2005 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 1,121 owner complaints filed for this model year. This is the 4th highest complaint count among 26 F-150 model years with reports.
Of the 2005 reports, 50 involved a crash and 29 involved a fire. 57 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Representative owner complaints
1,121 reports, newest first.
Visibility, Seats, Feb 12, 2007
NORMAL USE OF MY 2005 FORD F-150 IN THE PAST TWO YEARS HAS LEAD TO A FEW ITEM I BELIEVE CAN BE A SAFETY ISSUE. THE LATEST IS THE DRIVERS SEAT BREAKING ITS LOWER FRAME AND SEAT PAD TRAY. FORD HAS YET TO FIX THIS ISSUE AS THEY CLAIM PARTS ARE NOT AVAILABLE AT THIS TIME. THE SEAT IS "ROCKING" DURING NORMAL DRIVING AND IS A CONCERN OF MINE IF IT SHOULD TOTALLY FAIL WHILE THE VEHICLE IS IN USE LEADING TO A CRASH. IT IS ALSO AT A SLIGHT TILT CAUSING ME TO SIT IN A VERY UNCOMFORTABLE POSITION. IT HAS BEEN A MONTH SINCE I TOOK THE TRUCK IN TO HAVE IT REPAIRED, BUT THE PARTS ARE STILL ON ORDER TO FIX IT. THIS IS A UN-REASONABLE AMOUNT OF TIME TO HAVE TO WAIT. ALSO 3 OUT OF THE FIVE WINDOWS OF MY TRUCK HAVE BROKEN, THIS RESULTS IN THE WINDOW REGULATOR BREAKING CAUSING THE WINDOW TO DROP TO THE BOTTOM OF THE DOOR. THIS LEAVES ME AND MY VEHICLE OPEN TO THE WEATHER AND/OR BEING UNSECURED IF DRIVING IN A LESS THAN SAFE AREA. THE WINDOWS HAVE BEEN FIXED IN THE SAME DAY WITHOUT HAVING TO WAIT FOR PARTS AS THE DEALER HAS STATED "WE KEEP THE PARTS AVAILABLE AS IT IS A KNOWN PROBLEM". BUT THEY CAN NOT FIX THE OTHER TWO UNTIL THEY BREAK AS FORD WILL NOT ALLOW THEM TO UNLESS THEY BREAK. AS THIS IS A KNOWN PROBLEM IT SEEMS TO ME THE ISSUE SHOULD BE FIXED BEFORE ANY OTHER WINDOWS FAIL. *NM
Electrical system, Jan 25, 2007
I WAS ON A TRIP OUT OF TOWN AND I SMELT SOMETHING BURNING. FEW MINUTES LATER, I SAW SMOKE COMING OUT OF THE CORNER CENTER CONSOLE. I PULLED OVER TO INVESTIGATE AND SAW A LIGHT SHINING THROUGH THE SIDE OF MY CONSOLE THAT DIDN'T BELONG THERE. WHEN I TURNED OFF MY HEADLIGHTS AND THE LIGHT WOULD TURN OFF AND STOP MELTING THE PLASTIC OF THE CONSOLE. THIS COULD HAVE BEEN WORSE FOR ME HAD IT NOT BEEN DAYLIGHT! IT TURNS OUT IT WAS THE LIGHT THAT CONNECTS TO THE GEAR SHIFT TO ILLUMINATE THE LETTERS (P, R, D, ETC.) HAD NOT BEEN SCREWED IN TIGHTLY AT THE MANUFACTURE. FORD REPLACED THE CONSOLE, THE CONNECTION BRACKET AND THE LIGHT SOCKET AS THEY HAD MELTED TOGETHER. MY HUSBANDS LIGHT IN HIS F150 UNSCREWED TOO, BUT DIDN'T CAUSE ANY DAMAGE. *NM
