2007 Ford Fusion
Problems, recalls and owner-reported issues
Air bags is the leading concern among 1,064 owner complaints filed for this model year. This is the 9th highest complaint count among 15 Fusion model years with reports.
Of the 2007 reports, 58 involved a crash and 5 involved a fire. 56 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleMar 10, 2021
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.
Campaign 21V158000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleDec 18, 2019
Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.
If the valves do not properly close, additional brake pedal travel may be required to stop the vehicle, increasing the risk of a crash.
Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap. In addition, the HCU will be tested to detect a possible stuck valve condition, replacing the HCU as necessary. All services will be performed free of charge. The recall began April 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S54.
Campaign 19V904000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleDo not drive until repairedJan 10, 2017
Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
Campaign 17V024000 on NHTSA.gov
Air bags, frontal, passenger side, inflator moduleDo not drive until repairedMay 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
Campaign 16V384000 on NHTSA.gov
EquipmentMay 29, 2014
Ford Motor Company (Ford) is recalling certain all weather driver side accessory floor mats sold for use in model year 2006-2011 Ford Fusion and Mercury Milan, 2006 Lincoln Zephyr, and 2007-2011 Lincoln MKZ vehicles manufactured November 9, 2007, through October 31, 2010. The affected floor mats may move and possibly interfere with the accelerator pedal.
The floor mat could shift such that it could interfere with the accelerator pedal, preventing its return to an idle position, which could result in unintended vehicle speeds, increasing the risk of a crash.
Ford will notify owners, and dealers will install new replacement mats, free of charge. The recall began in July 2014. Owners may contact Ford's customer service at 1-800-392-3673. Ford's number for this recall is 14S07. NOTE: Vehicles built after October 31, 2010, while potentially equipped with the same floor mats, are equipped with a Brake Over Accelerator (BOA) feature that prevents simultaneous accelerator and brake application, allowing the vehicle to be safely stopped by pressing firmly and steadily on the brake pedal.
Campaign 14E028000 on NHTSA.gov
Representative owner complaints: power train
74 reports, newest first. Show all
Power train, Nov 7, 2014
WAS DRIVING ALL OF A SUDDEN CAR MADE A BANG WOULD NOT MOVE FORWARD HAD IT TOWED TO LOCAL GARAGE WAS DIAGNOSED THAT THE POWER TRAIN UNIT WENT HAD IT TOWED TO TRANSMISSION PLACE WHILE TAKING IT APART THEY DIAGNOSED THAT THE GASKET WAS THE COOPERATE OF IT COST ME $2200 DUE TO FORDS FAULTY GASKETS HAVE NOTICED THAT THERE TONS OF COMPLAINTS AGAINST FORD FORD THIS;. ALSO MY SISTER HAS A 2010 SAME THING HAPPEN TO HER WITH ONLY 57000 MILES ON VEHICLE FORD SHOULD RECALL THIS THERE NO REASON FOR THIS HAPPEN TONS OF PEOPLE TAKE SUBURU OFF ROAD AND THEY DON'T HAVE THEIR DRIVE TRAINS GO WILL NEVER BY FORD AGAIN. *TR
