2000 Ford F-150
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,204 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 F-150 model years with reports.
Of the 2000 reports, 92 involved a crash and 361 involved a fire. 79 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Vehicle speed control, cruise controlJan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Campaign 05V017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Equipment, other, labelsSep 21, 2000
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V284000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Representative owner complaints
1,204 reports, newest first.
Vehicle speed control, Jun 3, 2006, fire
AT AROUND 4:45 ON FRIDAY AFTERNOON MY HUSBAND WAS IN THE BACK YARD AND NOTICED SMOKE COMING FROM THE END OF OUR HOUSE. WHEN HE WALKED AROUND THE CORNER OF THE HOUSE TO SEE WHAT WAS SMOKING HE SAW FIRE COMING FROM THE HOOD OF OUR 2000 FORD F-150 XL TRUCK. THE TRUCK WAS NEAR THE HOUSE SO HE GOT OUR DAUGHTER OUT OF THE HOUSE AND CALLED 911. THE FIRE DEPARTMENT RESPONDED IN AROUND 10 MINUTES. WHEN THE FIRE DEPARTMENT ARRIVED THE TRUCK ENGINE AND CAB WERE COMPLETELY ENGULFED IN FLAMES. WHEN THE FIRE WAS EXTINGUISHED, THE ENTIRE FRONT OF THE TRUCK WAS DESTROYED INCLUDING THE FRONT GRILL, ENGINE, FRONT TIRES, CAB AND INTERIOR. THE BACK BED OF THE TRUCK AND THE BACK TIRES DID NOT APPEAR DAMAGED. MY HUSBAND HAD PICKED MY DAUGHTER UP FROM SCHOOL AND ARRIVED HOME AT AROUND 3:15. HE NOTICED THE FIRE AT AROUND 4:45. UP UNTIL THE FIRE, MY HUSBAND HAD NOT HAD ANY PROBLEM WITH THE TRUCK. AT THIS POINT I AM RESEARCHING TO SEE IF THE FIRE MAY BE RELATED TO NHTSA RECALL CAMPAIGN NUMBER 05V017000 NOTED ON YOUR WEB-SITE. I AM ALSO TRYING TO FIND OUT HOW TO GO ABOUT REPORTING IT TO FORD MOTOR COMPANY. *NM
Electrical system, Jun 1, 2006, fire
DT*: THE CONTACT STATED THE VEHICLE ERUPTED INTO FLAMES AFTER BEING PARKED FOR AN HOUR. THERE WERE NO PROBLEMS WITH THE VEHICLE PRIOR TO THE INCIDENT. THE VEHICLE WAS TOTALED. THE SERVICE DEALER REMOVED THE CRUISE CONTROL ONE YEAR AGO BECAUSE OF THE POTENTIAL OF FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND DETERMINED THE FIRE STARTED IN THE FRONT ENGINE COMPARTMENT UNDER THE HOOD. THE FIRE DEPARTMENT ALSO DETERMINED ALL OF THE WIRE HARNESSES WERE INTACT.
Steering, May 23, 2006
(1) DUE TO THE PARTICULAR DESIGN FLAW OF THE " TIE END RODS" (THE TIE ENDS DO NOT HAVE A GREASE NIPPLE TO ALLOW CRITICAL LUBRICATION OF THESE PARTS!), THE PASSENGER SIDE "UPPER TIE END ROD" COMPLETELY SEPARATED FROM ITS NORMAL POSITION WHILE THE VEHICLE WAS IN MOTION. (2) THE VEHICLE OPERATOR WAS UNABLE TO STEER THE VEHICLE TO A SAFE CLEARANCE AND WAS FORCED TO IMMEDIATELY STOP ON A TWO LANE BRIDGE AND BLOCK ONE OF THE LANES. (3) ALL OF THE "TIE ENDS RODS" WERE REPLACED WITH NEW PARTS THAT HAVE A NIPPLE FOR LUBRICATION SO THAT THE "WEAR" ITEM CAN BE MAINTAINED BY APPLYING GREASE. THE OLD PART IS AVAILABLE. *NM
