2005 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 1,121 owner complaints filed for this model year. This is the 4th highest complaint count among 26 F-150 model years with reports.
Of the 2005 reports, 50 involved a crash and 29 involved a fire. 57 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Representative owner complaints
1,121 reports, newest first.
Air bags, Jul 14, 2010
TL* THE CONTACT OWNS A 2005 FORD F150. WHILE DRIVING AT 5 MPH, THE AIR BAGS INDEPENDENTLY DEPLOYED WITHOUT BEING INVOLVED IN A CRASH. THE CONTACT SUSTAINED BRUISES TO HIS LEFT HAND. THE DEALER WOULD NOT PROVIDE ANY ASSISTANCE AND ADVISED THAT THE VEHICLE WOULD BE REPAIRED AT THE CONTACT'S EXPENSE. THE VEHICLE WAS NOT REPAIRED OR INVESTIGATED FOR THE CAUSE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 98,000.
Visibility, Jul 14, 2010
2005 FORD F-150 PASSENGER WINDOW FELL AND COST 300.00 TO REPAIR. TWO WEEKS LATER THE DRIVERS WINDOW FELL, HAVEN'T HAD IT REPAIRED YET. ONLY 22000 MILES ON VEHICLE. *TR
Engine and engine cooling, Jul 13, 2010, fire
THE F-150 WAS PARKED IN THE CARPORT ATTACHED TO MY SON'S HOUSE. IT HAD BEEN PARKED AND NOT RUNNING FOR AT LEAST 3 HOURS. A PASSERBY NOTICED THE TRUCK ON FIRE AND TRIED TO WAKE ALL OCCUPANTS IN THE HOUSE(DUPLEX). AT 5 A.M ON 9/11/2008. MY SON NEVER LEFT THE HOUSE. HIS BODY WAS FOUND JUST INSIDE THE HOUSE BY THE CARPORT DOOR. THE FIRE WAS COMING FROM SOMEPLACE IN THE ENGINE COMPARTMENT. DUE TO MY SONS EMPLOYMENT WITH THE MILITARY AT THAT TIME AND LIVING ON POST THERE HAS BEEN EXTENSIVE INVESTIGATION INTO THIS INCIDENT. I CAN SUPPLY FURTHER DATA WHEN ASKED. I HADN'T BEEN ALLOWED TO SEE ANY OF THE INVESTIGATIVE INFO UNTIL THE MILITARY COMPLETED THEIR INVESTIGATION. THAT IS THE REASON FOR THE LONG DELAY IN REPORTING THIS INCIDENT. *TR
Visibility, Jul 11, 2010
I AM THE OWNER OF A 2005 FORD F150 SUPERCAB TRUCK. I RECENTLY HAD ANOTHER POWER WINDOW REGULATOR FAIL ON MY VEHICLE. THIS FAILURE OCCURRED WHILE I WAS DRIVING DOWN THE ROAD AT A SPEED OF ABOUT 35MPH. THIS IS THE SECOND REGULATOR THAT HAS BEEN REPLACED ON THIS VEHICLE (THE FIRST ONE OCCURRED THREE YEARS AGO). WHEN THIS FAILURE OCCURS THE WINDOW JUST DROPS COMPLETELY DOWN INTO THE DOOR WITH NO WARNING. WHEN THIS FAILURE OCCURS WHILE YOU ARE DRIVING IT CAUSES A VERY BIG DISTRACTION TO THE DRIVER AND PASSENGERS OF THE VEHICLE. THREE YEARS AGO, WHEN THE FIRST REGULATOR FAILED, I HAD MY VEHICLE PARKED (LUCKILY AT HOME) AND I NOTICED THAT THE WINDOW WAS IN THE DOWN POSITION. I RECALLED ROLLING THE WINDOW UP WHEN I PARKED MY VEHICLE, SO I GOT IN IT TO PUT THE WINDOW IN THE