2000 Ford F-150
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,204 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 F-150 model years with reports.
Of the 2000 reports, 92 involved a crash and 361 involved a fire. 79 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Vehicle speed control, cruise controlJan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Campaign 05V017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Equipment, other, labelsSep 21, 2000
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V284000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Representative owner complaints
1,204 reports, newest first.
Vehicle speed control, Aug 10, 2010, fire
TL*THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS PARKED IN THE DRIVEWAY WHEN SHE HEARD TWO LOUD EXPLOSIONS. THE CONTACT NOTICED THAT THE VEHICLE WAS ON FIRE. THE FIRE AND POLICE DEPARTMENT WERE CONTACTED AND A REPORT WAS FILED. THE FIRE INVESTIGATOR STATED THAT IT WAS DUE TO THE CRUISE CONTROL. THE DEALER STATED THAT THEY WILL CONTACT HER REGARDING THE FAILURE . THE CONTACT STATED THAT SHE WAS THE SECOND OWNER OF THE VEHICLE. NHTSA CAMPAIGN ID NUMBER: 05V017000, VEHICLE SPEED CONTROL, CRUISE CONTROL RECALL REPAIR WAS NOT PERFORMED. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGES WERE 150,000.
Vehicle speed control, Aug 9, 2010, fire
MY VEHICLE WAS PARKED FOR SEVERAL DAYS ON A PARKING LOT NEXT TO MY RESIDENCE AND I WAS NOTIFIED BY EMPLOYEES FROM A NEARBY BUSINESS MY VEHICLE WAS ON FIRE. SMOKE WAS OBSERVED COMING OUT FROM UNDER THE HOOD, HOWEVER NO FLAMES WERE OBSERVED. THE ORIGIN OF THE SMOKE WAS DETERMINED TO BE FROM THE CRUISE CONTROL SWITCH LOCATED ON THE FRONT OF THE BRAKE MASTER CYLINDER. THE HEAT FROM THE FIRE HAD MELTED THE CRUISE CONTROL SWITCH AND WIRING AND HAD ALSO MELTED THE PLASTIC BRAKE FLUID RESERVOIR. THE VEHICLE ALSO HAS NO BRAKE LIGHTS OR TURN SIGNALS DUE TO THE FIRE. FORD HAS REFUSED TO REPAIR ANY DAMAGE ASSOCIATED FIRE CAUSED BY THE CRUISE CONTROL SWITCH. FORD STATED THEY WOULD ONLY PERFORM WORK ASSOCIATED WITH THE CRUISE CONTROL RECALL AND NOT REPAIR ANY DAMAGE CAUSED BY THE DEFECTED SWITCH. *TR
Vehicle speed control, Aug 8, 2010, fire
2000 FORD F150 SPEED CONTROL SWITCH WAS FAULTY AND BURNED THE TRUCK TO THE GROUND, BURNED THE CAR AND HOUSE IT WAS PARKED NEXT TO. *TR
Engine and engine cooling, Aug 6, 2010
2000 FORD 5.4L SPARK PLUG EJECTION FORD KNOWS OF THE PROBLEM' THEY SHOULD HAVE TO FIX THE FLAW. THIS HAPPENED TO MY WIFE AND CHILD WHILE DRIVING, SHE NEARLY DROVE OFF THE ROAD DUE TO THE LOUD NOISE AND LOSS OF POWER. *TR
Vehicle speed control, Equipment, Jun 13, 2010
OWN 2000 F150 4X4, CRUISE CONTROL SWITCH WAS REPLACED ON RECALL A FEW YEARS AGO. LAST YEAR HAD TO REPLACE THE CRUISE CONTROL SWITCH AGAIN AT MY COST BECAUSE IT HAD ALREADY BEEN REPLACED ON RECALL. HOW CRUISE CONTROL IS BAD AGAIN AND WELL HAVE TO REPLACE AGAIN AT MY COST AGAIN. FORDS FIX ISN'T A GOOD FIX. *TR
Fuel system, Gasoline, Jun 11, 2010
FUEL TANK FELL OUT OF TRUCK WHILE DRIVING CAUSING SIGNIFICANT ENVIRONMENTAL CLEAN UP (LUCKILY NO FIRE) AND REPAIR BILL. *TR
Vehicle speed control, Jun 10, 2010, fire
TL*THE CONTACT OWNS A 2000 FORD F-150. WHILE THE VEHICLE WAS PARKED IN FRONT OF HIS HOME, IT CAUGHT FIRE. THE CONTACT STATED THAT ANOTHER VEHICLE NEAR THE FORD F-150 ALSO CAUGHT FIRE. THE CARPORT WAS DAMAGED. A FIRE REPORT WAS FILED. THE FIRE INSPECTOR ADVISED THE CONTACT THAT THE FIRE COULD HAVE BEEN CAUSED BY THE CRUISE CONTROL. THE CURRENT AND FAILURE MILEAGES WERE 112000.