Fuel system, Diesel, May 22, 2006
MY 2000 F-150 FORD PICKUP. I WENT OUT IN MY DRIVEWAY AND NOTICED SOMETHING HANGING DOWN FROM UNDER THE TRUCK. IT TURNED OUT TO BE THE REAR STRAP THAT HOLDS THE GAS TANK ON THE TRUCK. IT HAS RUSTED AND CAME APART. THE GAS TANK HAD DROPPED DOWN ABOUT 3 INCHES AND HAS ALL THE HOSES PULLED TIGHT. FORD SAYS THERE ARE NO RECALL ON MY TRUCK. *JB
Power train, May 2, 2006
TRANSMISSION WENT OUT. VEHICLE IS ONLY DRIVEN ABOUT 200 MILES A WEEK, AND SITS FROM MONDAY TO FRIDAY WITHOUT BEING DRIVEN AT ALL. IT JUST WENT OUT WHILE DRIVING DOWN THE ROAD. HAS NOT BEEN FIXED YET. WAS NOT GOING FAST AT THE TIME BECAUSE WE HAD JUST STOPPED AT A LIGHT AND WHEN WE STARTED DRIVING IT HAD NO POWER. *NM
Engine and engine cooling, Apr 28, 2006, crash
WAS DRIVING ON FREEWAY FORD F150 PICKUP ENGINE BLOW OUT THE #1 SPARK PLUG, SECOND 6 MTHS AGO SAME ENGINE BLOW OUT THE #4 REAR SPARK PLUG NEAR PASSENGER, NOW HAVE TO REPLACE ENGINE VERY COSTLY. *NM
Visibility, Apr 8, 2006
I OWN A 2000 FORD F-150 AND YESTERDAY THE HEATER CORE STARTING LEAKING. THIS TRUCK HAS BEEN SERVICED ACCORDING TO THE MANUAL. I ONLY HAVE 64000 MILES ON IT. I HAVE CONTACTED SEVERAL REPAIR SHOPS AND WAS TOLD THAT FORD HAS HAD PROBLEMS WITH THE CORE FAILING AND THAT THEY HAD A RECALL ON IT. I CONTACTED SEVERAL FORD DEALERSHIPS IN MY AREA AND WAS TOLD THERE WAS NO RECALLS ON THIS PROBLEM. I HAVE HAD ESTIMATES OF FROM $600.00 TO $800.00 TO FIX THE PROBLEM. I AM GOING TO GET IT FIXED BUT I WOULD LIKE TO KNOW IF THERE WAS A RECALL ON THIS PROBLEM ?????? THIS PART SHOULD NOT HAVE FAILED THIS SOON. *NM
Latches/locks/linkages, Apr 6, 2006
DT*: THE CONTACT STATED THE DOOR LOCKS FAILED TO OPERATE NORMALLY USING THE KEY FOB. THE LOCKS MUST BE MANUALLY OPENED OR CLOSED. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO DETERMINED THE ACTUATOR NEEDED TO BE REPLACED. THE CONTACT MADE SEVERAL ATTEMPTS TO PURCHASE A USED ACTUATOR FROM LOCAL JUNK YARDS WITHOUT SUCCESS.
Vehicle speed control, Apr 5, 2006, fire
DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, IT ERUPTED INTO FLAMES. THE FIRE DEPARTMENT CAME AND EXTINGUISHED THE FIRE. THE MANUFACTURER SENT A REPRESENTATIVE TO INSPECT THE REMAINS OF THE VEHICLE. THE FIRE WAS TOO EXTENT TO DETERMINE THE EXACT CAUSE. THE CONTACT RECEIVED A RECALL LETTER SEVERAL WEEKS AFTER THE INCIDENT; NHTSA RECALL # 05V388000 CONCERNING THE CRUISE CONTROL.
