2006 Ford F-150
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 589 owner complaints filed for this model year. This is the 6th highest complaint count among 26 F-150 model years with reports.
Of the 2006 reports, 58 involved a crash and 18 involved a fire. 42 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Visibility, windshield wiper/washer, motorNov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Campaign 05V520000 on NHTSA.gov
Representative owner complaints
589 reports, newest first.
Engine and engine cooling, Feb 27, 2014
I TRIED TO START MY TRUCK, BUT IT WOULDN'T START. IT TURNED OVER PERFECTLY BUT WOULD NOT START. IT HAD STARTED TWICE EARLIER IN THE DAY. THE FUEL PUMP DRIVER MODULE, LOCATED ABOVE THE SPARE TIRE ON THE FRAME OF THE TRUCK, HAD CORRODED AND FAILED.
Engine, Feb 12, 2014
I BROUGHT MY TRUCK IN TO MY LOCAL FORD DEALER BECAUSE THE CHECK ENGINE LIGHT CAME ON. IT IS A 2006 F150 4.6L - AFTER HIS INSPECTION, THE MECHANIC STATED THAT THE BOTTOM OF THE #2 SPARK PLUG (MANUFACTURE INSTALLED) HAD DISINTEGRATED AND FELL INTO THE HEAD CAUSING SO MUCH DAMAGE TO THE #2 CYLINDER THAT I HAVE TO REPLACE THE ENTIRE ENGINE AT A COST OF OVER $6,000 PLUS TAX. IT WILL TAKE OVER A WEEK TO FIX AND I DO NOT HAVE ANOTHER VEHICLE. I WOULD LIKE FORD TO REIMBURSE ME FOR THE EXPENSE. I HAVE WRITTEN TO THEIR "CUSTOMER CARE"( [XXX]) DEPARTMENT, BUT HAVE HAD NO HELPFUL OR SATISFACTORY RESULTS. THIS IS A KNOWN ISSUE AS FORD HAS ISSUED A TSB AND DEVELOPED A TOOL TO ASSIST WITH THE REMOVAL OF FAULTY SPARK PLUGS. *TR
Suspension, Structure, Feb 7, 2014
THE FRAME BROKE WHERE THE FRONT DIFFERENTIAL MOUNTS, THIS LET THE FRONT AXLE TWIST AND YOU CAN NOT STEER THE TRUCK!!! I THINK THIS IS VERY DANGEROUS, IF YOU WERE GOING OVER 5 MPH. YOU COULD NOT TURN.FORD FACTORY REP. SAYS THE TRUCK IS OUT OF WARRANTY SO NOT THERE PROBLEM, THEY WILL NOT DO ANYTHING ABOUT IT. FORD SHOULD FIX THIS AT THERE EXPENSE AS THIS A SAFETY CONCERN. HOW MANY OTHER FORD PICK UPS HAVE HAD THIS SAME PROBLEM BUT NOT REPORTED IT BECAUSE THEY DID NOT HOW TO OR WHO TO COMPLAIN TO. THE NTSB SHOULD LOOK INTO THIS VERY CAREFULLY TO SEE IF THIS IS A MAJOR PROBLEM. *TR
Engine, Feb 5, 2014
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS HESITANT TO ACCELERATION. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUGS WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS UNKNOWN.
Steering, Jan 24, 2014
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH THE POWER STEERING FAILED WITHOUT WARNING. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO HER RESIDENCE. THE FAILURE WAS NOT DIAGNOSED BY A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATELY FAILURE MILEAGE WAS 154,618.
