2002 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 955 owner complaints filed for this model year. This is the 5th highest complaint count among 26 F-150 model years with reports.
Of the 2002 reports, 58 involved a crash and 100 involved a fire. 67 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Representative owner complaints
955 reports, newest first.
Fuel system, Gasoline, Dec 27, 2010
TL*THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING APPROXIMATELY 50 MPH, THE FUEL TANK FELL OFF OF THE VEHICLE AND STARTED SPARKING. THE MANUFACTURER WAS CONTACTED WHO STATED THE FAILURE COULD HAVE BEEN THE BANDS THAT HOLD THE GAS TANK WERE RUSTED AND THE PROBLEM HAD BEEN REPORTED BEFORE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 143,000.
Electrical system, Dec 25, 2010
I HAVE A 2002 FORD F150 WITH THE 4.6L V8. THE TRUCK HAS 109,000 MILES. NUMBER 4 PLUG EJECTED ON NOVEMBER 11TH WITHOUT ANY SERIOUS DAMAGE. I REPLACED THE PLUG AND COIL. I WAS DRIVING HOME ON DECEMBER 23RD THIS TIME THE PLUG EJECTED AND HIT THE UNDER SIDE OF THE HOOD AND SOUNDED LIKE A BOMB WENT OFF. I DID SOME RESEARCH ON THE INTERNET AND FOUND THIS IS A WIDE SPREAD SERIOUS PROBLEM WITH THE FORD TRITON ENGINES. I ALSO DISCOVERED THAT FORD WILL NOT COVER THE COST OF THE REPAIR. IF I HAVE THE DEALER REPAIR THE PROBLEM THEY WILL ONLY REPAIR THE ONE PLUG. SO I WILL PURCHASE A REPAIR KIT AND REPAIR ALL THE PLUGS MYSELF. THIS SEEMS TO BE A DESIGN PROBLEM THAT SHOULD BE COVERED BY FORD. *TR
Engine and engine cooling, Nov 23, 2010
MY 2002 FORD F150 WITH A 5.4 L TRITON V8 ENGINE SPIT OUT A SPARK PLUG FOR NO APPARENT REASON. MY F150 HAS 117,000 MILES ON IT AND HAS HAD NO MECHANICAL PROBLEMS OVER IT'S LIFE. IT IS SERVICED REGULARLY AND IS USED FOR ROUTINE DRIVING. I HAPPENED TO BE 30 MILES FROM HOME WHEN I HEARD A LOUD TAPPING COMING FROM THE ENGINE COMPARTMENT. KNOWING A LITTLE ABOUT ENGINES I CHECKED TO SEE WHAT HAD HAPPENED AND NOTICED THAT THE SPARK PLUG HAD BEEN PUSHED OUT OF THE CYLINDER HEAD, CAUSING THE COMPRESSION TO CAUSE IT AND THE COIL PACK TO CONTINUALLY STRIKE THE FUEL RAIL. FORTUNATELY I KNEW A MECHANIC IN THE AREA 1/4 MILE FROM MY LOCATION AND SLOWLY DROVE TO HIS SHOP. HE SAID THAT IT WAS A COMMON PROBLEM WITH FORD 4.6, 5.4 AND 6.8 TRITON ENGINES. HE ADDED THAT THE ALUMINUM USED FOR THE HEADS WAS TOO SOFT CAUSING THE SPARK PLUGS TO SPIT OUT. THERE WAS NO WAY OF PREVENTING THIS FROM HAPPENING OR PREDICTING WHEN IT WOULD HAPPEN. THE HOLE FOR THIS SPARK PLUG HAD ALL THE TREADS BLOWN OUT WHEN THE PLUG CAME OUT SO I HAD TO LEAVE MY TRUCK AT THE GARAGE FOR