2007 Toyota RAV4
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,003 owner complaints filed for this model year. This is the highest complaint count among 26 RAV4 model years with reports.
Of the 2007 reports, 53 involved a crash and 37 involved a fire. 41 people were injured.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Air bagsApr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V245000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints
1,003 reports, newest first.
Electrical system, May 3, 2016, fire
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE SUDDENLY STOPPED AND SMOKE AND FLAMES WERE PRESENT BEHIND THE STEERING WHEEL. THE CONTACT USED WATER TO EXTINGUISH THE FLAMES. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 90,000.
Engine, Apr 25, 2016
UNINTENDED ACCELERATION AFTER THE CAR HIT A POT HOLE ON I-270 SOUTHBOUND. WITH BOTH BRAKE AND EMERGENCY BRAKE FULLY ENGAGED THE CAR STILL WENT WITH A SPEED FASTER THAN MOST OF THE CARS ON THE ROAD. I WAS FORCED TO DRIVE THE CAR IN THE GRASS INTERMEDIATE AREA FOR ~10 SECONDS TILL THE CAR ROLLED OVER AND THE ENGINE FINALLY CAME TO A STOP. THIS RAV4 WAS RECALLED BY TOYOTA AND HAD ITS "STUCK GAS PEDAL" PROBLEM FIXED A FEW YEARS AGO. TOYOTA ALSO FIXED THE EXCESSIVE ENGINE OIL CONSUMPTION PROBLEM LAST YEAR AND I HAVE BEEN PLEASED WITH TOYOTA'S SERVICE AND HOW THE PERFORMANCE OF THE CAR IN GENERAL TILL THIS LIFE THREATENING EVENT OCCURRED YESTERDAY.
Seat belts, Apr 20, 2016
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V096000 (SEAT BELTS); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Suspension, Apr 19, 2016
THE CAR WAS RECALLED IN 2014 FOR THE REAR CONTROL ARMS. THEY WERE REPLACED IN 2014. 2 YEARS LATER AND THE PART BROKE AGAIN. HAD JUST PULLED OUT OF A SIDE STREET WHEN IT BROKE, SO WAS ABLE TO PULL TO THE SIDE OF THE ROAD. HAD CAR TOWED TO MECHANIC. COST $560 TO HAVE IT REPLACED. COULD HAVE BEEN DEADLY IF I HAD BEEN ON THE INTERSTATE.
Structure, Seats, Engine, Apr 18, 2016, fire
ON MARCH 29, 2016, I WAS DRIVING TO WORK IN THE FAR LEFT LANE WHEN A GENTLEMAN DRIVING A GREEN PICKUP TRUCK COME RUSHING UP BESIDE ME. HE WAS WAVING AT ME POINTING DOWN AT THE RIGHT FRONT SIDE OF MY TOYOTA. I THOUGHT THAT MAYBE I WAS DRIVING ON A FLAT TIRE AND DIDN'T REALIZE IT SO I ROLLED DOWN THE WINDOW. HE YELLED AS HE WAS STILL POINTING DOWN AT THE FRONT OF MY TOYOTA "YOUR CAR IS ON FIRE". HE GOT AHEAD OF ME AND I PULLED OVER TO THE RIGHT SHOULDER OF THE FREEWAY. HE GOT OUT OF HIS TRUCK AND RAN BACK TO MY 2007 TOYOTA RAV4 AND SAID "MA'AM, YOU BETTER GET YOUR PURSE AND THINGS AND GET OUT, YOUR CAR IS ON FIRE". AT THAT TIME, SMOKE WAS POURING OUT SOMEWHERE UP FRONT ON THE PASSENGER SIDE BY THE TIRE. I GOT MY THINGS AND WE MOVED TO THE BACK OF MY TOYOTA WHEN AT THAT TIME, IT WENT UP IN FLAMES. I TOOK CARE OF THAT VEHICLE BECAUSE I CAN NOT AFFORD ANOTHER. MY LAST OIL CHANGE WAS IN NOVEMBER 2015 WITH ONLY 50035 MILES ON THE VEHICLE. WHEN IT WAS LAST INSPECTED, EVERYTHING WAS FINE. SO I AM NOT UNDERSTANDING HOW THIS HAPPENED. TIRES WERE ABOUT A YEAR OLD AS WELL. CAR JUST DON'T CATCH ON FIRE DRIVING DOWN THE FREEWAY. ON APRIL 4, 2016 A FRIEND AND I TOOK A DRIVE TO MY BURNT VEHICLE AND SHE COULD NOT BELIEVE THAT WAS MY TOYOTA. AND I COULD NOT BELIEVE I HAD WALKED AWAY WITHOUT ANY INJURIES. THERE IS NO ENGINE, NO DASHBOARD, NO STEERING WHEEL, NO FRONT SEATS, AND NO BACK SEATS. ALL BURNED! HOW COULD THIS HAPPEN?
