2006 Ford F-150
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 589 owner complaints filed for this model year. This is the 6th highest complaint count among 26 F-150 model years with reports.
Of the 2006 reports, 58 involved a crash and 18 involved a fire. 42 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Visibility, windshield wiper/washer, motorNov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Campaign 05V520000 on NHTSA.gov
Representative owner complaints: electrical system
61 reports, newest first. Show all
Electrical system, Sep 5, 2014
THE ELECTRIC WINDOWS AND DOOR LOCKS AND MIRROR ADJUSTMENTS ALL STOPPED WORKING ON MY 2006 F150. AFTER DOING SOME LOOKING I FOUND THAT THE WIRE HARNESS THAT RUNS TO THE DOOR HAS MOST OF THE WIRES BROKEN OR BREAKING IN HALF THUS LEAVING BARE WIRES EXPOSED AND A POSSIBLE FIRE HAZARD THE WAY IT LOOKS TO ME. *TR
Electrical system, Other or unspecified, Engine, Sep 1, 2014
WENT TO STOP FOR TRAFFIC LIGHT APPLIED THE BRAKES AND VEHICLE TOOK OFF///////SLAMMED ON BRAKES TO TRY TO STOP AND SLAMMED IN PARK .CAME WITH IN INCHES OF CRASHING INTO CAR IN FRONT OF ME. TODAY IS SEPT.1ST HAVE NOT DRIVEN TRUCK AGAIN////// CALL FORD CORP. THEY WILL NOT PAY TO CHECK OUT TRUCK. AT 3100 MILES HAD TO REPLACE TIRES. ORIG. HAD DRY ROT,,,,,, *TR
Electrical system, Jun 2, 2014
ALL THE GAUGES IN MY TRUCK STOPPED WORKING. FIRST THE SPEEDOMETER THEN ALL THE GAUGES. AT FIRST THEY JUST FLUCTUATED THEN THEY ALL STOPPED. THEN THE LIGHTS STARTED FLASHING ON AND OFF INSIDE THE VEHICLE. THEN THE FUEL SENSOR WARNING STARTED BEEPING FOLLOWED BY THE SEATBELT BEEPER. OCCASIONALLY THE ENTIRE DASH GOES BLANK FOLLOWED BY A TEST SCREEN ON THE DASH. ALL INTERIOR ELECTRICAL SYSTEMS SHUT OFF FOR ABOUT TWO TO THREE SECONDS THEN COME BACK ON WHILE DRIVING. VERY WORRIED THAT THE VEHICLE WILL JUST STOP WHILE DRIVING. *TR
Fuel system, Gasoline, Electrical system, Engine, Jan 23, 2014
WENT TO START TRUCK AND ENGINE WOULD CRANK BUT WOULD NOT FIRE. I TRIED THE STARTING FLUID TEST TO SEE IF IT WAS AN IGNITION PROBLEM OR FUEL PROBLEM. GAVE A LITTLE SHOT OF STARTING FLUID INTO THE INTAKE AND THEN TRIED TO START. MOTOR ACTED LIKE IT WAS GOING TO START BUT NEVER STARTED BEINGS I DIDN'T GIVE IT ENOUGH STARTING FLUID TO START BECAUSE I'M NOT A FAN OF USING IT. WITH THAT I ELIMINATED THE IGNITION HAD TO BE FUEL. I GOT ON THE INTERNET AND SEARCHED NO START PROBLEM FOR 2006 F-150 AND FOUND A YOU TUBE VIDEO OF THE FUEL PUMP CONTROL MODULE RUSTING OUT. WENT OUT AND DROPPED SPARE TIRE AND TOOK THE CONTROL MODULE OFF THE CROSS MEMBER AND NOTICED THE HOLE CORRODED THROUGH THE HOUSING JUST LIKE THE VIDEO. I GOT THE UPGRADED PART FROM A FORD DEALER FOR $163 AND INSTALLED. RUNS FINE NOW. MY BIGGEST COMPLAINT IS FORD KNOWS THERE'S A PROBLEM SINCE THE HAVE CAME OUT WITH AN UPGRADED CONTROL MODULE SO WHY ISN'T THIS A RECALL? I LIVE IN A STATE THAT TEMPERATURES IN THE WINTER MONTHS CAN BE BELOW 0 DEGREES FAHRENHEIT AND DRIVE AN HOUR ONE WAY TO WORK, THIS COULD HAVE HAPPENED WHEN I WAS ON THE ROAD IN EXTREME COLD, COULD OF HAD MY TWO CHILDREN WITH ME BROKE DOWN ON THE SIDE OF THE ROAD AND COLD OUT. LUCKILY IT HAPPENED AT HOME BUT STILL IT WAS 4 DEGREES OUT AND LAYING UNDER MY TRUCK TAKING THE MODULE OFF WAS NOT VERY PLEASANT. THINK THIS IS SOMETHING THAT FORD NEEDS TO DO SOMETHING ABOUT. *TR