Steering, Suspension, Jan 19, 2007
I HAD ABOUT 9500 MILES ON MY 2005 F150 WHEN THE ALIGNMENT NEEDED REPAIR. I HAD IT ALIGNED AT A LOCAL DEALER, AND THEY COULDN'T GET MY STEERING WHEEL STRAIGHT WITH THE ROAD. HAD TAKEN BACK SEVERAL TIMES, AND THEY STILL COULD NOT FIX THE PROBLEM. TRUCK STILL HAS A HARD PULL TO THE LEFT WHEN STEERING WHEEL IS STRAIGHTENED OUT. *JB
Electrical system, Jan 5, 2007, fire
OUR 2005 FORD F-150 PICK UP TRUCK WAS PARKED IN OUR DRIVEWAY. DURING THE NIGHT THE TRUCK CAUGHT FIRE AND BURNED THROUGH THE GARAGE AND THROUGH THE ATTIC. OUR HOME AND CONTENTS WERE DESTROYED AS WELL AS LOSS OF A FAMILY PET. *NM
Electrical system, Jan 4, 2007, fire
ON DECEMBER 22, 2006, THE CONTACT HAD USED THE CRUISE CONTROL AND IT SMELLED LIKE SOMETHING ELECTRICAL WAS BURNING. HE TURNED OFF THE VEHICLE AND WHEN HE RETURNED 2 HOURS LATER THE SMELL HAD DISSIPATED. THE CONTACTED STATED THAT ON DECEMBER 28, 2006 HIS 2005 FORD F150 CREW CAB CAUGHT ON FIRE. HE HAD BEEN DRIVING APPROXIMATELY 8 MINUTES. THE CONTACT WAS DRIVING APPROXIMATELY 35-40 MPH. THE WEATHER CONDITIONS WERE DRY. THE CONTACT STATED SMOKE STARTED COMING UP OUT OF THE DASH BOARD. THERE WERE NO WARNING SIGNS OR ALARMS. HE PULLED OVER TO THE SIDE OF THE ROAD AND WAS ONLY ABLE TO ROLL THE WINDOW DOWN A QUARTER OF AN INCH. THE DOORS ON THE VEHICLE WOULD NOT OPEN. THE CONTACT HAD TO KEEP BANGING HIS SHOULDER AGAINST THE DOOR AND JIGGLING THE HANDLE BEFORE THE DOOR WOULD OPEN. THE CONTACT WAS USING THE CRUISE CONTROL. THE POLICE AND FIRE DEPARTMENT CAME TO THE SCENE. THE CONTACT WAS TRANSPORTED TO THE HOSPITAL FOR SMOKE INHALATION. THE VEHICLE BECAME COMPLETED ENGULFED IN FLAMES. THE CONTACT HAS A POLICE REPORT AND FIRED DEPARTMENT REPORT. KB
Engine and engine cooling, Dec 17, 2006
I HAD STOPPED AT A LOCAL SHOP ON MY WAY BACK TO WORK AND WHEN I WENT TO START MY PICKUP TO RETURN THE ENGINE WOULD NOT TURN OVER. ON THE THIRD ATTEMPT, IT FINALLY STARTED, BUT SMELLED LIKE A MOTOR BURNING UP. I WAS PROCEEDING UP A HILL AND WAS APPROACHING A STOP SIGN. WHEN I PRESSED ON THE BRAKES, THERE WERE NO BRAKES. I COULD NOT STOP THE TRUCK AT THE STOP SIGN. I COASTED THROUGH THE STOP SIGN AT APPROXIMATELY 10MPH AND I PULLED RIGHT INTO A PARKING LOT. NO MATTER HOW HARD I PRESSED THE BRAKE PEDAL I COULDN'T GET THE TRUCK TO STOP COMPLETELY SO I PUT THE TRANSMISSION INTO PARK. I THEN PROCEEDED TO CALL FOR HELP. WHEN THE MECHANIC ARRIVED, HE FOUND THAT THE VACUUM HOSE HAD COME UNATTACHED. AFTER SPEAKING WITH A FORD MECHANIC OVER THE PHONE, HE STATED THAT THE MECHANIC HAD SINCE SEVERAL TRUCKS IN THE SAME MAKE AND MODEL AS MINE THAT ALSO HAD THIS SAME PROBLEM OCCUR. AT THIS TIME, MY TRUCK IS IN THE PROCESS OF BEING FIXED BY THE MECHANIC WHO TOLD US OF THIS PROBLEM. *NM
