2000 Ford F-150
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,204 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 F-150 model years with reports.
Of the 2000 reports, 92 involved a crash and 361 involved a fire. 79 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Vehicle speed control, cruise controlJan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Campaign 05V017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Equipment, other, labelsSep 21, 2000
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V284000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Representative owner complaints
1,204 reports, newest first.
Power train, Sep 13, 2006
DT*: THE CONTACT STATED A PUDDLE OF OIL WAS NOTICED UNDER THE TRANSMISSION. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHO DETERMINED THE TRANSMISSION SEAL RUPTURED. THE SEAL WAS REPLACED. THE REPAIR SHOP WOULD NOT JUST REPLACE THE SEAL, THEY STATED WOULD FOLLOW THE TSB'S INSTRUCTIONS AND REPLACE ALL THE NECESSARY PARTS. UPDATED 09/25/06. *JB
Suspension, Sep 13, 2006
DT*: THE CONTACT STATED WHILE TRAVELING 15 MPH, THE FRONT DRIVER TIRE FLIPPED SIDEWAYS. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHERE THE FRONT END WAS REBUILT. THE EXACT COMPONENTS REPLACED WERE UNKNOWN.
Vehicle speed control, Sep 11, 2006, fire
ON AUGUST 31 MY 2000 FORD F-150 EXPLODED IN A DRIVEWAY AFTER BEING PARKED THERE FOR APPROXIMATELY 25 MINUTES THE FIRE WAS FROM A RECALLED CRUISE CONTROL SWITCH , FORD SAYS THEY NOTIFIED ME MARCH 23, 2006 ABOUT THE SWITCH HOWEVER THEY SENT THE RECALL TO AN OLD ADDRESS. THE TRUCK WAS A TOTAL LOSS AND THEY HAVE SENT ME A LETTER WHICH SAYS "FORD DECLINES TO PROVIDE ANY ASSISTANCE AT THIS TIME".*JB
Vehicle speed control, Aug 29, 2006, fire
DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED FOR SEVERAL HOURS, THE CONTACT NOTICED FLAMES COMING FROM UNDERNEATH THE DRIVER'S SIDE FRONT END. THE VEHICLE WAS TOTALED. THERE WERE NO PROBLEMS WITH THE VEHICLE PRIOR TO THIS INCIDENT. THE CONTACT USED THE CRUISE CONTROL OCCASIONALLY. THE FIRE DEPARTMENT CAME TO THE SCENE AND EXTINGUISHED THE FIRE. THE FIRE DEPARTMENT DETERMINED THE FIRE WAS CAUSED FROM A FAULTY CRUISE CONTROL SWITCH. THERE WAS A POLICE REPORT FILED.
Air bags, Aug 17, 2006
DT*: THE CONTACT STATED THE AIR BAG WARNING LIGHT ONLY WORKED INTERMITTENTLY, WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS NOT TAKEN IN FOR SERVICE.
