2005 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 1,121 owner complaints filed for this model year. This is the 4th highest complaint count among 26 F-150 model years with reports.
Of the 2005 reports, 50 involved a crash and 29 involved a fire. 57 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Representative owner complaints
1,121 reports, newest first.
Power train, Aug 25, 2010
TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT WHEN ACCELERATING FROM LOW SPEEDS OF 15-25 MPH, THE VEHICLE WOULD VIBRATE EXCESSIVELY, CAUSING THE TRANSMISSION TO SHIFT HARD. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ADVISED THE CONTACT TO TAKE THE VEHICLE BACK TO THE DEALER FOR THEM TO INSPECT AND DIAGNOSE THE VEHICLE FOR REPAIRS. THE FAILURE MILEAGE WAS 64,000.
Engine and engine cooling, Electrical system, Equipment, Aug 23, 2010
7 OF 8 SPARK PLUGS BROKE OFF WHILE CHANGING OUT ON MY VEHICAL THIS IS CRAZY HEARD ALOT OF COMPLAINTS. *TR
Visibility, Aug 20, 2010
WHEN OPERATING THE POWER WINDOW OF MY 2005 FORD F-150 THERE WAS A SUDDEN BANG AND THE WINDOW FELL DOWN INSIDE THE DOOR CAVITY. RESEARCHING THIS ON THE INTERNET I HAVE FOUND THAT MANY OTHERS HAVE HAD THE SAME FAILURE. FORD HAS SO FAR REFUSED TO DO ANYTHING OTHER THAN CHARGE HUNDREDS OF DOLLARS TO THE CONSUMER FOR REPAIRS TO THESE FAILED POWER WINDOWS. IN MANY, MANY CASES AS SOON AS ONE WINDOW FAILS THE OTHERS BEGIN TO FAIL WITHIN WEEKS. I URGE YOU TO FULLY INVESTIGATE AND USE YOUR AUTHORITY AND INFLUENCE WITH FORD MOTOR COMPANY TO INITIATE A RECALL. *TR
Power train, Aug 19, 2010
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD ATTEMPT TO SHIFT INTO FOUR-WHEEL DRIVE INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE IT WAS FOUND THAT WATER WAS LEAKING THROUGH THE FRONT CHASSIS IN FRONT OF THE FOUR-WHEEL DRIVE AND CORRODING THE SOLENOIDS. THE DEALER ORDERED THE NECESSARY PARTS TO REPAIR THE VEHICLE. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE IS 83,000. UPDATED 11/10/10
Structure, Aug 18, 2010
TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 5-10 MPH AND ATTEMPTING A TURN, THE DRIVER SIDE MIRROR WAS OBSTRUCTING HER VIEW OF ANYTHING ON THE DRIVERS SIDE OF THE VEHICLE. THE CONTACT STATED THE OUTSIDE TRIM OF THE DOOR WAS ALSO OBSTRUCTING HER VIEW OF THE LEFT SIDE WHEN ATTEMPTING A TURN. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS UNKNOWN.
Visibility, Aug 18, 2010
REAR RIGHT WINDOW FALL DOWN INSIDE DOOR WHILE I WAS DRIVING ON THE FREEWAY AND THE LEFT REAR WINDOW DID THE SAME THING IN APRIL OF THIS YEAR, I HAD THE FIRST ONE REPAIRED FOR ABOUT $300.00. FORD HAS A DEFECTIVE WINDOW REGULATOR. *TR
Visibility, Equipment, Aug 16, 2010