UP POSITION. AFTER TURNING THE IGNITION ON AND PRESSING THE UP BUTTON, NOTHING HAPPENED. THIS TIME IT WAS THE DRIVERS WINDOW. I AM VERY FORTUNATE TO HAVE NOT PARKED MY VEHICLE IN A PUBLIC PLACE WHEN THIS FAILURE OCCURRED BECAUSE IT WOULD HAVE GIVEN ANYONE ACCESS TO THE INSIDE OF MY VEHICLE. ALTHOUGH THE FAILURES DID NOT RESULT IN ANY INJURY OR LOSSES, THIS IS A VERY IMPORTANT ISSUE CONCERNING VEHICLE SAFETY. I CONDUCTED SOME INTERNET RESEARCH ON THIS ISSUE AND IT APPEARS THAT OTHER 2004-2005 F150 OWNERS HAVE HAD THE SAME ISSUE WITH THESE WINDOW REGULATORS. I AM VERY CONCERNED THAT THE REMAINING 2 WINDOWS WILL FAIL OVER TIME. ON BOTH OCCASIONS, I TOOK MY VEHICLE TO THE LOCAL DEALERSHIP TO HAVE A REPLACEMENT WINDOW REGULATOR INSTALLED. ONE OF THE REGULATOR REPLACEMENTS WAS COVERED UNDER WARRANTY AND THE MOST RECENT ONE WAS NOT. THIS REPAIR COST WAS $220. I FEEL THAT THIS IS AN ISSUE THAT REGULAR MAINTENANCE NOR NORMAL VEHICLE CARE COULD PREVENT. THIS IS A DEFINITE EQUIPMENT FLAW THAT THE OWNER HAS NO WARNING OF WHEN IT WILL OCCUR. THEREFORE I FEEL THAT THESE REGULATORS SHOULD BE INVESTIGATED BECAUSE IT POSES A SAFETY ISSUE TO THE VEHICLE OWNER AS WELL AS OTHER DRIVERS ON THE ROADWAY. *TR
Air bags, Jul 6, 2010
TL*THE CONTACT OWNS A 2005 FORD F150. WHILE THE VEHICLE WAS PARKED, THE DRIVER SIDE AIR BAG DEPLOYED. HE STATED THAT THERE WAS A LOUD NOISE WHEN THE AIR BAG DEPLOYED AND HIS CLOTHES WERE STAINED FROM THE MATERIAL IN THE AIR BAG. THE VEHICLE WAS TOWED TO AND WAS CURRENTLY AT AN AUTHORIZED FORD DEALER. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 65,000.
Visibility, Jul 1, 2010
2005 FORD F-150, POWER WINDOW REGULATOR FAILURE. DRIVER'S SIDE 2 YEARS AGO NOW PASSENGER SIDE. NO KNOWN CAUSE. FIRST ONE REPLACED UNDER WARRANTY. OUT OF WARRANTY AND NOT REPLACED PSNGR. SIDE YET. *TR
Steering, Jun 30, 2010, crash
TL*THE CONTACT OWNS A 2005 FORD F150. WHILE DRIVING APPROXIMATELY 45-50 MPH, AND ATTEMPTING TO DRIVE AROUND A CURVE THE VEHICLE CONTINUED GOING STRAIGHT AND CRASHED INTO TREE BRANCHES AND MAILBOXES. THE CRASH CAUSED THE VEHICLE'S TIE ROD TO BRAKE. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP. THE REPAIR SHOP REPLACED THE FENDER, FENDER EMBLEM, WINDSHIELD, SUN ROOF GLASS, BUG GUARD, LEFT HAND GRILL, UPPER BUMPER COVER. BUMPER BRACKET, FOG LAMP, TWO TAILGATE SCRAPES. A TIRE, 1 STRUT, ONE SWAY BAR AND LINK, ONE LISPH BRACKET, ONE FENDER MOLD, 1 MUD FLAP, ONE LC KNUCKLE, AND ONE LOWER CONTROL ARM. A POLICE REPORT WAS FILED. THE CONTACT STATED NO ONE WAS INJURED. THE APPROXIMATE FAILURE MILEAGE 86,000 AND THE CURRENT MILEAGE WAS 90,061.
