2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints
2,036 reports, newest first.
Power train, Jul 24, 2005
WHILE ACCELERATING FROM A STOP OR SLOWING AND TURNING TRANSMISSION SLIPS GEARS. VERY NOTICABLE BETWEEN SECOND TO THIRD SHIFT. GEAR SLIPAGE CAUSING LOSS OF ACCELERATION POWER. TRANSMISSION ALSO SHIFTS HARD AS IT SLIPS.
Suspension, Jul 22, 2005
2004 FORD F150 DEVELOPED A PROBLEM WITH VIBRATION WHEN DRIVING AT 45 TO 60 MPH.***NO ANSWER REQUIRED***. *MR THE VIBRATION BEGAN AT ABOUT 7000 MILES. THE TRUCK WOULD VIBRATE SO BADLY THAT THE CONSUMR WAS FORCED TO PULL TO THE SIDE OF THE ROAD. MANY ATTEMPTS WERE AMDE TO REPAIR THE PROBLEM BUT THEY WERE NOT SUCCESSFUL. *NM
Power train, Jul 15, 2005
1. NO SIGNS OR EVENTS LEAD UP TO THE DRIVE-LINE ON MY FORD F-150 DETACHING FROM MY VEHICLE. 2. NO CONSEQUENCES OR FAILURES OCCURED. 3. MY VEHICLE IS UNDER WARRANTY AND NOTHING HAS BEEN DONE FOR OVER 30 DAYS. DESCRIPTION: ON JUNE 14, 2005 BETWEEN 7:30-8:00 AM, I WAS TRAVELING TO WORK ON FREEWAY 99 IN FRESNO, CALIFORNIA. I HEARD A 'BANG' UNDERNEATH MY TRUCK AND MY TWO REAR TIRES LOCKED-UP. I PROCEEDED TO SKID IN THE LEFT HAND LANE, UNTIL I MY TRUCK RESTED ON THE SHOULDER. MY TRUCK DID NOT DISPLAY ANY SIGNS BEFORE THE INCIDENT.
Parking brake, Equipment, Jul 15, 2005
SINCE 3000K MILES MY TRUCK WOULD SHIMMY/SHAKE VIOLENTLY TO THE POINT I WOULD HAVE TO PULL OFF THE ROAD. AFTER MULTIPLE TIMES TO DEALESHIP PROBLEM STILL THERE. I NOTICED MY EMERGENCY BRAKE LIGHT STAYED ON ONCE AFTER PULLING RELEASE. HAD TO REAPPLY AND PULL AGAIN AND DID RELEASE. A WEEK LATER, E BRAKE WOULD NOT RELEASE AFTER MULTIPLE ATTEMPTS. AFTER PUTTING IN GEAR, FINALLY DID RELEASE. AFTER BACKING OUT OF DRIVEWAY, AS I STARTED TO DRIVE TRUCK WAS SHAKING BADLY. I DEDUCTED E-BRAKE STICKING CAUSING SHAKING. BROUGHT TO DEALER- FOUND STUCK E-BRAKE. REPLACED ADAPTOR, ROTOR ASY-BRAKE, CABLE ASY-PARKING BRAKE. PICKED UP TRUCK-TRIED E-BRAKE AND WENT TO FLOOR, DID NOT HOLD TRUCK WHEN IN GEAR. EBRAKE NOT WORKING AGAIN AFTER JUST BEING REPLACED.
