2019 Ford Fusion
Problems, recalls and owner-reported issues
Engine is the leading concern among 377 owner complaints filed for this model year. This is the 14th highest complaint count among 15 Fusion model years with reports.
Of the 2019 reports, 5 involved a crash and 2 involved a fire. 7 people were injured.
What owners report most often
Recalls and investigations
Equipment, electrical, engine block heaterOct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
An electrical short circuit can increase the risk of a fire.
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Campaign 25V685000 on NHTSA.gov
Back over prevention, softwareJun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Campaign 25V442000 on NHTSA.gov
Electrical system, propulsion system, traction battery, management system/energy control module (bms/becm)Jun 23, 2023
Ford Motor Company (Ford) is recalling certain 2019-2020 Fusion PHEV vehicles. The battery energy control module (BECM) may become damaged due to excessive voltage and current flow.
A damaged BECM can result in a loss of drive power or fire, increasing the risk of a crash.
Owners are advised not to charge their vehicles until the remedy is completed. Dealers will replace the battery and update the BECM software for free, or Ford will repurchase the vehicle. If your vehicle is currently operating normally, Ford has authorized dealers to replace the fuse block and a software update as an interim repair before the availability of remedy parts for the final repair. This repair will be free of charge (parts and labor). As an alternative remedy, Ford is offering a vehicle refund. Please see Ford's owner notification letter or contact Ford for full details. Owner notification letters were mailed May 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S33.
Campaign 23V440000 on NHTSA.gov
Representative owner complaints: power train
74 reports, newest first. Show all
Power train, Service brakes, Aug 7, 2023
car gave error message of system shift fault car would not shift from park to drive and would automatically shift back into park. issue could be a bushing or solenoid issue Car has premature wear on rotors and needed to be replaced
Power train, Jun 28, 2023
The contact owns a 2019 Ford Fusion. The contact stated that while driving at various speeds, the vehicle shuddered with an engine misfire. There was no warning light illuminated. The vehicle was taken to the dealer on three separate occasions and diagnosed with a defective torque converter. The torque converter was replaced after remaining in dealer's possession for more than 30 days. The engine misfiring returned, and the vehicle hesitated while depressing the accelerator pedal. The vehicle was taken back to the dealer, but the contact was offered no assistance. The manufacturer was then notified of the failure and the contact was referred to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was approximately 29,000.
Power train, Jun 27, 2023
I have a 2019 Ford Fusion Titanium that I just recently sold to my son. I purchased the car used from a dealership in January of 2020. In October of 2021the flexplate went out and was replaced under the manufacturer warranty. The part went out again in May of 2023 and since the car had been totaled out due to a hail storm I have been told the manufacturer warranty is no longer valid. I have been able to find that there was a bad batch of replacement parts that may have found its way into several vehicles that have experienced this same problem. When Ford replaced the flexplate it was only the flexplate that was replaced. I was required to replace the flexplate, the front fluid pump assembly and the torque converter when I had to have it fixed again. I believe that if Ford has updated this recall it is due to them knowing that either the parts used in the original repair were defective and they don't know which ones it was; or, they now know that the original fix should have included the front fluid pump assembly as well as the torque converter. I believe that either way I should at least be able to ask for Ford to cover the cost of the parts under this second repair in less than two years on the same issue. The parts that I had put on now are guaranteed for two years, why is that? The labor should be at a discounted rate as well. It is my hope that you will investigate this or look at your database to see how many other customers are experiencing the same issue.
Power train, Engine, Jun 23, 2023
Last year my car started overheating for no apparent reason checked coolant reservoir and visibly seemed empty but when I removed the cap antifreeze rose fast. Added antifreeze and it stopped overheating. About 3 months ago Because it overheated I had to get the head gasket replaced, timing components replaced, heads repaired, and engine flushed(antifreeze had entered engine), not to mention labor all costing roughly $3,000. Only for it to happen again and now I’m out of $3,000 because the same thing is happen only this time my car is shaking and smoking from the tail pipe badly. In the mean time my fiancé has lost his job due to us not being able to drive the car. After doing god knows how much research to find out this is an ongoing problem with this particular make of car. Because of having to pay for countless repairs and no one seeming to know what’s going on with my car I am now behind on bills and still without a car that is only 4 years old. I haven’t done any long driving to other states beside neighbors states that are about 2-3 hours away but that shouldn’t matter because it’s a new car I shouldn’t have any problems driving it wherever. I purchased this car at a lil over 30k miles my problems started at about 61k miles which is odd since the manufacturer warranty had just expired about 1k miles before that. I believed in ford for the longest and now I am regretting ever buying one. My very first car purchase from a lot and it turns out to be the worst car I’ve ever purchased. I’m sure me typing all of this probably won’t get read or even looked into but this is an experience I wouldn’t dare want anyone else to go through so I’m sure to leave many reviews but I thought you should know. Also because of the over heating my car has cut off at times where my life could have been taken (at lights and intersections) have a good day!
