2000 Ford F-150
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,204 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 F-150 model years with reports.
Of the 2000 reports, 92 involved a crash and 361 involved a fire. 79 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Vehicle speed control, cruise controlJan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Campaign 05V017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Equipment, other, labelsSep 21, 2000
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V284000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Representative owner complaints
1,204 reports, newest first.
Engine and engine cooling, Dec 29, 2009, fire
TL* THE CONTACT OWNS A 2000 FORD F-150. WHILE PARKED HE NOTICED FLAMES FROM UNDERNEATH THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE VEHICLE WAS COMPLETELY DESTROYED. A FIRE REPORT WAS AVAILABLE. THE CAUSE OF THE FAILURE HAS NOT BEEN DETERMINED. A TECHNICIAN FROM THE DEALER STATED THAT HIS COMPLAINT WOULD BE FORWARDED TO THE OFFICE OF GENERAL COUNCIL AND THAT THEY WILL GIVE HIM A CALL BACK. THE VEHICLE WAS TOWED TO A FORD COLLISION CENTER FOR INSPECTION. THE FAILURE AND CURRENT MILEAGES WERE 125000.
Engine and engine cooling, Dec 26, 2009
SPARK PLUG BLOW OUT ON 2000 F150 5.4 TRITON ENGINE. DAMAGING COIL AND HEAD. RELEASING FUEL MIXTURE INTO ENGINE COMPARTMENT CREATING AN ENVIRONMENT FOR POTENTIAL EXPLOSION. *TR
Power train, Dec 8, 2009
2000 F150 SPARK PLUG BLOW OUT. 4.6L. *TR
Vehicle speed control, Dec 7, 2009, fire
TL* THE CONTACT OWNS A 2000 FORD F150. WHILE PARKED FOR 15 MINUTES, THE VEHICLE CAUGHT ON FIRE. THE PROCEEDING VEHICLE ALSO CAUGHT ON FIRE. THE FIRE THEN SPREAD QUICKLY TO HIS HOME, AND CAUSED SEVERE PROPERTY DAMAGE. THE FIRE INVESTIGATOR DISCOVERED THAT THE FIRE ORIGINATED FROM UNDER THE HOOD AREA. THE VEHICLE WAS COMPLETELY DESTROYED. THE MANUFACTURER WAS NOTIFIED, AND HE WAS ADVISED TO CONTACT HIS INSURANCE COMPANY. THE CURRENT AND FAILURE MILEAGES WERE OVER 100,000.
Engine and engine cooling, Nov 27, 2009
2000 FORD F-150 #3 SPARK PLUG BLOWS OUT OF CYLINDER HEAD. THIS INCIDENT HAS HAPPENED TWICE. *TR
Vehicle speed control, Nov 6, 2009, fire
WENT TO LUNCH. RETURNED TO WORK. WAS AT WORK FOR APPROX.1 HOUR. FELLOW EMPLOYEE COMES TO ME AND SAYS THERE IS SMOKE POURING OUT OF MY TRUCK. RAN OUTSIDE TO SEE MY TRUCK ON FIRE. TRIED USING EXTINGUISHERS BUT TO NO AVAIL. CALLED FIRE DEPT. AND THEY ARRIVED 5-10 MINUTES LATER. TRUCK WAS A TOTAL LOSS. HAD NO PREVIOUS PROBLEMS PRIOR TO THIS. INSURANCE COMPANY STATES IT WAS TO DUE A RECALL ON THIS VEHICLE. *TR
Vehicle speed control, Nov 5, 2009, fire