Fuel system, Gasoline, Electrical system, Engine, Jan 23, 2014
WENT TO START TRUCK AND ENGINE WOULD CRANK BUT WOULD NOT FIRE. I TRIED THE STARTING FLUID TEST TO SEE IF IT WAS AN IGNITION PROBLEM OR FUEL PROBLEM. GAVE A LITTLE SHOT OF STARTING FLUID INTO THE INTAKE AND THEN TRIED TO START. MOTOR ACTED LIKE IT WAS GOING TO START BUT NEVER STARTED BEINGS I DIDN'T GIVE IT ENOUGH STARTING FLUID TO START BECAUSE I'M NOT A FAN OF USING IT. WITH THAT I ELIMINATED THE IGNITION HAD TO BE FUEL. I GOT ON THE INTERNET AND SEARCHED NO START PROBLEM FOR 2006 F-150 AND FOUND A YOU TUBE VIDEO OF THE FUEL PUMP CONTROL MODULE RUSTING OUT. WENT OUT AND DROPPED SPARE TIRE AND TOOK THE CONTROL MODULE OFF THE CROSS MEMBER AND NOTICED THE HOLE CORRODED THROUGH THE HOUSING JUST LIKE THE VIDEO. I GOT THE UPGRADED PART FROM A FORD DEALER FOR $163 AND INSTALLED. RUNS FINE NOW. MY BIGGEST COMPLAINT IS FORD KNOWS THERE'S A PROBLEM SINCE THE HAVE CAME OUT WITH AN UPGRADED CONTROL MODULE SO WHY ISN'T THIS A RECALL? I LIVE IN A STATE THAT TEMPERATURES IN THE WINTER MONTHS CAN BE BELOW 0 DEGREES FAHRENHEIT AND DRIVE AN HOUR ONE WAY TO WORK, THIS COULD HAVE HAPPENED WHEN I WAS ON THE ROAD IN EXTREME COLD, COULD OF HAD MY TWO CHILDREN WITH ME BROKE DOWN ON THE SIDE OF THE ROAD AND COLD OUT. LUCKILY IT HAPPENED AT HOME BUT STILL IT WAS 4 DEGREES OUT AND LAYING UNDER MY TRUCK TAKING THE MODULE OFF WAS NOT VERY PLEASANT. THINK THIS IS SOMETHING THAT FORD NEEDS TO DO SOMETHING ABOUT. *TR
Tires, Wheels, Jan 20, 2014
MY FACTORY TIRES, BF GOODRICH LONG TRAIL T/A, ON MY FORD F-150 KING RANCH BOUGHT NEW IN 2006 LASTED ONLY 21,428 MILES. THEY GAVE ME A LOUSY $236. AND IT COST ME $708.TO REPLACE ALL 4. NOW, 18,270 MILES LATER THERE ARE LESS THE 4/32 LEFT ON THE TREAD. ON A RECENT OIL CHANGE, A DEALER WOULD NOT ROTATE MY TIRES BECAUSE OF THE WARE. NOW I AM BEING TOLD - SORRY NO WARRANTY LEFT! - I AM LIVID! CAN ANYTHING BE DONE? *TR
Engine, Fuel/propulsion system, Jan 15, 2014
WHEN DRIVING HOME, CHECK ENGINE LIGHT STARTED FLASHING, IMMEDIATELY STOPPED AND HAD VEHICLE TOWED TO A WELL REPUTABLE SHOP FOR DIAGNOSIS AND REPAIR. WAS DIAGNOSED WITH TWO FUEL INJECTORS FAILING AND NEEDING REPLACED ALONG WITH ALL SPARK PLUGS NEEDED REPLACED. 6 OF THE 8 PLUGS SNAPPED IN HALF AND NEEDED TO BE BURROWED OUT ON TOP OF IT COSTING $90 PER PLUG DRILLING OUT. TOTAL FOR REPAIRS CAME TO $2300. BUT AFTER REPAIRS WERE COMPLETED I STILL DO NOT HAVE A RUNNING VEHICLE. THE ENGINE STARTS BUT OIL PRESSURE DROPS AFTER 5 MINS OF RUNNING. I WOULD LOVE TO FIND A SOLUTION TO THIS, IF THIS IS COMMON OR NOT. AND IF SO, WHY IS IT NOT RECALLED? *TR
Engine, Jan 7, 2014