Power train, Jun 20, 2023
The contact owns a 2019 Ford Fusion. The contact stated while parking the vehicle, the contact shifted to drive(D) to reverse(R) and the “System Fault – Service Required” message was displayed. The contact stated that the vehicle failed to drive or reverse as needed. The vehicle was towed to the dealer to be diagnosed and the contact was informed that the shifter cable bushing was missing, and that the vehicle had experienced the failure listed in NHTSA Campaign Number: 22V413000 (Power Train) however, the VIN was not included. The vehicle was repaired. The manufacturer was contacted, and a case was filed but no assistance was provided. The failure mileage was 70,945. The contact stated the dealer replaced the shift cable bushing and transmission shifter cable bushing. Also, installed a protective cap.
Power train, Engine, Apr 18, 2023
The contact owns a 2019 Ford Fusion. The contact stated while attempting to start the vehicle, the vehicle hesitated to start. Additionally, the contact stated that the vehicle hesitated to respond while depressing the accelerator pedal. The check engine warning light was illuminated. The contact stated that the failure reoccurred while driving at various speeds and depressing the accelerator pedal. The dealer was contacted and informed the contact that they could not assist as the VIN was not included in a recall. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 92,770.
Power train, Exterior lighting, Forward collision avoidance, Mar 28, 2023
my transmission is faulty my car is a 2019 Ford Fusion and it has all the same problems as earlier models with recalls that are equipped with the same components as mine my it keeps stalling when I come to a stop which I see numerous complaints of the same thing it there were no warning lights on at the time it occurred I've done research on my own through forums and there are thousands of complaints of the same thing happing to there's there's no way that can be just are luck there has to be something wrong with the way the car is built or made
Power train, Mar 27, 2023
The contact owns a 2019 Ford Fusion. The contact stated that while driving approximately 50 MPH, the vehicle was jerking. There was o warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the torque converter needed to be replaced. The contact was made aware that the VIN was not included in NHTSA Campaign Number: 17V427000 (Power Train). The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 78,000.
Power train, Feb 15, 2023
The contact owns a 2019 Ford Fusion. The contact stated that while the vehicle was idling the contact attempted to accelerate and the vehicle stalled and then inadvertently shifted to reverse. While attempting to correct the failure, the vehicle the failure reoccurred. The instrument panel showed that the vehicle was in reverse. The contact was unable to shift to the intended gear. The contact had the vehicle towed to the dealer who diagnosed that the transmission shift cable bushing failed and needed to be replaced. The vehicle had been repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA hotline. The approximate failure mileage was 80,000.
Power train, Oct 27, 2022
I routinely take my car to get oil changes and check for any other problems. So 2 days after getting my oil changed at a dealership my car began to overheat which shouldn’t have happened because when I got my oil changed they filled the liquids to proper levels. So I added antifreeze because my reservoir was empty once cooled I opened my reservoir and antifreeze began to come back up to the proper level. After getting it home that same thing happened and haven’t moved it since. Now my car shakes and the overheating light stays on. There is no visible leak and I don’t know where the antifreeze goes. My car is only about 3 years old and I don’t believe this should be happening. I take good care of my car routine check ups and oil changes. After doing some research online I’ve seen so many people with my same car reporting the same issue. I believe this problem has been recalled in older years (2014-2016) unsure of exact years but I believe it wasn’t fixed and now has cause major stress for me because I only have one car. Please look into this because right now I’m out of a car and I don’t know what to do and I am still paying on it and can’t even drive it.