Power train, Engine, Oct 13, 2014
MY CAR HAS A HISTORY OF LOST POWER/STALL DURING NORMAL DRIVING, IT IS HAPPENING MORE FREQUENT SO I WANT TO FILE THIS COMPLAIN TO HAVE SOME INVESTIGATION. WHILE ACCELERATING TO MERGE TO THE HIGHWAY TRAFFIC/SPEED, THE ENGINE LOST POWER AND NOT RESPONSE TO PRESSING ON THE GAS PEDAL. MY WIFE HAD TO STEER THE CAR BACK TO THE SHOULDER TO AVOID ACCIDENT. THIS CAR IS SERVICE BY FORD DEALER UNDER PURCHASED MAINTENANCE PLAN SINCE WE BOUGHT IT NEW. THERE WAS NO MENTION TO SERVICE THE INTAKE/THROTTLE BODY ASSEMBLY, WHICH IS NOT SERVICEABLE. I UNDERSTAND THIS CAR SHARE SAME PLATFORM WITH FORD ESCAPE WHICH HAD A RECALL ON THE THROTTLE BODY ASSEMBLY LAST YEAR. I WONDER THIS CAR MODE SHOULD BE RECALLED TO FIX THE PROBLEM. *TR
Power train, Engine, Oct 13, 2014
THIS CAR HAD A HISTORY OF LOST POWER/STALL WHILE DRIVING ON CITY AND HIGHWAYS WITHOUT ANY SYMPTOMS NOR WARNINGS. MY PARTICULAR CONCERN WAS LAST WEEK IT LOST POWER/STALL WHILE DRIVING ON MULTI-LANE EB I-96 FROM DETROIT TO GRAND RAPIDS, MI, WHICH WE HAD TO PERFORM EMERGENCY EVASIVE ACTIONS TO GET OUT OF THE BUSY HIGHWAY TRAFFIC TO AVOID COLLISION/ACCIDENT THAT MAY RESULT WITH PERSONAL INJURY OR DEATH. IT HAD NO SYMPTOMS NOR WARNING. THE CAR SIMPLE LOST POWER REDUCE TO IDLE SPEED AT AROUND 600 RPM. IT FAILED TO RESPONSE TO CRUISE CONTROL, GAS PEDAL CONTROL. MECHANIC DETERMINED THAT THE CAUSE LIKELY THE THROTTLE BODY ASSEMBLY OR THE MASS AIRFLOW SWITCH. BOTH OF THEM ARE NOT SERVICEABLE PARTS AND NOT RELATE TO MAINTENANCE, WEAR OR TEAR. THIS CAR HAD BEEN SERVICED BY FORD DEALER SINCE WE BOUGHT IT NEW. NO ADVICE OR ANYTHING WAS GIVEN ABOUT THIS PROBLEM. I BELIEVE THIS IS A MANUFACTURER DEFECT WHICH HAS DETRIMENTAL EFFECT ON SAFETY THAT NEEDS TO BE INVESTIGATED. THANK YOU. *TR
Power train, Engine, Sep 1, 2014
A WRENCH IS DISPLAYED ON THE DASH, AND THE ENGINE LOSES POWER. THE POWER IS NOT RESTORE UNTIL THE CAR IS TURNED OFF. *TR
Power train, Electrical system, Jul 18, 2014
CAR JOLTED WHILE CRUISING AT 70 MPH ON THE INTERSTATE, THEN WENT IN TO LIKE A FIRST GEAR AND HIGH RPM. ALL THE DASHBOARD GAUGES, LIGHTS AND RADIO WENT OFF. PUT IN NEUTRAL AND EVERYTHING CAME BACK ON AND FUNCTIONED. PUT BACK IN DRIVE AND THE SAME ISSUE WITH GEAR, SPEED, GAUGES, ETC. RETURNED. BACK IN NEUTRAL SO I COULD USE MY FLASHERS AND AFTER COASTING FOR A LITTLE BIT THE ENTIRE CAR SHUT DOWN AND WOULD NOT COME BACK ON. HAD TO TOW TO A NEARBY DEALERSHIP (54 MILES AWAY) WHERE THEY ARE TELLING ME THE THROTTLE BODY HAS FAILED AND NEEDS REPLACED. *TR
Power train, Electrical system, Jul 18, 2014