Steering, Service brakes, Hydraulic, Electrical system, Exterior lighting, Jun 9, 2010
I WAS TRAVELING IN NEUTRAL, DOWNHILL, AT ABOUT 40MPH THROUGH A SHALLOW TURN AS I WAS EXITING A HIGHWAY. WHEN I PUT THE TRUCK IN 4TH GEAR TO ACCELERATE, I HAD NO POWER. THE TACHOMETER WAS AT ZERO AND I TRIED TO TURN ON THE HAZARD LIGHTS AND BEGIN BRAKING, BOTH FAILED TO WORK. I HAD NO LIGHTS OR ANY OTHER ELECTRICAL POWER (IT WAS DAYLIGHT) I DOWNSHIFTED AND TURNED TO EASE OFF THE ROAD, I HAD NO POWER STEERING, THEN THE STEERING WHEEL LOCKED. I HALTED THE TRUCK WITH THE E BRAKE ONCE I WAS SLOW ENOUGH AND ON THE EDGE OF THE ROAD. I TRIED TO RESTART IT SEVERAL TIMES BUT NOTHING WOULD HAPPEN. THE TRUCK HAD ZERO ELECTRICAL POWER. AFTER ABOUT 15 MINUTES IT STARTED BACK UP AS IF NOTHING WAS WRONG. WHEN I GOT IT TO JOHN ELWAY FORD IN DENVER CO, THE MECHANICS SAID THE COMPUTER DIDN'T LOG ANY ERRORS AND THERE WAS NOTHING THEY COULD DO. I CONTACTED FORD AND THEY REFUSED TO DO ANYTHING. I CONTACTED THE BBB AND THEY JUST REITERATED FORDS POLICY. THE PROBLEM HAS NEVER BEEN FIXED SINCE NO ONE CAN FIND THE REASON FOR IT. IT HAS HAPPENED ONE OTHER TIME TO ME IN 2007 (I THINK). *TR
Fuel system, Gasoline, Electrical system, Jun 5, 2010, fire
DRIVING TRUCK FOR ABOUT AN HOUR, CAME HOME, TRUCK SAT FOR ABOUT AN HOUR AND A HALF. CAUGHT ON FIRE. FIRE WAS MAINLY IN THE ENGINE COMPARTMENT AND SEEMED TO GET THE HOTTEST NEAR THE DRIVERS SIDE. *TR
Vehicle speed control, May 24, 2010, fire
OUR 2000 FORD F150 CAUGHT ON FIRE WHILE SITTING IN OUR CARPORT. WE HAD RETURNED FROM ACROSS THE STREET AND PARKED IT IN THE CARPORT. ABOUT 20 MINUTES LATER OUR SON CAME RUNNING IN AND SAID THE TRUCK WAS ON FIRE. WE THINK THE FIRE WAS DUE TO A RECALLED SPEED CONTROL DEACTIVATION SWITCH. THE FIRE CAUSE ALOT OF DAMAGE TO THE ELECTRICAL SYSTEM AND ALL THE PLASTIC PARTS ARE MELTED. *TR
Vehicle speed control, May 11, 2010, fire
ON APRIL 28TH, AT APPROXIMATELY 6 PM, WHILE IT HAD BEEN SITTING, HAVING NOT BEEN DRIVEN FOR ALMOST AN HOUR, OUR 2000 FORD F-150 CAUGHT FIRE. THERE WAS NO INDICATION PRIOR TO THE EVENT THAT WOULD HAVE TIPPED US OFF THAT THIS WAS GOING TO HAPPEN OUR CRUISE CONTROL WAS STILL OPERATIONAL. WE RECEIVED OUR RECALL NOTICE IN JANUARY 2005 AND WE TOOK IT TO THE DEALERSHIP IN LATE MAY EARLY JUNE 2005 WHERE IT WAS PURCHASED TO HAVE IT SERVICED FOR SMOKE COMING FROM UNDERNEATH THE HOOD. IT WAS NOT UNTIL THIS FIRE THAT WE FOUND OUT THE CRUISE CONTROL WAS NOT FIXED, OUR INSURANCE COMPANY, FARM BUREAU, DID AN INVESTIGATION AND THAT WAS THEIR FINDING. WE WERE VERY FORTUNATE THAT NOBODY WAS HURT BUT THE TRUCK IS A TOTAL LOSS. *TR
Vehicle speed control, Apr 29, 2010, fire
FAULTY CRUISE CONTROL DE-ACTIVATION SWITCH IN 2000 F150 CAUGHT ON FIRE AND BURNED MY HOUSE DOWN. *TR
Service brakes, Hydraulic, Air bags, Seat belts, Apr 22, 2010, crash
