2006 Ford F-150
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 589 owner complaints filed for this model year. This is the 6th highest complaint count among 26 F-150 model years with reports.
Of the 2006 reports, 58 involved a crash and 18 involved a fire. 42 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Visibility, windshield wiper/washer, motorNov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Campaign 05V520000 on NHTSA.gov
Representative owner complaints
589 reports, newest first.
Power train, Jun 10, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE SHIFTED OUT OF GEAR WHILE AT A STOP AND THEN LUNGED FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE TRANSMISSION HAD DEVELOPED A PLANETARY NOISE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE WAS REPORTED TO THE MANUFACTURER. THE FAILURE MILEAGE WAS 24,000. THE CURRENT MILEAGE WAS 35,800.
Electrical system, May 29, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE INSTRUMENT CLUSTER SHUT OFF WHENEVER THE TEMPERATURE WAS ABOVE 70 DEGREES. THE CONTACT MENTIONED THAT IT WOULD RETURN TO NORMAL ONCE THE TEMPERATURE WAS COOLER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE INSTRUMENT CLUSTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 114,000. *TR
Engine, May 10, 2013
WHILE REPLACING THE SPARK PLUGS, EVERY PLUG BROKE OFF AND WAS VERY DIFFICULT TO REMOVE. MY MECHANIC GOT OUT THE FIRST SEVEN, BUT THE EIGHTH WOULD NOT COME OUT. IT SUBSEQUENTLY FELL INTO MY ENGINE, CAUSING IT TO SEIZE. I SHOULD HAVE GOTTEN ANOTHER 100,000 MILES OUT OF THIS TRUCK! *TR
Electrical system, May 7, 2013
THE LED DISPLAY THAT INDICATES THE MILEAGE, GEAR SELECTOR AND WARNING INDICATOR IS NO LONGER OPERABLE. FROM A QUICK WEB SEARCH AND A DISCUSSION WITH THE LOCAL FORD SERVICE DEPARTMENT THIS IS A KNOWN ISSUE THAT IS NOT CURRENTLY COVERED BY A RECALL. INABILITY TO VIEW MILEAGE AND WARNING INDICATORS RESULTS IN UNSAFE DRIVING CONDITIONS. *TR
Fuel/propulsion system, May 3, 2013
DRIVING EAST ON I90 (ABOUT 20 MILES WEST OF STEWARTVILLE, MN) DURING FREAK MAY BLIZZARD. DUE TO ROAD CONDITIONS, COULD ONLY DRIVE BETWEEN 15-40 MPH. SUDDENLY THE ENGINE STOPPED RUNNING. I WAS ABLE TO START IT UP AGAIN AND DRIVE ABOUT 3 MINUTES AND THEN IT WOULD DIE AGAIN. THERE WAS NO PLACE TO PULL OVER, AS THE SHOULDERS OF THE ROAD WERE NOT CLEARED AND THERE WAS 12" OF WET HEAVY SNOW. MY TRUCK IS NOT 4WD SO WE WOULD HAVE GOTTEN STUCK. WE HAD TO DRIVE WITH THE HAZARDS ON, BUT IT WAS LOW VISIBILITY AND WE COULD EASILY HAVE BEEN HIT FROM BEHIND. WE COULD NOT GET OFF ON THE EXIT RAMP BECAUSE A SEMI TRUCK JACKNIFED AND THE EXIT WAS CLOSED. WE HAD TO CONTINUE THIS HAZARDOUS JOURNEY TO THE NEXT EXIT, WHICH WAS ABOUT 12 MILES AWAY, TO STEWARTVILLE, MN. WE FOUND A AUTO REPAIR SHOP AND DESCRIBED THE PROBLEM. THE MECHANIC SUSPECTED IMMEDIATELY THAT IT WAS THE FUEL PUMP CONTROL MODULE. HE SAID THAT HE HAS BEEN INSTALLING