REPAIR. THE REPAIR CONSISTED OF HAVING TO PUT A STEEL THREADED INSERT INTO THE HEAD IN ORDER TO SECURE THE NEW SPARK PLUG / COIL PACK. THE MECHANIC STATED THAT I SHOULD DEFINITELY NOT DRIVE IT SINCE IT COULD CAUSE A FIRE. I COULD SMELL THE GAS FUMES FROM THE ENGINE COMPARTMENT AND FULLY BELIEVE THIS TO BE A GOOD POSSIBILITY. I CAN ONLY IMAGINE IF SOMEONE WAS UNFAMILIAR WITH ENGINES AND CONTINUED TO DRIVE WITH THIS CONDITION WITH THE POSSIBLE RESULT OF A FIRE IN THE VEHICLE WHILE THEIR FAMILY IS ABOARD. I THINK FORD NEEDS TO DO A RECALL ON THESE ENGINES TO HAVE THEM REPAIRED IN A SAFE FASHION TO PREVENT A TRAGEDY OF A FIRE WHILE IN OPERATION. UPON A GOOGLE SEARCH OF THIS TOPIC IT LOOKS AS THOUGH THERE ARE A MULTITUDE OF THE SAME TYPE OF INCIDENTS WITH THESE ENGINES. THANK YOU FOR YOUR CONSIDERATION. *TR
Electrical system, Nov 11, 2010, fire
I GOT INTO MY 2002 FORD F150 ONE MORNING, CRANKED IT AND WENT TO PUT IT IN DRIVE AND IT WOULD NOT.ALSO MY INTERIOR LIGHTS WOULD NOT WORK. AFTER DOING RESEARCH I FOUND OUT IT COULD POSSIBLY BE A FUSE. I CHANGED THE FUSE AND IT WORKED., ABOUT A MONTH LATER IT DID IT AGAIN SO I CHANGED THE FUSE AGAIN, THAT ALSO WORKED AGAIN. IN THE MEAN TIME I ALSO HAD PROBLEMS WITH MY BRAKES, WHICH I HAD JUST CHANGED. AFTER ABOUT A MONTH WITH NO PROBLEMS WITH MY FUSES, I TOOK MY TRUCK OUT OF TOWN FOR FOUR DAYS. WHEN I GOT BACK I HAD TO GO STRAIGHT TO WORK, APPROXIMATELY 3:00 PM. AT THE FIRE STATION I WORK AT. AT 11:45PM DISPATCH WOKE ME UP OUT OF THE BUNKROOM TO INFORM ME MY TRUCK WAS ON FIRE. *TR
Engine and engine cooling, Nov 8, 2010
IN APRIL OF 2010 MY F-150 TRUCK "SPIT" A SPARK PLUG WHILE TRAVELING AT FREEWAY SPEED. THIS WAS A DANGEROUS SITUATION SINCE IT WAS DURING RUSH HOUR AND MANY 18 WHEEL TRUCKS WERE TRAVELING DOWN THE I-5 AT THE TIME AND WERE RELUCTANT TO ALLOW A CAR TO PULL OVER. I HAD THE TRUCK FIXED AT A AAA APPROVED REPAIR STATION WHICH REMOVED THE REMAINING SPARK PLUG, RETAPPED THE BLOCK, INSTALLED AN INSERT AND NEW PLUG. THEN, THE SAME THING HAPPENED AGAIN IN OCTOBER OF 2010 TO A DIFFERENT PLUG. AGAIN I HAD THE TRUCK REPAIRED IN THE SAME MANNER. THE RISK OF FIRE AND COLLISION WAS DIRECTLY CAUSED BY THE FAILURE OF THESE SPARK PLUGS. *TR
Service brakes, Hydraulic, Nov 3, 2010
THE CAR WAS STOPPING TO DROP OFF MAIL AT A MAILBOX. THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. INSPECTION REVEALED BRAKE FLUID ON THE GAS TANK. A RUSTED BRAKE LINE WAS THE CAUSE. DEALER REPLACED THE LINE AT COST OF $511.95 INCLUDING BRAKE FLUID FLUSH. THE REAR BRAKE LINE WAS REPLACED. IT RUNS FROM THE FRONT TO THE BACK.
