2000 Ford F-150
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,204 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 F-150 model years with reports.
Of the 2000 reports, 92 involved a crash and 361 involved a fire. 79 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Vehicle speed control, cruise controlJan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Campaign 05V017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Equipment, other, labelsSep 21, 2000
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V284000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Representative owner complaints
1,204 reports, newest first.
Electrical system, Feb 22, 2007, fire
FORD 2000 EXPITITION CAUGHT ON FIRE AND WAS TOTALLY DESTROYED AND OCCURED IN MY DRIVEWAY AROUND 7AM AND THE VEHICLE WAS NOT ON AND THE LAST TIME USED AROUND 10:30 PM THE PREVIOUS NIGHT. *NM
Parking brake, Feb 11, 2007
ON THE INTERSTATE TRAVELING 60-65 MPH I STARTED FEELING A VIBRATION. PULLED OFF TO CHECK TIRES AND SEEN NOTHING OBVIOUS BUT COULD SMELL SOMETHING HOT. PULLED INTO WELL LIT PARKING GARAGE. FOUND REAR DRIVERS SIDE BRAKE LOCKED ON TO TIRE. THE INVOICE STATES 'DRIVER REAR PARKING BRAKE CABLE WAS NOT RELEASING. HAD TO TEAR APART THE DRIVER REAR DRUM ASSEMBLY AND UNHOOK CABLE FROM SHOES. HAD TO UNLOAD SPRING TENSION ON PARKING BRAKE PEDAL ASSEMBLY IN ORDER TO UNHOOK CABLES. WHEN DRIVERS REAR CABLE REMOVED IT WAS LOCKED UP. *JB
Engine and engine cooling, Feb 3, 2007
#8 SPARK PLUG POPPED OUT OF HEAD CAUSING THE THREADS TO STRIP IN HEAD & BUSTED COIL PACK. CONVERTER WAS GLOWING RED & POPPING. *NM
Vehicle speed control, Feb 2, 2007, fire
MY TRUCK, OWNED BY MY COMPANY, HAD BEEN SITTING IN THE ALLEY WHERE I WAS WORKING NOT RUNNING. THE 2000 FORD F-150 EXT -CAB 2-WD PICKUP CAUGHT FIRE FOR NO REASON, THE FIRE STARTED AT THE DRIVER SIDE WHEEL WELL AT THE HOOD LEVEL,ONCE THE FIRE STARTED THERE WAS NO STOPPING IT. I WAS LUCKY THE FIRE CAUSED NO DAMAGE TO PEOPLE OR OTHER PEOPLES PROPERTY. THE TRUCK HAD A RECALL ISSUE WITH THE SPEED CONTROL MODULE, THIS TRUCK WAS LISTED WITH FORD ON THE WEB SITE. I NEVER RECEIVED THE NOTICE. I HAVE CONTACTED FORD, WE WILL SEE. THIS IS A SMALL COMPANY WITH LIMITED FUNDS, NOT INSURED FOR THIS, MY OWN FAULT.*JB
Steering, Air bags, Jan 25, 2007, crash
TL* - THE CONTACT OWNS A 2000 FORD F150. THE CONTACT STATED THAT A COLLISION OCCURRED ON A BACK ROAD COVERED WITH SNOW. THE CONTACT STATED THAT THE SHAFT IN THE STEERING GEAR BOX TO THE PITMAN ARM SNAPPED. THE CONTACT WAS DRIVING 30 MPH WHEN THE FAILURE OCCURRED AND CAUSED THE CRASH. THE AIR BAGS DID NOT DEPLOY. THE CONTAC DID NOT KNOW THE EXTENT OF THE DAMAGE. NO POLICE REPORT WAS TAKEN. *AK
Vehicle speed control, Jan 22, 2007, fire