Power train, Engine, Aug 28, 2022
2019 Ford Fusion SE. Car kept stalling and running hot. I took it in and there’s coolant in the cylinders, which means new engine. Haven’t had the car a year and a half. Chevy sent me to Ford, Ford wants my extended warranty to pay for it. If it does, I’ll be capped off and still have to come up with $1000!!
Power train, Jul 20, 2022
My Ford Fussion has a Cracked flex plate. It cracked while I was driving and no service or warning lights turned on.it is currently at dealership waiting for warranty company to approve repairs.
Power train, Jul 7, 2022
The contact owns a 2019 Ford Fusion. The contact stated while shifting into drive(D), the gear inadvertently shifted back to park(P). The shifter bushing light illuminated. The vehicle was unable to be driven. The vehicle was diagnosed at the residence by an independent mechanic as a shifter cable failure. The vehicle was not repaired. The manufacturer was notified of the failure. The vehicle was not included in NHTSA Campaign Number: 22V413000 (Power Train). The approximate failure mileage was 70,000.
Power train, Jun 23, 2022
The flywheel apparently broke and messed up the crankshaft as well as the front pump in the transmission. Which in turn caused the transmission to slip out of gear and kill while being operated on a busy interstate requiring a tow home and then to ford service for diagnostics. With repairs totaling in excess of $8000.
Power train, Engine, Jun 12, 2022
Car has been blowing excessive smoke from the exhaust only on start up after car has been parked for a few hours. Ford acknowledged new engine was needed however a week after my car had been waiting for the engine ford said it didn't need an engine. Started after the first oil change at about 9000 miles car stalled immediately after I left the dealership from getting an oil change.
Power train, May 8, 2022
I had my flexplate fail twice within 12500 miles of each other. First break was in December of 2021 at 52xxx miles. The flexplate can fail and have multiple cracks in it causing it to rattle and break further on each start and drive, causing the possibility of it completely breaking while driving if someone does not verify what it is. It sounds like a knock in the motor and be mistaken as that if the flexplate is not looked at. I only caught the break cause I heard a slight ticking getting louder every couple of days. And when I went to the dealership to get it looked at it broke further and started making a louder tick/clank. I have talked to a dealer worker that has has the same issue come up (cracked flexplate) with his edge with the 2.0 motor. Along with other research I’ve done I see there are MANY fusions and edges with the 2.0 EcoBoost that have the same issue. So this is a wide spread issue. Ford knows of this issue but does not take responsibility for the issue if the vehicle is no longer under warranty.
Power train, Feb 26, 2022
The vehicle has a defective transmission that does won't recall or acknowledge. The vehicle has been shifting erratically since it hit 180 mile.
Power train, Engine, Feb 23, 2022
The contact owns a 2019 Ford Fusion. The contact stated that the vehicle was making a rattling noise coming from the engine compartment while idling. The vehicle was taken to a local mechanic where it was diagnosed with needing the flex plate replaced. The vehicle was repaired however, the failure persisted. The manufacturer was informed of the failure and the contact was awaiting a response. The failure mileage was approximately 52,500.
Power train, Nov 26, 2021
The contact owns a 2019 Ford Fusion. The contact stated that while driving at various speeds, the vehicle experienced random hesitation and stalling with the check engine warning light illuminated. The vehicle was taken to the local dealer who diagnosed that the transmission was faulty and needed to be repaired. The vehicle was repaired but the failure had reoccurred. The contact indicated that the transmission had been rebuilt on three separate occasions. The manufacturer was notified of the failure. The approximate failure mileage was 5,000.
Power train, Engine, Jan 12, 2021
COMING TO STOP AT A PARKING LOT AND ALL OF SUDDEN THE CAR ACCELERATED (SEEM LIKED 90 MPH) ON IT'S OWN JUMPED THE CURB WENT UP ON THE LAWN BEFORE I COULD REACT AND APPLIED THE BRAKES! I WAS PROBABLY ALMOST STOPPED BEFORE THE CAR RAPIDLY ACCELERATED FOR NO REASON!