CAR JOLTED THEN WENT IN TO LIKE A FIRST GEAR WITH HIGH RPM. ALL GAUGES WENT TO ZERO AND ALL DASHBOARD THINGS STOPPED, INCLUDING RADIO. PUT IN NEUTRAL, ALL GAUGES RETURNED TO NORMAL AND ALL LIGHTS FUNCTIONED. PUT BACK IN DRIVE AND THE SAME ISSUER WITH GEAR, SPEED, GAUGES, ETC. RETURNED. BACK IN NEUTRAL SO I COULD USE HAZARD LIGHTS BUT THEN THE ENTIRE CAR SHUT DOWN. HAD TO TOW TO A DEALERSHIP WHERE THE ARE TELLING ME THE THROTTLE BODY HAS FAILED AND NEEDS REPLACED. *TR
Power train, Engine, Jul 17, 2014
HAD THROTTLE BODY REPLACED AFTER MULTIPLE STALLS AT IDLE. REPLACEMENT THROTTLE BODY STILL STALLING ENGINE AT IDLE. FORTUNATE TO NOT HAVE IT STALL IN MOTION. *TR
Power train, Jun 29, 2014
SEVERAL TIMES OVER THE PAST 3 YEARS MY 2007 FORD FUSION SE V6 WOULD SUDDENLY LOSE POWER. ENGINE WOULD REMAIN RUNNING BUT VEHICLE WOULD NOT ACCELERATE. WRENCH LIGHT AND ENGINE LIGHT WOULD ILLUMINATE WHEN THIS OCCURS. SOLUTION IS TO PULL OVER AND SHUT CAR COMPLETELY OFF FOR 30 SECONDS AND RESTART. SOMETIMES THIS WOULD WORK FOR A FEW MINUTES OR SEVERAL 1000 MILES BEFORE REPEATING AGAIN. I HAVE HAD THE CAR INTO THE FORD DEALER MULTIPLE TIMES AND THEY KEEP TELLING ME THEY CAN NOT DUPLICATE THE PROBLEM. I HAVE FOUND 1000'S OF COMPLAINTS ONLINE WITH THE SAME ISSUES FOR WHAT APPEARS TO BE A KNOWN ISSUE AT FORD WITH THE THROTTLE BODY ASSEMBLY. I RETURNED TO THE DEALER WITH ALL OF THIS INFORMATION AND WAS TOLD THE THROTTLE BODY ASSEMBLY WOULD TAKE WEEKS TO GET AND THAT THE REPLACEMENT PART IS THE EXACT OEM PART WHICH HAS THE SAME DEFECT. FORD WANTS ME TO PAY TO REPLACE A DEFECTIVE PART WITH A DEFECTIVE PART. THE ENGINE SUDDENLY LOSING POWER IS EXTREMELY DANGEROUS IF IN HIGH SPEED TRAFFIC THE RISK OF A CRASH IS EVEN MORE OF A CONCERN. WHY IS FORD NOT FIXING THIS ISSUE ON A RECALL? THIS IS GOING TO GET PEOPLE KILLED! *TR
Power train, Jun 23, 2014
WHEN SPEEDING UP TO PASS SOMEONE ON THE HIGHWAY THE CAR REVVED UP TO ALMOST 6K RPM AND JERKED VIOLENTLY INTO THE NEXT GEAR. THE WRENCH LIGHT CAME ON SHORTLY AFTER AND THE CAR WAS PARKED. THE NEXT MORNING THE LIGHT WAS OFF UNTIL A SHORT TRIP TO THE MECHANIC FOR DIAGNOSIS. THE MECHANIC DIAGNOSED THE CAR AND GOT 2 ERROR CODES. BOTH SHOWING TRANSMISSION FAILURE. *TR
Power train, Vehicle speed control, May 29, 2014
UPON DRIVING THE SPEED BECAME ERRATIC AND THE CAR SLOWED DOWN VERY QUICKLY REQUIRING ME TO PULLOVER QUICKLY FOR FEAR OF A REAR END COLLISION. AT THAT TIME I SAW THE WRENCH LIGHT ON MY DASH. I FEEL THAT IS A HAZARD THAT SHOULD BE CORRECTED UNDER THE WARRANTY OR AS A RECALL FROM FORD COMPANY. THE WAIT FOR PARTS IS ALMOST A MONTH, FORD SHOULD GIVE A LOANER CAR AS I AM AFRAID TO DRIVE MY CAR IN TRAFFIC. THANK YOU *TR
Power train, Vehicle speed control, Engine, May 13, 2014
I WAS DRIVING TO HOUSTON FROM SAN ANTONIO ON I10 AND GOING THE SPEED LIMIT. SHORTLY AFTER STARTING MY DRIVE I WAS SHOCKED BY A SLIGHT JERK AND A "WRENCH" SYMBOL APPEAR. I WAS IN THE CENTER LANE AND HARDLY HAD ANY ACCELERATION TO MOVE OFF THE ROAD. EVENTUALLY, I WAS ABLE TO GET TO THE SIDE OF THE HIGHWAY, TURN OFF MY CAR AND TURN IT BACK ON. IT ALLOWED ME TO DRIVE ABOUT 5 MIN BEFORE HAPPENING AGAIN. I ENDED UP PULLING OF THE ROAD 8 TIMES UNTIL I JUST DECIDED TO CALL AAA AND PAY ADDITIONAL FEES TO TOW MY CAR INTO HOUSTON. IT WAS SCARY AND DEF. A SAFETY HAZARD FOR ANYONE EXPERIENCING THIS MALFUNCTION. I TOOK THE CAR TO GET A DIAGNOSTIC AND SURE ENOUGH IT'S A THROTTLE BODY FAILURE. I DROVE TODAY WITH NO ISSUES, BUT I AM SURE IT WILL OCCUR AGAIN VERY SOON. FORD REALLY NEEDS TO RECALL AND THINK ABOUT THEIR CUSTOMER'S SAFETY. *TR