Engine and engine cooling, Oct 22, 2010
FORD F150 2002 WAS HAVING WHAT WE THOUGHT WAS A WHEEL BALANCE ISSUE. DAY BEFORE SOUNDED LIKE LIFTERS WE NEEDING ADJUSTMENT (TAPPING) THAT SEEMED TO GET BETTER AS IT DROVE. WAS TURNING ONTO A HIGHWAY TYPE ROAD, ENGINE MADE A BANG THAT SOUNDED LIKE IT THREW A ROD, FOLLOWED BY LOUD POPS. THERE WAS NO SMOKE OR OIL. IMMEDIATELY PULLED OVER AND CUT THE ENGINE. HAD TO TOW TRUCK TO DEALER ($90). FORD DEALER IDENTIFIED BLOWN SPARK PLUG #3, AND USED A KIT TO INSTALL HELICOIL TO ALLOW REPLACEMENT SPARK PLUG. THEY SAID INDUCTION CLEANING WAS ALSO NECESSARY DUE TO THE NON-FIRING CYL, PLUS ALL NEW PLUGS. REPAIR COST $950. LOST USE OF TRUCK FOR TWO DAYS, AND THEN FOUND OUT THIS IS A KNOWN ISSUE WITHOUT A RECALL; AND IT COULD HAPPEN AT ANY TIME ON OTHER SPARK PLUGS. SPARK PLUGS ORIGINAL TO VEHICLE AND NORMAL MAINTENANCE WAS CONDUCTED ON THE TRUCK. WAS ADVISED I COULD HAVE DONE NOTHING DIFFERENT TO PREVENT THIS FROM HAPPENING.. SHOCKED AND APPALLED TO READ OF THOUSANDS OF SIMILAR OCCURRENCE, AND FORD EVEN HAS A KIT TO REPAIR THEIR MANUFACTURING DEFECT. *TR
Engine and engine cooling, Oct 19, 2010
I OWN A 2002 FORD F150 WITH A 5.4 TRITON ENGINE. I JUST HAD AN ISSUE WITH A SPARK PLUG COMING OUT OF THE HEAD. I HAVE READ MANY REPORTS OF PEOPLE HAVING THIS SAME ISSUE WITH NEW FACTORY PLUGS AND REPLACEMENT PLUGS. THIS SEEMS TO BE A DESIGN FLAW THAT FORD HAS YET TO ADMIT IS A DESIGN FLAW. THIS ISSUES CAN RESULT IN A FIRE LUCKILY IT DID NOT HAPPEN WITH MINE. I WORK AT A SALVAGE YARD AND THIS IS ONE OF THE COMMON THINGS WE SEE HAPPEN TO THESE MOTORS. I THOUGHT I HAD ONE THAT WAS NOT PART OF THE ISSUE BUT I GUESS NOT. NOW I WILL HAVE THE COST OF A TOW CALL AND WHAT EVER IT WILL COST TO FIX IT AND FROM WHAT I HAVE SEEN SO FAR AROUND $500-1500 IF HEADS ARE NOT CHANGED. IF HEADS ARE CHANGED THEN IT COULD BE ALOT MORE. *TR
Vehicle speed control, Oct 16, 2010, fire
OUR 2002 F150 CAUGHT FIRE WHILE PARKED IN THE FRONT OF OUR HOME. AFTER TRYING TO FIGURE OUT WHY OUR TRUCK CAUGHT ON FIRE WE FOUND ONLINE THAT THERE WAS AN OPEN RECALL ON THE CRUISE CONTROL/BRAKE SAFETY SWITCH RECALL FROM FORD. WE CALLED FIRE DEPARTMENT AFTER WE PUT OUT FIRE AND HAVE RECORD THAT THEY CAME TO MAKE SURE ALL HARM WAS OUT OF THE WAY. *TR
Engine and engine cooling, Oct 7, 2010
TL*THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT HEARD A LOUD RATTLING NOISE FROM THE ENGINE AREA. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT ONE OF THE SPARK PLUGS HAD BLOWN OUT. THE VEHICLE WAS BEING REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 110,000.