Vehicle speed control, Mar 30, 2006, fire
A VEHICLE FIRE OCCURRED ON A 2000 FORD F150 AT THE HOME OF THE OWNER ON MARCH 8, 2006. THE FIRE STARTED IN THE ENGINE COMPARTMENT OF THE TRUCK WHILE IT WAS PARKED UNDER THE CARPORT, WITH THE ENGINE OFF, AND THE IGNITION KEY REMOVED. THE TRUCK HAD BEEN PARKED APPROXIMATELY 2 1/2 HOURS WHEN THE FIRE OCCURRED. WHEN THE FIRE WAS DETECTED, FLAMES HAD ALMOST REACHED THE CEILING OF THE CARPORT. THE OWNER WAS ABLE TO PUSH THE TRUCK INTO THE STREET, WHERE IT CONTINUED TO BURN UNTIL EXTINGUISHED BY THE FIRE DEPARTMENT. THE TRUCK WAS DESTROYED IN THE FIRE. ON MARCH 20, 2006, AND INDEPENDENT INVESTIGATOR INSPECTED THE VEHICLE AND DETERMINED THAT THE FIRE WAS CAUSED BY FAILURE OF THE SPEED CONTROL DEACTIVATION SWITCH. THE INVESTIGATOR DOCUMENTED HIS INVESTIGATION WITH PHOTOGRAPHS. FORD MOTOR COMPANY (FMC) STATED THAT THE VEHICLE WAS INCLUDED IN A RECALL TO CORRECT A PROBLEM WITH SPONTANEOUS FIRES ERUPTING IN THE SPEED CONTROL DEACTIVATION SWITCH, BUT THE OWNER WAS NEVER NOTIFIED OF A RECALL. THE OWNER HAS CONTACTED AND PROVIDED INFORMATION AND PHOTOGRAPHS TO THE FMC SPEED CONTROL DEACTIVATION SWITCH RECALL CUSTOMER INFORMATION TEAM, FMC CONSUMER AFFAIRS, AND THE LOCAL FMC DEALERSHIP. *NM
Vehicle speed control, Mar 24, 2006, fire
DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED, IT ERUPTED INTO FLAMES ON THE LEFT DRIVER'S SIDE UNDERHOOD AREA. THE FIRE DEPARTMENT WAS CONTACTED AND EXTINGUISHED THE FLAMES. A MANUFACTURER REPRESENTATIVE INSPECTED THE VEHICLE AND TOOK PICTURES OF THE SEVERE FIRE DAMAGE. AFTERWARDS, THE REPRESENTATIVE SUGGESTED THAT DUE TO THE EXTENSIVE FIRE DAMAGE, IT COULD NOT BE DETERMINED IF THE FIRE WAS CRUISE CONTROL RELATED. THE VEHICLE WAS INCLUDED IN THE NHTSA RECALL # 05V388000 CONCERNING THE CRUISE CONTROL, BUT NO RECALL NOTIFICATION WAS RECEIVED BY THE CONTACT.
Engine and engine cooling, Mar 19, 2006
2 ENGINE FAILURES. *JB
Exterior lighting, Mar 16, 2006
2000 FORD EXCURSION LIGHT SWITCH TO HEADLIGHT BROKE. *NM
Electrical system, Vehicle speed control, Feb 23, 2006, fire
SHORTLY AFTER MY RECALL THE SWITCH SHORTED OUT, I TOOK MY VEHICLE TO VELDE FORD IN VERO BEACH FLORIDA, THEY CLAIM THEY REPLACED THE PARTS REQUIRED FOR THE RECALL AND MY CRUISE CONTROL STILL WASN'T BACK TO BEING OPERATIONAL (WHICH IT WAS PRIOR TO THE FIRE) AND CHARGED ME 246.78 PLUS TAX TO DO THE REPAIR. THEY CLAIM IT WAS UNRELATED. *JB
Steering, Feb 16, 2006
DT*: THE CONTACT STATED WHILE DRIVING 45 MPH, THE DRIVER SIDE TIRE STARTED BOUNCING. THE VEHICLE WAS PULLED OVER AND TOWED TO THE CONTACT'S RESIDENCE WERE IT WAS REPAIRED BY A FAMILY MEMBER. THE INNER TIE ROD WAS REPLACED ON THE DRIVER SIDE. ALSO, WHILE PULLING INTO A PARKING SPACE AT LESS THAN 5 MPH, THE PASSENGER SIDE TIRE DID NOT RESPOND TO THE STEERING WHEEL. THE VEHICLE WAS AGAIN TOWED TO THE RESIDENCE AND THE PASSENGER SIDE INNER TIE ROD WAS REPLACED. THE MANUFACTURER HAS BEEN ALERTED.