Electrical system, Engine, Sep 20, 2013
WHILE APPROACHING A STOP THE TRUCK GAUGES STARTED GOING CRAZY. TRUCK STALLED BUT RESTARTED WITH GAUGES STILL ACTING CRAZY. ALL GAUGES WOULD BOTTOM OUT AND COME BACK UP AND RADIO WAS TURNING ON AND OFF. REPLACED BATTERY BUT ONLY STALLING ISSUE WAS RESOLVED. TOOK TO LOCAL FORD DEALER BUT SINCE THE TRUCK ONLY DOES THIS RANDOMLY, THEY WERE NOT ABLE TO DIAGNOSE THE PROBLEM. TRUCK RUNS PERFECTLY BUT GAUGES AND RADIO STILL GO ON AND OFF MAKING IT EXTREMELY ANNOYING TO DRIVE. VERY FRUSTRATING TO KNOW THAT SO MANY OTHER FORD OWNERS HAVE THE SAME PROBLEM BUT NO SOLUTION HAS BEEN OFFERED FROM FORD. *TR
Electrical system, May 29, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE INSTRUMENT CLUSTER SHUT OFF WHENEVER THE TEMPERATURE WAS ABOVE 70 DEGREES. THE CONTACT MENTIONED THAT IT WOULD RETURN TO NORMAL ONCE THE TEMPERATURE WAS COOLER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE INSTRUMENT CLUSTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 114,000. *TR
Electrical system, May 7, 2013
THE LED DISPLAY THAT INDICATES THE MILEAGE, GEAR SELECTOR AND WARNING INDICATOR IS NO LONGER OPERABLE. FROM A QUICK WEB SEARCH AND A DISCUSSION WITH THE LOCAL FORD SERVICE DEPARTMENT THIS IS A KNOWN ISSUE THAT IS NOT CURRENTLY COVERED BY A RECALL. INABILITY TO VIEW MILEAGE AND WARNING INDICATORS RESULTS IN UNSAFE DRIVING CONDITIONS. *TR
Electrical system, Engine, Fuel/propulsion system, Mar 19, 2013
2006 FORD F-150 HARLEY DAVIDSON HAS COIL MISFIRE PROBLEM. ALL EIGHT COILS HAVE BEEN REPLACED IN THE LAST 24 MONTHS AND THREE HAVE BEEN REPLACED TWICE. CAT CONVERTER HAS BEEN REPLACED TWICE IN THE SAME TIME PERIOD. ALL PLUGS HAVE BEEN REPLACED. THE CAR CONTINUES TO MISFIRE. AS A RESULT, THE VEHICLE HAS AN EXTREMELY STRONG ODOR OF FUEL RESONATING. THE DEALER STATES THAT THEY CANNOT DO ANYTHING TO FIND THE ROOT OF THE PROBLEM. THIS VEHICLE IS DEALER SERVICED. *TR
Steering, Electrical system, Engine, Jan 9, 2013
WHILE APPROACHING AN INTERSECTION, ABOUT TO MAKE A RIGHT AT THE LIGHT, (I WAS DRIVING ABOUT 20MPH) ON 12/24/12 (WITH MY TWO CHILDREN AND HUSBAND IN THE TRUCK) THE VEHICLE BEEPS AND IT DISPLAYS "ENGINE SAFE MODE...LOW OIL PRESSURE" THEN THE POWER STEERING CUTS OFF AND THE WHOLE VEHICLE SHUT DOWN! I AM FRANTIC AT THIS POINT BECAUSE I HAVE NO CLUE WHAT IS GOING ON! I WAS IN THE MIDDLE OF TRAFFIC AND HAD TO CUT THE CAR OFF AND CRANK IT UP AGAIN. LUCKILY I DIDN'T GET REAR ENDED OR IN AN ACCIDENT. THAT SAME DAY I WENT AND GOT MY OIL CHANGE BECAUSE IT WAS OVER DUE. WELL ON 1/4/13 THE SAME THING HAPPENS AS I AM TURNING INTO THE PARKING LOT OF MCDONALD'S. I GET THE SAME ERROR MESSAGE AS BEFORE, THE STEERING WHEEL LOCKS UP, AND TRUCK CUTS OFF! THIS SO EXTREMELY DANGEROUS. I LOOKED THIS ISSUE UP ONLINE AND SEE THAT IT APPEARS TO BE A COMMON ISSUE WITH THE 2006 F-150 AND THE EXPEDITION. MY BOTHER-IN-LAW, WHO ALSO HAS A SIMILAR F-150 TO OURS, SAID THE SAME THING HAS HAPPENED TO HIM TWICE. *TR