Engine and engine cooling, Oct 4, 2010
BLOW SPARK PLUG ON A 2002 FORD F-150 5.4 PICKUP. *TR
Engine and engine cooling, Oct 3, 2010
EVENTS LEADING UP TO THE FAILURE WOULD HAVE TO BE...EVERYDAY DRIVING.... THE FAILURE - FOR THE THIRD TIME NOW, A SPARK PLUG EJECTED FROM THE CYLINDER HEAD. CONSEQUENCES - $800 FORD DEALERSHIP PARTS/LABOR, PLUS 2 TOW TRUCK SERVICES. NEW PLUG, INSERT, AND COIL. *TR
Engine and engine cooling, Sep 28, 2010
ON SEPTEMBER 28TH 2010 I WAS DRIVING FROM INDIANAPOLIS, IN TO LOUISVILLE, KY ON A VERY BUSY I-65 INTERSTATE. AT APPROXIMATELY 4PM I HEARD A VERY LOUD POP AND LOST ALL POWER. I COULD HEAR A VERY LOUD BANGING NOISE AND AT FIRST I THOUGHT I BLEW A TIRE. I IMMEDIATELY TRIED TO GET FROM THE FAST LANE TO THE EMERGENCY LANE BUT WITH AS MANY CARS ON THE ROAD THIS WAS DIFFICULT. I FINALLY MADE IT TO THE EMERGENCY LANE AND TURNED MY FLASHERS ON. WHEN I GOT OUT OF MY VEHICLE I CHECKED FOR A FLAT TIRE BUT THAT WAS NOT THE ISSUE. I RESTARTED THE TRUCK AND LIFTED THE HOOD OF MY ENGINE. I NOTICED THAT ONE OF MY COIL POWER PACKS WAS AT A WEIRD ANGLE. WHEN I WENT TO CHECK IF IT WAS STILL ATTACHED THE COMPRESSION OF MY NUMBER 2 CYLINDER BLEW THE SPARK PLUG THE REST OF THE WAY OUT OF THE ENGINE AND HIT MY HOOD VERY NARROWLY MISSING MY HEAD. THE COIL WAS ALSO DESTROYED BY THE FORCE OF THE SPARK PLUG COMING OUT OF THE CYLINDER. MY TRUCK IS A 2002 FORD F-150 WITH LESS THAN 100K MILES. THIS IS A VERY DANGEROUS ISSUE THAT NEEDS TO BE CORRECTED. *TR
Service brakes, Hydraulic, Fuel system, Gasoline, Sep 28, 2010
THE REAR FUEL TANK STRAP ON MY 2002 FORD F 150 RUSTED THROUGH CAUSING THE TANK TO COME LOOSE. THE RUST WAS SO BAD THAT THERE WAS ALSO A SMALL HOLE IN THE FUEL TANK. I HAVE TAKEN THE TRUCK IN FOR REPAIRS AND AFTER THE TANK WAS REMOVED IT WAS DISCOVERED THAT THE BRAKE LINES ABOVE THE TANK WERE ALSO RUSTED WITH ONE STARTING TO LEAK. *TR
Fuel system, Gasoline, Sep 15, 2010
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE ANOTHER DRIVER WAS DRIVING APPROXIMATELY 20 MPH, BOTH STRAPS ON THE FUEL TANK FELL OFF AND THE TANK DROPPED DOWN ON THE GROUND. ANOTHER DRIVER ALERTED HER TO THE FAILURE. THE VEHICLE WAS TOWED TO A REPAIR SHOP. THE CONTACT CALLED THE DEALERSHIP WHO REFERRED HIM TO THE MANUFACTURER WHO ASSIGNED HIM A CASE NUMBER. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 241,000.