Service brakes, Hydraulic, Dec 8, 2006
DT*: THE CONTACT STATED WHILE DRIVING 18 MPH, THE BRAKES FAILED. THE VEHICLE WAS TOWED TO THE SALES/SERVICE DEALER, WHO DETERMINED THE VACUUM HOSE HAD COME OFF. THE MANUFACTURER WAS NOTIFIED. UPDATED 1/19/2007 - *NM
Electrical system, Dec 4, 2006, fire
DT*: THE CONTACT STATED WHILE DRIVING 30 MPH, SMOKE WAS NOTICED COMING FROM THE ENGINE. THE VEHICLE WAS MANEUVERED OFF THE ROAD WHERE THE CONTACT PUT OUT THE FIRE BEFORE THE FIRE DEPARTMENT ARRIVED. THE CONTACT DETERMINED THE IGNITION WIRING HARNESS STARTED THE FIRE. A POLICE REPORT WAS TAKEN. THE VEHICLE WAS TOWED TO THE DEALER TO AWAIT INSPECTION. *AK
Power train, Nov 19, 2006
VEHICLE ROLLED AWAY WITH TRANSMISSION PLACED IN PARK AND KEY REMOVED. INCIDENT HAS HAPPENED 8 TIMES AND DEALER ATTEMPTED REPAIR 4 TIMES, LAST REPAIR IS 17 NOV 2005. UNKNOWN IF IT WILL WORK. *NM
Service brakes, Hydraulic, Nov 17, 2006
I EXPERIENCED EXTREME FRONT BRAKE SHUDDER AFTER ONLY 6200 MILES ON THIS VEHICLE. I FEEL THAT THIS IS A SERIOUS DESIGN FAULT OF THE FRONT ROTORS. I HAD THE VEHICLE SERVICED UNDER WARRANTY AND THE FRONT ROTORS WERE CUT. I AM JUST WAITING FOR THE ROTORS TO WARP AGAIN, AND HOPEFULLY THEY WON'T CAUSE AN ACCIDENT. NO HELP FROM INQUIRIES WITH FORD MOTOR COMPANY ABOUT THIS PROBLEM. *NM
Tires, Nov 6, 2006
DT*: THE CONTACT STATED THE DRIVER'S REAR SIDE TIRE BLEW OUT. THE SERVICE DEALER COULD NOT DETERMINE THE CAUSE OF THE PROBLEM. THE TIRES WERE REGULARLY ROTATED AND CHECKED FOR ACCURATE TIRE PRESSURE.*AK
Vehicle speed control, Oct 30, 2006
DT*: THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT LOW SPEED THROUGH A PARKING LOT, THE VEHICLE LURCHED FORWARD INTO AN EMBANKMENT WITHOUT WARNING. NO INJURIES OR DAMAGE WAS SUSTAINED. THE POLICE WAS NOT ALERTED. THE VEHICLE WAS DRIVEN TO THE DEALER WHO WAS UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS NOT CONTACTED. *AK THE CONSUMER STATED THE TRUCK WAS IN PARK, WHEN HE APPLIED THE BRAKE TO IT IN GEAR, THE PEDAL BECAME STUCK. UPDATED 02/22/07.*JB
Service brakes, Hydraulic, Vehicle speed control, Oct 28, 2006, crash