MY FORD F150 PICK UP TRUCK EXPLODED AND BURST INTO FLAMES AFTER BEING PARKED FOR ABOUT 10 HOURS. THE VEHICLES IS A TOTAL LOSS AND NEARLY DAMAGE OTHER ADJACENT VEHICLE PRIOR TO THE FIRE DEPARTMENT 'S RESPONSE . *TR
Vehicle speed control, Oct 26, 2009, fire
I OWN A FORD F150. ON THURSDAY, OCTOBER 22, AT APPROXIMATELY 8:30AM, THE ENGINE BURST INTO FLAMES IN THE PARKING LOT OF MY WORK. I WORK AT A PUBLIC SCHOOL, BUT LUCKILY NO ONE WAS INJURED AND NO OTHER CARS WERE DAMAGED. APPARENTLY, THE FIRE WAS CAUSED BY A FAULTY CRUISE CONTROL DEACTIVATION SWITCH. I AM NOT THE ORIGINAL OWNER OF THE TRUCK AND WAS NOT AWARE OF THE RECALL OR THE DANGER OF THE SITUATION. THE TRUCK WAS TOTALED. I AM NOW WAITING FOR MY INSURANCE COMPANY TO RESOLVE THE MATTER. *TR
Engine and engine cooling, Oct 20, 2009, fire
I PARKED MY 2000 FORD F 150 , ABOUT [2] HRS LATER I HEARD NOISES OUTSIDE, I WENT TO SEE WHAT THE NOISE WAS, AND MY TRUCK WAS IN FLAMES. *TR
Vehicle speed control, Sep 29, 2009, fire
2000 FORD F150 CAUGHT FIRE WHILE PARKED ON THE STREET. VEHICLE WAS TOTALLY DESTROYED. *TR
Engine and engine cooling, Sep 27, 2009
2000 FORD F-150 BLEW OUT A SPARK PLUG WHILE DRIVING ON HIGHWAY. *TR
Engine and engine cooling, Sep 20, 2009, fire
2000 FORD F150. BLEW NO. 3 SPARK WHILE DRIVING. IT BLEW AT PARTIAL THROTTLE, 45 MPH. TRUCK HAS BEEN PROPERLY MAINTAINED, NEVER HAD THIS HAPPEN ON ANY OTHER CAR I EVER OWNED. COME TO FIND OUT THIS A COMMON PROBLEM ON TRITON V-8 ENGINES. I'VE OWNED CARS WITH ALUMINUM HEADS BEFORE SO FOR FORD TO CLAIM ITS A TORQUING PROBLEM AND THE FAULT OF THE OWNER IS DISGRACEFUL TO ALL THE PEOPLE THAT MAINTAIN THEIR OWN CARS. FORTUNATELY THE FIRE WAS ONLY TEMPORARY AND WENT OUT WHEN I STOPPED THE TRUCK AND KILLED THE ENGINE, BUT THERE OBVIOUSLY HAD BEEN A FIRE AT SOME POINT. THIS IS THE SAME TRUCK THAT HAS ALREADY BEEN RECALLED ONCE, STILL HAVE A BURN MARK ON THE MASTER CYLINDER RESERVOIR FROM WHERE IT ALMOST BURST INTO FLAMES IN MY DRIVEWAY ONE DAY, THANK GOD I JUST SO HAPPENED TO HAVE THE HOOD UP TO REPLACE MY COOLANT WHEN IT HAPPENED, OR THE WHOLE TRUCK WOULD HAVE BURNT DOWN, I MANAGED TO PULL THE FUSE BEFORE IT DID, BUT FOR THIS TO HAPPEN ON TOP OF THAT IS RIDICULOUS. *TR
Vehicle speed control, Aug 24, 2009, fire
I BOUGHT A USED 2000 FORD F-150 A FEW MONTHS AGO AND ONE NIGHT AFTER BEING PARKED FOR AT LEAST 5 HOURS, IT CAUGHT ON FIRE. LATER I FIND OUT ABOUT A RECALL, THE DEALERSHIP WHERE I BOUGHT MY TRUCK NEVER MENTIONED ANYTHING ABOUT A RECALL. *TR
Fuel system, Gasoline, Structure, Aug 3, 2009