VEHICLE BEGAN TO SMELL LIKE GAS IN THE CAB ON NUMEROUS OCCASIONS. TOOK IT TO FORD DEALERSHIP MECHANIC AND WAS TOLD THAT THE SOURCE OF THE GAS SMELL COULD NOT BE FOUND. A FEW DAYS LATER UPON STARTING THE VEHICLE, A VERY LOUD EXPLOSIVE SOUND WAS HEARD UNDER THE HOOD. THE VEHICLE WAS TURNED OFF AND TOWED BACK TO THE FORD DEALERSHIP WHERE IT WAS DETERMINED THAT THE ORIGINAL #2 SPARK PLUG HAD BLOWN OUT OF THE ENGINE AND DAMAGED THE HEAD. REPAIR EXCEEDING $700 WITH ABSOLUTELY NO RESPONSIBILITY TAKEN BY FORD. REPEAT INCIDENT LESS THAN ONE YEAR LATER WITH ANOTHER CYLINDER. *TR
Air bags, Jan 2, 2014, crash
I WAS INVOLVED ON A ACCIDENT ON FEBRUARY 17 2013 A CAR RUN IN TO MY TRUCK .DRIVER SIDE MY TRUCK SPIN AROUND AND I HIT THE DIVIDER IN THE MIDDLE AT THE STREET THE AIRBAG NEVER DEPLOY THE TOTAL DAMAGE ON MY TRUCK WAS $10,800 DOLLARS AND 2 MONTHS LATER A REVISE A LATTER FROM FORD COMPANY SAID THAT MY TRUCK HAS A RECALL ON THE AIRBAG ...SO I REVISE THE NOTIFICATION REALLY LATE ... SO I WAS THIS DRIVING A DEFECT TRUCK FOR YEARS REALLY I M REALLY UPSET ..WHEN I REVISE THE RECALL LATTER I TOOK MY TRUCK TO THE BIG VALLEY FORD DEALER SHIP AND THEY FIX MY AIRBAG ...SO THERE WAS A PROBLEM I TRY TO GET A HOLD OF THE FORD COMPANY AND THEY GIVE ME A CASE NUMBER BUT THEY DON'T DUE NOTHING ABUT IT I NEED HELP AND SOME INFO HOW CAN I GO AGAINST FORD COMPANY. *TR
Structure, Jan 2, 2014
TRUCK WAS AT DEALERSHIP FOR REPAIRS, WHEN I WAS TOLD NOT TO HAVE REPAIRS DONE BECAUSE THE FRAME IS CRACKED AND RUSTED THRU. THEY SAID THE VEHICLE IS UNSAFE TO DRIVE. THE TRUCK IS NOW WORTHLESS. IN MY 50 YEARS OF OWNING AND DRIVING NUMEROUS VEHICLES IN THE NORTHEAST, I NEVER HAD A RUSTED FRAME ISSUE. FORD WILL NOT HELP NOR INVESTIGATE THE SITUATION. *TR
Tires, Nov 5, 2013
HANKOOK DYNAPRO AS P255/65SR17 SEPARATED AT APPROX. 10,000 MILES. POTENTIAL FOR ACCIDENT SINCE IT WAS A STEERING TIRE. PURCHASED AT PEPBOYS STORE # 661 TUCSON, AZ. *TR
Steering, Fuel system, Gasoline, Vehicle speed control, Oct 28, 2013
MY 2006 FORD F150 FX4 HAS STALLED ON THE HIGHWAY AT TWO DIFFERENT TIMES IN THE LAST 9,000 MILES. I AM DRIVING AT NORMAL SPEEDS, WITH NORMAL WEATHER CONDITIONS, HALF TANK OF GAS, AND I WAS COASTING AS HIGHWAY SPEEDS SLOWED - AS I WENT TO HIT THE ACCELERATOR TO SPEED UP, I LOST THE ABILITY TO ACCELERATE. FIRST THE WRENCH DASH LIGHT CAME ON, THEN I NOTICED STEERING WAS SLIGHTLY DIFFICULT AND THEN THE BATTERY AND TRANSMISSION LIGHT CAME ON. I GOT THE VEHICLE TO THE SIDE OF THE ROAD, BUT I DID NOT LOSE HEADLIGHTS, RADIO, HEAT, OR POWER. I TURNED THE TRUCK OFF AND WAITED 2 MINUTES, THEN IT STARTED BACK UP - A LITTLE DIFFICULT ON THE STARTER, BUT IT WORKED. I HAVE READ NUMEROUS CHAT FORUMS ONLINE WITH USERS HAVING THIS SAME ISSUE WITH 2006 V8'S IN THE F150. WHAT IS FORD DOING ABOUT THIS? MY VEHICLE HAS BEEN METICULOUSLY MAINTAINED AND CARED FOR. FROM WHAT I READ THIS IS A FUEL PUMP CONTROL PANEL ISSUE WITH CORROSION OF DISSIMILAR METALS - WHERE IS THE RECALL? *TR