TL* - THE CONTACT OWNS A 2001 FORD F-150. THE VEHICLE WAS TOWED TO THE DEALER DUE TO A VERY LOUD NOISE UNDER THE HOOD. THE REPAIR MECHANIC INSTALLED A HELICOIL IN THE THREADS OF THE CYLINDER HEAD AND REPLACED THE SPARK PLUG COIL. THE VEHICLE WAS PARKED ON THE DEALER'S LOT AND CAUGHT FIRE FROM THE ENGINE COMPARTMENT. THE FIRE DAMAGED THE WIRE HARNESS, SPEED CONTROL, AND THE ENGINE. IN OCTOBER 2006 THE CONTACT REQUEST THE DEALER HONOR NHTSA RECALL #05V388000 (FORD RECALL #05S28) PERTAINING TO THE VEHICLE SPEED CONTROL. THE DEALER WOULD NOT COVER THE RECALL STATING THE CONTACT NEVER RESPONDED TO THE RECALL NOTICE. THE CONTACT STATED THAT HE NEVER RECEIVED RECALL NOTICE. THE CONTACT HAS PICTURES OF THE VEHICLE. *AK
Vehicle speed control, Jan 19, 2007, fire
2000 FORD F-150 PICK UP CAUGHT ON FIRE WHILE PARKED IN DRIVEWAY IGNITION OFF. *JB
Electrical system, Jan 16, 2007, fire
MY 2000 FORD F-150 BURNED TO A CRISP LAST NIGHT. I HAD DRIVEN THE VEHICLE AND PARKED IT IN MY DRIVEWAY AND WAS INSIDE PUTTING THE GROCERIES AWAY WHEN I HEARD A "BOOM" OUTSIDE AND WHEN I RAN OUT I OBSERVED A FIRED FROM THE ENGINE COMPARTMENT. IT APPEARS TO ME THAT THE VEHICLE IS TOTALED. THERE WAS SOME MINOR DAMAGE TO MY RESIDENCE AND I NOW HAVE A REALLY COOL LOOKING GARBAGE CAN FROM THE HEAT OF THE FIRE. FRIENDS INFORMED ME TODAY THAT THERE HAVE BEEN NUMEROUS RECALLS, AND SIMILAR INCIDENTS, BUT I HAVE NOT HEARD ABOUT ANY RECALLS. WHAT CAN I DO ABOUT THIS BESIDES CONTACTING MY INSURANCE COMPANY(S)? *NM
Air bags, Jan 10, 2007, crash
NO DESCRIPTION WAS GIVEN.
Suspension, Wheels, Jan 6, 2007, crash
WAS ON A SLICK ROAD. I WAS GOING 15 MILES AN HOUR, WHEN MY 2000 FORD F-150 SPUN COMPLETELY AROUND. WHEN THE TRUCK SPUN AROUND IT WENT TOWARDS THE DITCH BACKWARDS. WHEN I HIT THE DITCH THE TRUCK FLIPPED ONTO THE PASSENGER SIDE. WHEN THE TOW TRUCK ARRIVED ON THE SCENE HE INFORMED ME THAT THE REAR TIRE BROKE OFF THE AXLE. I HAD NEVER HEARD OF THIS HAPPENING AT SUCH A SLOW SPEED, NEITHER HAD THE TOW TRUCK DRIVER, ESPECIALLY SINCE IT WAS A HEAVY HALF TON LOAD AXLE . WHEN WE WERE LOOKING AT THE AXLE IN THE LIGHT IT APPEARED THAT IT CRYSTALLIZED AND SNAPPED. I AM A WELDER AND WORK WITH METAL EVERY DAY AND THE AXLE LOOK ALMOST LIKE CAST. *NM
Fuel system, Gasoline, Jan 2, 2007
TL* - THE CONTACT STATED THAT WHILE DRIVING THE GAS TANK UNATTACHED ITSELF FROM THE VEHICLE. THE CONTACT STATED THAT HE WAS DRIVING AT 55 MPH WHEN THE STRAPS HOLDING THE GAS TANK CAME OFF. THE TANK FELL TO THE GROUND, AND HE WAS ABLE TO PULL TO THE SIDE OF THE ROAD WITHOUT INCIDENT, THE CONDITIONS ON 12-24-06 WERE DRY. THE CONTACT STATED THAT HE KEPT THE TRUCK IN A GARAGE. *AK UPDATED 02/27/07. *JB
Electrical system, Dec 22, 2006, fire
TL* - THE CONTACT'S ENGINE CAUGHT ON FIRE EARLIER THIS WEEK ON HIS FORD F-150. THE ARSON INSPECTOR INFORMED THE CONTACT THAT THE FIRE WAS CAUSED BY A FAILURE OF HIS CRUISE CONTROL SWITCH. THE CONTACT STATES THAT THE WEATHER WAS BRIGHT AND SUNNY ON THE DAY OF THE FAILURE.