WHILE TRYING TO STOP MY FORD F-150 TRUCK, I WAS ACTUALLY HITTING THE ACCELERATOR AT THE SAME TIME AS I WAS PUSHING THE BRAKE PEDAL. I COULD NOT TELL THAT IT WAS HAPPENING UNTIL IT WAS TOO LATE. AS I PSHED ON THE BRAKE THE TRUCK DID NOT SEEM TO SLOW DOWN NEARLY AS FAST AS IT SHOULD HAVE, SO I PUSHED HARDER ON THE BRAKE AND THAT DID NOT SEEM TO WORK PROPERLY, THEN I REALIZED THE RIGHT EDGE OF MY FOOT WAS ACTUALLY DEPRESSING THE ACCELERATOR, BUT YOU COULD NOT REALLY FEEL IT SINCE IT HAS VERY LITTLE RESISTANCE. WHEN I REALIZED WHAT WAS HAPPENING, I TRIED TO LIFT MY FOOT OFF THE ACCELRATOR, BUT TO DO SO I HAD TO RELEASE THE BRAKE A BIT. WHEN I DID THAT, THE VEHICLE LURCHED FORWARD TOWARD THE CAR IN FRONT OF ME AND HIT IT. IT HAPPENS BECAUSE AS YOU ARE HITTING THE ACCELERATOR WHILE TRYING TO BRAKE, THE ENGINE REVS UP TO HIGH RPM, AS YOU TRY TO GET YOUR FOOT OFF THE ACCELERATOR, AND RELEASE THE BRAKE A BIT, THE CAR THINKS YOU WANT TO GO FAST AND TAKES OFF BECAUSE OF THE HIGH RPM. THIS HAPPENED TO ME ABOUT TWO OR THREE WEEKS AGO, BUT IT JUST SEEMED LIKE AN ODDITY AT THE TIME SO I DID NOT REALLY THINK IT WAS A BIG DEAL. THEN IT HAPPENED TO ME AGAIN YESTERDAY WHEN I NEEDED TO STOP QUICKLY BECAUSE EVERYONE HAD SLAMMED ON THE BRAKES IN FRONT OF ME, SO WHEN I WENT TO HIT MY BRAKES, I INADVERTANTLY WAS HITTING THE ACCELERATOR AT THE SAME TIME AGAIN, ONLY THIS TIME, IT CAUSED AN ACCIDENT AS I PLOWED INTO THE CAR IN FRONT OF ME. I HAD PLENTY OF ROOM IN FRONT OF ME, AT LEAST 10 TO 15 FEET OR MORE, AND WE WERE ONLY TRAVELING BETWEEN 5 TO 10 MILES PER HOUR. I WONDER HOW MANY OTHER DRIVERS HAVE HAD THIS OCCUR TO THEM. I HAVE BEEN DRIVING VEHICLES FOR THIRTY YEARS AND HAVE NEVER HAD THIS HAPPEN TO ME UNTIL I DROVE THIS TRUCK, AND IT HAS NOW HAPPENED AT LEAST 2 TIMES IN THE LAST MONTH. I AM DRIVING THIS TRUCK SINCE AUGUST THIS YEAR. *NM
Fuel system, Gasoline, Vehicle speed control, Oct 27, 2006, crash
WHILE OPERATING VEHICLE IN COLD CONDITIONS OR ON COLD STARTS THE ENGINE RACES. ALSO DURING THIS TIME AS YOU TRY AND APPLY THE BRAKES THE MOTOR RACES AND IF IN GEAR IT WILL SURGE/LEAP FORWARD. THIS CAUSE THE VEHICLE TO CRASH INTO A BLOCK WALL AND DAMAGE THE FRONT END OF THE TRUCK. *NM
Fuel system, Gasoline, Oct 20, 2006
DT*: THE CONTACT STATED WHILE DRIVING 40 MPH, THE VEHICLE HESITATED AND STALLED. IT WAS MANEUVERED OFF THE ROAD AND LATER DRIVEN TO THE DEALER WHO DETERMINED THE FUEL INJECTORS FAILED CAUSING ENGINE DAMAGE RESULTING IN THE ENGINE NEEDING TO BE REPLACED.
Tires, Oct 11, 2006
DT*: THE CONTACT STATED AFTER PARKING THE VEHICLE, FLAKING OF THE TIRE'S SIDEWALLS WERE NOTICED. THE VEHICLE WAS DRIVEN TO THE DEALER WHO DETERMINED THE TIRE PRESSURE WAS TOO LOW AND THE TIRES NEEDED TO BE REPLACED. TIRE MANUFACTURER: GENERAL TIRE & RUBBER CO. BRAND & TIRE LINE: AMERI-TECH. SIZE:P255/70R17. UPDATED 11/21/06. *JB
Electrical system, Latches/locks/linkages, Equipment, Sep 21, 2006
DT*: THE CONTACT STATED THE VEHICLE'S FACTORY KEY WAS DEFECTIVE AND DOES NOT START THE VEHICLE. THE VEHICLE INCLUDED 3 KEYS; 2 GOOD AND 1 DEFECTIVE. ANY TIME A GOOD KEY WAS USED TO LOCK THE DOOR, THE DEFECTIVE KEY DOES NOT WORK AT ALL WHEN ATTEMPTING TO START THE VEHICLE. THE DEFECTIVE KEY WORKED IF IT USED TO LOCK THE DOOR BEFORE STARTING UP. THE VEHICLE WAS TAKEN TO A DEALER, WHO PROGRAMMED ANOTHER KEY, BUT THE PROBLEM PERSISTED. THE VEHICLE WAS BROUGHT BACK TO THE DEALER WHO EXPRESSED THAT ANOTHER KEY COULD NOT BE REPROGRAMMED BECAUSE OF THE WAY THE VEHICLE WAS MANUFACTURED. THE MANUFACTURER WAS CONTACTED THREE TIMES AND SUGGESTED THAT THE VEHICLE BE TAKEN TO ANOTHER DEALER. THE OTHER DEALER COULD NOT DUPLICATE THE PROBLEM, AND OFFERED NO RESOLUTION.
Service brakes, Hydraulic, Sep 19, 2006
DT*: THE CONTACT STATED UPON STARTING THE VEHICLE IN THE MORNING, WITHOUT ANY WARNING SIGNAL TO INDICATE BRAKE FAILURE, THE BRAKE PEDAL WAS DEPRESSED AND WOULD NOT GO ALL THE WAY TO THE FLOOR. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHO DETERMINED A VACUUM LINE HAD DISCONNECTED DUE TO OIL PRESENCE IN THE CONNECTION. THE RUBBER HOSE WAS REPLACED. THE CONTACT DENIED ANY TRACES OF OIL IN THE SURROUNDING OF THE VACUUM HOSE CONNECTION. UPDATED 11/03/06. *JB
Visibility, Sep 16, 2006
I HAVE A 2005 F-150 4-DOOR 2WD WITH A RETRACTABLE SUNROOF. AT ABOUT 3000 MILES IT STARTED LEAKING FROM RAINING SO MUCH IN WA STATE. I TOOK IT TO TITUS-WILL FORD IN TACOMA AND THEY FIXED IT IN A TIMELY MANNER. I HAVEN'T HAD ANY OTHER PROBLEMS SINCE THEN. *NM
Service brakes, Hydraulic, Parking brake, Fuel system, Gasoline, Sep 7, 2006
2005 F150 RWD VEHICLE HAS BEEN INTO FORD REPAIR 3 TIMES FOR BRAKES (PARKING BRAKE, ABS). ONE OCCASION THE TEMPERATURE OF THE LT REAR HUB WAS 385 DEGREES F BY INFERRED THERMOMETER. ANOTHER OCCASION RT REAR WAS TOO HOT TO TOUCH AFTER SITTING FOR AN HOUR. THIS VEHICLE HAS ALUMINUM RIMS THAT THE DEALER STATES SHOW NO DAMAGE. ALSO UNKNOWN IS WHAT THIS TEMPERATURE MAY HAVE CAUSED TO THE REAR BEARINGS, SEALS AND OTHER BRAKE COMPONENTS (CALIPERS). ABS LIGHT INTERMITTENT ON AND DRIVEABLITY WAS INTOLERABLE WITH SHAKING AND VIBRATION. FUEL CONSUMPTION GOT WORSE BY 30%. VEHICLE TAKEN TO DEALER AND PARTS WERE REPLACED (ROTOR, ABS SENSOR, PARKING BRAKE REATTACHED) , PARKING BRAKES WAS FOUND DISCONNECTED IN THE SEMI LOCKED POSITION ON THE SECOND RETURN, MISSED ON FIRST RETURN. UNABLE TO GET OLD PARTS. *NM
Service brakes, Hydraulic, Vehicle speed control, Sep 7, 2006
DT*: THE CONTACT STATED THE VEHICLE HAD AN IMPROPER BRAKE ADJUSTMENT WHICH MADE THE SLACK ADJUSTER LENGTH DIFFERENT ON EACH SIDE OF AN AXLE. THE DEALERSHIP DID NOT FIND ANY PROBLEM AND THE CONTACT REQUESTED THAT THE BRAKE CHAMBERS BE REPLACED AND EACH OF THE SERVICE CHAMBERS MUST BE OF THE SAME SIZE ACROSS THE VEHICLE'S AXLES. UPDATED 10/18/2006 - THE BRAKE PEDAL TRAVELS PAST THE ACCELERATOR PEDAL AND HAS CAUSED TROUBLE WHILE THE CONSUMER ATTEMPTS TO STOP THE VEHICLE. THE CONSUMER HAS INADVERTENTLY IT BOTH PEDALS AT THE SAME TIME. *NM
Service brakes, Hydraulic, Sep 1, 2006, crash
DT*: THE CONTACT STATED WHILE ON A HILL APPLYING BRAKE PRESSURE AT 8MPH , THE BRAKE PEDAL DROPPED TO THE FLOORBOARD AND THERE WAS A LOSS OF ALL BRAKING POWER. THE VEHICLE WAS PLACED IN NEUTRAL WHICH ALLOWED THE VEHICLE TO ROLL DOWNHILL AND STRIKE A FENCE. THE SEATBELT WAS WORN AND NO INJURIES WERE SUSTAINED. HOWEVER, THE WAS MINOR DAMAGE TO THE VEHICLE. THE POLICE WAS NOT ALERTED. THE VEHICLE WAS TOWED TO THE DEALER WHO DETERMINED THE MASTER CYLINDER WAS INOPERATIVE. THE MASTER CYLINDER REPLACEMENT CORRECTED THE BRAKING PROBLEM. THE MANUFACTURER WAS NOT ALERTED.
Air bags, Aug 17, 2006
WHEN DRIVING PAST LUKE AIR FORCE BASE THE AIR BAG LIGHT ON THE DASH ILLUMINATES IN MY 2005 FORD F150. I HAVE BEEN TOLD THAT THIS IS CAUSED BY THE RADAR. I WANT TO KNOW IF THE AIR BAG SYSTEM WILL FUNCTION NORMALLY IN THE EVENT AN ACCIDENT OCCURS WHEN THE LIGHT IS ON. OTHER PEOPLE WE KNOW ARE ALSO HAVING THIS PROBLEM WITH THEIR 2005 FORD TRUCKS AND SUVS. *NM
Vehicle speed control, Aug 12, 2006
THE FIRST TIME THIS HAPPENED AT 3000 MILES, THE SECOND TIME, IT WAS AROUND 19,300 MILES AND WAS A BIT MORE INTENSE. I WAS SITTING AT THE STOP LIGHT, WITH FOOT ON BRAKE, THE TRUCK STARTED ACCELERATING TO THE POINT,I STARTED GOING INTO TRAFFIC. I THEN PUT IT IN NEUTRAL AND TAPPED ON THE GAS PEDAL TO GET IT TO IDLE DOWN. LUCKILY I WAS ABLE TO AVOID WHAT COULD HAVE BEEN DEADLY. I THEN TOOK IT STRAIGHT TO THE DEALER, WHERE I WAS TOLD THEY COULD NOT DUPLICATE THE PROBLEM, AND WAS TOLD I PROBABLY HAD ONE FOOT ON THE BRAKE AND THE OTHER ON THE GAS, WHEN I TOLD HIM I DRIVE WITH ONE FOOT, HE SAID MY FOOT COULD HAVE SLIPPED FROM THE BRAKE TO THE GAS PEDAL. EVERY TIME HE CAME UP WITH A LAME EXCUSE AS TO WHAT COULD HAVE HAPPENED I LET HIM KNOW HE WAS WRONG. NOTHING WAS DONE AND WAS TOLD IF IT HAPPENS AGAIN BRING IT BACK IN AND THEY WILL LOOK AT IT. NEEDLESS TO SAY I WILL BE TAKING IT TO SOMEONE ELSE NEXT TIME OR GETTING A HOLD OF FORD TO FIND A SOLUTION. *NM
Vehicle speed control, Aug 5, 2006, crash
I WAS GOING TO MEET MY HUSBAND ON THE SIDE OF THE HIGHWAY TO PICK UP MY SON. I STARTED SLOWING DOWN FROM HIGHWAY SPEED OF 90KMS/HR QUITE A WAYS BACK. I SLOWED THE TRUCK TO ABOUT 30KMS/HR ABOUT 40 FEET BEHIND HIS PICKUP. ALL OF A SUDDEN THE TRUCK I WAS DRIVING GAVE A COUPLE OF LURCHES, SPED UP AND SLAMMED INTO THE BACK OF MY HUSBANDS TRUCK. I DID NOT REMOVE MY FOOT FROM THE BRAKE THE WHOLE TIME. THERE WAS NOTHING I COULD DO TO STOP THE TRUCK. ON THE GROUND BESIDE THE TRUCK THERE WAS EVIDENCE OF SOMETHING STRANGE GOING ON WITH THE PASSENGER SIDE REAR TIRE. LIKE IT HAD REVVED UP, BRAKED, REVVED AND BRAKED AGAIN. THE SALESMAN THAT SOLD US THE TRUCK CAME OUT TO THE SCENE AND SAID THAT HE BELIEVED SOMETHING WENT TERRIBLY WRONG AND SPOKE TO THE SERVICE MANAGER AT LACOMBE FORD. THEY WERE UNABLE TO DUPLICATE THE PROBLEM AND COULD NOT COME UP WITH A CAUSE FOR THE BRAKES TO MALFUNCTION LIKE THEY DID. FORD CANADA DID NO FURTHER TESTING ON THE TRUCK. THERE WAS $8000 DAMAGE TO THE FRONT END OF THE F150 AND $1000 DAMAGE TO THE OTHER PICKUP WHICH WE HAVE TO PAY FOR. WE HAD THE DAMAGE ON THE FRONT END REPAIRED AND DECIDED TO TRADE IT IN FOR SOMETHING THAT MIGHT NOT KILL ME AND MY FAMILY. THE DAY I WAS TAKING IT IN TO BE TRADED IT FAILED AGAIN, THIS TIME AT THE STOP SIGN AT AN OVERPASS. LUCKILY NO ONE WAS COMING THAT DAY. NOTHING WAS EVER CORRECTED ON THE TRUCK. *NM