Electrical system, Engine, Sep 20, 2013
WHILE APPROACHING A STOP THE TRUCK GAUGES STARTED GOING CRAZY. TRUCK STALLED BUT RESTARTED WITH GAUGES STILL ACTING CRAZY. ALL GAUGES WOULD BOTTOM OUT AND COME BACK UP AND RADIO WAS TURNING ON AND OFF. REPLACED BATTERY BUT ONLY STALLING ISSUE WAS RESOLVED. TOOK TO LOCAL FORD DEALER BUT SINCE THE TRUCK ONLY DOES THIS RANDOMLY, THEY WERE NOT ABLE TO DIAGNOSE THE PROBLEM. TRUCK RUNS PERFECTLY BUT GAUGES AND RADIO STILL GO ON AND OFF MAKING IT EXTREMELY ANNOYING TO DRIVE. VERY FRUSTRATING TO KNOW THAT SO MANY OTHER FORD OWNERS HAVE THE SAME PROBLEM BUT NO SOLUTION HAS BEEN OFFERED FROM FORD. *TR
Engine, Sep 15, 2013
WHEN I STARTED THE TRUCK, A SPARK PLUG BLEW INTO THE HEAD. THE MECHANIC AT THE FORD DEALERSHIP TOLD ME THIS WAS A COMMON PROBLEM WITH THESE TRUCKS. THE REPAIR COST ME $3,448. TO REPLACE THE HEAD. IF FORD IS AWARE OF THIS PROBLEM, THE VEHICLES SHOULD BE RECALLED AND THE PROBLEM CORRECTED. MY FAMILY WAS LEFT STRANDED 7 HOURS AWAY FROM HOME, HAD TO RENT A VEHICLE TO GET HOME AND THEN TWO WEEKS LATER, HAD TO RETURN TO DEALERSHIP AND PICK UP THE TRUCK. SO STRESSFUL AND EXPENSIVE. JUST GLAD WE WERE IN A TOWN WHEN THIS HAPPENED! *TR
Engine, Sep 11, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED DURING ROUTINE MAINTENANCE ON THE VEHICLE SHE WAS INFORMED THAT THE SPARK PLUGS WERE FRACTURED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO REPAIRED THE VEHICLE. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 71,000.
Steering, Sep 9, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE STEERING SHAFT EXHIBITED EXCESSIVE RUST, MAKING THE VEHICLE DIFFICULT TO STEER AT ALL SPEEDS. THE CONTACT CLEANED AND LUBRICATED THE STEERING SHAFT BUT THE SERVICE ONLY REMEDIED THE ISSUE TEMPORARILY. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER. THE CONTACT CALLED THE MANUFACTURER AND OFFERED THE CONTACT A NEW PART TO PURCHASE. THE CONTACT DID NOT PURCHASE THE PART. THE FAILURE MILEAGE WAS 48,000.
Engine, Sep 4, 2013, fire
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS STARTED AND THE ENGINE EXHIBITED A LOUD NOISE. ADDITIONALLY, THE CONTACT SMELLED A BURNING ODOR. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC, WHO STATED THAT THE SPARK PLUG HAD MELTED DUE TO THE HEAT FROM THE HEAD GASKET. THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE FAILURE MILEAGE WAS 40,000.