A LOT OF THESE LATELY ON F150S, ESPECIALLY 2006'S. HE SAID HE FELT THERE SHOULD BE A RECALL, AS IT IS WELL-KNOWN AMONG MECHANICS THAT THESE ARE FAILING AT AN ALARMING RATE. THE PROBLEM IS THAT THE MODULE IS LOCATED TIGHT AGAINST THE FRAME, NEXT TO THE SPARE TIRE, AND THE METAL OF THE MODULE (ALUMINUM) REACTS ADVERSELY WITH THE STEEL METAL OF THE FRAME, CAUSING OXIDATION BETWEEN THE TWO. THIS CAUSES THE MODULE TO BREAK AND FAIL, THUS SHORTING OUT THE CIRCUIT BOARD. FORD KNOWS THAT THIS IS A PROBLEM, AS THE REPLACEMENT PARTS HAVE SPACER PLATES TO KEEP THE MODULE & FRAME SEPARATED. FORD SHOULD ISSUE A RECALL ON THIS PART BEFORE SOMEONE GETS KILLED. WE COULD EASILY HAVE BEEN KILLED, AS WE COULD NOT PULL OFF THE INTERSTATE. THE PART IS RELATIVELY INEXPENSIVE (WE PAID $189 FOR THE PART). WE SHOULD HAVE BEEN NOTIFIED OF THIS ISSUE. *TR
Fuel/propulsion system, Apr 25, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE REVERSING AT 3 MPH, THE VEHICLE STALLED AND WOULD NOT RESTART. AN INDEPENDENT MECHANIC DIAGNOSED THE VEHICLE AS HAVING A FAULTY FUEL PUMP AND/OR FAULTY FUEL DRIVER MODULE. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 103,000.
Air bags, Seat belts, Apr 22, 2013, crash
A DEER RAN OUT IN FRONT OF VEHICLE..ROAD WET AND IT WAS FOGGY..TRIED TO KEEP FROM HITTING DEER..BACK OF TRUCK FISHTAILED..LOSS CONTROL..HIT A DITCH AND EMBANKMENT...AIR BAGS DID NOT EMPLOY AND SEAT BELT DID NOT LOCK...HAD A FRACTURE IN L2 VERTEBRAE OF BACK..FORD HAS DENIED ANY FAULT IN AIR BAG OR SEAT BELT FUNCTION...TRUCK WAS TOTALED BY INSURANCE COMPANY..... *TR
Fuel/propulsion system, Apr 18, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING 44 MPH, THE VEHICLE SHOOK VIOLENTLY THEN STALLED. THE VEHICLE WAS RESTARTED AND THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TOWED TO A DEALER WHERE IT CONFIRMED THAT THE FUEL PUMP HAD FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 111,600. THE VIN WAS UNAVAILABLE.
Fuel/propulsion system, Apr 18, 2013
I WAS WARMING THE VEHICLE TO GO TO WORK, MY TRUCK JUST SUDDENLY STALLED, HAD TO GET A TOW TO THE NEAREST FORD DEALER, THE MECHANIC SAID THE FUEL PUMP MODULE UNIT WENT OUT, THE PART IS ON BACK ORDER OR EMERGENCY ORDER, I HAVE NO VEHICLE TO GET TO WORK, I NEED MY VEHICLE, THIS PART SHOULD BE ON RECALL FOR FORD F150. *TR
Service brakes, Apr 1, 2013
DRIVING VEHICLE DRIVE AND OVERDRIVE WENT OUT THIS IS TWO TIMES THIS HAPPENED FORD NEEDS TO PAY FOR REPAIRS OTHER PEOPLE HAVE SAME PROBLEM THIS PROBLEM SHOULD BE LOOKED INTO. *TR
Power train, Mar 25, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH WITH THE CRUISE CONTROL ACTIVATED, THE ENGINE RPMS INCREASED AND THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN ADVISED THE CONTACT THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. *TR
Fuel/propulsion system, Mar 22, 2013
FUEL PUMP MODULE, ENOUGH SAID FORD. TIME TO MAKE A RECALL. NO RECALL BUT THERE'S AN UPDATE TO MOUNT IT ON STUDS...THINK THERE'S AN ISSUE? *TR