Power train, Electrical system, Engine, Dec 12, 2020
T O WHOM IT MAY CONCERN, THANK YOU FOR ASSISTING ME DURING THIS PROCESS. MY CAR I PURCHASED NEW AND I WOULD LIKE TO SAY A FEW MONTH INTO OWNING MY CAR IVE HAD SERVAL INCIDENCE WHERE MY CAR WOULD COMPLETELY SHUT OFF WHILE I'M A RED LIGHT FOR AWHILE DUE TO TRAFFICS. MY CAR HAS AN ECO BUTTON WHERE I CAN TURN IT OFF AND ON SO IT DOESN'T 'SHUT DOWN' WHEN I COME TO A STOP. THE REASON I'M SO UPSET WITH THIS IS BECAUSE 2-3 TIMES IT'S HAPPENED TO I'VE HAD MY TODDLER WITH ME AND IN ORDER FOR ME TO GO (WHEN THE CAR SHOULD AUTOMATICALLY TURN ON ONCE I REMOVE MY FOOT FROM THE BREAK), I HAVE TO TURN OFF MY CAR AND TURN IT BACK ON AND IT'S HAPPENED DURING TRAFFIC AND BUG INTERACTIONS. I DON'T FEEL SAFE IN MY CAR AND MOST IMPORTANTLY I'M SCARED A CAR WILL HIT ME FROM BEHIND DO TO THIS ISSUE WITH MY SON IN THE CAR. I'VE ADDRESSED THIS ISSUE TO FORD AND WHEN I TAKE IT IN THEY SAID THEY CAN'T DETECT THE PROBLEM. THEY'VE CHANGED THE BATTERY THINKING IT WOULD HELP HIT IT DIDN'T. I'VE GIVEN THEM THE OPPORTUNITY TO ASSIST ME AS MUCH AS THEY CAN BUT YET I FEEL LIKE NOTHINGS BEEN DONE.
Power train, Engine, Sep 9, 2020
I WAS DRIVING OUT OF A STORE AND ALL OF A SUDDEN THE VEHICLE HAD THE BATTERY ENGINE COME OUT AND OTHER WEIRD VERBIAGE IVE NEVER SEEN. ALL OF A SUDDEN MY VEHICLE JUST STOP , BRAKES BECAME TOO STIFF TO TURN BACK THE VEHICLE AS YOU ARE SUPPOSE TO PRESS THE BRAKE AND PUSH THE START BUTTON. I WAIT WITH MY 9 YEAR OLD DAUGHTER ON A BUSY STREET AND IT WAS OVER 100 DEGREE WEATHER. WE WAITED MAYB 10MINS AND THE BRAKE BECAME SOMEONE MANAGEABLE TO PUSH AND THE VEHICLE STARTED AS SOON AS IT DID START SMOKE STARTED COMING OUT FROM THE HOOD DROVE TO A NEAR BY BUSINESS AND HAD TO WAIT OVER W HOURS FOR A TOW TRUCK. THIS IS SUCH A SAFETY HAZARD AS A MOTHER YOU WANT THE VEHICLE YOU DRIVE TO BE AS SAFE AS POSSIBLE BUT FOR A BRAND NEW VEHICLE ONLY A YEAR OLD TO STALL OUT THE WAY IT DID IS SO SCARY BECAUSE I COULD'VE BEEN HIT AND YOU NOT ONLY WORRY ABOUT YOUR SAFETY BUT YOUR CHILD'S SAFETY.