Fuel system, Gasoline, Air bags, Dec 22, 2006, crash
ON 12/12/06 A LADY TURNED LEFT IN FRONT OF ME CAUSING ME TO BROADSIDE HER. I WAS DOING APPROX 40 MPH AT THE TIME. ALL HER AIR BAGS DEPLOYED. NONE OF MINE DID, EVEN THOUGH THE ENTIRE IMPACT OF THE ACCIDENT WAS ACROSS MY FRONT END. ADDITIONALLY MY FUEL CUTOFF SWITCH DID NOT FUNCTION. WHEN THE VEHICLES CAME TO REST, AND I RECOLLECTED MY WITS, I REALIZED THE ENGINE WAS STILL RUNNING AND AT CLOSE TO FULL THROTTLE. *NM
Engine and engine cooling, Dec 1, 2006
2000 FLEETWOOD PACE ARROW MOTORHOME WITH FORD TRITON V10 ENGINGE: AT 32,000 BLEW A SPARK PLUG OUT OF THE HEAD. FORD DEALER QUOTED ME $6,000 TO REPLACE WITH NEW/IMPROVED HEAD. I CAN REPLACE THE WHOLE ENGINE FOR LESS THAN $3,000. THIS IS INCREDIBLE AND SOMETHING NEEDS TO BE DONE. EVEN THE TOW TRUCK DRIVER THAT TOWED ME TO THE DEALER SAID HIS FORD TRUCK WITH A V10 RECENTLY BLEW A PLUG AS WELL. I OWN FOUR MOTORHOMES ALL WITH THE FORD TRITON V10 ENGINE. THE COMPANY I USED TO WORK FOR HAD SIX MOTORHOMES WITH THE FORD TRITON V10 AND HAD FOUR SPARK PLUG BLOWOUT INCIDENCES WHILE I WAS WORKING THERE. SOMETHING NEEDS TO BE DONE ABOUT THIS. IT IS UNTHINKABLE THAT A COMPANY CAN GET AWAY WITH PEDDLING CRAP TO CUSTOMERS AND THEN CHARGING THEM $6,000 TO FIX THIS PROBLEM!!! CONTACT OSCAR AT DON KOTT FORD IN CARSON, CA TO CONFIRM MY ESTIMATE. DO SOMETHING, DO SOMETHING DO SOMETHING! THANK YOU VERY MUCH. *NM
Fuel system, Gasoline, Vehicle speed control, Nov 30, 2006, fire
DT*: THE CONTACT STATED THE VEHICLE WAS DRIVING 55 MPH OFF THE INTERSTATE ON NORMAL ROAD CONDITIONS WHEN A FIRE WAS NOTICED COMING FROM THE UNDERBODY OF THE VEHICLE. THE CONTACT PULLED OVER JUST AS THE FIRE SPREAD THROUGHOUT THE VEHICLE. THE CONTACT WAS NOT INJURED. A POLICE AND FIRE REPORT WERE TAKEN. THE FIRE DEPARTMENT COULD NOT DETERMINE THE CAUSE OF THE FIRE. THE VEHICLE WAS TOWED TO A LOCAL INDEPENDENT MECHANIC, WHO DETERMINED THE FIRE COULD HAVE POSSIBLY BEEN CAUSED BY THE FUEL, BUT COULD NOT FIND THE COMPONENT INVOLVED IN THE FIRE. THE MANUFACTURER WAS CALLED AND STATED THE VEHICLE WAS INCLUDED IN A RECALL REGARDING THE VEHICLE SPEED CONTROL, HOWEVER THE CONTACT FOUND A POSSIBLE NHTSA RECALL # 06E056000 REGARDING THE FUEL SYSTEM, GASOLINE THAT RELATED MORE TO THE FIRE THAT OCCURRED ON THE VEHICLE. HOWEVER, THE VEHICLE WAS NOT INCLUDED IN THIS RECALL DUE TO THE VIN. THE MANUFACTURER WAS NOT CLAIMING RESPONSIBILITY NOR PROVIDED FURTHER ASSISTANCE. THE VEHICLE WAS DEEMED TOTALED.