Fuel/propulsion system, Mar 22, 2013
I RECENTLY PURCHASED THIS VEHICLE USED BUT THE BODY WAS IN GREAT CONDITION AND IT RAN GOOD ON THE TEST DRIVE. AFTER THREE DAYS I NOTICED A FUEL SMELL IN THE CAB AND WHEN OVERTAKING A VEHICLE IT STARTED MISS FIRE. FORTUNATELY THE DEALER I BOUGHT IT FROM HAD ME TAKE IT TO THE MECHANIC HERE IN TOWN WHO SAID THAT IT WAS THE NUMBER FIVE IGNITION COIL WHICH HE REPLACED. THE NEXT DAY THE PROBLEM CONTINUED SO I TOOK IT BACK AND IT WAS THE SPARK PLUGS WHICH HE REPLACED (400.00) BUT IT RAN WELL. I DROVE IT TO PA. AND BACK WITH NO PROBLEM BUT YESTERDAY THE SAME PROBLEM HAPPENED AND NOW IT IS COIL NUMBER 2 (73.00). THE MECHANIC WHO HAS BEEN IN BUSINESS FOR 28 YEARS IN OUR FARM TOWN IN WHICH HE SERVICES NUMEROUS FORD TRUCKS SAID THAT THIS IS A SERIOUS PROBLEM WITH FORDS FROM THE COILS TO THE ILL DESIGNED SPARK PLUGS. NOW THAT I HAVE READ THE NUMEROUS COMPLAINTS WHICH ARE SYNONYMOUS WITH MY PROBLEM INCLUDING THE FUEL SMELL MAKES ME WONDER IF THE NHTSA IS ON THE TAKE FROM FORD TO OVERLOOK CERTAIN PROBLEMS. I THINK THAT I WILL USE SOME OF MY WELL CONNECTED FRIENDS IN CONGRESS TO LOOK INTO THIS IF I DO NOT GET A SATISFACTORY ANSWER TO THIS ISSUE. *TR
Electrical system, Engine, Fuel/propulsion system, Mar 19, 2013
2006 FORD F-150 HARLEY DAVIDSON HAS COIL MISFIRE PROBLEM. ALL EIGHT COILS HAVE BEEN REPLACED IN THE LAST 24 MONTHS AND THREE HAVE BEEN REPLACED TWICE. CAT CONVERTER HAS BEEN REPLACED TWICE IN THE SAME TIME PERIOD. ALL PLUGS HAVE BEEN REPLACED. THE CAR CONTINUES TO MISFIRE. AS A RESULT, THE VEHICLE HAS AN EXTREMELY STRONG ODOR OF FUEL RESONATING. THE DEALER STATES THAT THEY CANNOT DO ANYTHING TO FIND THE ROOT OF THE PROBLEM. THIS VEHICLE IS DEALER SERVICED. *TR
Engine, Mar 15, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE BRAKING TO A STOP, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE FAILURE COULD NOT BE REPLICATED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 127,000. THE VIN WAS UNAVAILABLE.
Vehicle speed control, Mar 12, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE REVERSING, THE ENGINE RPMS INCREASED EXCESSIVELY AND THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNABLE TO BE REPLICATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 34,000 AND CURRENT MILEAGE WAS 38,500. *TR UPDATED 5/7/13 *CN
Air bags, Feb 28, 2013, crash
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED HEAD-ON INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 76,624.
Engine, Feb 7, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING 50 MPH, THERE WAS A LOUD BEEP AND THE SAFE MODE SIGNAL ILLUMINATED THEN THE VEHICLE STALLED. THE VEHICLE WAS MERGED TO THE SHOULDER AND AFTER WAITING FOR ABOUT 15 MINUTES, THE VEHICLE WAS ABLE TO BE RESTARTED. THE VEHICLE HAD NOT BEEN INSPECTED. THE FAILURE AND CURRENT MILEAGES WERE 50,100.