Steering, Suspension, Mar 29, 2016
R/R SWAY BAR END LINK BROKEN. UPPER AND INTERMEDIATE STEERING SHAFT BROKEN.
Engine, Mar 25, 2016
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE CONSUMED AT LEAST FOUR QUARTS OF OIL PER MONTH. THE OIL PRESSURE WARNING INDICATOR CONSTANTLY ILLUMINATED. THE CONTACT ALSO RECEIVED A NOTIFICATION FROM THE MANUFACTURER TO HAVE AN OIL CONSUMPTION TEST PERFORMED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 124,413.
Air bags, Mar 16, 2016, crash
TL* THE CONTACT OWNED A 2007 TOYOTA RAV4. WHILE DRIVING 60 MPH, THE CONTACT CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED NECK, HIP, AND BACK INJURIES THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.
Engine, Mar 11, 2016
BURNING 1.5-2 QUARTS OF ENGINE OIL PER WEEK, THIS HAS BEEN AN ONGOING ISSUE FOR AT LEAST 2 YEARS. OIL CONSUMPTION TEST WAS DONE ON THE VEHICLE AND IT FAILED. THE DEALERSHIP HAS FAILED TO FIXED THE ISSUE.
Wheels, Mar 9, 2016
THE METAL RIMS WHICH HOLD THE TIRES GET RUSTED DUE TO DESIGN. THIS IS A GREAT SAFETY CONCERN. THE RIMS ARE DESIGN SUCH WAY THAT THEY HOLD WATER, RAINWATER, AND SALTY ICE/SNOW INSIDE THE RIMS AND NEVER DRAIN OUT; WHICH CAUSES THE WHEELS TO RUST, AND COULD CAUSE A SAFETY CONCERN. THE RIMS/WHEELS SHOULD HAVE BEEN RUST PROOF IN FIRST PLACE. THESE RIMS/WHEELS ARE NOT, AND ON THE CONTRARY HOLD WATER INSIDE ALONG THE OUTER EDGE.
Steering, Air bags, Mar 1, 2016
LEFT FRONT INPUT SEAL HAS LEAKED FLUID TWICE NOW. FIRST TIME WAS 9/25/2012 @ 56,516 MILES. SECOND TIME WAS ON 1/12/2016 @ 101,753 MILES. MY INDEPENDENT AUTO REPAIR SERVICE, CORAM PRECISION AUTO OF CORAM, NY WENT TO TOYOTA TO GET THE SEAL NEEDED TO FIX THE LEAK BOTH TIMES AND ASKED TOYOTA PARTS COUNTER IF THEY KNEW OF A RECALL AND THEY SAID NO. THEN THEY ASKED WHY THEY HAD SO MANY SEALS IN STOCK IF THERE HAD BEEN NO RECALLS. I AM ON THIS WEBSITE AND DON'T SEE ANY RECALLS EITHER BUT I WONDER IF ANY COMPLAINTS HAVE BEEN FILED. NOTE: I HAVE SEVERAL RECALLS FOR MY TOYOTA RAV4 FOR GAS PEDAL AND NOW FOR THE 'REAR DIFFERENTIAL COUPLING' WHICH EXTENDS MY WARRANTEE UNTIL 2017 FROM TOYOTA AND FROM NHTSA FOR MY DRIVERS SIDE AIR BAG IN 2014 BUT CAN'T FIND ANYTHING ON THIS WED SITE. PLEASE FOLLOW UP WITH ME ON THE SEAL PROBLEM AND IF THE AIRBAG NEEDS TO BE REPLACED. TOYOTA TOLD ME 'NO" BUT I DON'T TRUST THEM. THANKS, WPZIEMS 02/01/2016.