Other or unspecified, Jul 14, 2005
MY 2004 F 150 SHAKES / VIBRATES SO BAD IT LOOKS LIKE THERE ARE 5 CARS FOLLOWING ME (WHEN THERE IS ONLY ONE) IN MY REVIEW MIRROR. THE TIRES HAVE BEEN BALANCED @ 3100 MILES. TIRES REPLACED @ 3300 MILES.VIBRATION DAMPER@ 3200 MILES. NOW THEY WANT TO PUT A SPLIT DRIVE SHAFT ON IT. HOW AM I GOING TO REPLACE THESE NON STANDARD PARTS 3 YEARS FROM NOW? MY WIFE REFUSES TO RIDE IN IT-CALLS IT A DEATH TRAP!! I'VE OWNED THE TRUCK FOR A YEAR NOW AND ONLY HAVE 4400 MILES ON IT. I'M AFRAID OF IT TO. WILL SOMEONE PLEASE HELP. MY TRUCK IS A 2004 STANDARD CAB XLT 5.4 LITRE AUTO 4X4
Electrical system, Jul 13, 2005
DT: CONSUMER STATED HE HAS NO CONTROL GAUGES, NO SPEEDOMETER, NO AIR BAGS; THE DEALERSHIP DID NOT WANT TO BOTHER WITH IT. HE CALLED AGAIN THIS MORNING AND THEY SAID THEY WOULD GET TO IT WHEN THEY COULD. HE HAS NOT TALKED TO THE MANUFACTURER. HE NOTICED IT ABOUT 2 WEEKS AGO WHEN THE AC WENT OUT. THE CONSUMER SAID A MECHANIC HAD TOLD HIM FORD WAS HAVING A LOT OF PROBLEMS WITH THE COMPUTERS IN THEIR VEHICLES. *JB
Suspension, Jul 12, 2005
FORD F150 TRUCK - THE TRUCK INTERMITTENLY EXHIBITS SEVERE VIBRATION THAT CAN BE FELT IN THE STEERING WHEEL AS WELL AS IN THE CAB. THE WHOLE TRUCK SHACKES WHEN THIS OCCURS. THE VIBRATION OCCURS PRIMARILY AT SPEEDS OF 40-60 MPH; BUT, HAS OCCURRED AT SPEEDS IN THE 75 MPH RANGE TOO. THERE IS A LOW LEVEL VIBRATION THAT IS PRESENT MOST OF THE TIME WHILE DRIVING. THIS LOW LEVEL VIBRATION TURNS INTO THE SEVERE VIBRATION PERIODICALLY. THE PROBLEM OCCURS ON SMOOTH PAVEMENT. IT IS VERY SCAREY WHEN THIS PROBLEM OCCURS. THE DRIVE SHAFT AND ENGINE MOUNTS HAVE BEEN REPLACED AND THE DEALER TRIED 4 NEW TIRES ON THE TRUCK TOO. THE PROBLEM STILL EXISTS.....ALAS IT IS INTERMITTENT AND THE DEALER HAS NOT SEEN IT. ONE INTERESTING FACT. WHEN THE DEALER PUTS THE TRUCK ON THE LIFT TO CHECK IT, THE PROBLEM GOES AWAY FOR A WEEK OR TWO; BUT, THEN RETURNS.
Service brakes, Hydraulic, Electrical system, Other or unspecified, Jul 9, 2005
1) BRAKE SYSTEM MALFUNCTION. IT WAS SERVICED BY FRIENDLY FORD BUT THE PROBLEM STILL EXIST, EXTREME SEVERE VIBRATION THAT IT SHAKES THE WHOLE TRUCK WHEN YOU STEP ON THE BRAKE PEDAL. BRAKE FAILED TO SLOW DOWN THE SAID VEHICLE AT 65 MPH GOING DOWNHILL. THE CONDITION IS WORSE THAN BEFORE IT WAS SERVICED. I BEG NHTSA TO ADDRESS THE PROBLEM TO FORD MOTOR COMPANY BEFORE A FATAL ACCIDENT COULD OCCUR. 2) ENGINE OR COMPUTER ELECTRICAL PROBLEM? ENGINE LOSSES POWER AND DROPS TO FAIL SAFE MODE. TOTALLY GUTLESS WHILE COMING IN TO FREEWAY FROM AN OFFRAMP OR DURING CROSSING AN INTERSECTION. AFTER HOURS OF DRIVING IT COMES BACK TO NORMAL. I TRIED DIFFERENT GRADES OF FUELS OCTANE IT DIDN'T MAKE ANY DIFFFERENCE IT DID MALFUNCTION IN SIMILAR WAY. VERY SCARY AND DAGEROUS EXPERIENCE. 3) DRIVER'S SIDE POWER WINDOW AND REAR WINSHIELD POWER WINDOW MALFUNCTIONS. EXTREME WATER INTRUSION DURING RAIN AND CAR WASH TIME. IT HAS HARSH MECHANICAL NOISE INSIDE THE DOOR.