Electrical system, Visibility, Jan 3, 2013
THE DRIVER'S SIDE WINDOW REGULATOR ON MY 2006 FORD F150 HAS BROKEN THREE TIMES, I WAS ABLE TO GET TWO REPLACED UNDER WARRANTY, BUT THE THIRD TIME HAPPENED THIS LAST MONTH, I AM REPLACING IT TODAY. I BELIEVE FROM MY EXPERIENCE, AND FROM THOUSANDS OF FORUM ENTRIES CITING THE SAME THING, THAT FORD SHOULD RECALL THIS PART. THIS PART IS GOING TO COST ME APPROXIMATELY $400.00 TO REPAIR. *TR
Electrical system, Sep 26, 2012
ABS SENSOR SHORTED OUT AND FUSED TO WIRE HARNESS FOR WHOLE ELECTRICAL SYSTEM, FORD CLAIMS NO RECALL, COULD HAVE CAUSED MAJOR FIRE, NOTED COMPLAINT #10195595 WAS VERY SIMILAR. CAUSED $2300 DOLLAR REPAIR. *TR
Electrical system, Air bags, Jul 5, 2012
I WAS DRIVING ON THE HIGHWAY WHEN ALL OF MY GAUGES WENT DEAD INCLUDING THE SPEEDOMETER, A COUPLE OF MINUTES LATER THEY CAME BACK ON AND WHEN THEY DID THE AIRBAG WARNING LIGHT STARTED BLINKING RAPIDLY. A FEW MOMENTS LATER THE GAUGES WENT DEAD AGAIN, WHEN THEY CAME BACK ON THE SECOND TIME THE AIRBAG WARNING LIGHT STARTED BLINKING RAPIDLY AND ERRATICALLY. SINCE THAT TIME MY GAUGES HAVE FAILED 3 MORE TIMES WITH THE SAME BEHAVIOR FROM THE AIRBAG WARNING LIGHT. I DID SOME RESEARCH ONLINE AND FOUND THAT EVEN THOUGH FORD HAS NOT RECALLED THIS PROBLEM IT HAS BEEN EXPERIENCED BY HUNDREDS OF 2006 FORD F150 OWNERS. *TR
Electrical system, Visibility, Jun 2, 2012
THE PASSENGER IN MY VEHICLE TRIED ROLLING UP THE WINDOW WHILE AT A STOPLIGHT AND IT WOULD NOT GO UP. THE WINDOW SWITCH WILL WORK TO ROLL THE WINDOW DOWN BUT NOT TO ROLL IT UP. AFTER APPROXIMATELY 11 MONTHS THE DRIVERS SIDE WINDOW IS DOING THE SAME THING, WILL GO DOWN BUT NOT UP. WITH THE WINDOW STUCK IN THE DOWN POSITION, MY VEHICLE IS NOW EXPOSED TO THE ELEMENTS, RAIN PARTICULARLY, AND I FEAR THE WATER FROM THE RAIN IS GOING TO AFFECT THE REST OF MY DOOR SWITCHES, AND POSSIBLY RUIN THE LEATHER SEATS AND THE POWER FUNCTIONS FOR MY SEATS AS WELL. IT IS A DISTRACTION AND A HAZARD TO HAVE TO DRIVE WITH THE WINDOW DOWN CONSTANTLY. *TR
Electrical system, Dec 28, 2011
TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH AND NOTICED THE INSTRUMENT PANEL LED LIGHT FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO ADVISED THE CONTACT THAT THE INSTRUMENT PANEL CLUSTER WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE MALFUNCTION. THE APPROXIMATE FAILURE MILEAGE WAS 23,000. UPDATED 02/08/12
Electrical system, Dec 19, 2011
UNDER NORMAL OPERATION THE GAS PEDAL STOPS RESPONDING,THE CHECK ENGINE LIGHT COMES ON AND AFTER ABOUT 30 SECONDS THE ENGINE SHUTS OFF. I HAVE TO STOP , PUT THE TRUCK IN PARK , TURN OFF THE KEY AND RESTART THE TRUCK. THIS RESETS THE COMPUTER AND THE TRUCK SEEMS FINE FOR A WHILE TILL IT HAPPENS AGAIN. THIS HAS HAPPENED SEVERAL TIMES MOSTLY ON BACK ROADS. TODAY IT HAPPENED WHILE I WAS ENTERING A BUSY HIGHWAY. I WAS ALMOST HIT BY ON COMING TRAFFIC. *TR