Fuel system, Gasoline, Sep 15, 2010
GAS TANK LEAK AT STRAP HOLDING TANK IN PLACE. 2002 FORD F-150 4X4 4.6 LITER. AT THIS TIME I CAN NOT FILL THE VEHICLES TANK TO FULL. THE PROBLEM WILL ONLY GET WORSE WITH TIME. AT THIS TIME THE VEHICLE IS ONLY FILLED TO 1/2 FULL. *TR
Vehicle speed control, Sep 10, 2010, crash
TL*THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE EXITING A PARKWAY TO GET ON THE HIGHWAY WHILE DRIVING 55 MPH HE APPLIED THE BRAKES TO YIELD AND THE VEHICLE ACCELERATED WITHOUT DRIVER INTENT. HE WAS FORCED TO DRIVE THE VEHICLE ON A SIDEWALK IN ORDER TO GET OUT OF TRAFFIC WHICH CAUSED HIM TO LOSE CONTROL OF THE VEHICLE AND CRASHED INTO AN EMBANKMENT. HE TRIED TO PUT THE VEHICLE IN NEUTRAL BUT IT WENT INTO REVERSE INSTEAD. THE VEHICLE ACCELERATED ON IT'S OWN IN REVERSE AND CROSSED A SIX LANE HIGHWAY BEFORE CRASHING INTO A LIGHT POLE, WHICH FINALLY STOPPED THE VEHICLE FROM ACCELERATING. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO A STORAGE LOT. THE STATE POLICE RESPONDED TO THE SCENE AND FILED A REPORT WHICH IS AVAILABLE. THE VEHICLE WAS NOT REPAIRED. FORD WAS CONTACTED AND COULD NOT OFFER ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 82,200. UPDATED 11/22/10 *BF UPDATED 11/23/10*JB
Vehicle speed control, Sep 9, 2010, fire
MY 2002 F150 CATCH ON FIRE TODAY. THE FIRE SEEMS TO HAVE COME FROM THE BRAKE MASTER CYLINDER AREA. *TR
Engine and engine cooling, Fuel system, Gasoline, Sep 5, 2010
I WAS DRIVING IN THE URBAN STREET AND I SUDDENLY HEAR A NOISE COMING FROM THE ENGINE COMPARTMENT, LIKE SOMETHING IS LEAKING FROM THE ENGINE. SO I HAD IT TOWED TO MY HOUSE WHICH IS AROUND 2 KMS AWAY. WE DISCOVERED THAT ONE OF THE SPARK PLUG JUST PULL OUT OF THE ENGINE AND IT WAS THE ONE THAT WAS MAKING THE NOICE AND NO POWER. I BROUGHT IT TO MY FRIEND WHJO IS A MECHANIC AND HE DISCOVERED THAT THE TREAD IS DAMAGED AND HE CANNOT INSERT THE PLUG ANYMORE. I BOUGHT IT USED ON MARCH 2008. *TR
Structure, Sep 3, 2010
NUMEROUS FORD PICK-UP TRUCKS TO INCLUDE F SERIES AND RANGER HAVE AN ISSUE WITH THE CROSS BEAMS THAT HOLD THE PICK-UP BED TO THE TRUCK RUSTING OUT. THE POTENTIAL IS THERE THAT THE BED COULD COME LOOSE FROM THE TRUCK AND POSE A SERIOUS SAFETY HAZARD. I HAVE CONTACTED FORD ABOUT IT BUT AS YOU CAN GUESS THEY WERE UNRESPONSIVE. SEVERAL WORKERS AT THE LOCAL FORD DEALER ALSO HAVE THE SAME PROBLEM BUT HAVE BEEN UNABLE TO GET A SATISFACTORY RESPONSE FROM FORD. MY VEHICLE IS A 2002 MODEL BUT I HAVE BEEN TOLD THAT IT OCCURS IN OLDER AS WELL AS NEWER MODELS. I AM GOING TO HAVE TO HAVE THE BED REMOVED AND NEW CROSS BEAMS WELDED ON TO REPLACE THE DEFECTIVE ONES AT MY EXPENSE. I HAVE ONLY 77,000MILES. THE TRUCK IS OPERATED IN NC WITH SOME SALT USED IN THE WINTER. *TR
Engine and engine cooling, Aug 25, 2010
TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING APPROXIMATELY 3 MPH, THE VEHICLE EXHIBITED A LOUD POP FROM THE ENGINE AS THE VEHICLE BEGAN TO LOSE POWER. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE HE WAS INFORMED THAT A SPARK PLUG FRACTURED FROM THE ENGINE AND TORE AN ENGINE COIL. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 95,800.