Engine and engine cooling, Jul 8, 2005
2004 FORD F-150 2WD REG CAB LONG BED: 1 - SHIFTING VEHICLE WITH AUTOMATIC TRANSMISSION DURING A COMPLETE STOP FROM REVERSE TO DRIVE 2 - ONCE DRIVE ENGAGED, THE THROTTLE ENGAGED AT FULL POWER WITHOUT DRIVER'S INITIATION OF GAS PEDAL. TRIED TO STOP VEHICLE BY APPLYING BRAKE FIRST WITH ONE FOOT, THEN WITH TWO, WITH NO EFFECT. THE VEHICLE FINALLY STOPPED ONCE SHIFTED TO NEUTRAL AND THEN TO PARK. DAMAGE TO VEHICLE CAUSED BY RUNNING THROUGH A CHAINLINK FENCE WHICH RESULTED IN APPROX $2500 IN REPAIRS. 3 - FORD ROADSIDE ASSISTANCE TOWED VEHICLE TO DEALER. SERVICE TECHNICIANS COULD NOT LOCATE PROBLEM. DAMAGED FIXED IN DEALER BODY SHOP VIA DRIVER'S INSURANCE POLICY. ONCE BODY WORK COMPLETED, THE BODY SHOP TECHNICIAN PUT IN A REQUEST TO THE SERVICE TECHNICIAN TO CHECK THE VEHICLE AGAIN AS THE THROTTLE WAS NOT RESPONDING PROPERLY. VEHICLE IS CURRENTLY STILL IN SERVICE SHOP FOR FURTHER MECHANICAL INVESTIGATION.
Power train, Jul 5, 2005, crash
MY 2004 FORD F150 WAS PARKED IN MY DRIVEWAY IN PARK WITH THE ENGINE RUNNING AND AC ON MAX. I LEFT IT RUNNING WHILE I UNLOADED THE BACK SEAT OF SEVERAL ITEMS. I THEN CLOSED THE DOORS AND PROCEEDED TO UNLOAD 4 CASES OF WATER FROM THE BED OF THE TRUCK. I MADE 5 TRIPS FROM THE TRUCK TO THE HOUSE AND WHEN I RETURNED AND PUT THE TAILGATE BACK UP MY TRUCK TOOK OFF TOWARDS MY HOUSE AND IMPACTED THE BRICK WALL OF THE GARARGE (APPROX 20 TO 25 FOOT DISTANCE). I TRIED TO RUN FROM THE BACK AND OPEN THE DOOR AND APPLY THE BRAKE BUT THE TRUCK HIT THE HOUSE AS I GOT THE DOOR OPEN. THE SHIFTER WAS STILL IN PARK. I APPLYED THE BRAKE AND PUT IT IN REVERSE AND MOVED IT BACK TO REVEAL THE DAMAGE. MY WIFE AND I TESTED THIS AFTERWARDS TO ATTEMPT TO DUPLICATE THIS WITHOUT BEING ABLE TO REPRODUCE IT. MY HOUSE AND THE TRUCK ARE DAMAGED AND I FEEL THAT THIS HAS THE POTENTIAL TO REALLY HURT SOMEONE. AFTER BEING TOLD OF THIS SITE BY MY INSURANCE COMPANY I SEE THAT THIS HAS HAPPENED TO OTHER PEOPLE AND ONE HAS ALMOST AN IDENTICAL STORY. SEE COMPLAINT 10081205. I HAVE TAKEN THE VEHICLE TO THE DEALERSHIP AND HAVE NOT BEEN GIVEN ANY INFORMATION YET.