Engine and engine cooling, Jan 14, 2006
"FRONT ENGINE COVER GASKET FAILED IN LINE WITH RECALL 99B29. FORD DOES NOT INCLUDE MY TRUCK, BUILT 05/99 IN RECALL CAMPAIGN 99B29 INDICATING THE ORIGINAL RECALL HAS BEEN INADEQUATE." *JB
Engine and engine cooling, Jan 14, 2006
I BOUGHT A 2000 FORD F-150 WITH THE 4.2L V6 ENGINE AND I NOW HAVE TO REPLACE THE ENGINE BECAUSE OF A DEFECT THAT FORD IS AWARE OF I HAVE DONE A LOT OF RESEARCH ON THIS ISSUE AND HAVE FOUND THOUSANDS OF OTHER 4.2L V6 OWNERS THAT HAVE THE SAME PROBLEM AND FORD WILL NOT DO ANYTHING ABOUT IT I HAVE ASKED FORD FOR HELP IN THE REPLACEMENT OF THE ENGINE. I WAS GIVEN EXCUSES AND TOLD TO GO AWAY AND BUY A NEW ENGINE. I TRIED TO MAKE A FORMAL COMPLAINT TO FORD BUT I WAS TOLD THAT IT WOULD BE BROUGHT TO THEIR ATTENTION WITH NO PAPERWORK FILLED OUT. I AM VERY UPSET WITH THE WAY A LOYAL CUSTOMER OF FORD IS BEING TREATED. I NOW HAVE TO REPLACE THE ENGINE BUT CANNOT AFFORD TO. THERE IS A DEFECTIVE SEAL OR GASKET THAT LEAKS ANTIFREEZE INTO THE ENGINE AND CAUSES PISTONS TO BREAK ROD TO BE PUSHED OUT OF THE ENGINE AND SEVERAL OTHER INTERIOR ENGINE PARTS TO BREAK. FORD MOTOR COMPANY WILL NOT REPLACE THE ENGINE EVEN THOUGH IT IS A DEFECT ON THEIR BEHALF NOT THE BUYER. FORD DOES NOT TELL NEW CUSTOMERS ABOUT THE PROBLEM AND CONTINUE TO SELL THE VEHICLES KNOWING THAT THE ENGINE IS DEFECTIVE. ALL I WOULD LIKE IS FOR FORD TO TAKE RESPONSIBILITY FOR THEIR ENGINE AND REPLACE IT WITH A DIFFERENT ENGINE OR MAKE SURE THAT THE NEW ENGINE WILL NOT CAUSE THE SAME PROBLEM. *JB
Engine and engine cooling, Jan 6, 2006
(1) NOTHING REMARKABLE HAPPENED LEADING UP TO THE FAILURE. THE TRUCK WAS IDLING WHEN THE FAILURE OCCURRED. (2) THE FAILURE WAS THE #3 SPARK PLUG BLOWING OUT OF THE HEAD WHICH ALSO DAMAGED THE COIL IN MY 2000 FORD EXPEDITION 5.4L ENGINE, WHICH HAD 82000 MILES. (3) THE HEAD WAS REPAIRED WITH AN AFTERMARKET KIT THAT ALLOWED A NEW SPARK PLUG TO BE INSTALLED. OLD SPARK PLUG HAS BEEN DISCARDED. *JB
Engine and engine cooling, Jan 4, 2006
THE SPARK PLUG BLEW OUT OF THE HEAD, REPAIR WAS VERY COSTLY. THIS SHOULD NOT HAPPEN. I ALSO HAVE HAD 3 COIL PACKS GO BAD ON THIS VEHICLE. *JB
Engine and engine cooling, Power train, Dec 31, 2005
WELL I GOT SUCKERED OCT 4 2003 INTO A 2000 F-150 W/52,000 MILES . MY LOVELY TRUCK WAS DOING GREAT UNTIL SEPT 2004 AND THEN MY TRANNY WENT OUT. JUST BLEW OUT. WELL $1400 DOLLARS AND A LOT OF (I MEAN A LOT) OF MONEY AND TIME LATER (NOV 2004) I GOT IT FIXED (HAPPY TIMES RIGHT?). DAD, ME SOME BUDDIES PUT THE TRANNY IN. SO I AM DOING GREAT AND THEN I STARTED TO SMELL ANTI FREEZE AND WELL SOME TIME LATER IN AUG 2005 IT STARTED A STEEM SHOP OUT THE EXHAUST. WATER, ANTI FREEZE AND OIL THAT IS WHAT IS WAS. LOOKED LIKE HEAD GASKET OR HEAD MIGHT BE CRAKED SO GOT NEW GASKET SET AND GOT HEADS TESTED AND RESHAPED AND NEW HEAD BOLTS.($400 LATER) WELL I FINALY GOT TO GETTING IT BACK TOGETHER AND IT IS STILL SMOKING (TODAY IN DEC 2005). SO SOMETHING BAD IS WRONG MAYBE BLOCK IS CRAKED. I DONT KNOW BUT I AM VERY MAD I OWE $12,000 ON IT.
