULD CAUSE A REAR END COLLISION DUE TO HESITATION WHEN VEHICLE SHOULD BE EXCELERATED BUT IT SLOWS THEN JERKS BACK WHICH CAN BE FELT WHEN DRIVING. EVEN FELT DURING EXCELARATION IN NORMAL DRIVING CONDITIONS. THIS HAPPENS DURING PRESSING DOWN ON GAS PETAL WHEN THE TRANSMISSION GEARS SHOULD CHANGE SMOOTHER, IT SLIPS OR JERKS INTO PLACE, THEN SLOWS BACK DOWN AGAIN AFTER ACCELERATION.
Steering, Power train, Nov 1, 2016
WHEN I BACK UP ON ANY KIND OF AN INCLINE, THE CAR JERKS AND THE STEERING WHEEL SHAKES. IT FEELS LIKE I HAVE "HIT" SOMETHING IT JERKS SO BADLY. IF I LET OFF THE GAS PEDAL, IT STOPS THE JERKING BUT THE MINUTE I PRESS THE GAS PEDAL AGAIN, IT JERKS AGAIN AND MAKES A TERRIBLE NOISE. I CAN STILL BACK UP BUT IT FEELS LIKE THE UNDERSIDE OF MY CAR IS FALLING OUT. IT'S BEEN GOING ON SINCE I PURCHASED IT USED 2 YEARS AGO. I KEPT THINKING IT WAS ME UNTIL I GOOGLED IT TODAY AND SAW SEVERAL OTHER PEOPLE HAVE THE SAME ISSUE. I FEEL IT'S UNSAFE AND TOYOTA NEEDS TO TAKE CARE OF IT. MY VEHICLE ALREADY QUALIFIED FOR THE OIL CONSUMPTION ISSUE AND WAS REPAIRED EARLIER THIS YEAR. NEEDS TO BE A NATIONAL RECALL AND FIXED PROPERLY.
Power train, Engine, Jul 26, 2016
I WAS DRIVING TO FREDERICKSBURG ON I-95 AROUND MIDNIGHT LAST MONDAY. ALL OF A SUDDEN ALL MY WARNING LIGHTS CAME ON. MY ENGINE MADE A LOUD NOISE, STALLED AND THEN DIED WHILE I WAS DRIVING. I WAS ABLE TO GET MY CAR TO THE RIGHT SHOULDER LUCKILY OR I WOULD HAVE BEEN DEAD PROBABLY. GOT THE CAR TOWED TO THE NEAREST SHOP. THEY SAID I ONLY HAD 1 QUART OF OIL, AND I TOLD THEM I THAT IS IMPOSSIBLE BECAUSE I CHANGE MY OIL ON A REGULAR BASIS. MY OIL STICKER IS IN THE RIGHT SIDE OF MY WINDSHIELD. THEY SAID DUE TO THE LACK OF OIL, I BLEW A PISTON AND A BEARING AND THEY HAD TO TAKE MY ENGINE APART. SO NOW MY WARRANTY APPARENTLY WON'T COVER THIS SO I'M STUCK WITH A CAR WITH NO ENGINE.
Power train, Engine, Fuel/propulsion system, Feb 19, 2016
OIL BURNING RECALL. MY CAR RAV4 BURNS OIL AT LEAST ONE QUART PER 1200 MILES. THE DEALERSHIP REFUSED TO REPLACE ANY PART DUE TO THE 1200 MILES TEST DRIVING. TOYOTA SENT ME AN ENHANCEMENT WARRANTY NOTICE ABOUT THE PROBLEM OF OIL BURNING. THIS IS UNACCEPTABLE TO ME. WE PAID SO MUCH YET WHAT WE GET IS A DEFECT ENGINE IN A NEW RAV4. THIS SHOULD BE A RECALL AND TOYOTA IS RESPONSIBLE TO FIX THE RINGS AND OTHER PARTS THAT ARE REQUIRED TO REPLACE IN ORDER TO STOP THE PROBLEM.
Power train, Nov 24, 2015
OIL PAN LEAKING THEY REPLACED AND CHARGE ME $ 470. PAN SUB ASSY OIL FIPG OIL PAN PLUG W/HEAD STRAIGH GASKET ALL THE OIL IT WAS COMING OUT AND IT WAS ALMOST EMPTY
Power train, Oct 6, 2015
EXCESSIVE ENGINE OIL CONSUMPTIONS. 1ST NOTICED AROUND MAY 2014 AT 95000 MILES. NEED TO ADD 1 TO 1.5 QUART EVERY 1000 MILES OF DRIVING.