Vehicle speed control, Nov 20, 2006, fire
ON OCT. 28TH 2006 AT 3:00 AM OUR FORD F-150 IGNITED AND BURNED IN OUR DRIVEWAY THERE WAS A RECALL ON THE CRUISE CONTROL FOR DOING THIS VERY THING WHEN THE DEALER WAS CALLED THEY SAID OUR TRUCK WASN'T INVOLVED. FORD SAID IT WAS AND NOW SAYS IT WAS BURNED TO BADLY FOR THEM TO TELL IF IT WAS THERE FAULT. *JB
Engine and engine cooling, Nov 20, 2006
SEVERE SMELL OF ANTIFREEZE IN CABIN OF TRUCK. "MIST" FROM THE VENTS. MUST RUN WITH WINDOWS OPEN AND STILL SMELL AND TASTE ANTIFREEZE. CERTIFIED FORD DEALERSHIP WAS ABLE TO FIND NOTHING WRONG. HAS BEEN LIKE THIS FOR 2 YEARS. *NM
Electrical system, Vehicle speed control, Nov 17, 2006, fire
I GOT OFF WORK AT 6:00 PM AND WENT STRAIGHT TO THE GYM (APPROX. 1 MI.). I LEFT THE GYM AT 7:00 PM, AND DROVE HOME (APPROX 1 MI.). I GOT HOME ABOUT 7:15 PM AND WENT INSIDE AND WATCHED TELEVISION WITH MY FAMILY UNTIL 8:30 PM, WHICH IS WHEN I WENT TO BED. MY WIFE AND I WOKE UP AT 11:30 PM FROM A BRIGHT LIGHT COMING THROUGH OUR BEDROOM WINDOW. WHEN WE LOOKED OUT THE WINDOW THE LIGHT WE HAD SEEN WAS THE WHOLE FRONT END OF MY 2000 FORD F-150 ENGULFED IN FLAMES. WE CALLED 911 AND THE FIRE DEPT. RESPONDED. MY WIFE'S CAR A 2002 HYUNDAI ACCENT WAS PARKED IN FRONT OF THE TRUCK AND HAD THE REAR BUMPER AND TAIL LIGHTS MELTED ON IT BEFORE I COULD GET IT MOVED. ABOUT 1 YEAR AGO I HAD TO HAVE THE MASS FLOW AIR SENSOR REPLACED ON THE TRUCK AND THE DEALERSHIP SUPPOSEDLY TOOK CARE OF THE CRUISE CONTROL RECALL THAT WAS PLACED ON THAT MODEL. *JB
Electrical system, Nov 11, 2006, fire
MY UNCLE'S F-150 2000 FORD WAS SITTING OUTSIDE MY BUSINESS FOR 1-1 1/2 HOURS WHEN A KID RODE UP ON A BIKE AND TOLD THEM THERE WAS A TRUCK OUT FRONT ON FIRE. THEY TRIED TO PUT IT OUT BUT FAILED. IT WENT UP THE FRONT WALL OF MY BUILDING AND COMPLETELY BURNED MY BUSINESS DOWN. *NM
Electrical system, Oct 31, 2006
INTERMITTENT ELECTRICAL FAILURES IN WET CONDITIONS. MOST SEVERE WAS WHEN WINDSHIELD WIPERS QUIT WORKING WHILE DRIVING IN THE RAIN. LESS SEVERE, RADIO WILL STOP, ODOMETER WILL TURN BLANK, ACCESSORIES WILL REMAIN ON WITH TRUCK TURNED OFF. *NM
Vehicle speed control, Oct 10, 2006, fire