MY SON WAS INVOLVED IN AN ACCIDENT ON 4/22/2010 WHILE DRIVING A 2000 FORD F-150 4X2 TWO DOOR PICKUP TRUCK. SIDE MARKS AT THE SCENE REVEALED THAT THE F-150'S ANTI-LOCK BRAKES DID NOT ENGAGE CAUSING THE TRUCK TO SLIDE RESULTING IN A FAILURE TO STOP IN TIME TO AVOID THE ACCIDENT. THE AIR BAG DID NOT DEPLOY AFTER THE FRONT-END IMPACT AND THE SEATBELT DID NOT LOCK CAUSING MY SON TO BE THROWN FORWARD HEATING HIS HEAD ON THE SUN VISOR AND SNAPPING HIS HEAD BACKWARD ROLLING HIS FACE INTO THE ROOF OF THE TRUCK AND INJURING HIS NECK. HE ALSO BRUISED SOME RIBS ON THE STEERING WHEEL AND JAMMED SEVERAL FINGERS. THE SEATBELT DID KEEP HIM FROM BEING EJECTED FROM THE VEHICLE BUT BY NOT ENGAGING, CAUSED UNNECESSARY INJURIES. HAD HE BEEN DRIVING AT A HIGHER RATE OF SPEED AT THE TIME OF THE IMPACT HE INJURIES WOULD HAVE BEEN FAR MORE SERIOUS AND EVEN LIFE THREATENING. WE PURCHASED THIS F150 ON 1/19/2010 FROM THE CITY OF MOUNT JULIET, TN. THE VEHICLE WAS WELL MAINTAINED BY THE CITY ACCORDING TO THE VEHICLE MAINTENANCE RECORDS. WE REQUEST TO HAVE A NON-PARTIAL EXPERT EXAMINE THE VEHICLE TO DETERMINE THE CAUSE OF THE SAFETY FEATURES FAILURE TO DEPLOY ON THIS VEHICLE. *TR
Engine and engine cooling, Electrical system, Apr 13, 2010, fire
MY 2000 FORD F150 WAS SITTING IN MY PARENTS DRIVEWAY AS WE WERE VISITING. WE HEARD A LOUD NOISE BUT COULDN'T FIGURE OUT WHAT IT WAS. WHEN I LOOKED OUT THE WINDOW, I SAW MY TRUCK ON FIRE. MY DAD GOT A HOSE AND I CALLED 911 AND BETWEEN DAD AND THE FIREMEN, THE FIRE WAS PUT OUT WITHOUT HITTING THE OTHER VEHICLES NEARBY OR THE GARAGE. THE F150 IS TOTALED WITH THE HOOD TOTALLY GONE AND THE ENGINE, ELECTRICAL AND OTHER COMPONENTS IN THE COMPARTMENT BURNED UP AS WELL AS THE FRONT WINDSHIELD AND THE DASHBOARD. THIS COULD HAVE BEEN MORE SERIOUS AS I WAS JUST ABOUT TO LEAVE TO TAKE MY 5 YEAR-OLD NIECE HOME W/MY 9 YEAR-OLD DAUGHTER. *TR
Engine and engine cooling, Apr 10, 2010
OWN 2000 F150 WITH 4.6 MOTOR. RIGHT REAR SPARK PLUG BLEW COMPLETELY OUT ON TRIP FROM WYOMING TO VERMONT. ON A SUNDAY SO HAD TO COMPLETE THE RUN, FIXED IT WITH A SPARK PLUG INSERT AND REPLACED INDIVIDUAL COIL THAT WAS BLOWN APART BY THE PLUG, BUT TRUCK HAS NOT RUN RIGHT SINCE. WHAT IS BEING DONE ABOUT THIS AS IT SEEMS TO BE A VERY COMMON COMPLAINT ? *TR
Engine and engine cooling, Mar 17, 2010, fire
THE CONTACT OWNS A 2000 FORD F150. WHILE THE VEHICLE WAS PARKED AND UNATTEND IT CAUGHT ON FIRE. THE VEHICLE WAS DESTROYED THE FIRE STARTED UNDER THE HOOD. THE POLICE AND FIREMAN WAS CALLED. THE CONTACT STATED TWO OTHER VEHICLES WERE DAMAGED. THE FAILURE MILEAGE AND CURRENT WERE 180,000. VWB
Electrical system, Feb 26, 2010, fire
TL*THE CONTACT OWNS A 2000 FORD F-150. WHILE THE VEHICLE WAS PARKED THE CONTACT HEARD A NOISE AND OBSERVED THAT HIS VEHICLE CAUGHT FIRE. THE CONTACT ALSO STATED THAT A FIRE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE NOT AVAILABLE.