Steering, Feb 27, 2016
CLUNKING NOISE WHEN STEERING EITHER RIGHT OR LEFT, NOTICEABLE AT SLOWER SPEEDS. THIS HAS BEEN A PROBLEM SINCE IT WAS NEW BUT WE WERE TOLD IT WAS THE LEFT FRONT STRUT. ON OUR LAST SERVICE WE WERE TOLD IT INVOLVED THE STEERING. NOTE: RAV'S FRONT BUMPER HAD BEEN REPAIRED, BEFORE VEHICLE WAS DELIVERED TO US. WE WERE TOLD IT WAS MINOR DAMAGE JUST NEEDED REPAINTING..THIS VEHICLE HAS 64,000 ORIGINAL MILES.
Power train, Engine, Fuel/propulsion system, Feb 19, 2016
OIL BURNING RECALL. MY CAR RAV4 BURNS OIL AT LEAST ONE QUART PER 1200 MILES. THE DEALERSHIP REFUSED TO REPLACE ANY PART DUE TO THE 1200 MILES TEST DRIVING. TOYOTA SENT ME AN ENHANCEMENT WARRANTY NOTICE ABOUT THE PROBLEM OF OIL BURNING. THIS IS UNACCEPTABLE TO ME. WE PAID SO MUCH YET WHAT WE GET IS A DEFECT ENGINE IN A NEW RAV4. THIS SHOULD BE A RECALL AND TOYOTA IS RESPONSIBLE TO FIX THE RINGS AND OTHER PARTS THAT ARE REQUIRED TO REPLACE IN ORDER TO STOP THE PROBLEM.
Air bags, Feb 17, 2016, crash
I HAD A FRONT END CRASH WHEN DRIVING 60-65 MPH ON I-94 ON FEB 4 2016, SKIDDED ON ICE NEAR ALEXANDRIA MN, AND COLLIDED NEAR FENCE. THE AIRBAG DID NOT DEPLOY. NO INJURIES. STATE PATROL REPORT FILED-CASE #716900207. COUNTRY INSURANCE CLAIM-205-006-8259. IT WAS DECLARED A TOTAL LOSS. TOYOTA IS NOT GIVING ME A PROPER RESPONSE, JUST GAVE THEIR CASE #:CASE #1602060045.
Air bags, Feb 16, 2016, crash
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING 65 MPH, THE CONTACT WAS INVOLVED IN A CRASH AND THE AIR BAGS FAILED TO DEPLOY. IN ADDITION, THE INSTRUMENT PANEL LIGHTS ILLUMINATED, INDICATING THAT THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED NECK, BACK, AND HIP INJURIES THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.
Air bags, Feb 2, 2016
TAKATA RECALL. THE DRIVER'S SIDE AMMONIUM NITRATE INFLATOR IS NOW SUSPECT ACCORDING TO TOYOTA. A REPLACEMENT PART WILL NOT BE IN THE PIPELINE FOR QUITE A WHILE AT BEST. TOYOTA REFUSES TO REMOVE THE EXPLOSIVE BECAUSE IT'S A "SAFETY ITEM." IT DEFIES COMMON SENSE. I WANT IT DISABLED UNTIL THEY CAN FIX IT. WHAT KIND OF MORON WOULD DRIVE AROUND WITH A LOADED GUN AIMED AT THIS HEAD? ARE YOU GUYS LISTENING?