HAVE A 2000 FORD F150 HAD TANK FILLED WITH GAS AND WAS DRIVING DOWN ROAD WHEN GAS TANK FELL OF FOUND THAT BOTH STRAPS THAT HELD TANK HAD RUSTED THROUGH THANKFULLY WE WERE NOT MOVING FAST OR IT IS HARD TO TELL WHAT WOULD HAVE HAPPENED THERE IS ONLY 125000 MILE ON VEHICLE AND HAS BEEN MAINTAINED FEEL THAT AN INCIDENT LIKE THIS IS UNCALLED FOR THAT THERE SHOULD HAVE BEEN A SAFER WAY OF MOUNTING SINCE VEHICLE HAD EVEN BEEN RUSTPROOFED WE ARE THANKFULL THAT THIS DID NOT HAPPEN A HIGH SPEED FOR WE FEEL THAT SOMETHING GRAVE COULD HAVE HAPPENED TO US AND ANYONE BEHIND US IF AND WHEN IT MAY HAVE EXPLODED. *TR
Vehicle speed control, Jul 23, 2009, fire
MY 2000 FORD F-150 HAD BEEN DRIVEN FOR 15 MINUTES, THEN PARKED FOR 2 1/2 HOURS WHEN IT CAUGHT FIRE UNDER THE HOOD ON THE DRIVERS SIDE NEAR THE FIREWALL AT THE FENDER WELL. *TR
Engine and engine cooling, Jul 23, 2009, fire
ON WEDNESDAY, JULY 22, 2009, I DROVE TO WORK AND ARRIVED AT 9:00AM WITHOUT INCIDENT. AT 11:00AM I WAS NOTIFIED THAT MY TRUCK (2000 FORD F150) WAS ON FIRE IN THE PARKING LOT. IT APPEARS THAT AN ELECTRICAL FIRE HAD STARTED IN THE ENGINE COMPARTMENT. I READ LATER (ONLINE) THAT THERE IS A RECALL ON NUMEROUS FORD VEHICLES REGARDING A DEFAULT WITH A CRUISE CONTROL SWITCH THAT HAS CONSTANT POWER THAT HAS LEAD TO NUMEROUS F150'S (AND OTHER FORD VEHICLES) TO UNEXPECTEDLY BURST INTO FLAMES. THIS APPEARS TO HAVE BEEN CAUSED BY THIS PROBLEMATIC SWITCH BECAUSE THE FIRE STARTED IN THE LOCATION WHERE THIS DEFECTIVE SWITCH IS LOCATED. FORTUNATELY NOBODY WAS INJURED AND THE VEHICLE WAS INSURED.*TR
Fuel system, Gasoline, Structure, Jun 19, 2009
EMAIL FROM THE OFFICE OF CONGRESSMAN DINGELL RE CONSTITUENT WHO BELIEVES FORD MOTOR CO. MAYBE IN VIOLATION OF THE TREAD ACT. *NJ THE CONSUMER STATED THE DESIGN FLAW DATES BACK TO THE LATE 1990'S. THE CONSUMER BELIEVED THAT THE FORD F SERIES SUPER DUTY PICK-UP TRUCKS NEED TO BE INVESTIGATED FOR A DEFECT THAT INVOLVES THE SIDE POLE WHICH COULD CAUSE INJURIES/DEATHS DURING A SIDE IMPACT CRASH. *JB THE CONSUMER CLAIMED THAT THE RELATIONSHIP OF THE FRAME RAIL SPACING AND OCCUPANT SEATING PLACED THE OCCUPANT IN UNDUE DANGER IN SIDE IMPACT CRASHES. ESPECIALLY WHEN THE SIDE IMPACT INVOLVES THE VEHICLE STRIKING A POLE. UPDATED 03/1/10 UPDATED 03/15/10 THE CONSUMER STATED THE FUEL LEAK WAS A RESULT OF A TANK STRAP THAT RUSTED. ALSO, THE OTHER STRAP IS SEVERELY CORRODED. UPDATED 01/28/11 UPDATED 03/08/11 UPDATED 9/24/13*CN
Tires, Jun 19, 2009
TL*THE CONTACT OWNS A 2000 FORD F-150. THE VEHICLE HAS GRABBER AW TIRES, SIZE P275/60 R17. WHILE DRIVING 55 MPH, THE VEHICLE BEGAN SHAKING AND THE TIRE TREAD BEGAN TO SEPARATE. THE CONTACT PULLED THE VEHICLE OVER AND CALLED THE POLICE. A POLICE REPORT WAS FILED. THE DEALER ADVISED HIM TO PLACE THE SPARE TIRE ON THE VEHICLE. SHE FEELS THAT THE DEALER SHOULD REPLACE THE TIRE EVEN THOUGH THE VEHICLE WAS PURCHASED AS IS. THE DOT NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 106,000.