Visibility, Jun 29, 2010
THE FRONT AND REAR DRIVERS SIDE WINDOWS HAVE SUDDENLY FAILED ON MY 2005 FORD F-150. THE WINDOWS SUDDENLY ROLL DOWN AND ARE NOT ABLE TO ROLL BACK UP. *TR
Tires, Jun 29, 2010
TL* THE CONTACT OWNS A 2005 FORD F150. THE VEHICLE HAS FOUR NITTO, DUNE GRAPPLER DESERT TERRAIN TIRES, AND LINE SIZE: 285/50/R20.THE CONTACT STATED THAT ALL FOUR TIRES EXHIBITED TREAD SEPARATION AND SPLITTING FROM THE SIDEWALL. THE DEALER WHERE THE TIRES WERE PURCHASED ADVISED THE CONTACT THAT THE TIRES WERE UNDER RECALL AND REFERRED THE CONTACT TO THE MANUFACTURER .THE MANUFACTURER ADVISED THERE WAS NO A RECALL FOR THE TIRES AND WOULD NOT PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 45,000 UPDATED 10/04/10
Engine and engine cooling, Jun 28, 2010
IN THE 2005 FORD F-150 WITH THE 5.4 LITER 3 VALVE THERE IS A DEFECT PERTAINING TO THE SPARK PLUGS. IN THE EVENT THAT YOU TRY TO REMOVE THE SPARK PLUGS THEY TEND TO BREAK OFF IN THE HEAD POSSIBLY DAMAGING THE THREADS OF THE SPARK PLUG HOLE. WHEN THIS OCCURS, FORD IS CHARGING AN OUTSTANDING AMOUNT OF MONEY TO REPAIR IT. THIS PROBLEM IS ALL OVER THE INTERNET AND DOESN'T JUST AFFECT THE 2005 MODEL. IT IS A VERY SERIOUS DEFECT COSTING PEOPLE A LOT OF MONEY THAT I THINK SHOULD BE PLACED ON THE MANUFACTURES PLATE. IT IS ALMOST AS IF THEY DESIGNED THIS PROBLEM ON PURPOSE TO MAKE PEOPLE HAVE TO BRING IT TO THEIR REPAIR SHOP AND HAVE IT FIXED REGARDLESS OF THE PRICE. I HAVE PERSONALLY EXPERIENCED THIS PROBLEM ALONG WITH MANY OTHERS AND I THINK IT IS OBVIOUS THAT THE CUSTOMERS ARE NOT HAPPY WITH THE WAY FORD HAS HANDLED THE ISSUE. SPARK PLUGS ARE CONSIDERED TO BE PART OF PREVENTIVE MAINTENANCE BUT THIS IS SICKENING HOW THEY CAN GET AWAY WITH CHARGING THAT MUCH FOR A SMALL PROBLEM. THE PROBLEM WAS NOT DISCOVERED UNTIL FORD HAD SOLD SO MANY OF THEM THAT IT WOULD PROBABLY TAKE THEM YEARS TO CORRECT EVERY ONE. IT IS PRETTY MUCH GUARANTEED THAT YOU ARE GOING TO BREAK OFF AT LEAST ONE OF YOUR PLUGS WHILE TRYING TO DO THIS SMALL TASK. AS FAR AS I KNOW THE ONLY THING DONE TO CORRECT THE PROBLEM WAS THEY INVENTED A TOOL THAT WILL REMOVED THE BROKEN PART OF THE SPARK PLUG IN THE HEAD, BUT IF THE THREADS GET MESSED UP IN THE PROCESS THAT'S WHEN IT BEGINS TO START COSTING BIG BUCKS AND IT IS TOTALLY THE MANUFACTURES FAULT TO BEGIN WITH. PLEASE TAKE THIS REQUEST FOR A RECALL SERIOUSLY AS I AM NOT THE ONLY ONE WHO FEELS THIS WAY, JUST LOOK ONLINE. *TR
Engine and engine cooling, Fuel system, Other, Jun 28, 2010
NOTIFIED TODAY THAT THERE IS AN ISSUE WITH REMOVING AND REPLACING SPARK PLUGS FOR THE FORD 5.3 TRITON V8 3 VALVE ENGINE. FORD HAS ISSUED A TECHNICAL SERVICE BULLETIN TSB 08-7-6 AND IT IS NOT AVAILABLE ON YOUR WEBSITE. WHY? IF THIS IS INDEED A MANUFACTURERS DEFECT SHOULD IT NOT BE COVERED BY THEIR ORIGINAL WARRANTY OR THE MAGNUSEN-MOSS WARRANTY ACT AND OR THE UCC, ARTICLE 2. THIS PROCEDURE CAN BE BOTH TIMELY AND COSTLY FOR A CONSUMER. I HAVE RECEIVED QUOTES RANGING FROM 250 TO 1600 DOLLARS. SHOULD THE CONSUMER BE EXPECTED TO SHOULDER THE BURDEN OF THIS ISSUE? *TR