Fuel/propulsion system, Jan 28, 2013
TRUCK KEEPS SHUTTING OFF. IF YOU WAIT 45 MINUTES TO RESTART IT WILL START AND IDLE FOR ABOUT 15 SECONDS AND SLOWLY DIE. OR YOU CAN DRIVE A SHORT DISTANCE AND IT WILL DIE. REPAIR IS FOR THE FUEL PUMP CONTROL MODULE. BECAUSE OF WHERE IT IS MOUNTED ON THE TRUCK IT CORRODES VERY FAST ESPECIALLY IN SNOW STATES DUE TO THE SALT ON ROADWAYS. FORD CAN YOU PLEASE DO A RECALL OF THIS PART AND REIMBURSE US FOR THE COST! *TR
Steering, Power train, Wheels, Jan 22, 2013
MY 2006 FORD F150 HAS THE POSITRACTION REAR END. ITS WENT OUT AROUND 25000 TO 30000 MILES, WHILE THE TRUCK WAS STILL UNDER WARRANTY AND THE DEALER FIXED IT NO CHARGE. NOW THE TRUCK HAS A LITTLE OVER 62000 MILES AND THE REAR END HAS GONE OUT AGAIN. ALMOST EXACTLY THE SAME AMOUNT OF MILES ON THE REAR END. WARRANTY WAS UP AT 60000 MILES SO ITS NO LONGER COVERED. I THINK THIS SHOULD BE LOOKED INTO AS A RECALL BECAUSE THIS IS THE SECOND TIME ITS HAPPENED ON THE SAME TRUCK. *TR
Engine, Jan 18, 2013
WHILE TURNING TRUCK STARTED TO EMIT NOISES, SOUNDED LIKE AN EXHAUST PROBLEM, MANIFOLD ETC. NO SERVICE ENGINE LIGHT ON AND ALL GAUGES WERE NORMAL. THEN WHILE DRIVING, AS TRUCK SHIFTED DOWN TO OVERDRIVE, NOISE RETURNED, LOSS OF POWER, BUT AGAIN NO SERVICE ENGINE LIGHT, GAUGES ALL NORMAL. TOOK VEHICLE TO DEALER, HAVE BEEN TOLD, ENGINE NEEDS TO BE REPLACED,(81,250 MILES/130,000KM) FOR A MEAGER $6000. VEHICLE HAS BEEN DEALER MAINTAINED SINCE NEW, OIL CHANGED EVERY 3125, MILES/5000KM (BY DEALER) STILL NO SERVICE ENGINE LIGHT, GAUGES STILL READING NORMAL. MANUFACTURER WILL DO NOTHING. LOOKING FOR LAWYER WHO WOULD LIKE TO START CLASS ACTION SUIT AGAINST MANUFACTURER, CONSIDERING ALL THE ISSUES I HAVE FOUND ON THE 2006 F150 V8 TRITON SINCE STARTING RESEARCH YESTERDAY, THERE ARE A LOT OF US THAT FORD IS NOT WILLING TO ASSIST. *TR
Engine, Jan 9, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE FAILURE RECURRED FIVE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE COIL PACKS WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 6,000.
Steering, Electrical system, Engine, Jan 9, 2013
WHILE APPROACHING AN INTERSECTION, ABOUT TO MAKE A RIGHT AT THE LIGHT, (I WAS DRIVING ABOUT 20MPH) ON 12/24/12 (WITH MY TWO CHILDREN AND HUSBAND IN THE TRUCK) THE VEHICLE BEEPS AND IT DISPLAYS "ENGINE SAFE MODE...LOW OIL PRESSURE" THEN THE POWER STEERING CUTS OFF AND THE WHOLE VEHICLE SHUT DOWN! I AM FRANTIC AT THIS POINT BECAUSE I HAVE NO CLUE WHAT IS GOING ON! I WAS IN THE MIDDLE OF TRAFFIC AND HAD TO CUT THE CAR OFF AND CRANK IT UP AGAIN. LUCKILY I DIDN'T GET REAR ENDED OR IN AN ACCIDENT. THAT SAME DAY I WENT AND GOT MY OIL CHANGE BECAUSE IT WAS OVER DUE. WELL ON 