Power train, Other or unspecified, Engine, Jan 30, 2020
PRIOR TO RECALL NOTICE; ON 12-20-19 HUSBAND NOTICED COOLANT L LEVEL DOWN AT APPROXIMATELY 7,000 MILES. WENT TO LOCAL FORD DEALER TO PURCHASE COOLANT. WHILE THERE DEALER ASKED SEVERAL QUESTIONS CONCERNING SPECIFICS; LIKE, IS COOLANT LEAKING FROM YOUR ENGINE AND IS IT VISIBLE ON THE GROUND; HUSBAND SAID NO. RETUNED HOME WITH COOLANT AND FILLED THE RESERVOIR. JANUARY 18TH, 2020, RECEIVE RECALL NOTICE FROM FORD ADVISING COOLANT MAY BE INTRUDING INTO THE CYLINDERS; ADVISING TO CONTACT LOCAL DEALER FOR SERVICE. JANUARY 21ST, CAR INTO SERVICE TO REPROGRAM POWER TRAIN /CLEARED ALL CODES. JANUARY 22ST, 2020 TOOK AN 81 MILE TRIP TO LAKE AND BACK; HOURS LATER CHECKED THE COOLANT AND IT WAS DOWN AGAIN 5/8 'S INCH FROM MAX. JANUARY 23RD CALLED THE SCHEDULED ANOTHER APPT FOR JANUARY 29TH. JANUARY 29TH 2020, MCSPADDEN FORD HAD VEHICLE FOR 4.5 HOURS TO CONTINUE INVESTIGATION INTO EXCESSIVE COOLANT USE. UPON PICK UP OF VEHICLE, SERVICE MANAGER ADVISED THEY PUT CAR UP ON LIFT TO LOOK FOR LEAKS, NEGATIVE. HOOKED UP COMPUTER AND RAN CAR FOR 20 MINUTES LOOKING FOR ANYTHING UNUSUAL, NO PROBLEMS FOUND. REMOVE VALVE COVERS, INSPECTED BLOCK, PISTONS & CYLINDERS. IN PROCESS BOKE A SPARK PLUG THAT WAS REPLACED AT NO CHARGE. SERVICE MANAGER ADVISED THEY DID NOT FIND ANYTHING TO FIX; WE SHOULD JUST DRIVE IT LIKE NORMAL. DRIVING HOME AT 1.3 MILES (4 MIN) CAR SPUTTERS. ANOTHER .3 MILES (1 MIN) CAR SPUTTERS, BUCKS, STEERING VIBRATES, CAR SHAKES. ANOTHER .6 MILES (1 MIN) , CAR SPUTTERS & BUCKS, STEERING VIBRATES, CARE SHAKES, RPM GAUGE BOUNCING, CHECK ENGINE LITE COMES ON. ANOTHER .5 MILES (1 MIN) I PULL OFF THE HIGHWAY INTO RESIDENTIAL NEIGHBORHOOD AND CALL MCSPADDEN SERVICE WHO ADVISE TO IMMEDIATELY RETURN THE CAR TO THEM IF I AM ABLE. CAR LEFT AGAIN AT THE SHOP AT 1-29-2020 5:45.
Power train, Electrical system, Engine, Sep 25, 2019
STARTED THE CAR WHETHER MANUAL OR BY REMOTE START A POWERTRAIN MALFUNCTION WILL COME ON MY FORD PASS APP. ALSO ON THE DASHBOARD IT WILL SAY SHIFT SYSTEM FAULT. ONCE I PUT THE CAR IN DRIVE THE SERVICE LIGHT DISAPPEARS. THE VEHICLE WAS IN MY DRIVEWAY STATIONARY. ON 2 OTHER OCCASIONS SEPTEMBER 18 2019 AND SEPTEMBER 25 2019 THE CAR WAS IN MY DRIVEWAY STATIONARY. I STARTED THE CAR MANUALLY CAR WOULD NOT START (NO ENGINE TURN OVER) BUT CAR START STOP BUTTON WOULD BE GREEN AS IF CAR WAS RUNNING. THE DASHBOARD WOULD SAY FULL ACCESSORY MODE ACTIVE, TRANSMISSION NOT IN PARK, SHIFT SYSTEM MALFUNCTION. THE CAR DASHBOARD WOULD SAY THE CAR WAS IN DRIVE BUT THE TURN DIAL GEAR WOULD SHOW PARK. THE CAR GEAR DIAL WAS ALSO LOCKED AND WOULD NOT TURN. IF I TOOK OFF THE EMERGENCY BRAKE THE CAR WOULD ROLL BACKWARDS. ALSO I COULD NOT TURN THE CAR OFF AFTER THAT. AFTER 40- 60 MIN THE CAR SHOWED IT WAS GOING TO TURN OFF IN 15 MIN TO SAVE POWER. ONCE IT TURNED OFF. THE CAR WOULD START AND ENGINE WOULD TURN OVER AS IF NOTHING HAPPEND. I ALSO HAVE VIDEO OF BOTH TIMES CAR WOULD NOT START. WEBSITE WILL NOT LET ME UPLOAD VIDEOS