Engine and engine cooling, Jun 22, 2010
APPROXIMATELY 2 YEARS AGO I PURCHASED A 2005 FORD F-150 EXTENDED CAB TRUCK. I HAVE HAD NO PROBLEMS WITH THE TRUCK UP UNTIL THIS POINT AND MY TRUCK CURRENTLY HAS APPROXIMATELY 67,000 MILES ON IT. HOWEVER, APPROXIMATELY THREE (3) WEEKS AGO I NOTICED MY TRUCK "SPUTTERING" AND "MISSING" AND HAVING SOME DIFFICULTY STARTING. I TOOK IT TO THE DEALERSHIP (KAMAAINA MOTOR'S) THAT I PURCHASED IT FROM. THE MECHANICS ARE NOW TELLING ME THAT THE SPARK PLUGS BROKE OFF AND FELL INTO THE ENGINE "HEAD". THEY HAVE ATTEMPTED TO RETRIEVE THE PIECES OF THE SPARK PLUGS (TWO AS THEY ARE CURRENTLY REPORTING) BUT THEY FEEL THAT THE IMPACT OF THE SPARK PLUGS FALLING INTO THE HEAD MAY HAVE NOW CAUSED MY MOTOR TO FREEZE UP. AT THIS POINT THEY ARE RECOMMENDING COMPLETE ENGINE REPLACEMENT FOR MY TRUCK WHICH WILL COST THOUSANDS OF DOLLARS. I AM DEVASTATED. THIS IS MY ONLY VEHICLE AND I STILL OWE MONEY TO THE BANK TO PAY IT OFF. I DON'T HAVE THOUSANDS OF DOLLARS TO REPLACE THE MOTOR AND I KNOW CAN'T JUST GET ANOTHER LOAN FOR ANOTHER CAR. I HAVE BEEN READING ONLINE ABOUT THIS REPEATED FAILURE ON FORD'S FAULT OF DEFECTIVE SPARK PLUGS AND THAT THIS IS COMMON AND OF NO FAULT OF THE OWNERS OF THE VEHICLES. AT THIS POINT MY TRUCK IS STILL SITTING AT THE MECHANICS AND IS NOT MOVING AND I AM WITHOUT A CAR. IS THERE NOT ANYTHING THAT THE FORD COMPANY CAN DO TO BE RESPONSIBLE FOR THEIR DEFECTIVE PRODUCTIONS?? I DEVASTATED BY THIS AND HAVE NO IDEA WHAT I AM GOING TO DO TO GET BACK INTO A RUNNING VEHICLE SO I CAN GET TO WORK AND TAKE MY KIDS TO AND FROM SCHOOL. PLEASE HELP????? *TR
Visibility, Jun 20, 2010
WAS DRIVING DOWN HIGHWAY, WENT TO LET DRIVER WINDOW UP, THE WINDOW SLAMS UP VERY FAST, MADE THIS LOUD POPPING SOUND THAN FALLS TO THE BOTTOM OF DOOR, IT WOULD NOT GO BACK UP OR DOWN, IT REALLY SCARED ME DIDN'T NO WHAT WAS GOING ON. HAD TO PUT FOILED PAPER IN WINDOW TO KEEP IT UP. ALL YOU CAN HERE IS SOMETHING MOVING INSIDE BUT WINDOW WILL NOT MOVE. THIS COULD REALLY BE A SAFETY ISSUE. *TR
Visibility, Jun 17, 2010
2005 FORD F150 POWER WINDOW. TWO WINDOWS IN TWO MONTHS DROPPED WHILE DRIVING AND ONE SHATTERED. *TR
Visibility, Jun 15, 2010
2005 FORD F150 WINDOW REGULATOR FAILURE. *TR
Visibility, Jun 13, 2010
WINDOW ON DRIVERS SIDE WILL NOT GO UP, IN A ROLLOVER, LIMBS AND HEAD COULD PROTRUDE OUTSIDE CAUSING SERIOUS BODILY HARM AND OR DEATH, THIS ACCIDENT HAS NOT TAKEN PLACE YET, I AM ONLY SAYING IT COULD. *TR
Visibility, Jun 7, 2010
I WAS DRIVING ON THE INTERSTATE AND HEARD A LOUD POP AND THOUGHT SOMEONE HAD SHOT AT MY CAR, IT SCARED ME AND WITH MY RESPONSE SWERVED AND I ALMOST HAD AN ACCIDENT. LATER AS IT TURNED OUT IT WAS A COMMON WINDOW REGULATOR DEFECT ON FORD TRUCKS AND SUV'S. THEY HAVE BUILT IT WITH THE PURPOSE OF FAILURE AND A HIGH COST TO THE OWNER TO REPAIR THIS AND NO GUARANTEE THAT IT WILL WORK AND NOT FAIL AGAIN SOON. THIS SHOULD BE A RECALL TO ALL THOSE FORD'S WITH THIS FAILURE. IT IS GOING TO COST JUST UNDER $400.00 TO FIX WITH NO GUARANTEE. IT IS INDEED A SAFETY ISSUE WHEN IT HAPPENS WHILE DRIVING AT HIGH SPEEDS OR ANYWHERE AROUND ANY OTHER CARS, NOT TO MENTION THE WINDOW DROPPING, WHO KNOWS IT COULD SHATTER AND CAUSE A SEVERE INJURY. *TR