Engine and engine cooling, Dec 23, 2005
THE PASSENGER SIDE REAR SPARK PLUG BLEW OUT OF THE ENGINE HEAD. THIS TRUCK HAS 54,000 MILES ON IT AND IS VERY WELL MAINTAINED. REPAIR ESTIMATES ARE IN EXCESS OF $3,000.00. THIS HAPPENED IN A WELL TRAVELED AREA AND IT WAS ME AND NOT MY WIFE AND KIDS STRANDED. THERE IS AN OBVIOUS FLAW IN THE HEAD DESIGN THAT FORD HAS SINCE RECTIFIED. IT IS OUTRAGEOUS THAT A $30,000 TRUCK THAT IS WELL MAINTAINED SHOULD HAVE THIS KIND OF FAILURE 18,000 MILES OUT OF FACTORY WARRANTY. *NM
Engine and engine cooling, Dec 19, 2005
I OWN A 2000 FORD F-150. ONE OF THE SPARK PLUGS BLEW OUT OF IT'S HOLE CAUSING PROBLEMS WITH THE ENGINE. *JB
Engine and engine cooling, Electrical system, Dec 15, 2005
THERE ARE NO EVENTS THAT INDICATE ANYTHING IS WRONG UNTIL THE ENGINE HAS NO POWER AND RUNS ROUGH. A COIL PACK FAILURE ON # 8 CYLINDER ON 11/14/05. A COIL PACK FAILURE ON # 6 CYLINDER ON 12/05/05. A COIL PACK FAILURE ON # 1 CYLINDER ON 12/15/05. ALL INCIDENTS SHOW A MISFIRE ON A PARTICULAR CYLINDER. CORRECTION TO THE PROBLEM IS TO HAVE A COIL PACK INSTALLED ALONG WITH A SPARK PLUG. DEALER SUGGESTS REPLACEMENT OF ALL COIL PACKS. *JB
Engine and engine cooling, Dec 12, 2005
I HAVE A 2000 F-150 THAT I HAVE HAD SINCE 2000. I KEPT MY TRUCKS OIL CHANGED ON A REGULAR BASIS. ON A NOVEMBER SATURDAY AS MY FAMILY AND I WAS GOING TO VISIT SOME RELATIVES ABOUT 30 MILES AWAY FROM MY HOME. MY TRUCK SHUT DOWN WITHOUT ANY APPARENT REASON. I HAD IT TOWED TO THE NEAREST FORD DEALERSHIP TO BE CHECKED. THE TECHNICIAN SAID THAT THE TIMING HAD JUMPED AND THE OIL PRESSURE DROPPED. THE TECHNICIAN TOOK THE VALVE COVERS OFF TO SEE WHAT THE PROBLEM WAS. TO HIS SURPRISE IT WAS STILL FILLED WITH OIL AND AFTER DOING A MORE IN-DEPTH STUDY OF THE ENGINE, SLUDGE WAS IN THE OIL PAN AND EVERYWHERE ELSE. I ASKED THE FORD TECHNICIAN AS TO HOW COULD THIS HAVE HAPPENED AND WITH A REPLY OF I DON'T KNOW. AS A RESULT MY MOTOR IS NO GOOD. *NM
Visibility, Structure, Dec 7, 2005
BATTERY KEPT DRAINING AND THE IGNITION CHIMED WITH KEY REMOVED. HEATER BLOWER RAN AFTER IGNITION WAS TURNED OFF AND TOUCH KEY PADS STUCK CAUSING LIGHTS TO STAY ON. ALL OF THESE SYMPTOMS WERE ATTRIBUTED TO A WATER LEAK IN THE WINDSHIELD WHICH LEAKED INTO A ELECTRICAL CONNECTION BLOCK BEHIND DRIVER'S SIDE DASHBOARD CAUSING A SHORT CIRCUIT. THE ELECTRICAL BLOCK MELTED AND CAUSED DAMAGE TO BLOCK AND WIRING AND WAS SUBSEQUENTLY REPLACED. WINDSHIELD WAS REMOVED AND RESEALED TO PREVENT RECURRENCE OF LEAK. *JB