Engine, Aug 28, 2013
2006 FORD F-150. CONSUMER REQUESTS REIMBURSEMENT FOR VEHICLE REPAIRS. *SMD THE CONSUMER STATED HE WAS QUOTED A PRICE OF $447 TO REPLACE THE SPARK PLUGS. HOWEVER, WHEN HE RECEIVED THE BILL, THE PRICE HAD DOUBLED.
Service brakes, Jul 29, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE BRAKES FAILED WHILE DRIVING 45 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE BRAKE BOOSTER FAILED. THE CONTACT SPOKE TO THE MANUFACTURER AND WAS TOLD THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER:08V208000(SERVICE BRAKES, HYDRAULIC). THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 101,000.
Engine and engine cooling, Jul 28, 2013
THE RIGHT EXHAUST MANIFOLD STUDS HAD BROKEN APPROXIMATELY 5/5/2012, IN WHICH THEY DID NOT TELL ME THE FULL EXTENT OF THE DAMAGES. THEY JUST TOLD ME THE MANIFOLD WAS LEAKING AND THE COST TO REPAIR IT. THIS CAUSED THE MANIFOLD TO WARP AND LEAK. THE DEALER WOULD NOT REPAIR IT UNDER THE EXTENDED WARRANTY. APPROXIMATELY ONE YEAR LATER I CALLED THE WARRANTY COMPANY AND FOUND OUT IT WAS ACTUALLY COVERED. WHEN I HAD TAKEN IT IN, IN MAY 2012 THE DEALER WANTED TO CHARGE 1500.00 FOR THE REPAIRS. THE REPAIRS WERE FINALLY MADE IN MAY OF 2013 TO THE EXHAUST MANIFOLD, BUT NOT TO THE CATALYTIC.CONVERTER WHICH STARTED CAUSING PROBLEMS IN JANUARY OF THIS YEAR. THIS LEAK MAY HAVE CAUSED THE RIGHT CATALYTIC CONVERTER TO FAIL ALSO, BUT HAVE FOUND MANY FORUMS STATING THAT FAILURE OF THE CATALYTIC CONVERTERS ARE A COMMON PROBLEM ON THESE PICK UPS. AT THIS TIME I AM DRIVING THE PICK UP AND IT THROWS THE CODE P0420, FOR CATALYTIC CONVERTER BELOW EFFICIENCY THRESHOLD. THIS PROBLEM SHOULD ALSO BE FORWARDED TO THE E.P.A. BECAUSE PEOPLE CANNOT AFFORD TO REPLACE THEIR CATALYTIC CONVERTERS AT THE PRICE OF 1200.00 PER SIDE. IF THIS IS A COMMON PROBLEM WITH FORD F-150'S THIS NEEDS ADDRESSED. ALSO THE FAILURE OF THE EXHAUST MANIFOLD IS A SAFETY HAZARD THAT COULD CAUSE THE OCCUPANTS IN THE CABIN TO BE EXPOSED TO CARBON MONOXIDE. THE LEAKING MANIFOLD ALSO CONFUSES THE COMPUTER BY TELLING IT THAT THE OF BANK CYLINDERS IS RUNNING TO LEAN IN RESPONSE TO THOSE READINGS IT THEN ADDS FUEL TO THAT BANK WHICH CAUSES IT TO RUN RICHER ON THAT BANK THAN IT SHOULD. I BELIEVE THAT THIS CAUSED DAMAGE TO THE CATALYTIC CONVERTER MAKING IT FAIL PREMATURELY. *TR
Power train, Jul 9, 2013
WENT TO BACK UP AND NO REVERSE. *TR
Engine, Jul 5, 2013