Power train, Service brakes, Engine, May 10, 2014
VERY NOTICEABLE IS THE JERKING OF THE CAR, ESPECIALLY WHEN ACCELERATING. *TR
Power train, Apr 13, 2014
THROTTLE BODY ISSUE - CONFIRMED SINCE I JUST SPENT $930.00 AT THE FORD DEALERSHIP TO REPLACE. WIFE GOT IN CAR AT MALL. FIRST CAR WOULD NOT START LOOSE CONTACT ON TERMINAL. SHE CALLED ME I JIGGLED WIRE, CAR STARTED BUT YOU COULD PUSH THE PEDAL ALL THE WAY DOWN AND ONLY VERY SLIGHT POWER (WRENCH LIGHT ON...). SHE PARKED THE CAR AS IT WOULD ONLY GO ABOUT 3 MILES AN HOUR AND I TURNED IT OFF AND RESTARTED THE CAR TO SEE IF IT WOULD DRIVE AND IT WOULD NOT. HAD TO GET IT TOWED TO PLANET FORD DEALERSHIP WHO REPLACED THE THROTTLE BODY. THE EXACT SAME ISSUE HAD HAPPENED ONE WEEK EARLIER BUT WHEN I TURNED THE CAR OFF AND RESTARTED THE ENGINE IT RAN FINE. I HAD A MECHANIC DO THE CODES THE FIRST TIME AND IT WAS THROTTLE BODY AND THE FORD DEALERSHIP DID IT THE SECOND TIME. *JS
Power train, Apr 11, 2014
AFTER AN ENGINE LIGHT CAME ON, I TOOK MY CAR TO HAVE THE CODE READ. THE CODE THAT APPEARED WAS FOR THE THROTTLE BODY. AFTER DOING SOME RESEARCH, I DISCOVERED THAT THERE WAS A RECALL FOR THE THROTTLE BODY FOR THE FORD FUSION FROM 2009 -2012. MY CAR WAS NOT INCLUDED IN THE RECALL, BUT MY THROTTLE BODY ACCORDING TO THE DEALERSHIP IS "ERRATIC". I FEEL THAT THE RECALL ON THE THROTTLE BODY MAY NEED TO BE REEXAMINED AS MY CAR, ONLY TWO YEARS OLDER THAN THOSE BEING RECALLED, IS HAVING THE SAME ISSUE. THE PART SHOULD NOT GO BAD THAT QUICKLY. THE CAR HAS LESS THAN 100,000 MILES. *JS
Power train, Mar 8, 2014
VEHICLE IS A DAILY DRIVE, EXPERIENCED TSB 13-4-17, PCM FAILURE CAUSING THE IGNITION COILS TO BURN OUT ON CYLINDER 4. VEHICLE WAS TOWED TO FORD DEALERSHIP, WHERE VEHICLE WAS REPAIRED, AT A COST OF OVER $2000. IMMEDIATELY AFTER THE VEHICLE HAD A HOWL AND VIBRATION, VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND DIAGNOSED AS A TRANSFER CASE (PTU) FAILURE, THIS WAS A FEW DAYS AFTER LEAVING THE FORD DEALERSHIP. MY LOCAL MECHANIC REPLACED THE PTU AT A COST OF $1000. VEHICLE WAS FINE FROM NOVEMBER 2013 TILL JUST THIS PAST WEEK MARCH 6 2014 WHERE A LEAK OF GEAR OIL WAS FOUND IN THE DRIVEWAY, CAR WAS BROUGHT TO LOCAL FORD DEALERSHIP WHICH CONFIRMED A LEAK OF THE SEAL ON THE TRANSFER CASE (PTU). VEHICLE HAS BEEN BROUGHT TO LOCAL MECHANIC THAT MADE THE REPAIR. I FIND IT UNBELIEVABLE THAT SINCE THIS VEHICLE HAS HIT 100K MILES THAT IT IS IN NEED OF CONSTANT REPAIR. I HAVE OWNED MANY FORDS AND HAVE NEVER HAD AN ISSUE LIKE THIS. AFTER MUCH RESEARCH I HAVE FOUND THAT THESE ARE COMMON PROBLEMS!! FORD NEEDS TO DO SOMETHING ABOUT THIS!! THEY CLAIM TO HAVE RELIABLE VEHICLES BUT THIS IS NOT RELIABLE, ESPECIALLY SINCE I BOUGHT THIS CAR AS A CERTIFIED PRE-OWNED FROM A FORD DEALERSHIP IN JULY OF 2010 I ONLY GOT 3 GOOD YEARS OUT OF THIS VEHICLE. ITS A SHAME CAUSE ITS SUCH A BEAUTIFUL CAR AND NOW I HAVE NOTHING BUT MECHANICAL ISSUES. *TR