Air bags, May 28, 2009, crash
I WAS DRIVING NORTHBOUND ON A 3 LANE MAIN ROAD (2 LANES GOING ONE WAY, 1 LANE GOING THE OTHER WAY) AT ABOUT 40 MPH. WHILE COMING UP TO A T-INTERSECTION (I HAD THE RIGHT OF WAY, THE SENTRA HAD A STOP SIGN) ABOUT 20 TO 30 FEET FROM CROSSING THE INTERSECTION, THE SENTRA PROCEEDED TO CROSS MY LANES TO MAKE HER LEFT TURN. AS I TRIED TO AVOID THE ACCIDENT I ENDED UP HITTING HER SENTRA HEAD ON. AFTER THE IMPACT MY AIRBAGS DID NOT DEPLOY. AS FOR HER SENTRA THE IMPACT WAS ON THE FRONT LEFT TIRE SO NO AIRBAGS DEPLOYED IN HER CAR. I HAVE A 2000 FORD F-150 AND HIT HER HEAD ON....BUT NO AIRBAGS DEPLOYED. COULD THIS HAVE BEEN A POSSIBLE DEFECT ON MY TRUCK. I HAD PICTURES TAKEN MINUTES AFTER THE ACCIDENT. *TR
Engine and engine cooling, May 23, 2009
I OWN A 2000 FORD F-150, TRITON 4.6 LITER. JULY 2007, BLOWN SPARK PLUG FROM CYLINDER HEAD; COST FOR REPAIR $636.00. MAY 2009, BLOWN SPARK PLUG (#3) FROM CYLINDER HEAD; COST FOR REPAIR $606.00 PLUS $81.00 FOR RENTAL VEHICLE. I UNDERSTAND FORD WILL NOT TAKE RESPONSIBILITY FOR REPAIRING AND OR REIMBURSING A CUSTOMER FOR THEIR EXPENSES. SIGNED, ANOTHER UNHAPPY FORD OWNER. *TR
Engine and engine cooling, May 19, 2009, fire
TL*THE CONTACT OWNS A 2000 FORD F-150. THE VEHICLE CAUGHT FIRE WHILE PARKED IN FRONT OF THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE FIRE ORIGINATED UNDER THE HOOD AND THEN SPREAD TO THE FRONT SEAT AND REAR OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT. THERE WERE NO INJURIES. THE FAILURE MILEAGE WAS 148,000.
Vehicle speed control, May 17, 2009, fire
2000 FORD F-150. SITTING IN OUR DRIVEWAY, NEIGHBOR SAID THEY SAW A FLASH. VEHICLE IGNITED ON DRIVER'S SIDE UNDER THE HOOD. OWNER WAS ABLE TO EXTINGUISH THE FIRE BEFORE FIRE DEPARTMENT ARRIVED. FORD MOTOR COMPANY STATED NO ASSISTANCE WOULD BE OFFERED. CURRENTLY BEING EVALUATED BY INSURANCE COMPANY. *TR
Vehicle speed control, May 14, 2009, fire
TL*THE CONTACT OWNS A 2000 FORD F150. THE VEHICLE SUDDENLY CAUGHT FIRE WHILE IT WAS PARKED. THE CONTACT EXTINGUISHED THE FIRE WITH A GARDEN HOUSE, ALTHOUGH THE FIRE DEPARTMENT WAS CALLED. HE DID NOT RECEIVE A REPORT FROM THE FIRE DEPARTMENT. HE BELIEVED THAT THE FIRE WAS DUE TO NHTSA CAMPAIGN ID NUMBER 05V017000. THE MANUFACTURER WAS NOT NOTIFIED AND THERE WERE NO PRIOR ISSUES WITH THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 92,900.
Engine and engine cooling, Apr 13, 2009, fire
2000FORD F150 BURNED TO THE GROUND CAUSING DAMAGE TO HOUSE. *TR
Suspension, Mar 18, 2009
TL*THE CONTACT OWNS A 2000 FORD F150 XL 4X4. THE CONTACT STATED THAT THE REAR SUSPENSION ON THE VEHICLE FAILED DUE TO THE RACK AND PINION. BEFORE THE VEHICLE WAS DIAGNOSED, HE HEARD A GRINDING SOUND COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS REPAIRED AT THAT TIME. HE STATED THAT OTHER FORD F-150 OWNERS HAVE EXPERIENCED THE SAME ISSUE. THE CONTACT DOES NOT WANT TO DRIVE THE VEHICLE WHILE HAULING SOMETHING AND THE REAR SUSPENSION FAILS AND CAUSES A MAJOR CRASH. THE CURRENT MILEAGE WAS 117,000 AND FAILURE MILEAGE WAS 116,900.