I HAVE BEEN CHANGING OUT MY REGULATORS FOR MY F-150 5.4 LITER XLT 2005 SINCE 2008. TOTAL AMOUNT OF TIMES IS UP TO THREE AND TODAY 08-16-2010 MY DRIVER SIDE WINDOW IS NOW STUCK IN THE DOWN POSITION. COMING HOME FROM WORK DRIVING THE SPEED LIMIT ON THE HIGHWAY TODAY I WAS ROLLING DOWN MY WINDOW AND THEN HEARD A CRACK AND THEN IT WOULDN'T ROLL BACK UP. WELL I KNEW WHAT THE SOUND MENT BECAUSE I HAVE HAD TO CHANGE ALL THE OTHER THREE WINDOWS IN MY TRUCK AND HEARD THE SAME NOISE WHEN IT HAPPENED TO THEM. TOTAL AMOUNT OF MONEY SPENT ON JUST THE FIRST THREE WINDOW REGULATORS AND LABOR $1,062.54, THAT'S NOT COUNTING WHAT I'M ABOUT TO SPEND THE FORTH TIME ON MY DRIVERS SIDE WINDOW. I WAS TOLD AND ON THE RECEIPTS IT HAS REPLACED WITH NEW PARTS, DID NOT SEE THE OLD PARTS THAT WERE TAKEN OUT THOUGH. THIS IS GETTING OLD, IS THERE ANYBODY OUT THERE THAT CAN STOP THIS. I KNOW THAT I'M NOT THE ONLY ONE THAT THIS IS EFFECTING. *TR
Visibility, Aug 16, 2010
TWICE THE PASSENGERS SIDE WINDOWS HAVE JUST FALLEN, ONCE IN THE PARKING LOT DURING WORK, THE OTHER WHILE TRAVELING TO WORK ON THE ROAD. THIS IS 2005 F150 VEHICLE, BOTH WINDOWS ARE SELDOM USED. MY MOTHER HAS A 2004 F150 VEHICLE, AND BOTH WINDOW IN THE FRONT HAVE FALLEN, BOTH TIMES SHE WAS ON THE INTERSTATE, WHICH SCARED HER BOTH TIMES, SHE IS SEVENTY THREE. *TR
Visibility, Aug 16, 2010
I HAVE A 2005 FORD F150 WITH 45K MILES ON IT I WAS DRIVING DOWN THE ROAD AT ABOUT 30MPH AND ALL OF THE SUDDEN THE DRIVER SIDE WINDOW FELL DOWN ALL BY ITSELF NO WARNING NOTHING. SCARED THE HECK OUT OF MY WIFE. IT APPEARS IT IS A COMMON ISSUE AND THAT FORD IS AWARE THEY HAVE THE ISSUE BUT REFUSE TO DO ANYTHING. IT COST $450.00 TO REPLACE THE REGULATOR AND JUDGING BY WHAT I READ THIS WILL NOT BE THE LAST TIME I HAVE TO DO THIS IF I KEEP THE CAR. I HAVE HAD TOO MANY ISSUES FOR SO FEW MILES. *TR
Visibility, Aug 13, 2010
HI I HAVE A 2005 FORD F150 THAT THE WINDOW REGULATOR LET GO AND THE GLASS JUST FELL DOWN ITS THE THIRD REGULATOR I HAVE HAD TO REPLACE 2 FRONTS AND ONE REAR. *TR
Air bags, Aug 10, 2010
TL*THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT HE WAS AT A COMPLETE STOP WHEN THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED MAJOR INJURIES TO HIS STOMACH. THE DEALER WAS CONTACTED AND STATED THAT THERE WAS NO WARRANTY ON THE VEHICLE. THEY ALSO STATED THAT THEY WOULD LIKE TO INSPECT THE VEHICLE TO DETERMINE WHY THE AIR BAGS DEPLOYED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 87000.
Visibility, Aug 9, 2010
PAID MY TOLL FOR THE BRIDGE CROSSING WENT TO ROLL UP DRIVER SIDE DOOR , HEARD A LOUD POP PLUS GLASS BREAKAGE AND MY WINDOW BEGAN TO FALL INTO THE DOOR. *TR
Fuel system, Diesel, Aug 6, 2010
LOST OF POWER, THEN CRANK BUT NOT START THEN START A DEALER AFTER BEING TOWED TO THEM, EXCESSIVE SMOKING TO BLAME ON ERG VALVE AND COOLER, AND TURBO AIR CHARGER LEAK. REQUIRED REPLACEMENT OF ERG VALVE AND COOLER, AND REPLACEMENT OF AIR TURBO CHARGER (COVERED BY EXTENDED WARRANTY PURCHASE). *TR
Visibility, Aug 3, 2010
PASSENGER WINDOW FELL INTO THE DOOR WITH NO WARNING AT ALL. I WAS DRIVING AT THE TIME AND IT CAUSED A BIG DISTRACTION. THIS IS THE 2ND FAILURE OF THE WINDOW REGULATOR ON THIS VEHICLE. *TR
Air bags, Aug 2, 2010