Power train, Sep 8, 2015
FROM PARKED, AS THE VEHICLE ACCELERATED, VEHICLE RESPONSE RESEMBLED HAVING PARKING BRAKE ON, AND A GRINDING NOISE EMANATED FROM THE REAR AXLE, CENTER. DROVE UNDER 20 MPH TO TOYOTA DEALER, WHICH DIAGNOSED THE PROBLEM AS THE DRIVESHAFT/DIFFERENTIAL COUPLER, WITH METAL SHAVINGS AROUND THE DRIVESHAFT WHERE IT ENTERS THE DIFFERENTIAL COUPLER. TOLD THE VEHICLE IS UNSAFE TO DRIVE, AS THE REAR WHEELS COULD LOCK UP, AND CAUSE AN ACCIDENT. REPAIR COSTS: PARTS $1,300 PLUS TAX; LABOR - 3 HOURS ($400). TOYOTA ISSUED SERVICE BULLETING TBS 0080-13, AND SPECIAL POLICY ADJUSTMENT WAB 2190.
Power train, Jun 11, 2015
I WAS MAKING A LEFT HAND TURN ON SIDE STREET AND I HEARD A LOUD THUMP (ALMOST LIKE I WENT OVER SOMETHING) MY CAR STOPPED GOING FORWARD OR BACKWARDS. I COULD NOT USE THE GEARS. I HAD NO WARNING. THE CAR JUST STOPPED MOVING IN THE MIDDLE OF THE STREET. THIS IS A MAJOR SAFETY COMPLAINT. I DON'T KNOW IF TOYOTA DID NOT SERVICE THE CAR CORRECTLY. I AM NOT TOLD THE PRICE WILL BE ANYWHERE BETWEEN 2,500-4,500 CAR WAS TOWED AND I WAS TOLD IT NEEDS A NEW TRANSMISSION. I HAVE TAKEN CARE OF THE CAR AND SERVICED IT MOSTLY AT THE TOYOTA DEALER. *TR
Power train, Engine, Mar 13, 2015
TRANSMISSION STARTED TO WHINE,. BEARINGS. *TR
Power train, Mar 10, 2015
I HAVE A WHINING NOISE AND VIBRATION FELT IN MY GAS PEDAL WHICH MY MECHANIC HAS DETERMINED TO BE FROM THE TRANSAXLE ASSEMBLY. MY RESEARCH HAS SHOWN THAT ON AUGUST 8, 2012 TOYOTA SENT OUT A SERVICE BULLETIN # T-SB-0130-12 WHICH DIRECTLY ADDRESSES THIS PROBLEM. I HAVE BEEN TO MY TOYOTA DEALER SINCE THAT TIME ADDRESSING OTHER RECALL ISSUES HOWEVER THEY NEVER MENTIONED THIS SERVICE BULLETIN NOR DID THEY CHECK IF THIS WAS AN ISSUE. IT SEEMS THE REMEDY IS TO REPLACE THE ENTIRE TRANSAXLE ASSEMBLY WHICH I AM SURE THEY DON'T WANT TO DO BECAUSE OF THE EXPENSE. THEIR WARRANTY IS FOR 60 MONTHS OR 60,000 MILES BUT SINCE THEIR SERVICE BULLETIN WASN'T ADDRESSED UNTIL AUGUST OF 2012, IT WOULD BE UNLIKELY UNDER NORMAL DRIVING MILEAGE THAT A VEHICLE THAT WAS 5 YEARS OLD AT THE TIME WOULD BE INCLUDED UNDER THIS WARRANTY AND THEY NEVER ADDRESSED THIS PROBLEM WHEN THEY HAD MY VEHICLE AFTER THIS DATE. I THINK THEY SHOULD BE HELD ACCOUNTABLE AT THIS TIME FOR NEGLECTING TO ADDRESS THIS PROBLEM. *TR
Power train, Apr 10, 2014
TL* THE CONTACT OWNS A 2007 TOYOTA RAV. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE LUNGED FORWARD WHILE IN SECOND GEAR. THE FAILURE RECURRED CONTINUOUSLY OVER A PERIOD OF NINE MONTHS. THE VEHICLE WAS TAKEN TO THE DEALER, WHO COULD NOT DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 99,000. UPDATED 05/28/14 MA
Engine and engine cooling, Power train, Apr 9, 2014
AFTER HEARING ABOUT TSBS RELATED TO PREMATURE WATER PUMP FAILURE, I NOTICED THAT MY RAV4 WAS LOW ON COOLANT. THE DEALER SERVICE DEPARTMENT TESTED AND FOUND THE PUMP WAS LEAKING, AND REPLACED IT UNDER THE POWER TRAIN WARRANTY. LESS THAN 15,000 MILES AND 2 YEARS LATER I AM NOTICING THAT THE COOLANT LEVEL IS BEGINNING TO RUN LOW AGAIN, AND SUSPECT THE REPLACEMENT WATER PUMP MAY AGAIN BE DEFECTIVE. *TR