1/4/13 THE SAME THING HAPPENS AS I AM TURNING INTO THE PARKING LOT OF MCDONALD'S. I GET THE SAME ERROR MESSAGE AS BEFORE, THE STEERING WHEEL LOCKS UP, AND TRUCK CUTS OFF! THIS SO EXTREMELY DANGEROUS. I LOOKED THIS ISSUE UP ONLINE AND SEE THAT IT APPEARS TO BE A COMMON ISSUE WITH THE 2006 F-150 AND THE EXPEDITION. MY BOTHER-IN-LAW, WHO ALSO HAS A SIMILAR F-150 TO OURS, SAID THE SAME THING HAS HAPPENED TO HIM TWICE. *TR
Fuel/propulsion system, Jan 4, 2013
2006 F-150 FUEL CONTROL MODULE SHOULD BE A MANDATORY SAFETY RECALL FOR FORD. THE 2006 F-150 HAS A POORLY DESIGNED FUEL MODULE THAT ABSOLUTELY WILL FAIL OVER TIME IN RUST BELT STATES, PRODUCING A LOSS OF POWER, INABILITY TO START OR A COMPLETE ENGINE STALL / LOSS OF CONTROL AT ANY SPEED, INCLUDING HIGHWAY SPEEDS. MY COMPLAINT STARTS AFTER THE FIRST SNOWSTORM THIS YEAR. THE TRUCK WAS SLUGGISH TO ACCELERATE ON THE HIGHWAY AND IT SEEMED TO NEED MORE GAS PEDAL JUST TO MAINTAIN SPEED. A FEW DAYS LATER I DROVE UP HEAVILY SALTED ROADS TO A SKI AREA. AT THE END OF THE DAY, THE TRUCK WOULD NOT START WITHOUT THE GAS PEDAL BEING FULLY DEPRESSED. (FIRST TIME I HAVE EVER HAD TO USE THE GAS PEDAL TO START IT.) I GOT IT RUNNING FOR ABOUT 2 MINUTES, THEN IT STALLED OUT WHILE STILL IN PARK. IT TOOK SEVERAL TRIES TO RESTART IT. I FINALLY GOT IT GOING AGAIN AND IT PERFORMED OK ON THE 60 MILE HOME TRIP, SOME OF THAT AT INTERSTATE SPEEDS. THE NEXT DAY THE TRUCK WOULD NOT START AT ALL. IT WOULD CRANK, BUT NOT TURN OVER. THE SHOP I TOOK IT TO DID THE DIAGNOSIS AND IT TURNED OUT THAT IT WAS NOT BAD GAS OR A CLOGGED FUEL LINE. IT WAS A FAULTY FUEL CONTROL MODULE LOCATED ABOVE THE SPARE TIRE. THIS MODULE IS FLAWED NOT ONLY IN DESIGN BUT IN PLACEMENT AS WELL. IT IS NOT WEATHERPROOF AND NOT EVEN THE RIGHT TYPE OF METAL TO BE EXPOSED TO SALT, SAND AND WATER. IT HAS DISSIMILAR METAL FROM THE TRUSS IT MOUNTS TO, DISINTEGRATED OVER TIME AND I ALSO QUESTION FORD'S SUPPOSED FIX TO THE PROBLEM (SPACERS). HTTP://WWW.YOUTUBE.COM/WATCH?V=_2E9KMF1_KG IT SHOULD BE COMPLETELY REDESIGNED WITH YEARS OF RUST BELT ELEMENT EXPOSURE IN MIND. YOU DON'T WANT TO HAVE AN ENGINE STALL - EVER. (I WOULD HAVE PUT IT INSIDE THE CAB OR UNDER THE HOOD). WHY IS THIS NOT MORE IMPORTANT THAN A FLAWED HEADLAMP? *TR
Electrical system, Visibility, Jan 3, 2013
THE DRIVER'S SIDE WINDOW REGULATOR ON MY 2006 FORD F150 HAS BROKEN THREE TIMES, I WAS ABLE TO GET TWO REPLACED UNDER WARRANTY, BUT THE THIRD TIME HAPPENED THIS LAST MONTH, I AM REPLACING IT TODAY. I BELIEVE FROM MY EXPERIENCE, AND FROM THOUSANDS OF FORUM ENTRIES CITING THE SAME THING, THAT FORD SHOULD RECALL THIS PART. THIS PART IS GOING TO COST ME APPROXIMATELY $400.00 TO REPAIR. *TR