WHILE LEAVING TO GO TO WORK I GOT IN MY TRUCK (2005 F-150) AND STARTED IT. WAITED A FEW SECONDS TO WARM UP THE MOTOR, AND WENT TO PUT IN REVERSE (NEVER PUT INTO GEAR) AIRBAG DEPLOYED. MY RIGHT HAND INCLUDING THUMB AND 1ST FINGER WAS INJURED WITH LACERATIONS. I TOOK PICTURES AND WENT TO FORD DEALER WHILE STILL BLEEDING AND SHOCKED AND STUNNED OF WHAT HAD HAPPENED. DEALER WANTED ME TO PAY OUT OF POCKET 1,300 PLUS SOME DOLLARS OR TO CLAIM ON INSURANCE. INSURANCE WOULDN'T PAY FOR IT BECAUSE THERE NO COLLISIONS. *TR
Visibility, Jul 30, 2010
1) NO PARTICULAR EVENT PRECEDED THIS FAILURE. 2) PASSENGER POWER WINDOW FELL DOWN DUE TO FAILED WINDOW REGULATOR PLASTIC PART ON 2005 FORD F-150 FX4 SUPERCAB WITH 32K MILES WHILE PARKED OUTSIDE AT WORKPLACE. LUCKILY THE CONSEQUENCES WERE LIMITED BUT COULD HAVE BEEN MUCH WORSE, SUCH AS THEFT, INTERIOR DAMAGE DUE TO WEATHER, OR A PASSENGER SAFETY HAZARD. 3) FAILURE WAS CORRECTED BY REPLACING ENTIRE WINDOW REGULATOR MECHANISM. *TR
Visibility, Jul 27, 2010
2005 FORD F150 EXTENDED CAB FX4 I WAS CLOSING MY DRIVERS SIDE WINDOW WHEN I HEARD A LOUD POP, THEN THE WINDOW FELL THROUGH THE DOOR SEAL. NOW THE WINDOW IS STUCK IN THE DOWN POSITION INSIDE THE DOOR. *TR
Exterior lighting, Interior lighting, Jul 26, 2010, fire
LIGHT BULB ATTACHED TO TRANSMISSION PLACEMENT WINDOW IN CONSOLE, DETACHES AND BURNS OTHER WIRES AND WHAT EVER ELSE IT CAN INSIDE CONSOLE, THEN BURNS THROUGH SIDE OF CONSOLE RELEASING SMOKE INTO CAB OF VEHICLE ,IN THE END YOU HAVE AN EXTRA LIGHT STICKING OUT THE SIDE OF THE CONSOLE BETWEEN THE DRIVERS SEAT. *TR
Child seat, Jul 24, 2010
SEAT WILL NOT RECLINE ENOUGH. BABY'S HEAD WAS JUST HANGING OVER HELD UP WITH THE CHEST STRAP. HIS FACE WAS RED AND I'M AFRAID THAT HE WOULD HAVE BEEN SUFFOCATED HAD I NOT TAKEN HIM OUT WHEN I DID. I TOOK THE SEAT TO HEALTH DEPARTMENT TO VERIFY IT WAS INSTALLED CORRECTLY, AND IT WAS. THE INSTRUCTIONS SAY TO PUT A ROLLED TOWEL UNDER THE FRONT OF THE SEAT TO HELP WITH RECLINING, BUT IT WAS VERY UNSTEADY WHEN I DID THAT. THE SEAT WAS IN A FORD TRUCK THAT HAS PRETTY FLAT SEATS SO THE RECLINE FUNCTION SHOULDN'T HAVE BEEN A PROBLEM. I HAVE 2 PICTURES OF HIM IN THE SEAT WITH HIS HEAD HANGING FORWARD. *TR
Service brakes, Hydraulic, Jul 23, 2010
BRAKE PEDAL ON 2005 F150 FADES EVEN WITH BRAND NEW PADS INSTALLED. *TR
Air bags, Jul 22, 2010
STOPPED FOR FUEL AFTER FUELING STARTED THE VEHICLE, PUT THE TRUCK IN GEAR ROLLED ABOUT 10 FEET WHEN I BRAKED BEFORE ENTERING INTO TRAFFIC THE DRIVER SIDE AIRBAG DEPLOYED WHILE I WAS COMPLETELY STOPPED. THE DEPLOYMENT CAUSED MINOR CUTS AND BRUISING TO BOTH WRIST AND MY CHEST. *TR
Visibility, Jul 21, 2010
2005 FORD F150 WINDOW REGULATOR BROKE WITH WINDOW DOWN ,SAFETY ISSUE. *TR
Visibility, Jul 20, 2010
TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE DRIVER SIDE WINDOW BECAME LOOSE AND FELL INSIDE THE DOOR. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE WINDOW REGULATOR WAS REPLACED. A FEW MONTHS LATER THE PASSENGER SIDE WINDOW EXHIBITED THE EXACT SAME FAILURE. THE REGULATOR WAS REPLACED ON THE PASSENGER SIDE BY THE DEALER. THE CONTACT HAS NOT CONTACTED FORD MOTOR COMPANY. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. THE VIN WAS NOT AVAILABLE. THE CURRENT MILEAGE WAS APPROXIMATELY 75,000.