Steering, Feb 1, 2016
NOTICED CLUNKING IN STEERING WHEN TURNING EITHER RIGHT OR LEFT. LOOKED UP PROBLEM ON INTERNET AND FOUND THAT IT IS A HUGE PROBLEM WITH THESE VEHICLES. ACCORDING TO INTERNET THERE OVER 400,000 COMPLAINTS. CALLED TOYOTA AND WAS TOLD THERE IS A TECHNICAL BULLETIN ON THE PROBLEM AND IT REQUIRES REPLACING STEERING SHAFT. I ALSO READ ON THE INTERNET THAT VEHICLES WHO REPLACED THE INTERMEDIATE STEERING SHAFT OFTEN HAVE TO REPLACE IT AGAIN. THIS SEEMS TO ME THAT TOYOTA CAN NOT FIX THE ORIGINAL PROBLEM AND NOW IT BECOMES THE OWNERS RESPONSIBILITY TO KEEP ON CHANGING AN INTRICATE PART TO DRIVING THEIR VEHICLES. WHY WITH SO MANY FAILURES HASN'T YOUR AGENCY WARNED THE PUBLIC OR IS NHTSA SAYING THERE IS NO ISSUE OR SAFETY CONCERN. PLEASE INFORM ME THAT THIS ISSUE IS NOT A PROBLEM AND I SHOULD NOT HAVE TO WORRY ABOUT IT AND I DON'T HAVE TO SPEND $800.00 TO FIX IT.
Steering, Wheels, Electronic stability control (ESC), Jan 26, 2016
DRIVING 50 MPG AROUND CURVE IN HEAVY TRAFFIC STEERING LOCKED UP HARDLY ABLE TO PULL.OFF SIDE OF ROAD. HAPPENED AGAIN TODAY 2 TIMES AND HAPPENED AT LEAST 5 TIMES BEFORE IN THE PAST 3 MONTHS.STEERING FROZE HAD TO GET OF TO THE SIDE AND RESTART THEN IT WAS ABLE TO STEER BUT BATTERY.LIGHT FLICKERS. THREE OTHER LIGHTS ON THE LEFT OF THE DASHBOARD STAYED ON AFTER RESTARTING THE VEHICLE. WENT TO PEP-BOYS AND I WAS ASKED TO REPLACE THE BATTERY DUE TO LOW VOLTAGE. BATTERY WAS REPLACED AND ONE DAY LATER SAME THING HAPPENED AGAIN.
Visibility/wiper, Jan 25, 2016
DRIVER'S SIDE SUN VISOR WILL NOT STAY IN CLOSED POSITION AT ANY TIME. IT IS HANGING DOWN ABOUT 45 DEGREES FROM THE ROOF HEADLINER, PARTIALLY BLOCKING THE DRIVER'S VIEW AND PRESENTING AN OBVIOUS SAFETY HAZARD. IN ADDITION, AN INJURY HAZARD EXISTS IN THE EVENT OF A FRONT END CRASH, SINCE THE DRIVER'S HEAD WILL IMPACT THE SUN VISOR FIRST. THERE HAVE BEEN NUMEROUS OTHER REPORTS OF THIS DESIGN FLAW.
Steering, Electrical system, Electronic stability control (ESC), Jan 19, 2016
DRIVING ON THE HIGHWAY GOING ABOUT 75MPH AFTER ABOUT 5 HOURS WHEN A BUNCH OF WARNING LIGHTS CAME ON (INCLUDING BATTERY, AIR BAG, AND BRAKE), MY POWER STEERING FAILED AND MY SPEEDOMETER QUIT WORKING. PULLED OVER ON THE SIDE OF THE HIGHWAY AND LET MY CAR SIT FOR A MINUTE, RESTARTED MY CAR AND THREE DIFFERENT LIGHTS CAME ON (VSC, CHECK ENGINE AND SLIP INDICATOR) AND MY CRUISE CONTROL WOULDN'T WORK ANYMORE. MY CAR CURRENTLY HAS ABOUT 110,000 MILES. THIS IS NOT A WEAR AND TEAR ISSUE; THIS IS A DEFECT. FROM READING ONLINE, THERE ARE MANY COMPLAINTS OF THE SAME ISSUE. THIS COULD BE A FATAL DEFECT AND SHOULD BE TAKEN SERIOUSLY. THIS IS THE SECOND TIME MY POWER STEERING HAS FAILED WHILE DRIVING.