DT*: THE CONTACT STATED WHILE PARKED, THE ENGINE BAY CAUGHT ON FIRE. THERE WERE NO WARNING SIGNALS PRIOR TO THE INCIDENT. THE FIRE DEPARTMENT WAS CONTACTED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS DEEMED TOTALED THERE WERE TWO VEHICLES THAT WERE PARKED NEXT TO THE CONTACT'S VEHICLE THAT WERE TOTALED AS WELL. NEIGHBORS NOTICED SMOKE AND SPARKS COMING FROM THE VEHICLE'S ENGINE BAY PRIOR TO THE FIRE. A POLICE REPORT WAS TAKEN. THE DEALER WAS CONTACTED, AND SUGGESTED THAT A LETTER SHOULD BE PROVIDED TO THE MANUFACTURER'S CONSUMER AFFAIRS DEFERMENT. THERE WERE TWO NHTSA RECALLS #05V388000 AND #05V017000 PERTAINING TO THE VEHICLE SPEED CONTROL. THE CONTACT NEVER RECEIVED A NHTSA LETTER. THE MANUFACTURER WAS CONTACTED AND SUGGESTED THAT THE VEHICLE'S OWNER NEEDED TO PROVIDE A LETTER OF REPRESENTATION. PICTURES OF THE BURNED VEHICLE WERE AVAILABLE.
Vehicle speed control, Oct 3, 2006, fire
ON THE EVENING OF AUGUST 9 2006 WHILE WORKING IN MY GARAGE I NOTICE A BRIGHT FLICKER OF LIGHT COMING FROM OUTSIDE THE GARAGE IN THE GENERAL DIRECTION OF MY 2000 FORD F-150. I QUICKLY NOTICED THAT THE VEHICLE WAS ON FIRE UNDER THE HOOD AND MOLTEN PLASTIC WAS DRIPPING ALONG WITH FIRE THROUGH THE LEFT FRONT FENDER WELL. I IMMEDIATELY GRABBED A FIRE EXTINGUISHER AND PUT OUT THE FIRE. THE VEHICLE HAD NOT BEEN OPERATED FOR A PERIOD OF ABOUT 3 HOURS PRIOR TO THE FIRE OCCURRING. IT IS ONLY BECAUSE THAT I WAS WORKING IN MY GARAGE AND NOTICED THE BEGINNING OF WHAT COULD HAVE BEEN A MUCH MORE SERIOUS FIRE THAT THE VEHICLE WAS NOT A TOTAL LOSS AND MY HOME AND FAMILY WERE NOT DESTROYED OR INJURED. THE VEHICLE WAS TOWED TO A LOCAL FORD DEALERSHIP FOR REPAIRS AT THE DIRECTION OF MY INSURANCE CLAIMS ADJUSTER. FOR THE PURPOSE OF ASSIGNING THE INSURED'S LIABILITY, THE CLAIMS ADJUSTER DETERMINED THE CAUSE OF THE FIRE TO BE LEAKING BRAKE FLUID AT THE BRAKE MASTER CYLINDER RESULTING IN AN ELECTRICAL SHORT. THE CLAIMS ADJUSTER ALSO STATED THAT THIS WAS POSSIBLY A RECALL ITEM. *NM
Vehicle speed control, Oct 2, 2006, fire
DT*: THE CONTACT STATED WHILE DRIVING 10 MPH, THERE WAS A SMELL OF SOMETHING ELECTRICAL BURNING, FOLLOWED BY SMOKE BILLOWING FROM UNDER THE HOOD. UPON EXITING THE VEHICLE, THE CONTACT NOTICED FLAMES NEAR THE MASTER CYLINDER. THE FIRE WAS QUICKLY EXTINGUISHED. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO DETERMINED THAT THE CRUISE CONTROL DEACTIVATION SWITCH HAD BURNED. THERE WERE NO IMMEDIATE REPAIRS MADE. THE MANUFACTURER WAS NOTIFIED, WHO INFORMED THE CONTACT THAT THERE HAD BEEN 4 RECALL NOTICES FOR NHTSA RECALL# 05V388000 SENT OUT FOR THAT VEHICLE. THE CONTACT STATED THAT NONE OF THOSE NOTICES HAD BEEN RECEIVED.