Engine and engine cooling, Feb 22, 2010, fire
2000 FORD F150 CAUGHT FIRE. THE TRUCK HADN'T BEEN MOVED IN 8 HOURS. I AWOKE AT 1 AM AND SAW MY TRUCK WAS ON FIRE. I DIDN'T GET NOTICE ABOUT A RECALL ON A PART THAT CAUSE THEM TO JUST CATCH ON FIRE. *TR
Engine and engine cooling, Feb 18, 2010
2000 FORD F150. HAS LAUNCHED SPARK PLUGS ON TWO OCCASIONS. FIRST ONE SHOT THROUGH COIL PACK, DISABLING VEHICLE. LAST ONE TOOK THREADS WITH IT, FORD SAYS HEAD WOULD HAVE TO BE REPLACED FOR AROUND 4000 DOLLARS.HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/FORD_SPARK.HTML , THIS SITE HAS OVER 300 PEOPLE WHO HAVE HAD THE SAME PROBLEM ON MODELS FROM 1997 TILL PRESENT. HOW CAN THE SAME PROBLEM CONTINUE TO HAPPEN FOR OVER TEN YEARS WITHOUT ANY RECALL BEING ISSUED? FIRST COUPLE OF YEARS MIGHT BE RECALL, CONTINUING FOR THE NEXT TEN MODEL YEARS AMOUNTS TO FRAUD. THE SPARK PLUGS ALSO REST BELOW THE FUEL RAIL, ITS JUST A MATTER OF TIME BEFORE SOMEONE BURNS TO DEATH OR CRASHES DUE TO THE SUDDENNESS OF THE PROBLEM. AT THIS POINT ONLY FORD WILL CHANGE THESE PLUGS AND WHEN THEY WONT THREAD IN BECAUSE THE THREADS ARE GONE, THEY TELL YOU 4000 DOLLARS FOR A NEW HEAD OR TOW IT OUT. OUR FORD DEALER TOLD US IT WAS SAFE TO DRIVE HOME, I STARTED IT UP, I DON'T THINK SO. FORD TOLD ME IT WAS A SPARK PLUG DESIGN ISSUE, BUT THE PLUGS THEY INSTALLED WERE MOTORCRAFT, ALSO A FORD PRODUCT. SO IN MY MIND IT STILL A FORD DESIGN PROBLEM, NOT MINE. *TR
Steering, Engine and engine cooling, Vehicle speed control, Feb 16, 2010
2000 F250 SD 7.3 DIESEL INCIDENT DATE 2/15/2010 2/12/2010 I TOOK MY TRUCK INTO THE DEALER TO GET A OIL CHANGE AND A RECALL FIXED ON THE CRUISE CONTROL. THAT MORNING WHEN I STARTED IT UP, IT HAD A NOISE WHEN I TURNED THE WHEEL, WHEN I BROUGHT IT IN, THEY SAID THE GASKET ON MY POWER STEERING HAD GONE BAD, AND I NEEDED A COMPLETE REPLACEMENT OF MY POWER STEERING PUMP. NOW IS WHEN THE REAL PROBLEM STARTS... I HAD NOT EXPERIENCED THIS PROBLEM PRIOR TO THE DEALER VISIT. ALL OF THE SUDDEN WHEN I DRIVE ON THE HIGHWAY, ANY ROUGH ROAD SENDS IT INTO UNCONTROLLABLE SHAKING, I THOUGHT I WAS GOING TO LOSE COMPLETE CONTROL OF THE TRUCK, IT COULD EASILY CAUSE AN ACCIDENT. I LOOKED FOR THIS PROBLEM ON THE INTERNET, AND FOUND THIS IS A PROBLEM FOR MANY FORD SD DRIVERS, AND AS OTHERS HAVE PUT IT, FORD WON'T DO ANYTHING UNTIL THE DEATHS OUT WAY THE RECALL COST. IT IS UP TO PEOPLE LIKE YOU, TO KEEP US SAFE, AND MAKE THESE CAR COMPANIES FIX THEIR PROBLEM VEHICLES BEFORE THERE ARE TOO MANY DEATHS. I AM SURE THERE HAS TO OF BEEN AN ACCIDENT CAUSED BY THIS PROBLEM, VERY POSSIBLY 1 OR MORE DEATHS, I KNOW OF ONE PERSON WITH THIS PROBLEM