Steering, Jan 14, 2016
LOUD CLUNKING NOISE WHEN TURNING LEFT OR RIGHT AND WHILE BACKING OUT OF DRIVEWAY NEAR THE STEERING WHEEL. I PURCHASED THIS VEHICLE IN 2007 AND WITHIN 2 YEARS (~30000 MILES) THE SAME ISSUE HAD OCCURRED AND TOYOTA DEALER REPLACED THE PART UNDER WARRANTY. WITHIN 6 YEARS OF THE FIRST OCCURRENCE I AM FACING THE SAME ISSUE AGAIN. I HAVE REACHED OUT TO TOYOTA FOR A FREE REPAIR BUT TOYOTA HAS REFUSED TO REPLACE THE PART UNDER PRODUCT DEFECT. THIS IS A PRODUCT DEFECT AND ALSO A SAFETY ISSUE AND HENCE TOYOTA SHOULD MAKE A NATIONAL RECALL.
Vehicle speed control, Jan 12, 2016
APRIL, 2015 TOOK RAV4 IN FOR RECALLS. AFTER RECEIVING THE VEHICLE BACK PERIODICALLY IT WOULD FAIL TO ACCELERATE. I THOUGHT THE COMPUTER WOULD MAYBE ADJUST ITSELF. IT DIDN'T. IT PERIODICALLY STALLS OR FAILS TO ACCELERATE. I HAVE ALMOST BEEN RUN OVER SEVERAL TIMES. CALLED TOYOTA OF DENTON TODAY. THEY DENIED THAT ANYTHING THEY DID WOULD HAVE ANYTHING TO DO WITH THAT, EVEN THOUGH WE DROVE THE VEHICLE 60K MILES AND NEVER HAD A PROBLEM. I HAVE TWO TOYOTAS AND DENIAL OF A PROBLEM IS FIRST ON THE LIST IT SEEMS. THIS DRIVE BY WIRE SHOULD BE OUTLAWED.
Engine, Dec 27, 2015
2007 RAV4 USES AN EXCESSIVE AMOUNT OF OIL. I RECENTLY PURCHASED THIS VEHICLE USED WITH APPROXIMATELY 146,000 MILES. THE VEHICLE HAS BEEN DRIVEN APPROXIMATELY 4,000 AND I HAVE HAD TO ADD 2 QUARTS OF OIL TO THE ENGINE. I HAVE READ NUMEROUS COMPLAINTS ONLINE ABOUT THE SAME SITUATION AND TOYOTA IS DOING NOTHING TO FIX THE PROBLEM.
Steering, Dec 26, 2015
AT 51,000 MILES, THERE IS A HEAVY RATTLE IN THE FRONT END WHEN DRIVING ON ROUGH ROADS. AFTER REPLACING SEVERAL PARTS, LOCAL MECHANICS NOW TELL ME THAT THE RACK AND PINION STEERING GEAR NEEDS REPLACEMENT. THIS DOES NOT SEEM TO BE THE INTERMEDIATE STEERING SHAFT PROBLEM THAT IS THE SUBJECT OF TOYOTA SERVICE BULLETIN #T-SB-0319-08. I DO NOT FEEL ANYTHING ABNORMAL IN THE STEERING WHEEL, STEERING IS SMOOTH AND THE PROBLEM IS NOT NOTICEABLE DRIVING ON SMOOTH ROAD SURFACES. THE NOISE SEEMS TO BE GETTING WORSE WITH TIME, SO I AM CONCERNED THAT THE STEERING COULD FAIL ALTOGETHER.
Air bags, Dec 22, 2015
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING AT ANY SPEED, THE AIR BAG LIGHT ILLUMINATED AND FLASHED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER, BUT NO FAILURES WERE FOUND WITH THE AIR BAGS. THE MANUFACTURER AGREED WITH THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS 125,000.