Power train, Service brakes, Engine, Apr 8, 2014
THE CAR UNEXPECTEDLY ACCELERATED AS I WAS APPROACHING A RED TRAFFIC LIGHT. MY FOOT WAS ON THE BRAKE TO SLOW DOWN WHEN THE CAR'S ENGINE REVVED UP AND THE CAR KEPT MOVING FORWARD WITH MY FOOT ON THE BRAKE PEDAL AS FAR AS IT COULD GO. THE CAR FINALLY STOPPED ABOUT 6 FEET INTO THE INTERSECTION. THE NEXT MORNING THE CAR REPEATED THE UNEXPECTED ACCELERATION WHILE I WAS TRYING TO SLOW DOWN PRIOR TO STOPPING FOR A STOP SIGN. THE DRIVER'S SIDE FLOOR MAT WAS REMOVED TWO OR THREE YEARS AGO AND WAS NOT PRESENT THAT EVENING OR THE NEXT MORNING. I REPORTED THIS EPISODE TO THE TOYOTA DEALER AND I TOLD HIM I WAS AFRAID TO DRIVE THE CAR. THE DEALER TOLD ME THE CAR WAS OUT OF WARRANTY, BUT IF I WANTED HAVE TO CAR TOWED TO THE DEALERSHIP, HE WOULD HAVE TO TECHNICIANS CHECK IT FOR HISTORICAL RECORD OF THE EPISODE. I WAS ALSO TOLD I WAS RESPONSIBLE FOR TOWING CHARGES AND THE COST OF THE DIAGNOSTIC ANALYSIS. THE COMPUTERIZED DIAGNOSTIC CHECK SHOWED NOTHING HAD HAPPENED AND NOTHING WAS WRONG WITH THE CAR. I TOLD THE DEALER THE I WAS NOT IMPRESSED WITH THE DIAGNOSTIC TEST DEVICE, AS THE ACCELERATION DID HAPPEN AND THE TEST SET WAS OBVIOUSLY NOT CHECKING THE SOURCE OF THE PROBLEM. I CALLED TOYOTA CUSTOMER SERVICE TELEPHONE NUMBER IS TORRANCE CALIFORNIA, TOLD THEM MY STORY AND ASKED IF TOYOTA HAD RECEIVED ANY OTHER SUCH COMPLAINTS. I WAS TOLD THAT TOYOTA COULD NOT RELEASE THAT INFORMATION. I ASKED WHAT TOYOTA DID WITH MY REPORT OF THE PROBLEM. I WAS TOLD IT WENT INTO A TOYOTA DATA BASE. I ASKED FOR A COPY OF RAV4 EPISODES IN THE DATA BASE. I WAS TOLD TOYOTA COULD NOT FURNISH THAT TO ME. I THEN ASKED FOR A COPY OF MY REPORT THAT TOYOTA ENTERED INTO THE DATA BASE. TOYOTA TOLD ME IT COULD NOT FURNISH THAT TO ME. TOYOTA SEEMS TO DISCREDIT REPORTS OF THIS ACCELERATION/SAFETY ISSUE AS IF IT COULD NOT POSSIBLY HAPPEN. *TR
Power train, Vehicle speed control, Mar 23, 2014
IN THE FALL OF 2011, THE VSC AND 4WD LIGHTS CAME ON IN MY 2007 RAV4. AT THE SAME TIME MY CRUISE CONTROL AND 4WD STOPPED WORKING. I TOOK MY CAR TO TETON TOYOTA IN IDAHO FALLS, ID AND WAS TOLD THAT THE CHARCOAL CANISTER WAS CRACKED AND NEEDED TO BE REPLACED AT A COST OF $1775.00. I COULD NOT AFFORD TO FIX THE CAR AND EVENTUALLY I PURCHASED A USED CHARCOAL CANISTER AND HAD IT INSTALLED BY AN INDEPENDENT MECHANIC. THEN IN FEB. 2012, THE LIGHTS CAME ON AGAIN SO I TOOK MY CAR TO STONES TOYOTA IN REXBURG, ID. THE MECHANIC THERE CONFIRMED THAT THE CHARCOAL CANISTER WAS CRACKED AGAIN. I TOLD HIM THAT I HAD REPLACED IT WITH A USED PART AND HE STATED THAT TOYOTA HAD REDESIGNED THE PART SO THAT IT WOULDN'T CRACK, SO IF I WANTED TO FIX THE PROBLEM FOR GOOD, I'D HAVE TO PURCHASE THE NEW PART. I HAVE NOT YET REPLACED THE UNIT AT THIS TIME. IF TOYOTA KNEW THAT THE ORIGINAL PART WAS DEFECTIVE AND HAVE NOW REDESIGNED IT, WHY ARE THEY CHARGING THEIR CUSTOMERS OVER $1500 TO REPLACE IT? BESIDES NOT HAVING ANY 4WD IN RURAL IDAHO IN THE WINTER, THE EMISSIONS SYSTEM IS NO LONGER WORKING DUE TO THIS DEFECTIVE PART. *TR