Electrical system, Aug 16, 2006, fire
WOKE UP AT 3:55 A.M. AND MY 2000 FORD F150 WAS FULLY INVOLVED IN FLAMES. IT ALSO CAUGHT A VEHICLE IN FRONT OF IT 1999 DODGE DURANGO IN FLAMES. IT THEN PROCEEDED TO CATCH MY HOUSE ON FIRE. *NM
Electrical system, Aug 12, 2006, fire
2000 F-150 TRUCK IGNITED AND BURNED MASTER CYLINDER AND WIRING. *JB
Vehicle speed control, Aug 10, 2006, fire
DT*: THE CONTACT STATED THE PARKED VEHICLE ERUPTED IN FLAMES DURING THE NIGHT. THE FIRE DEPARTMENT WAS CONTACTED, EXTINGUISHED THE FIRE, AND DETERMINED THAT THE ANTI-LOCK BRAKE OR THE CRUISE CONTROL COULD HAVE CAUSED THE FIRE. A FIRE REPORT WAS TAKEN AND PICTURES OF THE BURNED VEHICLE WERE AVAILABLE. THE FIRE OCCURRED FROM THE ENGINE COMPARTMENT. THE CONTACT STATED THE CRUISE CONTROL STOPPED FUNCTIONING 3 MONTHS PRIOR TO THE FIRE. THE FIRE WAS ELECTRICAL AND CAUSED DAMAGE TO THE CONTACT'S OTHER VEHICLE AND RESIDENCE. UPDATED 09/05/06. *JB
Engine and engine cooling, Aug 7, 2006
I HAVE HAD 3 SPARK PLUGS EJECT FROM MY 2000 F150 5.4L IN THE PAST 3 MONTHS. SO FAR, REPAIRS HAVE TOTALED $150, BUT THE LAST ONE TOOK THE THREADS WITH IT. ESTIMATE TO FIX THIS ONE IS $400 WITH A SPECIALLY MADE REPAIR KIT. AS MOST KNOW, THIS IS "THE PROBLEM THAT MUST NOT BE NAMED". EVERYONE KNOWS IT EXISTS, FORD DOESN'T WANT TO DEAL WITH IT. *NM
Vehicle speed control, Aug 3, 2006, fire
WE PURCHASED A 2000 FORD F-150 PICKUP IN OCTOBER 2003. WE RECEIVED A RECALL NOTICE FROM FORD AND TOOK THE VEHICLE TO A LOCAL FORD DEALER IN FEBRUARY 2005 TO HAVE THE REPAIR WORK PERFORMED. WE WERE TOLD THIS WAS AN INTERIM REPAIR AND PERMANENT REPAIRS WOULD BE MADE ONCE REPLACEMENT PARTS WERE MORE WIDELY AVAILABLE. ON SATURDAY, JULY 1, 2006, OUR 2000 FORD F-150 EXPLODED WHILE SITTING IN OUR DRIVEWAY. THE RESULTING FIRE DESTROYED THE TRUCK AND CAUSED CONSIDERABLE DAMAGE TO OUR HOME. THE TRUCK HAD NOT BEEN DRIVEN FOR 24 HOURS BEFORE IT EXPLODED. THE LOCAL FIRE CHIEF STATED THE FIRE WAS CAUSED BY AN ELECTRICAL PROBLEM ON THE DRIVER'S SIDE OF THE TRUCK'S ENGINE. PLEASE NOTE THE TRUCK EXPLODED AFTER WE HAD THE REPAIR WORK DONE IN ACCORDANCE WITH FORD'S RECALL NOTICE. *JB
Electrical system, Vehicle speed control, Equipment, Jul 30, 2006, fire
WE HAVE FALLEN VICTIM TO FORD'S COMPARTMENT FIRE ISSUE. FROM EVERYTHING WE HAVE JUST RESEARCHED, IT APPEARS OUR F150 CAUGHT ON FIRE AROUND 5 AM SUNDAY JULY 30. IT HAD BEEN PARKED SINCE 10:30 PM. IN TRYING TO RESEARCH THIS BIZAARE INCIDENT, I DISCOVERED THEIR RECALL WHICH I NEVER RECEIVED. I HAVE OWNED THE VEHICLE SINCE 2001. I HAVE NOT HAD ANY PRIOR PROBLEMS WITH THE VEHICLE, WHICH IS WHY I FOUND THIS SO BIZAARE TO WAKE UP AT 5 AM TO MY WIFE YELLING "YOUR TRUCK IS ON FIRE!". LUCKILY, I HAVE NEVER BEEN MOTIVATED TO CLEAN OUR GARAGE SO WE COULD PARK INSIDE. HOWEVER, OUR HOME DID SUFFER DAMAGE TO THE SIDING. FORD IS NOT BEING AGGRESSIVE IN ENSURING THIS IS BEING HANDLED. *JB