Parking brake, Jul 5, 2005
DT VEHICLE HAS CONSTANT VIBRATION, IT SHAKES VIOLENTLY AT 45 MPH AND ABOVE. THE DEALER STATES ITS THE EMERGENCY BRAKE CABLE CAUSES THIS TO HAPPEN. THEY HAVE ALREADY REPLACED THE MOTOR MOUNTS, AND THE REAR END TWICE BECAUSE THE ORIGINALLY THOUGHT THAT WAS THE PROBLEM. CURRENTLY, IT STILL SHAKES AND THEY THINK ITS BECAUSE REAR EMERGENCY BRAKE LOCKED UP. *AK.
Power train, Jul 4, 2005
I PURCHASED A NEW 2004 F-150 REGULAR CAB PICKUP IN MAY OF 04. IT HAS HAD A SERIOUS VIBRATION SINCE NEW. AT FIRST I THOUGHT IT WAS "TEETHING" PROBLEMS, GETTING BROKEN IN AS IT WERE. THE DEALER REPLACED TWO DRIVE SHAFTS, A DAMPENER AND A COMPLETE REAR END DOWN TO THE BREAK ROTORS. NONE OF THIS HAS HELPED WITH THE VIBRATION. I TOOK IT TO A SECOND DEALER AFTER THE ORIGINAL REFUSED TO SWAP THE TRUCK OUT AS A GOOD FAITH GESTURE. INSTEAD THEY WANTED TO "TRADE" THE TRUCK. I WAS OFFERD TEN THOUSAND PLUS LESS THAN I HAD PURCHASED THE TRUCK FOR, LESS THAN FIVE MONTHS EARLIER. THE TRUCK I WANTED TO "SWAP" FOR WENT UP OVER SIX THOUSAND MORE THAN THE STICKER PRICE. THE SECOND DEALER KEPT IT MORE THAN TWO WEEKS AND COULD NOT FIX THE ISSUE. THEIR SERVICE MANAGER TOLD ME THAT THEY HAVE HAD SEVERAL TTRUCKS WITH THE SAME ISSUE AND HAD NO LUCK WITH RECTIFYING IT. THE ORIGINAL SERVICE MANAGER TOLD ME IT WAS A LEMON, THE SECOND SERVICE MANAGER TOLD ME IT WAS A LEMON. NEITHER WOULD PUT IT IN WRITING, FOR FEAR OF JOB LOSS. FORD HAS BEEN NO HELP WITH THE ISSUE, AFTER REPEATED PHONE CALLS AND EMAILS, NOTHING HAS BEEN DONE. THIS IS MY ONLY "RELIABLE" VEHICLE. IT NOW HAS @17800.0 MILES ON IT MAINLY HIGHWAY. THE VIBRATION IS GETTING WORSE WITH TIME AND MILAGE. I FEEL THAT ANY THING MECHANICAL THAT VIBRATES WILL EVENTUALY BREAK. IF I WAS LOOKING TO BUY THIS VEHICLE USED AND FELT THE VIBRATION I WOULD WALK AWAY FROM IT! IT IS THAT BAD. INCIDENT DATE APPROXIMATE
Power train, Jul 4, 2005
CONTINUOUS VIBRATIONS IN 2004 F150 AFTER FIVE TIMES TO DEALER FOR REPAIRS. DRIVE SHAFT HAS BEEN REPLACED BUT STILL HAVE VIBRATIONS. ACCORDING TO RADAR AND GPS THE SPEEDOMETER IS INCORRECT UP TO 3 MILES PER HOUR CLOCKING EXAMPLE. OPERATING AT 55 MPH SPEEDOMETER SHOWING 58 TO 58 1/2 MPH.