Fuel system, Gasoline, Equipment, Jun 3, 2010
VEHICLE JUST DIED. THE FUEL PUMP CONTROL MODULE WAS REPLACED. *TR
Fuel system, Gasoline, Jun 1, 2010
2005 FORD F-150 INJECTOR FAILURE. FORD MOTOR COMPANY WILL REIMBURSE FOR INJECTOR FAILURES THAT ARE "OPENED OR STUCK". THE DEALER DIAGNOSED THAT ONE OF THE FOUR INJECTORS IN MY TRUCK IS ELECTRICALLY FAILED. THE VEHICLE HAS 53,500 MILES. I CAN'T JUSTIFY PAYING $200 - $300 FOR FAILED INJECTOR. *TR
Power train, May 29, 2010
TRUCK ENGINE CUTTING OFF AT ANY TIME WHILE DRIVING ,LOSS OFF STEERING AND CONTROL OF TRUCK. MANY COMPLAINTS ON LINE OF SAME PROBLEM. TRUCK IS OUT OF WARRANTY. IT HAS 40,000MILES. IT HAPPENS A COUPLE TIMES A WEEK. *TR
Visibility, May 28, 2010
2005 FORD F150 - DRIVER'S SIDE WINDOW SUDDENLY FAILED AND FELL DOWN INSIDE THE DOOR. *TR
Visibility, May 26, 2010
I WAS DRIVING DOWN THE ROAD AND OUT OF NOWHERE! MY DRIVER'S DOOR WINDOW SLID/FELL HARD DOWN INTO MY DOOR FOR NO REASON!! I DIDN'T EVEN HIT A BUMP! NOT SURE IF THE WINDOW BROKE AT THE BOTTOM INSIDE THE DOOR OR NOT. NOW IT WON'T GO UP. UPON LOOKING FOR THE POSSIBLE CAUSE ONLINE, I READ THAT FORD KNOWS THAT THIS IS AN EQUIPMENT DEFECT AND POTENTIAL SAFETY ISSUE BUT HAS SO FAR REFUSED TO DO ANYTHING ABOUT IT. THIS COULD HAVE HAPPENED ANYWHERE, EVEN IN A MALL PARKING LOT WHERE SOMEONE WOULD HAVE INSTANT ACCESS TO THE INTERIOR. NOT TO MENTION THE SAFETY ISSUES, WEATHER, ETC. *TR
Engine and engine cooling, May 25, 2010
TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING AT 55 MPH, THE SPARK PLUGS DISBURSED FROM THE ENGINE AND THE VEHICLE LOST POWER AND STALLED. THE DEALER WAS CONTACTED AND THE CONTACT WAS INFORMED THAT THE REPAIRS WOULD BE AT HER EXPENSE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 80,000.
Visibility, May 25, 2010
2005 FORD F-150 WINDOW REGULATOR FAILURE - DRIVING DOWN THE INTERSTATE HEARD A LOUD POP ON THE DRIVER SIDE I THOUGHT SOMETHING HIT MY TRUCK, THE WINDOW FELL INTO TO THE DOOR. ESTIMATED COST TO FIX $420.00 + TAX. AFTER SEEING THE THOUSANDS OF COMPLAINTS ON THE INTERNET SOMETHING NEEDS TO BE DONE. RECALL!! RECALL!! *TR
Visibility, May 22, 2010
WINDOW FAILURE/FALLING INTO DOOR: 1. NO KNOWN SPECIFIC EVENT, CAR WAS PARKED WHEN FAILURE OCCURRED WITHOUT HUMAN INTERVENTION. 2. DRIVER SIDE FRONT WINDOW FALLING INTO DOOR AND PASSENGER SIDE REAR WINDOW FAILURE. LUCKILY DRIVER SIDE WINDOW HAS NOT BROKEN/SHATTERED, BUT HAS ONLY FALLEN INTO DOOR AND DID NOT DISTRACT DRIVER WHEN DRIVING IN TRAFFIC. 2A. AFTER INSPECTING EACH WINDOW ALSO FOUND PASSENGER REAR WINDOW IS LOOSE AND FREELY MOVES. 3. DEALER EXPLAINED PROBLEM IS COMMON AND LIKELY THAT IT IS THE WINDOW REGULATOR AND/OR COMPONENTS. DEALER IS CHARGING $450 TO REPAIR DRIVER SIDE WINDOW. *TR