ON THE WEBSITE CAUSED A 3 CAR ACCIDENT. I CALLED THE DEALER, THEY WANT TO COME TO MY HOME AND DRIVE IT TO THE DEALERSHIP, I SAID I WOULD HAVE IT TOWED IN, BUT THEY WANT TO DRIVE IT, WHICH MAKES ME UNCOMFORTABLE, SINCE I AM LIABLE FOR WHAT HAPPENS WITH MY TRUCK. THERE HAS BEEN NO MODIFICATIONS DONE TO THIS VEHICLE, AND THE TIRES ARE THE APPROPRIATE TIRES AND THEY ARE FILLED WITH THE PROPER AIR PRESSURE. *TR
Engine and engine cooling, Feb 10, 2010, fire
THE FACTORY SPARK PLUG BLEW OUT OF THE CYLINDER HEAD ON MY FORD F-150. MY WIFE WAS DRIVING THE VEHICLE HOME AFTER PICKING MY SON UP FROM DAYCARE. A FIRE STARTED UNDER THE HOOD AND PASSER BY WAS KIND ENOUGH TO STOP AND HELP PUT IT OUT. I HAD A MACHINIST FIX THE HEAD AND I AM ABLE TO DRIVE THE TRUCK AGAIN. IT SCARES ME TO THINK THAT A MANUFACTURER IS ALLOWED TO PRODUCE A VEHICLE THAT COULD HAVE KILLED MY FAMILY. I HAVE LEARNED THAT I WILL NEVER OWN ANOTHER FORD VEHICLE WITH THIS TYPE OF ENGINE AND I WILL ENCOURAGE OTHERS TO THE SAME. *TR
Vehicle speed control, Feb 1, 2010, fire
I HAVE A 2000 MODEL FORD F-150. MY CRUISE CONTROL WENT OUT AND MAYBE A MONTH OR LESS LATER I CAME HOME ONE NIGHT AND ABOUT 30 MINUTES AFTER I WENT INTO THE HOUSE I HEARD A LOUD BANG. WHEN WE LOOKED OUT THE DOOR MY TRUCK WAS A BALL OF FLAMES. THE LOUD BANG I HAD HEARD WAS THE TIRE POPPING. I NEVER RECEIVED A RECALL NOTICE FOR THE CRUISE CONTROL SWITCH AND KNEW NOTHING ABOUT IT SHORTLY AFTER I GOT THE TRUCK I HAD IT AT THE DEALERSHIP AND THEY TOLD ME NOTHING ABOUT THIS RECALL WHEN I ASKED IF THE TRUCK HAD ANY. ALL I WAS TOLD IS THAT THERE WAS ONE ON THE PARKING BRAKE. *TR
Vehicle speed control, Jan 14, 2010, fire
2000 F150 CAUGHT FIRE AFTER BEING PARKED FOR APPROXIMATELY 2-HOURS. VEHICLE COMPLETELY DESTROYED AND TWO VEHICLES PARKED NEXT TO MY VEHICLE WERE DAMAGED. I WAS NEVER NOTIFIED BY FORD MOTOR COMPANY OF ANY RECALL. I WAS TOLD BY AN ACQUAINTANCE OF THE CRUISE CONTROL SWITCH RECALL THAT AFFECTED MY TRUCK AFTER THE FIRE OCCURRED. I HAVE MADE A CLAIM FOR DAMAGES WITH FORD MOTOR COMPANY AND AM AWAITING A RESOLUTION. *TR
Vehicle speed control, Jan 4, 2010, fire
2000 F150 MASTER CYLINDER PRESSURE SWITCH CAUGHT FIRE WHILE TRUCK WAS NOT RUNNING. $853 IN DAMAGES. *TR
Exterior lighting, Equipment, Jan 1, 2010
2000 FORD F-150 HAS A PROBLEM WITH THE TURN SIGNAL SWITCH FAILING. I HAVE REPLACED IT ONCE ALREADY AND THE PROBLEM OCCURRED AGAIN. I HAVE DONE RESEARCH VIA INTERNET AND OTHER PEOPLE HAVE HAD THE SAME PROBLEM. NEW BULB REPLACEMENT AND FUSE REPLACEMENT DOES NOT REMEDY THE PROBLEM. THE MULTIFUNCTION SWITCH IS DEFECTIVE. THIS COULD RESULT IN AN ACCIDENT OR INJURY. *TR