Engine and engine cooling, Sep 25, 2006
DT*: THE CONTACT STATED WHILE DRIVING 40 MPH, THE VEHICLE BEGAN TO LOSE POWER, ACCOMPANIED BY A KNOCKING NOISE COMING FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO DETERMINED THAT THE # 2 SPARK PLUG HAD BLOWN OUT OF THE HEAD. ONE YEAR PRIOR, THE # 7 PLUG HAD ALSO BLOWN OUT OF THE HEAD, AND THE DEALER REPLACED THE HEAD, HOWEVER THE PROBLEM PERSISTED.
Vehicle speed control, Sep 14, 2006, fire
I PURCHASED A USED 2000 FORD F150 IN FEB.- 2003 FROM A FORD DEALERSHIP IN FAYETTEVILLE, NC. ON AUGUST 8, 2005 THAT TRUCK CAUGHT FIRE AND DESTROYED OUR HOME AND HOME BASED BUSINESS,WE WERE NOT HOME AT THE TIME OF THE FIRE. WE ARRIVED HOME ABOUT 15 MINUTES AFTER. THEN NOTHING BUT A FIRE BALL AND MY HOUSE BURNING! JENNIFER SAT DOWN BESIDE A FIRE TRUCK AND LAID HER HEAD ON HER KNEES FOR 3 HOURS UNABLE TO COMFORT HER TWO SMALL CHILDREN AND I WAS IN COMPLETE SHOCK AND HELD MY DAUGHTER FOR OVER 3 HOURS IN MY ARMS AND I COULD NOT EVEN SPEAK. I ONLY REMEMBER ASKING JENNIFER, "WHAT HAPPENED AND WHAT WILL HAPPEN TO US NOW." A NEIGHBOR WAS DRIVING HOME THAT DAY AND SAID HE SAW FLAMES COMING OUT FROM UNDER THE HOOD OF MY TRUCK WHICH WAS PARKED PARTIALLY UNDER THE CARPORT. HE SAID THE TRUCK WAS THEN WITHIN SECONDS BURNING SO FIERCELY THAT IT BLEW UP LIKE A BOMB SENDING A FIRE BOMB INTO OUR HOME. I COULD NOT BELIEVE IT WHEN HE SAID THAT MY TRUCK HAD CAUGHT FIRE AND DESTROYED OUR HOME. WE LOST EVERYTHING. I RUN A ROOFING COMPANY AND JENNIFER HANDLED ALL MY PAPERWORK - THE OFFICE WAS SET UP AT HOME SO SHE COULD STAY HOME WITH OUR CHILDREN. WE LOST OUR BUSINESS, HOME AND MEMORIES SUCH AS PICTURES OF OUR CHILDREN AND FAMILY. I AM STILL TRYING TO RECOVER EMOTIONALLY AND FINANCIALLY FROM OUR LOSS DUE TO FIRE. FORD MOTOR CO. SENT A INVESTIGATOR TO INVESTIGATE THE FIRE AND OUR HOMEOWNERS INS. INVESTIGATOR ALSO WAS THERE THE DAY "FORD FINALLY SENT SOMEONE TO INVESTIGATE THE FIRE". JENNIFER'S BROTHER-IN-LAW, AN ATTORNEY IN TEXAS TOLD US ABOUT CRUISE CONTROL DEFECT ON SOME FORD VEHICLES. WE WERE NOT AWARE OF THIS. THE CRUISE CONTROL WAS FOUND BY MIRACLE AND SENT FOR X-RAY AND WAS FOUND TO BE THE CAUSE OF THE FIRE. WHAT IF JENNIFER HAD BEEN DRIVING THAT TRUCK ON THAT DAY? WHAT IF I HAD LOST MY CHILDREN AND THEIR MOTHER? FORD MOTOR COMPANY RUINED OUR LIVES. WE NOW LIVE IN A ONE BEDROOM HOUSE WITH THREE CHILDREN. *JB