Electrical system, Vehicle speed control, Equipment, Jul 30, 2006, fire
WE HAVE FALLEN VICTIM TO FORD'S COMPARTMENT FIRE ISSUE. FROM EVERYTHING WE HAVE JUST RESEARCHED, IT APPEARS OUR F150 CAUGHT ON FIRE AROUND 5 AM SUNDAY JULY 30. IT HAD BEEN PARKED SINCE 10:30 PM. IN TRYING TO RESEARCH THIS BIZAARE INCIDENT, I DISCOVERED THEIR RECALL WHICH I NEVER RECEIVED. I HAVE OWNED THE VEHICLE SINCE 2001. I HAVE NOT HAD ANY PRIOR PROBLEMS WITH THE VEHICLE, WHICH IS WHY I FOUND THIS SO BIZAARE TO WAKE UP AT 5 AM TO MY WIFE YELLING "YOUR TRUCK IS ON FIRE!". LUCKILY, I HAVE NEVER BEEN MOTIVATED TO CLEAN OUR GARAGE SO WE COULD PARK INSIDE. HOWEVER, OUR HOME DID SUFFER DAMAGE TO THE SIDING. FORD IS NOT BEING AGGRESSIVE IN ENSURING THIS IS BEING HANDLED. *JB
Structure, Jul 26, 2006
1995-2000 FORD PICKUP EXTENDED CAB THE DOORS CRACK ON THE OUT SIDE THAT I CAN SEE DON'T KNOW IF THERE DAMAGED INTERNALLY AND I DON'T KNOW THE CONSEQUENCES IF IT CONTINUES TO CRACK. CONTACTED FORD MOTOR COMPANY THEY SAID THEY KNEW NOTHING ABOUT IT WENT TO VARIOUS CAR LOTS AROUND INDIANAPOLIS IN. AND CHECKED OTHERS EVERYONE WAS CRACKED FORD ALSO SAID THERE IS A FIX FOR THIS PROBLEM AT OUR EXPENSE. *NM
Electrical system, Jul 25, 2006, fire
TRUCK CAUGHT ON FIRE PARKED AND SHUT OFF IN DRIVE WAY OF HOME. LOOKS TO BE ELECTRICAL FIRE. *JB
Vehicle speed control, Jul 25, 2006, fire
ON JULY 15, 2006 MY FORD F-150 TRUCK CAUGHT FIRE AND BURNED TO THE GROUND. THE VEHICLE HAD BEEN PARKED IN THE SAME PLACE FOR OVER 24 HOURS WITHOUT BEING STARTED OR DISTURBED. AT APPROXIMATELY 5:30 SATURDAY EVENING THE VEHICLE CAUGHT FIRE. THE FIRE CHIEF STATED THAT THE POINT OF ORIGIN WAS IN THE AREA OF THE SPEED CONTROL SWITCH. I CHECKED FORD'S WEBSITE AND ENTERED MY VIN NUMBER. THE TRUCK DID HAVE A RECALL BUT I NEVER RECEIVED A RECALL NOTICE. I HAVE CONTACTED FORD BUT HAVE RECEIVED NO RESPONSE FROM THEM. *NM
Engine and engine cooling, Jul 24, 2006
I OWN A 2000 FORD F150 5.4 LITER, IT HAS BLOW 2 SPARK PLUGS, ONE AT 90,000 MILES AND NOW A 140,000 MILES IT WILL COST $3000 FOR A NEW HEAD I CAN'T AFFORD IT SO NOW I WILL MAKE A $500 MONTHLY PAYMENT TO A TRUCK LOAN THAT DOESN'T RUN. *NM
Electrical system, Other or unspecified, Jul 13, 2006