Visibility, Jul 19, 2010
MY 2005 FORD F-150 FRONT PASSENGER SIDE WINDOW FELL IN THE DOOR. WHILE DRIVING DOWN A SMOOTH ROAD IN A RESIDENTIAL AREA I HEARD A HUGE CRACK, THEN THE WINDOW LITERALLY FELL IN THE DOOR AND WOULD NOT COME UP. THE CRACK SOUNDED LIKE A GUNSHOT AND COULD HAVE RESULTED IN SERIOUS INJURIES. REPAIRS FROM THE FORD DEALER ARE ESTIMATED AT 400 OR MORE DOLLARS. *TR
Visibility, Jul 16, 2010
MY COMPLAINT IS IN REGARDS TO THE WINDOW REGULATORS OF MY 2005 FORD F150 SUPERCREW 4X4. I HAVE NOW HAD THE FRONT DRIVER AND REAR RIGHT REGULATORS FAIL DUE TO NO FAULT OF MY OWN. THE REAR RIGHT FAILURE OCCURRED LAST FALL (AUGUST 2009) WHILE GOING THROUGH A CAR WASH WITH MY FAMILY IN THE VEHICLE. WITHOUT ANY WARNING, MY DAUGHTER STARTED SCREAMING AS HER WINDOW FELL INSIDE THE DOOR. THANKFULLY, THERE WERE NO INJURIES, BUT I DID HAVE WET CHILDREN AND WET INTERIOR. OF COURSE, THE CARWASH DENIED ANY WRONGDOING AND SUGGESTED I CONTACT FORD. IN DOING SO, FORD STATED THAT NHTSA DID NOT ISSUE A RECALL, SO THEY WERE NOT REQUIRED TO FIX/REPAIR AT THEIR OWN COST. NOT HAVING THE FUNDS AVAILABLE, I TORE THE DOOR PANEL OPEN, SLID THE WINDOW BACK UP IN THE TRACK, AND WEDGED A PIECE OF PVC PIPE TO KEEP THE GLASS IN PLACE. NOT A GREAT SOLUTION...BUT MUCH BETTER THAN WHAT FORD OFFERED TO DO. THE MOST RECENT INCIDENT OCCURRED SATURDAY, JULY 11, 2010, MID-AFTERNOON. MY FAMILY AND I WERE TRAVELING TO A COMMUNITY FUNCTION. WHILE DRIVING, I HEARD WHAT SOUNDED LIKE A SHOTGUN GO OFF NEXT TO MY EAR. OUR INITIAL THOUGHT WAS WE HIT SOMETHING ON THE ROAD OR AN ANIMAL RAN INTO US. I STOPPED AND GOT OUT OF THE TRUCK, BUT DID NOT SEE ANY DAMAGE. AT THAT POINT I DIDN'T KNOW WHAT TO THINK. WE CONTINUED ON TO OUR FUNCTION WITHOUT ANY FURTHER ISSUES. WHEN WE ARRIVED BACK AT THE VEHICLE LATER IN THE AFTERNOON, I STARTED TO ROLL DOWN THE WINDOWS WHILE THE A/C COILED OFF AND THUD...THE FRONT DRIVER WINDOW FELL DOWN. I KNEW EXACTLY WHAT HAPPENED. TORE INTO THE DOOR WHEN WE GOT HOME AND FOUND THAT THE WINDOW REGULATOR PULLEY FAILED IN THIS WINDOW ALSO. SO, I PUSHED THE GLASS BACK UP AND WEDGED ANOTHER PIECE OF PVC PIPE. ASIDE FROM THE RINGING IN MY EAR THE REMAINDER OF THE AFTERNOON FROM THE "GUNSHOT", THERE WERE NO INJURIES. FROM MY RESEARCH ON THE INTERNET, THIS APPEARS TO BE A VERY COMMON PROBLEM THAT FORD REFUSES TO ADDRESS. I WOULD APPRECIATE YOUR HELP AND RESEARCH IN THIS MATTER. *TR