Power train, Feb 13, 2014
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE WAS SECURED IN PARK AND THE EMERGENCY BRAKE WAS APPLIED HOWEVER, THE VEHICLE ROLLED AWAY AFTER THE CONTACT HAD EXITED. THE CONTACT'S FOOT BECAME TRAPPED UNDER THE WHEEL AND CAUSED INJURIES. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE AND VIN WAS NOT AVAILABLE. *TR
Power train, Engine, Nov 24, 2013
MY WIFE NOTICED OIL LITE CAME ON AND WENT OFF IN A SPLIT SECOND . AFTER THAT THE CAR SHUT OFF CAR WAS CHECKED NO OIL . MOTOR BLEW UP . CALLED TOYOTA AND REFUSED TO DO ANYTHING . HAD TO PUT A JASPER ENGINE IN. COST OUT OF POCKET $4990.00 AND $1000.00 TO INSTALL NEW ENGINE . I BELIEVE WITH ALL THE OTHER REVEIWS WITH THE SAME PROBLEM AND POOR ENGINE DESIGN TOYOTA NEEDS TO PAY FOR THE ENGINE THAT CUSTOMERS HAD TO PAY OUT OF POCKET . I HAVE MY PAPER WORK FOR PROOF AND MECHANIC ALSO . IF ANY INFO ON THIS PLEASE EMAIL ME ASAP [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Power train, Oct 10, 2013
9/30/2013 I BACKED OUT MY CAR OUT OF A PARKING SPOT, AFTER PUTTING IT IN DRIVE AND STARTED DRIVING WHEN SUDDENLY THE CAR LEAPED FORWARD, TOO FAST FOR THE INTENDED SPEED AND THEN CAME TO A GRINDING HALT, I COULD NOT PUT IT IN REVERSE AND I SHUT IT OFF. I RESTARTED THE CAR BECAUSE OF ITS LOCATION I COULD NOT STAY. I WAS ABLE TO DRIVE IT A BLOCK TO ONE OF MY CLIENTS. AFTER AN HOUR I STARTED THE CAR AND ATTEMPTED TO DRIVE AWAY, CAR DID NOT WANT TO SHIFT GEARS WHEN PICKING UP SPEED AND I FELT THE CARE WAS UNSAFE AS WELL AS UNABLE TO DRIVE ON A FREEWAY. AAA WAS CALLED AND TOWED TO TOYOTA.10/1/2013 THE CAUSE FOR SURGE AND NO REVERSE WAS SUSPECTED TO BE CAUSED BY LOW FLUID LEVEL IN TRANSMISSION. THE BEAVERTON TOYOTA SERVICE REP ([XXX]) TOLD ME THAT LOW LEVELS OF FLUID WOULD CAUSE THE CAR TO EVENTUALLY STOP AND UNABLE TO SHIFT. ONE QUART OF TRANSMISSION FLUID WAS ADDED, NO LEAKS WERE DETECTED AND MY CAR WAS TAKEN ON A ROAD TEST AND RETURN CAR WAS RECOMMENDED BY TAS, WHATEVER THAT MEANS. I FELT THAT THE CAR DID DRIVE DIFFERENT, THE SOUND OF THE GEAR SHIFTING AND THE WAY THE CAR REACTED WAS DIFFERENT, HOWEVER IF THE PROFESSIONALS FROM BEAVERTON TOYOTA DID A TEST DRIVE THEY WOULD HAVE NOTICED TOO, IT?S THEIR JOB. ON10/6/2013 LATE AFTERNOON, MY CAR CAME TO A GRINDING HALT RIGHT IN THE DRIVING LANE I WAS TRAVELING AT A SPEED OF APPROXIMATELY 20 TO 30 MPH. IT FELT I HIT A WALL HOW THE CAR STOPPED ABRUPTLY AND SOUND OF LOTS OF GRINDING METAL. I CALLED AAA AND HAD IT TOWED BACK TO TOYOTA AGAIN.10/9/2013 RECEIVED NOTICE THAT TRANSMISSION IS OUT, I WAS TOLD THAT THE TRANSMISSION WAS TOTALLY SHREDDED. IF THIS LAST SUDDEN STOP HAD HAPPENED ON THE FREEWAY OR CROSSING A BUSY INTERSECTION, MYSELF AND OTHERS COULD HAVE BEEN SERIOUSLY HURT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR