2005 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 1,121 owner complaints filed for this model year. This is the 4th highest complaint count among 26 F-150 model years with reports.
Of the 2005 reports, 50 involved a crash and 29 involved a fire. 57 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Representative owner complaints
1,121 reports, newest first.
Service brakes, Hydraulic, Jul 31, 2006
BRAKE FAILURE. *NM
Service brakes, Hydraulic, Jul 28, 2006
WHILE COMING TO A STOP OCCASIONALLY THE BRAKE PEDAL HAS A LOSS OF PRESSURE FEEL AND THE BRAKE PEDAL GOES TO THE FLOOR. ON THE 26TH OF JULY I TOOK THE VEHICLE TO POWER FORD IN VALENCIA CA. AND THEY STATED THEY COULD NOT FIND A PROBLEM. IT IS MY BELIEF THE VACUUM BRAKE BOOSTER IS LEAKING PRESSURE WHEN THE AMBIENT TEMPERATURE IS HIGH, BOTH TIMES THIS OCCURRED THE OUTSIDE TEMPERATURE WAS ABOVE 110 DEGREES. *JB
Tires, Jul 17, 2006
I HAVE A 2005 FORD F150 LEASED IN JULY OF 2005. I HAVE EXPERIENCED TWO INCIDENCES WHERE A TIRE HAS GONE FLAT IN A MATTER OF SECONDS WHILE HIGHWAY DRIVING AT SPEEDS NEAR 60 MPH. I WAS ABLE TO AVOID AN ACCIDENT IN EACH CASE BUT THIS COULD HAVE GONE TERRIBLY WRONG IF I WAS NOT ABLE TO CONTROL THE VEHICLE TO PULL OFF TO THE SIDE OF THE ROAD AS IT WAS DIFFICULT TO CONTROL OR TO KEEP IN MY LANE. THE SECOND INCIDENT OCCURRED ON JULY 17, 2006. WHILE DRIVING AT HIGHWAY SPEED, NEAR 65 MPH, MY RIGHT REAR TIRE WENT FLAT WITHIN 5 SECONDS. I HAD A DIFFICULT TIME TRYING TO STEER THE TRUCK AND NEARLY COLLIDED WITH THE VEHICLE NEXT TO ME. I REMOVED THE WHEEL FROM THE TRUCK AND TOOK IT TO A LOCAL FORD DEALER. THE TIRE TECHNICIAN INSPECTED THE WHEEL AND TOLD ME THE VALVE STEM WAS LEAKING; NO HOLE OR PUNCTURE IN THE TIRE COULD BE FOUND. THEY REMOVED THE TIRE FROM THE RIM AND INSPECTED THE TIRE TO FIND DAMAGE IN THE INNER WALL OF THE TIRE. I REQUESTED THAT THE TIRE, VALVE STEM, AND LABOR BE COVERED UNDER WARRANTY. THE SERVICE REPRESENTATIVE TOLD ME THAT HE DID NOT THINK IT WAS THEIR FAULT. HE STATED THAT I WOULD HAVE TO BUY A NEW TIRE AND THEY WOULD REPLACE THE VALVE STEM. I ARGUED THAT I HAD NOTHING TO DO WITH THE FAILURE OF THE TIRE AND I BELIEVED IT SHOULD BE COVERED UNDER WARRANTY. I EXPLAINED THAT I THOUGH FORD HAS A SAFETY ISSUE WITH THE VALVE STEMS AND HE CONTINUED TO TELL ME I MUST HAVE HIT A POT HOLE OR SOMETHING. I WAS VERY UPSET THAT HE WAS ENTIRELY AVOIDING THE ISSUE AT HAND AND BLAMING ME FOR WHAT APPEARS TO BE A MANUFACTURER'S DEFECT. *JB
Suspension, Jul 11, 2006
DT*: THE CONTACT STATED THERE WAS A LOUD ROARING NOISE COMING FROM REAR END. THE VEHICLE HAS BEEN TO THREE DEALERSHIPS. NEW PINION GEARS, AND NEW CARRIAGE BEARINGS WERE REPLACED BUT THE ROARING SOUND PERSISTED.
Service brakes, Hydraulic, Jun 29, 2006
DT*: THE CONTACT STATED AFTER RELEASING THE EMERGENCY BRAKES FROM THE VEHICLE IN PREPERATION TO DRIVE, THE EMERGENCY BRAKES WOULD STICK IN PLACE. THIS CAUSED THE VEHICLE TO TRAVEL WITH THE EMERGNECY BRAKES APPIED GENERATING PRESSURE TOWARD THE TIRES WHICH CAUSED THEM TO RUN HOT AND BURN. THE BURNING RELEASED A BURNING TIRE ODOR. THE DEALERS DETERMINED THERE WOULD BE A CHARGE FOR ANY SERVICE EVEN THOUGH VEHICLE WAS UNDER WARRANTY. NO REPAIRS WERE DONE.
Suspension, Service brakes, Hydraulic, Jun 15, 2006
HAD MY F150 FOR LESS THAN 3 MONTHS WHEN NOTICED THE VIBRATION WHEN APPLYING THE BRAKES, ALSO HAS ROUGH IDLE, AND ROUGH SUSPENSION. TOOK TO DEALER THEY STATED NOTHING WRONG... WELL NOW ITS BEEN ABOUT 9 MONTH AND THE VIBRATION HAS GOTTEN SO BAD THAT WHEN BRAKES ARE APPLIED YOU GET THE STEERING WHEEL SHAKING ALONG WITH THE TRUCK. AGAIN I TOOK TO THE DEALER NOW THEY TELL ME MY ROTORS ARE WARPED AND I NEED AN ALIGNMENT AND NEW TIRES CAUSE IT ATE THE TREAD OFF THE INSIDE OF THE TIRES, AND THEY WANT TO CHARGE ME $400.00. I TALKED TO THE TIRE WARRANTY DEPARTMENT HE EVEN SAID THAT IT SHOULDN'T BE HAPPENING ALONG WITH MANY OTHERS. BUT FORD SERVICE SAYS IT NORMAL.....NOW I AM DRIVING A TRUCK WITH KIDS THAT IS UNSAFE. ARE THEY WANTING FOR PEOPLE TO DIE BEFORE THEY CORRECT THIS PROBLEM?? *JB
Fuel system, Gasoline, May 23, 2006, crash
MY WIFE WAS AT A COMPLETE STOP AT A RED LIGHT IN THE LEFT TURN LANE. SHE IS DRIVING A FORD F150 TRUCK, WITH LESS THAN 6,000 MILES. WHILE WAITING AT THE LIGHT, THE ENGINE BEGAN ACCELERATING UNEXPECTEDLY. SHE HAD HER FOOT ON THE BRAKE AND THIS INITIALLY HELD THE VEHICLE IN PLACE. THE ACCELERATION CONTINUED TO INCREASE AND SHE PRESSED HARDER ON THE BRAKE PETAL, IN AN EFFORT TO KEEP THE VEHICLE FROM MOVING FORWARD. THE VEHICLE'S ACCELERATION INCREASED AND THE VEHICLE LURCHED FORWARD, STRIKING THE STOPPED VEHICLE IN FRONT OF HER. NO ONE WAS HURT AND I HAD THE VEHICLE TOWED TO THE FORD DEALERSHIP. THE SERVICE TECH AT THE DEALERSHIP, TOLD ME THAT IT COULD BE A NUMBER OF PROBLEMS WITH THE FUEL INJECTION SYSTEM. IT SHOULD BE NOTED THAT THE DAY BEFORE, I WAS DRIVING THE TRUCK AND WHILE STOPPED AT A RED LIGHT, I THOUGHT I HEARD THE ENGINE RUNNING IN A LOUD OR ROUGH MANNER. I TURNED THE RADIO OFF AND LISTENED INTENTLY. I CHECK THE GAUGES AND THEY WERE FIND. THE LIGHT CHANGED AND I DROVE FORWARD AND THE FUNNY NOISE WENT AWAY. COULD THIS HAVE BEEN AN INDICATION OF BAD THINGS TO COME? FINALLY, I FOUND A SIMILAR INCIDENT ON THE NHTSA COMPLAINT SITE, DATED SEPTEMBER 8, 2005. THE INCIDENT ON THAT DATE IS ALMOST EXACTLY WHAT HAPPENED TO MY WIFE. *NM
Power train, May 20, 2006
VEHICLE'S TRANSMISSION FAILED AFTER ONLY 18 MONTHS, 38,925 MILES. DEALER UNABLE TO DETERMINE WHY TRANSMISSION FAILED. NO LACK OF FLUID, VEHICLE IS NOT USED TO TOW. COULD ONLY STATE THAT EXCESSIVE HEAT BUILD UP IN TRANSMISSION AND RESULTED IN FAILURE. VEHICLE AND BEEN DRIVEN HOME PRIOR EVENING WITH NO ISSUES, NEXT MORNING FAILED AT START UP. MANUFACTURER WILL NOT WARRANTY DUE TO MILEAGE, REPLACED WITH A REBUILT UNIT AT A COST OF $2,800. *JB
Suspension, Power train, May 19, 2006
PLEASE HELP A CONSUMER! I QUESTION THE SAFETY AND LONG TERM VALUE OF THE NEW FORD F150 TRUCKS MY NAME IS [XXX] AND I AM WRITING YOU AS A LAST DITCH EFFORT TO INFORM THE PUBLIC ABOUT A PRODUCTION ISSUE WITH THE FORD F150 TRUCKS THAT VIBRATE UNDER NORMAL DRIVING CONDITIONS. ABOUT THREE MONTHS AGO I PURCHASED A NEW F150 AND FROM THAT POINT I HAVE HAD A VIBRATION AND TRANSMISSION ISSUE. FORD HAS NOT BEEN ABLE TO CORRECT IT AND IN THE PROCESS I FOUND THAT THE DEALERSHIP I BOUGHT THE TRUCK FROM FORGED SOME INVOICE DOCUMENTS. I WAS SHOCKED TO FIND THIS PROBLEM ALL OVER THE COUNTRY WHEN I STARTED TO LOOK INTO IT. YOU CAN SEE FOR YOURSELF IF YOU SEARCH GOOGLE FOR TOPICS LIKE "2005 F150 VIBRATION". IF YOU WOULD LIKE, I COULD SEND YOU A LIST OF WEBSITES TO HELP. IN ALL FAIRNESS TO FORD THEY DESERVE A CHANCE TO INFORM THE PUBLIC ABOUT THIS AND I AM IN THE PROCESS OF WORKING WITH A LAWYER TO GET MY MONEY BACK. I HAVE ATTACHED A COPY OF MY NIGHTMARE TO THIS EMAIL AND JUST WANTED TO LET YOU KNOW I HAVE FOLLOWED EVERY PROTOCOL SET BY FORD. I HAVE ALSO NOTICED THAT FORD JUST LIKES TO HAVE PROBLEMS DELAYED AND EXPECT PEOPLE TO RUN OUT OF MONEY WHEN TRYING TO RECOVER THEIR ORIGINAL PURCHASE. YOU WILL ALSO FIND EMAILS ATTACHED FROM PEOPLE ACROSS THE COUNTRY WITH THE SAME PROBLEM. THIS STORY IS NOT A WASTE OF YOUR TIME. PLEASE FEEL FREE TO SEARCH THE INTERNET, YOU WILL FIND ALL THE SUPPORTING INFORMATION YOU NEED. CAN YOU PLEASE FIND THE TIME TO HELP GET THE WORD OUT AND MAKE THINGS RIGHT? I JUST WANT MY MONEY BACK AND DO NOT WANT ANYONE ELSE TO FALL INTO THIS TRAP. HELP FROM THE PRESS WOULD NOT ALLOW FORD MOTOR COMPANY TO STONEWALL PEOPLE. LETS GIVE FORD A CHANCE TO HELP THE CONSUMER. CALL ANYTIME [XXX] - I AM WILLING TO PROVIDE ALL SUPPORTING INFO INCLUDING SERVICE RECORDS, RESEARCH, AND CONTACTS FROM ACROSS THE USA. THANKS [XXX]. *NM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Tires, May 16, 2006
DT*: THE CONTACT STATED THERE IS A VIBRATION WHILE DRIVING AT SPEEDS ABOVE 65 MPH. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THE DRIVER SIDE FRONT AND REAR TIRES WERE REPLACED WHICH CORRECTED THE PROBLEM FOR A SHORT PERIOD OF TIME. THE VIBRATION RECURRED THEREFORE, THE VEHICLE WAS RETURNED TO THE DEALERSHIP AND THE TIRES WERE ALIGNED. HOWEVER, THE PROBLEM PERSISTED RESULTING IN THE CONTACT NOT EXCEEDING 60 MPH WHILE DRIVING. THE TIRE MANUFACTURER IS BF GOODRICH RUGGED TRAIL (TA). THE TIRE LINE IS P275/65R18. THE DOT NUMBER IS APU9AU610905. *AK UPDATED 07/05/06. *JB
Engine and engine cooling, Power train, May 15, 2006
BAD VIBRATION FROM REAR OF TRUCK 55-60 MPH INTERMITTENT. FORD STATE IT IS AFTERMARKET TIRES. HAD TRUCK IN 2 TIMES WITH FACTORY TIRES AND 3 TIMES WITH NEW TIRES FOR SAME VIBRATION. PINION ANGLE CHANGED TWICE ON TRUCK CAUSING MORE VIBRATIONS THAT FORD WON'T FIX. NOW TRUCK IS LEAKING ENGINE OIL FROM REAR MAIN. I AM AFRAID TO TAKE TRUCK ON LONG TRIPS FOR FEAR OF DRIVELINE FAILURE. NUMEROUS COMPLAINTS ON WEB OF SAME PROBLEM. WHY IS FORD NOT MADE TO FIX THIS ISSUE?TRUCK HAS 6,200 MILES ON IT AND ALMOST A YEAR OLD. THIS COULD BE A BIG SAFETY CONCERN IF DRIVELINE FAILURE OCCURS AT HIGHWAY SPEEDS. I HAVE BEEN AN AUTO MECHANIC FOR 18 YEARS AT DEALERSHIPS AND I KNOW A TIRE VIBRATION FROM A DRIVELINE VIBRATION. *JB
Service brakes, Hydraulic, May 15, 2006, crash
THE ACCIDENT HAPPENED DECEMBER 19, 2005: CAUSE: BRAKE FAILURE. WE WERE STOPPED AT A RED LIGHT AND I WAS HOLDING PRESSURE ON THE BRAKE PEDAL WHEN IT COLLAPSED TO THE FLOOR AND ROLLED IN TO THE CAR IN FRONT OF US. AT THAT TIME THERE WAS ONLY 2000 MILES ON THE PICK-UP. I WASN'T SURE WHAT HAPPENED UNTIL WE WERE AT ANOTHER STOP LIGHT AND IT HAPPENED AGAIN, BUT THIS TIME I PUMPED THE BRAKE PEDAL UNTIL I HAD PRESSURE. WE RETURNED HOME IN MARCH AND I WENT TO THE DEALER WHOM WE PURCHASED IT FROM (VALU FORD AT ELBOW LAKE, MINNESOTA) AND TOLD THEM OF THE PROBLEM. HE TRIED IT AND SAID HE COULD NOT FIND A PROBLEM. I GOT INTO THE PICK-UP AND SHOWED HIM HOW THE MASTER CYLINDER COLLAPSES WHEN PRESSURE IS HELD ON IT. HE TRIED ANOTHER PICK-UP SAME YEAR AND SAID THAT'S THE WAY ITS SUPPOSED TO BE??? I WENT TO ANOTHER FORD DEALER IN ALEXANDRIA (JUETTNER MOTORS) AND TOLD HIM WHAT HAPPENED AND WHAT I WANTED DONE AND THEY TOLD ME MY INSURANCE COMPANY SHOULD TAKEN CARE OF THE PROBLEM AND DIDN'T EVEN CHECK THE BRAKES. I HAVE TAKEN THE PICK-UP TO 5 DIFFERENT INDEPENDENT GARAGES AND THEY HAVE ALL SAID THE MASTER CYLINDER SHOULD NOT COLLAPSE WHEN PRESSURE IS HELD ON THE PEDAL. I WENT BACK TO THE DEALER AND ASK IF THEY COULD HAVE A COMPANY TECH EXPLAIN TO ME WHY THE MASTER CYLINDER COLLAPSES WHEN PRESSURE IS HELD ON THE PEDAL. I HAVE HEARD NOTHING FROM THEM. I FEEL VERY STRONGLY THAT FORD HAS A PROBLEM WITH THEIR MASTER CYLINDER AND SHOULD BE FIXED. I COMPLAINED TO FORD AGAIN AND ASK THEM TO HAVE SOME ONE EXPLAIN TO ME WHY THE BRAKES SHOULD COLLAPSE WHEN PRESSURE IS HELD ON THEM. THEY SENT OUT AN INDEPENDENT SOURCE AND HE HAD THE PICK-UP FOR ABOUT THREE HOURS AND SENT A REPORT BACK TO FORD SAYING THAT THE ELECTRIC BRAKES FOR THE CAMPER WERE THE PROBABLE CAUSE?? THERE IS NO HYDRAULICS INVOLVED WITH THE ELECTRIC BRAKES. NOTHING HAS BEEN DONE TO FIX THE PROBLEM.. *JB
Service brakes, Hydraulic, May 11, 2006
AT 20,000 MILES I TOOK MY 2005 F150 SUPERCREW XLT 4X4 INTO FIRESTONE, TO HAVE THE BRAKES CHECKED. THE TECHNICIAN INFORMED ME THAT THERE APPEARED TO BE NOTHING WRONG WITH THE PADS, AS I STILL HAD ABOUT 65-70% LEFT ON THEM. HOWEVER THERE WAS AN ISSUE WITH THE ROTORS. HE STATED THEY WERE WARPED. KNOWING THIS IS NOT NORMAL, I ASKED IF THIS WAS A COMMON THING ON THE NEW MODEL FORDS. AND HE STATED THAT THEY HAVE HAD A LOT OF THEM IN FOR THE EXACT SAME THING, WARPED ROTORS. I TOLD HIM TO PUT THE TRUCK BACK TOGETHER AND WOULD TAKE TO FORD. HE STATED THAT THE REASON THEY WERE WARPING, WAS BECAUSE OF A DESIGN DEFECT WHICH DID NOT ALLOW THEM TO GET ENOUGH AIR TO COOL, AND IF BRAKES WERE APPLIED HARD, THEN CAUSED THEM TO WARP. I TOOK THE TRUCK TO FORD DEALERSHIP ( JENKINS AND WYNNE IN CLARKSVILLE, TN.) INFORMED THE SERVICE WRITER. AS I WAS SPEAKING TO HIM, A TECH FROM THE SHOP WALKED IN, AND SAID THERE WAS A BIG PROBLEM WITH THEM. THEY TOOK MY TRUCK INTO THE SHOP, AND AFTER A DAY INFORMED ME THAT MY TRUCK HAD THE "NEW AND IMPROVED BRAKES" ALREADY INSTALLED. I ASKED HOW THEY COULD BE NEW AND IMPROVED IF DOING THE SAME AS THE OLD STYLE. THEY STATED THEY WOULD TAKE CARE OF ME. WHEN I INQUIRED AS TO THE HOW? THE SERVICE WRITER STATED " WE WILL MACHINE THEM." I TOLD HIM THAT JUST MEANS THAT THEY WERE GOING TO GRIND THE ROTORS FLAT, AND THAT IT WASN'T FIXING THE ISSUE. I WOULD JUST HAVE TO HAVE A COMPLETE TOTAL BRAKE REPLACEMENT AT 40,000 MILES. HE COMMENTED THAT THERE WAS NOTHING THEY COULD DO. I ASKED IF THIS WAS NORMAL FOR TRUCKS TO BE COMING IN WITH WARPED ROTORS AT 20,000 MILES, AND HE JUST SHRUGGED HIS SHOULDERS. I ASKED HIM, WHAT ARE WE AS TRUCK OWNERS SUPPOSED TO DO, REPLACE THE ROTORS EVERY 30-40,000 MILES. AGAIN HE JUST SHRUGGED AND SAID THERE WAS NOTHING HE COULD DO. AFTER THEY GROUND THE ROTORS, AND PUT THE TRUCK BACK TOGETHER, LESS THAN 500 MILES THEY STARTED DOING THE SAME THING, AND I ALMOST HAD AN ACCIDENT. THEY WILL "PULSE AND THE VEHICLE WILL LURCH" *JB
Structure, Wheels, May 4, 2006
PURCHASED A 2005 F-150 4X4 FORD PICK-UP TRUCK AND IMMEDIATELY FELT A STRONG VIBRATION THROUGHOUT THE TRUCK. TOOK IT BACK TO THREE DIFFERENT DEALERSHIPS EACH ONE CLAIMING THEY FIX IT. THE VIBRATION STILL EXISTS AND NOW THE STEERING WHEEL IS VIBRATING. I BELIEVE THIS TRUCK IS UNSAFE. I WILL CONTINUE TO EXHAUST ALL AVENUES TO REPAIR OR REPLACE THIS TRUCK. *NM
Service brakes, Hydraulic, May 3, 2006, crash
MAY 2, 2006 THE ACCIDENT HAPPENED DECEMBER 19, 2005: CAUSE: BREAK FAILURE. WE WERE STOP AT A RED LIGHT AND I WAS HOLDING PRESSURE ON THE BREAK PEDAL AND IT COLLAPSED TO THE FLOOR AND ROLLING IN TO THE CAR IN FRONT OF US. AT THAT TIME THERE WAS ONLY 2000 MILES ON THE PICK-UP. I WASN'T SURE WHAT HAPPENED UNTIL WE WERE AT ANOTHER STOP LIGHT AND IT HAPPENED AGAIN, BUT THIS TIME I PUMPED THE BREAK PEDAL TILL I HAD PRESSURE. WE RETURNED HOME IN MARCH AND I WENT TO THE DEALER WHOM WE PURCHASED IT FROM (VALU FORD AT ELBOW LAKE, MINNESOTA) AND TOLD THEM OF THE PROBLEM. HE TRIED IT AND SAID HE COULD NOT FIND A PROBLEM. I GOT INTO THE PICK-UP AND SHOWED HIM HOW THE MASTER CYLINDER COLLAPSES WHEN PRESSURE IS HELD ON IT. HE TRIED ANOTHER PICK-UP SAME YEAR AND SAID THAT??S THE WAY ITS SUPPOSED TO BE??? I WENT TO ANOTHER FORD DEALER IN ALEXANDRIA (JUETTNER MOTORS) AND TOLD HIM WHAT HAPPENED AND WHAT I WANTED DONE AND THEY TOLD ME MY INSURANCE COMPANY SHOULD TAKE CARE OF THE PROBLEM AND DIDN'T EVEN CHECK THE BREAKS. I HAVE TAKEN THE PICK-UP TO 5 DIFFERENT INDEPENDENT GARAGES AND THEY HAVE ALL SAID THE MASTER CYLINDER SHOULD NOT COLLAPSE WHEN PRESSURE IS HELD ON THE PEDAL. I WENT BACK TO THE DEALER AND ASK IF THEY COULD HAVE A COMPANY TECH EXPLAIN TO ME WHY THE MASTER CYLINDER COLLAPSES WHEN PRESSURE IS HELD ON THE PEDAL. I HAVE HEARD NOTHING FROM THEM. I FEEL VERY STRONGLY THAT FORD HAS A PROBLEM WITH THEIR MASTER CYLINDER AND SHOULD BE FIXED. I COMPLAINED TO FORD AGAIN AND ASK THEM TO HAVE SOME ONE EXPLAIN TO ME WHY THE BREAKS SHOULD COLLAPSE WHEN PRESSURE IS HELD ON THEM. THEY SENT OUT A INDEPENDENT SOURCE AND HE HAD THE PICK-UP FOR ABOUT THREE HOURS AND SENT A REPORT BACK TO FORD SAYING THAT THE ELECTRIC BREAKS FOR THE CAMPER WERE THE PROBABLE CAUSE?? THERE IS NO HYDRAULICS INVOLVED WITH THE ELECTRIC BREAKS. *NM
Other or unspecified, May 2, 2006
THE DEALERSHIP LIEDTO ME THEY TOLD ME THAT I WAS BUYING THE CAR AND NOT LEASING IT. I HAVE GONE PLENTY TIMES TO THE DEALERSHIP BUT THEY DON'T PUT ANY ATTENTION TO ME. I HAD TALKEDTO THE SALES PERON GUSTAVO MAYA. I ALSO TALKED TO J.R. STARIKA THE MANAGER OF THE DEALERSHIP BUT HE NEVER TRIED TO GIVE ME A SOLUTION FOR MY PROBLEM. WHAT I WANTED WAS A PURCHASE AND NOT A LEASE. *NM
Structure, Apr 26, 2006
DT*: THE CONTACT STATED THE TAILGATE DETACHED FROM THE VEHICLE AND WAS HANGING BY THE CABLES. THIS OCCURRED WHILE DRIVING OVER A BUMP AT 10 MPH, HAULING A 300 POUND COUCH. THE DEALERSHIP AND MANUFACTURER DETERMINED THIS WAS NOT A MANUFACTURER'S DEFECT THOUGH THEY ADMITTED THAT IT WAS NOT THE CONTACT'S FAULT. THE CONTACT FELT THAT THE TAILGATE WAS BUILT EXTREMELY LIGHT, AND IT WAS SPRING LOADED. FELT THAT THE DEALER SHOULD TAKE RESPONSIBILITY AND REPAIR THE VEHICLE. *AK
Power train, Apr 20, 2006
THE AUTOMATIC TRANSMISSION IN THE CONSUMER'S 2005 FORD F150 FAILED. *NM
Seat belts, Apr 17, 2006
EVERYTIME I HIT THE BRAKES, THE PASSENGER SEAT BELT NEVER HOLDS. PERSON IN THE SEAT ALWAYS HAS TO BE READY WHEN I BRAKE, EITHER HARD OR SOFT. SEAT BELT NOT DOING ITS WORK, NOT LOCKING, NOT HOLDING. HAPPENS COUNTLESS TIMES. TOOK IN TO THE DEALER, THEY SAY NOTHINGS WRONG, BUT IF I REALLY HAVE TO HIT BRAKES ONE DAY, SOMEONE'S GOING TO GET HURT. *JB
Service brakes, Hydraulic, Apr 17, 2006
BRAKES FAILED 3 TIMES. LAST TIME PEDAL WENT TO FLOOR AND I WENT THROUGH STOP SIGN. ALSO HAD THROTTLE STICKING. AFTER PEDAL SINKS TO FLOOR & YOU TRY A SECOND ATTEMPT THEN IT WORKS FINE. TRUCK HAS BEEN AT DEALERSHIP SINCE FEBRUARY 10, 2006 & IS STILL THERE TODAY APRIL 17, 2006. FORD REFUSES TO ACKNOWLEDGE OR REPAIR PROBLEM. FORD TOLD ME TO DRIVE IT UNTIL IT HAPPENS AGAIN AND NOTIFY THEM. VEHICLE IS NOT DRIVABLE IN IT'S CURRENT CONDITION. *NM
Service brakes, Hydraulic, Vehicle speed control, Apr 14, 2006, crash
DT*: THE CONTACT STATED WHILE DRIVING 10 MPH THE BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE ACCELERATED FORWARD CRASHING INTO ANOTHER VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE PROBLEM COULD NOT BE DUPLICATED. NO POLICE REPORT WAS FILED HOWEVER; A REPRESENTATIVE FROM THE DMV FILED A REPORT. UPDATE 5/2/2006 - *NM
Structure, Apr 13, 2006
FORD F-150 DEVELOPED SEVERE CHASSIS SHUDDER AT 60 MPH ON FREEWAY. EXITED FREEWAY AND SHUDDER DID NOT CONTINUE WHEN TRAVEL RESUMED. *NM
Service brakes, Hydraulic, Apr 6, 2006
I HAVE NOT HAD A FAILURE AT THIS TIME. THE PROBLEM IS THE BRAKES ON MY 2005 F-150. THE PEDAL HAS ALWAYS BEEN MUSHY AND ENGAGES THE BRAKES AT DIFFERENT LEVELS WHEN APPLIED, I NEVER WHERE THE BRAKING WILL BEGIN. SOME TIMES IF I AM PARKING A TRAILER WHERE THE BRAKES ARE USED A LOT THE PEDAL WILL BE ALMOST TO THE FLOOR. I DID ALMOST BACK INTO A CAR WHEN PARKING BECAUSE THE BRAKES DIDN'T ENGAGE UNTIL PEDAL WAS QUITE LOW. *NM
Parking brake, Apr 4, 2006
PURCHASED MY FORD F - 150 [XXX]) ON AUGUST 18, 2005. ON SEPTEMBER 17TH, 2005, WAS TOWING A CARGO TRAILER OF FURNITURE AND OTHER ITEMS AND WENT TO UNLOAD SOME OF THE THINGS AT THE FIRST STOP. I SET THE PARKING BRAKE ON THE VEHICLE SINCE I HAD BACKED UP A DRIVEWAY AND WAS PARKED ON AN INCLINE. UPON UNLOADING CERTAIN ITEMS AT THE FIRST STOP, I PULLED THE RELEASE LEVER ON THE PARKING BRAKE AND PROCEEDED TO THE NEXT STOP, ABOUT 10 MILES AWAY. WHILE ON THE WAY, I NOTICED A SHIMMY TO THE TRUCK AND ACTUALLY PULLED OFF TO THE SIDE OF THE ROAD TO SEE IF I HAD A FLAT TIRE OR SOME OTHER PROBLEM WITH EITHER THE TRUCK OR THE TRAILER I WAS TOWING. I DID NOT SEE ANYTHING OBVIOUS AND CONTINUED TO MY DESTINATION. WHILE BACKING THE TRUCK AND TRAILER INTO THE DRIVEWAY AT THE NEXT PLACE, I NOTICED THE REAR WHEEL ON THE DRIVER'S SIDE ONLY, WAS SMOKING. THE WHEEL WAS TOO HOT TO TOUCH AND HAD THE SMELL OF BURNT BRAKE LINING. AFTER CONTINUING ON MY TRIP ABOUT AN HOUR LATER, THE PROBLEM SEEMED TO HAVE RESOLVED ITSELF. AFTER THAT, I HAVE NOT USED THE PARKING BRAKE SINCE. I NOTICED A SLIGHT SHAKING IN THE STEERING WHEEL SINCE THE INITIAL INCIDENT THAT OCCURS WHEN BRAKING. THE SHAKING DOES NOT OCCUR ALL THE TIME, BUT SEEMS TO MORE PROMINENT DURING GRADUAL BRAKING. I BROUGHT THE VEHICLE IN FOR INSPECTION AT A FORD DEALER ON FEBRUARY 1, 2006 TO HAVE THE BRAKES LOOKED AT. THEY SAID EVERYTHING LOOKED NORMAL. NO ANOMALIES WERE NOTED. WHEN THEY TEST DROVE THE VEHICLE, THEY DID NOT NOTICE A SHIMMY OR SHAKING IN THE STEERING WHEEL DURING BRAKING. SINCE THEN, THE SHIMMY OR SHAKING IN THE STEERING WHEEL HAS BECOME MORE PRONOUNCED WHEN BRAKING AND I AM BETTER ABLE TO TELL WHEN THIS WILL OCCUR. *JB UPDATED 07/16/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Apr 2, 2006
JERKING AND BUMPING NOISE IN DRIVE LINE AT LIGHT ACCELERATION JUST BEFORE OR JUST AFTER TRANSMISSION SHIFTS TO THE NEXT GEAR. DEALER ADDED A GEAR FLUID ADDITIVE THAT THEY SAID WAS LEFT OUT AT FACTORY. THIS DID NOT FIX THE PROBLEM. *NM