Vehicle speed control, Jun 29, 2005
THE CONTROL BUTTONS ON THE STEERING WHEEL DO NOT PERFORM INTENDED FUNCTION, OR FAIL ENTIRELY. OCCASIONALLY WHEN THE DASH LIGHTS ARE LIT, THE BUTTONS DO NOT LIGHT. THEY MAY OR MAY NOT COME ON LATER IN THE DRIVE. THE VOLUME + BUTTON MAKES THE CD TRACK OR RADIO STATION SKIP TO THE NEXT ONE, THE VOLUME - BUTTON MAKES THE VOLUME INCREASE. THE MEM BUTTON DOES NOTHING. THE CRUISE CONTROL STARTED SLIPPING, AS IF IT "FORGOT" THAT IT WAS ON. AND THE TRUCK ACCELLERATES, OR SLOWS. WHEN THE CRUISE WAS ON YESTERDAY, THE "RESUME" BUTTON DIDN'T WORK, AND THE "SET" BUTTON CAUSED THE TRUCK TO ACCELLERATE. FREQUENTLY, THE CRUISE CONTROL SIMPLY WILL NOT TURN ON AND SET AT ALL.
Vehicle speed control, Jun 29, 2005
ABOUT ONE WEEK AFTER I PURCHSED MY TRUCK I WAS STOPPING AT STOP SIGN, AND MY TRUCK SUDDENLY ACCLERATED. THIS HAPPENS OCASSOANALLY. IT CAN HAPPEN ONCE OR TWICE A WEEK OR IT CAN GO A COUPLE MONTHS WITHOUT A INCIDENT. I HAD IT TO THE DEALER (ZIMMERMAN FORD IN CEDAR RAPIDS IOWA) THEY REPROGRAMED IT AND THAT DID NOT FIX THE PROBLEM. I HAVE TOLD THEM MANY TIMES THAT IT WAS STILL OCCURING AND THEY SAID IF THEY COULD NOT DUPLICATE THE PROBLEM WHILE THEY HAD IT THEY COULD NOT DO ANYTHING ABOUT IT. I HAVE BEEN HAVING THIE PROBLEM FOR 18 MOUNTHS NOW. I CAME VERY CLOSE TO HAVING A ACCIDENT 3 TIMES AND WILL NOT DRIVE THE TRUCK ANYMORE. IT IS NOT SAFE TO DRIVE. I CALLED FORD MOTOR COMPANY AND THEY REFERED ME BACK TO THE DEALER, WHICH HAS GOTTEN ME NOWHERE. I SEE WHERE THERE HAVE BEEN 8 OR MORE COMPLAINTS ON YOUR WEBSIGHT WITH THE SAME PROBLEM. MY FORD DEALER SAID THEY HAVE A THING CALLED OASIS FOR DEALERS TO REPORT THEASE PROBLEMS TO FORD AND THERE WAS NOT ANY COMPLAINTS WITH THIS PROBLEM.
Power train, Jun 28, 2005
REAR AXLE WHINE AT HIGHWAY SPEED WHEN ACCELERATOR IS APPLIED. UNREPAIRED TWO TIMES BY DEALERSHIP. THIRD REPAIR REFUSED BY ME BECAUSE DEALERSHIP AND FORD REFUSED TO REPLACE THE REAR AXLE AND WANTED TO KEEP MY TRUCK FOR AN INDEFINATE PERIOD OF TIME TO DISCOVER WHAT THE PROBLEM WAS WITHOUT PROVIDING ME A LOANER/RENTAL. A MANDITORY RECALL SHOULD BE REQUIRED FOR ALL VEHICLES WITH THIS PROBLEM WHERE THE REAR AXLE ASSEMBLY IS REPLACED, NOT JUST THE RING AND PINION. UNDER THE CURRENT TSB'S FOR THIS PROBLEM THEIR IS TOO MUCH ROOM FOR ERROR! VEHICLE ONLY HAS 5000 MILES.