THE VEHICLE STARTED HOWEVER, I WAS UNABLE TO SHIFT IT INTO GEAR. AFTER THREE CALLS TO A FORD DEALERSHIP, I WAS ADVISED TO SHIFT IT INTO NEUTRAL, START IT THEN SHIFT IT INTO DRIVE. I WAS ABLE TO DRIVE IT HOME HOWEVER, THE POWER WINDOWS & WINDSHIELD WIPERS WERE NOT WORKING. I HEARD "CLICKING" NOISES COMING FROM THE FUSE BOX. AFTER PLACING IT INTO DRIVE, THE RADIO WOULD NOT WORK. WHEN I PLACED IT IN PARK, THE RADIO STARTED WORKING. WHEN USING THE PANEL/FLOOR DEFROST, I HEARD AN ELECTRICAL SHORTING NOISE COMING FROM UNDER THE HOOD. ON 1/23/05, IT WOULD NOT START; ONLY THE LIGHTS ON THE DASHBOARD CAME ON; I WAS UNABLE TO SHIFT IT INTO NEUTRAL; THE ENGINE DID NOT TURN OVER. THE VEHICLE WAS TOWED TO KRIEGER FORD. INITIALLY, I WAS TOLD THAT IT NEEDED A NEW STARTER. AFTER FURTHER TESTING, I WAS ADVISED THAT THE FUSE BOX AND GEM WERE WATER-LOGGED DUE TO WATER LEAKING INTO THEM AS THE RESULT OF A FAULTY SEAL IN THE WINDSHIELD WHICH IS THE ORIGINAL FACTORY INSTALLED WINDSHIELD. I FOUND AN ARTICLE IRONICALLY TITLED "QUALITY IS THE PRIME IMPERATIVE WITH FORD". THE 1ST PARAGRAPH STATES "INSTALLING WINDSHIELDS IN VEHICLES HAS ALWAYS BEEN A PAIN. FIXING WATER LEAKS IS THE LAST THING YOU WANT TO DO IN A VEHICLE ASSEMBLY PLANT". THE 2ND PARAGRAPH STATES "...HAS BROUGHT THE NUMBER OF WINDSHIELD LEAKS SIGNIFICANTLY UNDER 1 PER 20 HOURS OF PRODUCTION..." THE 3RD PARAGRAPH REFERENCES THE WORD "DEFECTS". I WROTE A LENGTHY LETTER DATED 2/5/05 TO THE CEO OF FORD WITH ATTACHMENTS OF THE ARTICLE, ONLINE COMPLAINTS STATING THE SAME PROBLEMS & QUESTIONED THE SEPTEMBER 2004 TIE ROD INSPECTION PROCEDURE MAILED TO ME FROM FORD WITH REGARD TO PREMATURE WEARING AND SEPARATION. I HAD ALSO SPOKEN TO INDIVIDUALS IN FORD'S CUSTOMER SERVICE CENTER ON SEVERAL OCCASIONS. I PAID KRIEGER FORD OVER $1,000 TO REPLACE THE STARTER (THEIR "QUICK" FIX), REPLACE THE GEM & FUSE BOX & REMOVE & RE-SEAL THE WINDSHIELD. FORD RESPONDED TO MY LETTER BY PLACING ME ON THEIR PROMOTIONAL MAILING LIST. DOCUMENTATION AVAILABLE. *JB
Engine and engine cooling, Jul 5, 2006
BLOWN SPARK PLUG ON MY 2000 FORD F-150 5.4 TRITON. KNOWN TO ONLY HAVE HALF THE REQUIRED THREADS IN THE CYLINDER HEAD FOR THE SPARK PLUG, HAVE HAD NEITHER COMPENSATION OR A RECALL. THIS IS VERY DANGEROUS AS IT HAPPENED TO ME TOWING A BOAT GOING ON TO THE INTERSTATE. DESTROYED THE PLUG, THE COIL PACK (COP STYLE) AND THE INTAKE ELBOW OF MY AFTER MARKET INTAKE SYSTEM. OVER $600 IN DAMAGES. *JB
Air bags, Jun 27, 2006, crash
I REAR ENDED ANOTHER VEHICLE THAT WAS COMPLETELY STOPPED. I WAS GOING ABOUT 35 TO 40 MPH. THERE IS $8500 DAMAGE TO MY F150 TRUCK. THE DAMAGE IS ALL IN THE FRONT END. MY AIR BAG DID NOT COME OUT. NO ONE CAN TELL ME WHY. HAD THE AIR BAG CAME OUT THAT WOULD HAVE BEEN ENOUGH DAMAGE TO TOTAL THE TRUCK. NOW I WILL BE DRIVING AROUND IN A TRUCK THAT I DON'T KNOW IF THE AIR BAG WILL WORK OR NOT. *JB