Power train, Feb 27, 2014
LOSS OF POWER, CAR WOULD NOT GO, STUCK IN BUSY TRAFFIC, SHIFTS VERY HARD TRANSMISSION SLIPPING. THIS HAS HAPPENED ABOUT TREE OR FOUR TIMES NOW. CALLED DEALER THEY SAY THEY ARE UNAWARE OF PROBLEM, BUT IT IS ALL OVER THE INTERNET EVERYONE HAVING PROBLEMS. TOOK IT IN BUT COST ME 400 BECAUSE OF COURSE IT IS OUT OF WARRANTY. REPROGRAMMED MY TRANSMISSION BUT NOW SHIFTS AT A HIGHER RPM CAUSING LOWER FUEL MILEAGE. THEY ARE HAVING PROBLEMS WITH THE THROTTLE BODIES GOING BAD BECAUSE THIS WAS A COLLABORATION WITH MAZDA. VERY EXPENSIVE REPAIR. NO WAY THESE SHOULD BE GOING BAD AT 70K. THEY NEED TO REPLACE TRANSMISSIONS AT THEIR COST. *TR
Power train, Electrical system, Feb 19, 2014
ON FEB 19 2014 AT 8:30 AS I PARKED MY 2007 FORD FUSION IN MY DRIVEWAY I WAS UNABLE TO REMOVE MY KEY FROM THE IGNITION. I NOTICED MY STEERING WHEEL WOULD NOT LOCK. MADE SURE THE VEHICLE WAS IN PARK AND STILL THE KEY WOULD NOT TURN ALL THE WAY BACK SO THAT THE WHEEL COULD LOCK AND KEY COULD BE REMOVED.I LOOKED ONLINE TO SEE HUNDREDS OF SAME PROBLEM WITH KEY GETTING STUCK. AND MOST OF THEM HAD TO DO WITH GEAR SHIFT SILVER BUTTON NOT RELEASING TO LET KEY TURN ALL THE WAY. SEEING THESE MANY SAME PROBLEM SHOULD WARRANT A RECALL TO THIS PROBLEM. *TR
Power train, Jan 25, 2014
WHILE DRIVING ON THE HIGHWAY THE ENGINE STARTED TO RUN ROUGH AND WITHIN A MINUTE THE ENGINE QUIT AND COULDN'T BE RESTARTED. LUCKILY I WAS ABLE TO COAST TO THE SIDE OF THE HIGHWAY. THE ENGINE HAD THE SAME FAULT AS IDENTIFIED IN NHTSA TSB-13-4-17. THE PCM UNIT FAILED, CAUSING DAMAGE TO MULTIPLE ON-PLUG IGNITION COILS. I BELIEVE THAT THE FORD TSB # FOR THIS PROBLEM IS 06-18-15. THIS IS A 6-CYLINDER ENGINE. I BELIEVE THIS IS A SAFETY ISSUE BECAUSE OF THE SUDDEN AND COMPLETE ONSET OF LOSS OF POWER. *TR
Power train, Engine, Oct 1, 2013
TL* THE CONTACT OWNS A 2007 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 72 MPH, THE VEHICLE BEGAN TO VIBRATE AND BACK FIRE. THE ENGINE WAS TURNED OFF HOWEVER, THE VEHICLE FAILED TO RESTART AND WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC INFORMED THE CONTACT THAT THE FAULTY PCM CIRCUIT BOARD OVERHEATED AND CAUSED THE FOUR COILS TO MELT. IN ADDITION, THE CATALYTIC CONVERTER WAS DAMAGED. THE VEHICLE WAS REPAIRED EXCLUDING THE REPLACEMENT OF THE CATALYTIC CONVERTER. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 93,100. UPDATED 11/07/13*LJ
Power train, Sep 8, 2013
DRIVING ON HIGHWAY AT ABOUT 65 MILES PER HOUR, CAR STOPPED ACCELERATING AND WHEN PRESSED THE GAS PEDAL CAR ACTUALLY CONTINUED TO SLOW DOWN. ALSO HAS STARTED TO NOT ACCELERATE FROM A STOPPED POSITION. HAVE ALMOST BEEN HIT FROM BEHIND AS I WAS NOT ABLE TO ACCELERATE.