Engine and engine cooling, Aug 23, 2010
2002 F-150 FORD 4.6 V-8 SPARK PLUG EJECTION. FIRST TIME HAPPENED ON JUNE 20 2008 IN THE NUMBER 3 CYLINDER TRUCK SHOWING 160,000 KMS. I REMOVED THE HEAD SENT IT TO MACHINE SHOP TO BE REPAIRED. 11 MONTHS LATER(182000) THE HELI-COIL THAT WAS INSTALLED CAME OUT WITH THE SPARK PLUG. REMOVED THE HEAD AND INSTALLED REMAN HEAD (ON RIGHT SIDE) DURING THE SPRING OF 2010 I STARTED TO LOOSE COMPRESSION ON ALL CYLINDERS, RANGING FROM 0-90 LBS AND THE BEST CYLINDER AT 120 LBS) BROUGHT IT TO A FORD DEALER, AND RESULTS SHOWED LEAKING WAS AROUND SPARK PLUGS. FORD DECLARED I NEED A NEW ENGINE. I AM LUCKY ENOUGH TO BE ABLE TO DO MY OWN REPAIRS. I PURCHASED A USED ENGINE FROM A WRECKER AND INSTALLED @ 190000KMS IN JULY 2010. I HAVE SPENT OVER $4000.00 ON THIS PROBLEM, AND I AM NOT DUMB ENOUGH TO CHANGE SPARK PLUGS WHEN THE ENGINE IS HOT, I USE ANTI-SEIZE WHEN INSTALLING, AND TORQUE AS FORD RECOMMENDS! FORD NEEDS TO FESS UP TO THIS ISSUE AND OFFER SOME SORT OF RECALL PROGRAM. I'M SURE THAT MY REPAIR BILLS WOULD HAVE BEEN DOUBLE IF I HAD TO PAY FOR LABOR. *TR
Air bags, Aug 23, 2010
TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE TRAVELING 20 MPH, THE FRONTAL DRIVER AND PASSENGER AIR BAGS DEPLOYED WITHOUT WARNING. THE VEHICLE WAS NOT INVOLVED IN A CRASH. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 120,000.
Vehicle speed control, Aug 22, 2010
FORD F150 HAD A RECALLED BACK IN 2005 WITH THE SPEED CONTROL WERE THE DEACTIVATION SWITCH MAY OVERHEAT, SMOKE OR BURN. WAS INSTRUCTED TO TAKE TO DEALER TO DISCONNECT UNTIL PARTS COME IN WAS NOTIFIED ON NEW PARTS WERE AVAILABLE WHICH WERE INSTALL. AUG 21 2010 THE BRAKE PRESSURE SWITCH STARTED LEAKING AND RUNNING FROM MY MASTER CYLINDER BRAKE PRESSURE SWITCH. THIS WAS PART OF THE PROBLEM FROM THE VEHICLE SPEED CONTROL SWITCH PART THAT WAS LEAKING. COULD NOT BUY PART FROM AUTO PART STORE. *TR
Engine and engine cooling, Aug 20, 2010
STARTING FROM A STOPLIGHT, I HEARD A SUDDEN POP AND SMELLED GAS. LOUD CLICKING OR POPPING NOISE CAUSED ME TO TURN AROUND AND HEAD STRAIGHT TO THE DEALER. THEY SAID A SPARK PLUG BLEW OUT, DAMAGING THE COIL. INITIAL ESTIMATE OF $500 GREW TO $3600 AS THEY SAID THEN THAT THE HEAD WOULD NEED TO BE REPLACED DUE TO DAMAGE THERE AS WELL. RESEARCHING THIS PROBLEM, IT APPEARS THAT THERE ARE QUITE A FEW (MANY MANY MANY) FORD OWNERS WITH THIS PROBLEM! WHY IS THERE NO RECALL? IMMEDIATE SAFETY OR NOT, THIS IS AN OBVIOUS DEFECT. *TR