SPARK PLUGS AND COIL PACKS HAVE FAILED ACROSS OUR ENTIRE FLEET OF 2005-2008 F-150'S. THE POTENTIAL FOR SEIZED SPARK PLUGS IS SIGNIFICANT DUE TO INCREASED HEAT FROM FAILED COIL PACKS. THE COIL PACKS SEEM TO FAIL APPROXIMATELY EVERY 25,000-75,000 MILES. THE REPAIRS HAVE BEEN VERY COSTLY - ESPECIALLY WITH A FLEET OF 200+ VEHICLES. FORD HAS NOT OFFERED ANY ASSISTANCE WITH ANY OF THE CLAIMS. SYMPTOMS - THE VEHICLE SPUTTERS OR BOGS DOWN UNDER LOAD WHILE TRAVELING UP A HILL OR UNDER HARD ACCELERATION. DANGERS - THE VEHICLE WILL NOT ACCELERATE WITH 100% POWER WHILE UNDER LOAD IN A DANGEROUS SITUATION. THE NEED TO QUICKLY ACCELERATE BECOMES ALTERED DUE TO POSSIBLE SPARK PLUG/ COIL PACK FAILURE. RISKS ARE ACCIDENTS, PERSONAL INJURY, OR EVEN WORSE. *TR
Engine and engine cooling, Vehicle speed control, Jul 1, 2013
VEHICLES MISFIRING AND STUMBLING DURING MODERATE ACCELERATIONS AND CRUISING WHEN A LOAD IS PUT ON MOTOR. ( GOING UP A HILL, SLIGHT INCLINE AND PASSING). SPARK PLUGS WERE UNABLE TO BE REMOVED FOR REPLACEMENT. THE SPARK PLUGS WERE NOT OF GOOD QUALITY AND WOULD NEED TO BE REPLACED MORE OFTEN THAN USUAL. THE MANUFACTURER WAS MADE AWARE, HOWEVER NO ASSISTANCE WAS PROVIDED. $1249.00 TO CHANGE ONE SPARK PLUG. *TR
Engine, Fuel/propulsion system, Jun 12, 2013
THE VEHICLE WAS BEING DRIVEN AT 35 MPH AND SIMPLY STOPPED RUNNING. VEHICLE COULD NOT BE RE-STARTED. TOWED TO REPAIR SHOP. THE MECHANIC TESTED THE FUEL SYSTEM AND DETERMINED THE FUEL PUMP HAD BURNED OUT. THE FUEL PUMP WAS REPLACED AT A COST OF $552.05. ONE DAY AFTER REPAIRS WERE COMPLETED THE CHECK ENGINE WARNING LIGHT WAS ACTIVATED AND THE CODE REVEALED A FUEL SYSTEM ISSUE. THE VEHICLE WAS IMMEDIATELY TAKEN BACK TO THE SAME REPAIR SHOP. THE FUEL PRESSURE WAS OPERATING AT 90 PSI. AFTER SEVERAL UNSUCCESSFUL VISITS, IT WAS EVENTUALLY DETERMINED THAT THE FUEL PUMP CONTROL MODULE WAS SEVERELY CORRODED AND MALFUNCTIONING. THE "POT" METAL HAS BEEN COMPLETELY CORRODED AND THERE IS AN APPROXIMATE 1 INCH DIAMETER HOLE LEADING DIRECTLY TO THE ELECTRIC PANEL. THE CONTROL MODULE WAS REPLACED FOR AN ADDITIONAL $399.89. THE DESIGN OF THIS MODULE USING "POT" METAL AND SIMPLY BOLTING TO THE STEEL AXLE IS RIDICULOUS. THIS ITEM SHOULD BE AN IMMEDIATE RECALL WITHIN THE "SALT BELT" AREAS OF NORTH AMERICA. I HAVE DOCUMENTED RECEIPTS FROM THE REPAIR SHOP AND HAVE KEPT THE ORIGINAL FUEL MODULE AS WELL. FORD MOTOR COMPANY SHOULD RECOGNIZE THIS ISSUE AS AN OBVIOUS RE-CALL ITEM AND BE HELD RESPONSIBLE FOR ASSOCIATED REPAIR BILLS. *TR