Tires, Jun 27, 2005
DT: THE CONTACT OWNS A 2004 FORD F150. THE TIRE MANUFACTURER IS CONTINENTAL TIRES, CONTRITRAC, SIZE P255/65R17. IT IS A TUBELESS RADIAL TIRE. AT ONLY 3000 MILES THE TRUCK SHOOK . THEY CHANGED TWO TIRES BECAUSE THE TIRES WERE NOT GOOD. ON JUNE 27, 2005 THE REAR DRIVER'S SIDE TIRE BLEW OUT. *AK
Power train, Jun 23, 2005
VEHICLE HAS DRIVE TRAIN VIBRATION & REAR END HOWL SENSE I TEST DROVE IT AUG 2004. I POINTED OUT THE DRIVE TRAIN VIBRATION TO MY SALESMAN AND HE SAID IT " PROBABLY LOST A WHEEL BALANCE WEIGHT". A FRIEND WENT INTO THE SAME DEALERSHIP ( LINDQUIST FORD) AND WAS TOLD THE SAME THING AFTER THEY HAVE ACKNOWLEDGED THERE ARE TSBS ON THIS PROBLEM AND AFTER MY TRUCK WAS IN & OUT OF THEIR SHOP NUMEROUS TIMES. SO FAR THE TIRES AND WHEELS HAVE BEEN FORCED BALANCE, DRIVE SHAFT REPLACED, CAB MOUNTS REPLACED, TRANSMISSION TAIL SHAFT END PLAY CHECKED & REAR END REPLACED. NONE HAVE RESOLVED THE ISSUES. THE SERVICE MANAGER TOLD ME FORD HAS IDENTIFIED THE AUTOMATIC TRANSMISSION AS THE PROBLEM. WE PRECEEDED TO ARRANGE REPLACEMENT AND I INSISTED ON A NEW NOT A REBUILT ONE. HE GOT BACK WITH ME AND SAID THE NEW FORD REP HE WAS DEALING WITH DOESNT REPLACE TRANSMISSIONS ! MINE SUDDENLY.......... YOU GUESSED IT.. ITS WITHIN SPECIFICATIONS !! THE DEALERSHIP MANAGEMENT WONT RETURN MY CALLS. FORD WONT BE SHAMED INTO FIXING THESE PROBLEMS UNLESS/ UNTIL THE MEDIA GETS INVOLVED.
Power train, Jun 23, 2005
WHEN USING PASSING GEAR AT 45-65 MPH YOU GET A VERY STRONG VIBRATION UNTIL YOU GO INTO OVERDRIVE. WHEN YOU USE THE OD SHUT OFF BUTTON AT 65 - 50 MPH YOU GET THE SAME VIBRATION. (1) FORD SENT LETTER IN JANURARY FROM 1ST COMPLAINT IN OCT 04 SAYING IT WAS THE TIRES AND WOULD ONLY WARRANTY THEM FOR 3 YEAR NOT REPLACE THEM NOW. (2) MAY BOTH FRONT STEEL RIMS. NOW AT THIS POINT VIBRATION IS ONLY BETWEEN 50 - 65. (3) TRUCK WAS IN SHOP FROM 31 MAY TO 10 JUN 05. REPLACED (A INSULATOR ASY - ENGINE SUPPORT), (DRIVE SHAT ASSEMBY -REAR) REMOVED AND INSTALLED. (INSULATOR - POWERTRAIN REAR SUPPORT) REPLACED. I DO NOT HAVE OLD PARTS, DEALER KEPT THEM. VIBRATION IS STILL THERE. THE MECHANIC TOLD ME THAT THIS PROBLEM IS ONLY IN 373 REAR ENDS. MY BROTHER IN TX (SAN ANGELO, WAS HELPING ME, HIS BEST FRIEND IS THE SERVICE MGR AT THE FORD DEALER THERE AND THEY HAVE THE SAME PROBLEM). A FRIEND TOLD ME HER FATHER IN AL HAS THE SAME PROBLEM AND FORD CAN NOT FIX IT. MY SERVICE MGR BRYAN AND I DROVE A 2005 IDENTICILE TO MY TRUCK AND THE VIBRATION WAS WORSE THEN MINE. MY CONCERN IS WHAT IN THE LON TERM WILL IT HAVE ON US WHO WILL BE TOWING CAMPERS AND GOING UP AND DOWN MOUNTAING AND USING THE LOWER GEAR FOR POWER AND BRAKING. WHAT WILL THAT VIBRATION DO TO THE DRIVE TRAIN? WHO LIVES WILL BE PUT IN AT RISK BECAUSE OF THIS. THANK YOU FOR YOUR HELP.