Engine and engine cooling, Electrical system, Oct 30, 2011
SPARK PLUGS ARE ENGINEERED COUNTER SUNK IN HOLES IN TOP OF THE HEADS, WHEN THE PLUGS ARE UNSCREWED THE BOTTOM OF THE PLUG MORE OFTEN THAN NOT BREAKS OFF INSIDE THE SPARK PLUG HOLE. THIS REQUIRES VERY EXPENSIVE TOOLS AND A SKILLED MECHANIC TO EXTRACT. I FEEL THE PART WAS ENGINEERED TO FAIL TO FORCE THE PRICE OF REPAIRS UP. LEADING UP TO THIS WHEN THE PLUGS BEGIN TO FAIL THE ENGINE WILL FAIL WITHOUT WARNING AND WITHOUT THE ENGINE NEEDS SERVICE LIGHT EVER COMING ON. WHEN THIS HAPPENS AND THEIR IS NO PLACE TO PULL OVER YOU HOPE YOUR NOT RAN INTO BY ONCOMING TRAFFIC. *TR
Electrical system, Interior lighting, Mar 9, 2011
LIGHT BULB INSIDE THE AUTOMATIC SHIFTER CAME LOOSE AND WAS INSIDE CONSOLE, WHEN I TURNED ON MY LIGHTS, I SMELLED PLASTIC BURNING THE LIGHT BULB BURNED A HOLE THROUGH THE SIDE OF THE CONSOLE WHICH IN TURN BURNED MY HAND, FORD DEALERSHIP REMOVED LIGHTBULB, BUT WAS INSISTING I PAY APPROX.$900.00 FOR REPAIRS, WHICH I REFUSE TO DO. *TR
Electrical system, Feb 20, 2011
ODOMETER FLASH THEN QUITS WORKING ALL INFO THE IS IN THAT INFO CENTER WON'T WORK. *TR
Electrical system, Feb 19, 2011
ODOMETER DOES WORK. *TR
Electrical system, Jul 30, 2010
TL*THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT THE LED DISPLAY FOR THE ODOMETER MALFUNCTIONED INTERMITTENTLY. FORD STATED THAT WOULD REPAIR THE VEHICLE FOR $500. THE CONTACT WAS CONCERNED ABOUT THE SAFETY RISK. THE FAILURE MILEAGE WAS APPROXIMATELY 62,000.
Electrical system, Aug 4, 2009, fire
MY 2006 FORD F 150 WITH A 4.6 LT V-8 FACTORY INSTALLED SPARK PLUG CAME OUT DAMAGING THE IGNITION COIL AND STARTING A SMALL FIRE. *TR
Electrical system, Dec 28, 2008
2006 F150 4X4 LARIAT, 7557 MILES. IN COLD TEMPERATURE BACKUP SENSOR SOUNDS ALARM AS IF OBSTRUCTION IS CLOSE WHEN THERE IS NONE. TOOK TO LOCAL DEALER AND SALES SAID THIS IS NORMAL FOR THIS MODEL. AM WAITING FOR SERVICE TO SCHEDULE APPOINTMENT AS TRUCK ONLY HAS A FEW MONTHS LEFT OF WARRANTY. TRUCK IS ONLY DRIVEN IN WINTER AND THIS IS FIRST TIME IN 3 YEARS THIS HAS HAPPENED. *TR
Electrical system, Service brakes, Electric, Dec 1, 2008, fire
FORD F-150 WOULD NOT SHUT OFF, REMOVED FUSE TO FUEL PUMP. FOUND ENERGY TO OTHER COMPONENTS NOT ON. REMOVED NEGATIVE BATTERY TERMINAL. HAD VEHICLE TOWED TO DEALER. REPORT FROM DEALER WIRE HARNESS FROM ABS SYSTEM BURNT SENDING ENERGY THROUGHOUT TRUCK. DEALER SAID TRUCK SHOULD HAVE BURNED UP. DEALER COULD NOT CONFIRM IF PROBLEM WAS WITH ABS OR HARNESS. *TR
Electrical system, Oct 7, 2008
ODOMETER STARTED BLINKING AND JUST QUICK WORKING, DEALER DOES NOT RECOGNIZE A RECALL FOR A ELECTRONIC FAILURE. IT SEEMS NUMEROUS FORD VEHICLES HAVE THE SAME ISSUE. DEALER WANT TO REPLACE THE ENTIRE CLUSTER FOR A SMALL FEE OF 700.00. FORD KNOWS IT IS A ISSUE BUT DOES NOT RECOGNIZE THE PROBLEM. *TR
Electrical system, Jul 23, 2008, crash
HORN DIDN'T BLOW LOUD ENOUGH AND I HIT A GRASSHOPPER. TOOK THE GRASSHOPPER TO THE EMERGENCY VET CLINIC FOR STITCHES. THIS COST ME 110 DOLLARS. *TR