Power train, Jul 29, 2013
TL* THE CONTACT OWNS A 2007 FORD FUSION. THE CONTACT STATED THAT WHILE AT A STOP LIGHT, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 53,000.
Power train, Jul 29, 2013
TL* THE CONTACT OWNS A 2007 FORD FUSION. THE CONTACT STATED THAT WHILE AT A STOP LIGHT, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 53,000.
Power train, Jul 25, 2013
ON JUNE 1ST MY WIFE WAS ON I-20 WEST OF RUSTON, LA TRAVELING TO MONROE, LA. THE CAR SUDDENLY LOST POWER AND HAD NO RESPONSE ON THE ACCELERATOR. SHE COASTED TO AN EXIT AND PULLED OVER. THE ENGINE WRENCH LIGHT WAS ON. SHE TURNED THE CAR OFF AND CALLED ME TO COME HELP.WHEN I GOT THERE THE CAR STARTED AND I DROVE IT HOME WITHOUT INCIDENT. I HAVE SINCE TAKEN THE CAR IN TO JIM TAYLOR FORD AND WAS TOLD THE CODE INDICATED THE PROBLEM CAME FROM THE THROTTLE BODY AND IT MAY HAVE TO BE REPLACED. IT HAS NOT HAPPENED AGAIN BUT I WAS TOLD THAT OTHER FUSIONS HAVE HAD THE SAME PROBLEM AND SOME OF THE OWNERS HAVE ELECTED TO REPLACE THE THROTTLE FOR SAFETY. THIS COULD BE A MAJOR PROBLEM IN TRAFFIC IF AND WHEN IT A HAPPENS AGAIN. SOMETHING IS FAULTY AND FORD SHOULD FIX THIS PROBLEM. *TR
Power train, Jul 20, 2013
WHILE PASSING ANOTHER CAR MY CAR LOST POWER.I PRESSED THE ACCELERATOR TO THE FLOOR AND NOTHING HAPPEN. I WAS ALMOST HIT HEAD ON BY ANOTHER ON COMING CAR. MY CERTIFIED FORD MECHANIC SAID IT MAY BE MY THROTTLE AND I SHOULD REPLACE IT BUT HE COULD NOT GUARANTEE THIS WOULD SOLVE MY PROBLEM. HE SAID I WAS ONE MANY TO HAVE THIS PROBLEM WITH THE 2007 FORD FUSION. *TR
Power train, Jul 3, 2013
PURCHASED THE CAR IN 02/07, IN 12/08 CRANKSHAFT PULLEY FAILED, 2009 FUEL INJECTION PUMP FAILED, 02/2013 T-STAT AND CV JOINT FAILED. 06/26/13, TRANSMISSION FAILED. TORQUE CONVERTER, PUMP, AND SEAL ALL FAILED IN THE CAR 204 MILES AFTER WARRANTY EXPIRED. GEAR SLIPPAGE, AND COMPLETE TRANSMISSION FAILURE IS A MAJOR ISSUE ON THIS CAR, AND THERE ARE MANY COMPLAINTS REGARDING THIS ISSUE. MANY COMPLAINTS OF TRANSMISSION FAILURES, REPLACEMENTS, OR REBUILDS ON CARS WITH AS LITTLE AS 36000 AND UP. *TR