Equipment, Other or unspecified, Jun 20, 2005, fire
HUSBAND DRIVING DOWN INTERSTATE ANS SEES FLAMES COMMING UP BEHIND HIM BETWEEN THE CAB ABD THE BED. PULLED OVER AND HAD FIRE DEPARTMENT PUT OUT FLAMES. FOR DEALER STATED THAT "SOMETHING CLOGGED THE BREATHER TUBE WHICH IGNITED THE FIRE" TWIN TODDLERS WERE STRAPPED INTO THE CARSEATS IN THE BACK OF THE CAB..
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Power train, Exterior lighting, Jun 20, 2005
DT: HAD TO PUT 4 SETS OF BRAKES ON VEHICLE SINCE PURCHASING THE CAR. THE ROTORS WERE GETTING GROOVED SO BADLY THAT VEHICLE PULLS OFF THE ROAD. THE CONSUMER TALKED TO FORD, AND THEY IGNORED HIM. HE TRAVELED AND SAW THIS PROBLEM WITH SEVERAL OTHER FORD CARS. FORD TOLD HIM IT WAS COSMETIC. *AK WHILE ON THE FIRST TRIP WITH THIS VEHICLE, THE REAR END HAD GONE OUT, THE CLUTCH PACK WAS REMOVED AND REPLACED, THE FOG LAMPS WERE HOLDING MOISTURE AND WERE REPLACED, THE BRAKES WOULD PULSATE AND PULL FROM ONE SIDE, THE SHIFTING WAS HARSH WHEN CHANGING FROM FIRST TO SECOND GEAR, A LOUD CLUNK WOULD BE PRESENT AT TIMES WHEN STARTING FROM STOP THEN DECELERATING AND THE VEHICLE WOULD CRANK BUT WOULD NOT START AT TIMES. SC
Service brakes, Hydraulic, Equipment, Jun 16, 2005
BRAKES WARPING... ABS COMES ON,BRAKES START PUMPING......TURN THE BRAKE DISC ABOUT THREE TIMES, REPLACED BRAKE DISC FOUR TIMES IN TWENTY THOUSAND MILES ON F 150 FORD PICKUP TRUCK........
Power train, Jun 16, 2005
BEEN TO DEALER 4 TIMES WITH COMPLAINTS OF VIBRATION. REPLACED TIRES, DRIVE SHAFT, ROTORS & CLUTHES IN REAR END. STILL HAD VIBRATION & RETURNED TO DEALER ONY TO HEAR "WE CAN NOT DUPLICATE THE PROBLEM". THE VIBRATION OCCURS ABOUT EVERY 500-1000 MILES.
Engine and engine cooling, Jun 14, 2005, crash
DT: ENGINE FAILURE. FAIL SAFE MODE LIGHT COMES ON, AND THE VEHICLE LOSES POWER. HAS BEEN TRYING TO GET IT FIXED FOR A YEAR. DEALER SAID THEY ARE TRYING TO FIND WHAT THE PROBLEM IS, BUT CANNOT FIND CAUSE OF THE PROBLEM. MANUFACTURER WILL NOT CONTACT CALLER BACK A,ND WILL NOT OFFER ANY HELP. COMPUTER PARTS AND ELECTRICAL PARTS HAVE BEEN REPLACED AND NOTHING HAS HELPED. *AK
Steering, Power train, Jun 13, 2005
2004 F150 XLT SEVERE DRIVELINE VIBRATION BETWEEN 40-60 MPH. THIS VIBRATION IS MORE PRONOUNCED WHEN TOWING OR HAULING A HEAVY LOAD. THIS VEHICLE HAS BEEN TO BACK TO THE DEALER 9 TIMES IN THE LAST EIGHT MONTHS FOR THIS CONDITION. THREE SETS OF TIRES AND TWO SETS OF WHEELS HAVE BEEN ON THIS TRUCK, ROAD FORCE TIRE BALANCING HAS BEEN TRIED SEVERAL TIMES WITH NO APPARENT CORRECTION FOR THIS CONDITION IN SIGHT.