Engine and engine cooling, Jun 25, 2006
FORD TRITON 5.4L V-8 HEADS. ALUMINUM HEADS ARE SO POORLY ENGINEERED THAT THEY WILL NOT RETAIN THE SPARK PLUGS UNDER NORMAL LOADS. OVER $5,000 IN REPAIR COSTS, FORD REFUSES TO ACKNOWLEDGE ANY PROBLEM. *NM
Vehicle speed control, Jun 21, 2006, fire
2000 FORD F-150. *NM
Electrical system, Jun 21, 2006
ODOMETER LIGHT KEEPS FADING ON/OFF AND AT TIMES WILL NOT TURN ON WHEN YOU START THE ENGINE OR GO OFF WHILE DRIVING. THIS HAS BEEN AN ON-GOING PROBLEM SINCE WE PURCHASED THE VEHICLE IN 09/2000. THE DEALERSHIP LOOKED INTO IT AND FOUND IT WAS INCONCLUSIVE. *NM
Steering, Jun 20, 2006
WHILE PULLING ONTO THE FREEWAY THIS MORNING IN RUSH HOUR TRAFFIC, THE LEFT TIE ROD ON MY 2000 F150 CAME APART, MAKING IT IMPOSSIBLE TO STEER THE VEHICLE. I WAS AFRAID FOR MY LIFE. THE VEHICLE HAD JUST 78,670 MILES ON IT AND IS USED MAINLY BY ME TO DRIVE TO WORK. ON AUG. 16, 2004, WITH JUST 55,849 MILES, I HAD TO HAVE THE RIGHT AND LEFT LOWER BALL JOINTS REPLACED, WHICH THE MECHANIC WARNED ME WERE ON THE VERGE OF TOTAL FAILURE. *NM
Electrical system, Jun 19, 2006, fire
DT*: THE CONTACT STATED ON SATURDAY JUNE 17TH SMOKE WAS NOTICED COMING FROM THE HOOD AREA AND FLAMES WERE PRESENT. THE FIRE OCCURRED IN THE ELECTRICAL HOUSING UNIT FOR THE MASTER CYLINDER WHICH HOLDS THE BRAKE FLUID. THE UNIT AND BRAKE FLUID CONTAINER MELTED. THE CONTACT DISCONNECTED THE BATTERY IMMEDIATELY AFTER THE FIRE WAS NOTICED. THIS WAS AN ELECTRICAL FIRE. THE VEHICLE WAS SITTING AT THE CONTACT'S RESIDENCE FOR ABOUT 45 MINUTES PRIOR TO THE FIRE. THE VEHICLE WAS NOT DRIVING UNUSUAL. THE VEHICLE WAS TOWED TO THE LOCAL DEALERSHIP TO PERFORM AN INVESTIGATION TO DETERMINE THE CAUSE OF THE FAILURE. *AK
Tires, Jun 17, 2006
1) DURING NORMAL DRY WEATHER DRIVING CONDITIONS, RIGHT REAR TIRE EXPERIENCED A CATASTROPHIC FAILURE. THE ENTIRE TREAD BELT SEPARATED FROM THE SIDEWALL. SPEED WAS APPROXIMATELY 60 MPH. 2) THERE WERE NO PERSONAL INJURIES OR PROPERTY DAMAGES AS A RESULT. 3) CONTACTED CORPORATE OFFICES OF COOPER TIRE. I WAS TOLD THE TIRE WAS DAMAGED BEFORE IT EXPERIENCED THE FAILURE. I HAVE HAD THE TIRES FOR APPROXIMATELY THREE YEARS AND WHILE THERE WAS A MINIMUM OF TREAD LIFE REMAINING, THERE WAS TREAD LIFE REMAINING (APPROXIMATELY 6 MON.). WHEN I TOOK THE TIRE TO THE COOPER TIRE DEALER, I WAS TOLD THE FAILURE WAS NOT NORMAL. I HAVE PICTURES OF THE FAILED TIRE. I HAD TO PAY FOR THE REPLACEMENT TIRE. THE COOPER TIRE CORPORATE REPRESENTATIVE PRESENTED HERSELF AND HER COMPANY AS NOT AT FAULT IN THIS CASE. I AM NOT CONCERNED ABOUT HAVING TO PAY FOR THE REPLACEMENT TIRE, I SIMPLY WANTED THIS ON RECORD IN CASE OTHERS EXPERIENCE SIMILAR INCIDENTS. *NM