2019 Ford Fusion
Problems, recalls and owner-reported issues
Engine is the leading concern among 377 owner complaints filed for this model year. This is the 14th highest complaint count among 15 Fusion model years with reports.
Of the 2019 reports, 5 involved a crash and 2 involved a fire. 7 people were injured.
What owners report most often
Recalls and investigations
Equipment, electrical, engine block heaterOct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
An electrical short circuit can increase the risk of a fire.
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Campaign 25V685000 on NHTSA.gov
Back over prevention, softwareJun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Campaign 25V442000 on NHTSA.gov
Electrical system, propulsion system, traction battery, management system/energy control module (bms/becm)Jun 23, 2023
Ford Motor Company (Ford) is recalling certain 2019-2020 Fusion PHEV vehicles. The battery energy control module (BECM) may become damaged due to excessive voltage and current flow.
A damaged BECM can result in a loss of drive power or fire, increasing the risk of a crash.
Owners are advised not to charge their vehicles until the remedy is completed. Dealers will replace the battery and update the BECM software for free, or Ford will repurchase the vehicle. If your vehicle is currently operating normally, Ford has authorized dealers to replace the fuse block and a software update as an interim repair before the availability of remedy parts for the final repair. This repair will be free of charge (parts and labor). As an alternative remedy, Ford is offering a vehicle refund. Please see Ford's owner notification letter or contact Ford for full details. Owner notification letters were mailed May 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S33.
Campaign 23V440000 on NHTSA.gov
Representative owner complaints: other or unspecified
35 reports, newest first. Show all
Electrical system, Other or unspecified, Jan 5, 2024
Manufacturer Recall Number 23S33 NHTSA Recall Number 23V-440 Ford denied my buyback claim due to the vehicle being pre-owned, but with the open recall, I believe this vehicle to be a significant safety risk. My vehicle has limited functionality and reduced fuel economy in a model for which I specifically paid extra money. There is no fix in sight until the end of 2024 at the earliest, and there are other accounts of people's vehicles leaving them stranded or catching on fire! Ford does not have a fix for this vehicle, and a fix will not be available within a reasonable timeframe.
Other or unspecified, Nov 17, 2023
I am writing to bring to your attention a serious matter regarding the delayed resolution of a safety recall for my plug-in hybrid vehicle, a 2019 Ford Fusion Energi, with the Vehicle Identification Number (VIN) [XXX] . The recall in question was issued by Ford Motor Company in June 2023. As a responsible vehicle owner, I promptly responded to the recall notice and attempted to address the safety concern with my vehicle. Unfortunately, Ford has been unable to remedy the issue in a timely manner, and this situation is causing considerable inconvenience, financial losses, and most importantly, concerns about my safety and the safety of others on the road. My plug-in hybrid vehicle, which typically boasts an electric-only range of 26 miles when fully charged, has been rendered unable to charge due to the safety recall. Given that I charge my vehicle daily, this has resulted in 154 days, or 4,004 miles, of forced reliance on the gasoline engine. This not only contradicts the purpose and efficiency of a plug-in hybrid but has also led to approximately $300 worth of wasted gasoline, calculated using the IRS mileage reimbursement rate. Furthermore, the anxiety and stress associated with driving a vehicle under recall are substantial. I am worried each time I get into my car that it may catch fire or suddenly stall while I am on the road. This not only impacts my daily life but also compromises the safety of myself, passengers, and fellow motorists. I kindly request the National Highway Traffic Safety Administration's intervention to ensure a swift and effective resolution to this matter. The delay in remedying the safety recall not only undermines the purpose of owning a plug-in hybrid but also places the safety of consumers at risk. I trust that the NHTSA will investigate this matter thoroughly and take the necessary steps to ensure a timely and satisfactory resolution. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Other or unspecified, Oct 22, 2023
The current unresolved recall has impacted me numbered 23S33. This issue has impacted me since June 16 2023 and I have received minimal compensation. Due to rising gas prices in California, my inability to charge my car for my typical usage which was covered by the battery, and the higher purchase price I paid for this car, this recall has significantly impacted me.
Electrical system, Other or unspecified, Jun 12, 2022
Not sure what system is causing it but my trunk keeps opening and it’s done it many while I was driving. I understand a lot of other Ford Fusion owners are having the same problem and I urge you to look into the problem as it can cause accidents and deaths.
Other or unspecified, Mar 4, 2020, crash
TL* THE CONTACT OWNS A 2019 FORD FUSION. THE CONTACT STATED THAT HER DAUGHTER WAS DRIVING AT 45 MPH, THE VEHICLE BEGAN TO PULL TO THE LEFT AS AN ABNORMAL NOISE BEGAN EMITTING FROM THE VEHICLE. THE VEHICLE THEN INDEPENDENTLY TURNED TO LEFT AND HIT THE BARRIER WALL ON A BRIDGE WITHOUT WARNING. THE AIR BAGS DID NOT DEPLOY UPON IMPACT. HER DAUGHTER SUSTAINED NO MAJOR INJURIES, ONLY MINOR SORENESS. A POLICE REPORT WAS FILED AT THE SCENE. THE VEHICLE WAS TOWED TWICE TO TWO DIFFERENT INDEPENDENT MECHANICS. THE VEHICLE HAD YET TO BE REPAIRED. THE CONTACT SPOKE WITH A DEALER (JENKINS & WYNNE FORD, HONDA, & LINCOLN 2655 TRENTON RD, CLARKSVILLE, TN 37040) WHO INFORMED HER THAT THERE WERE NO ACTIVE RECALLS ON THE VEHICLE. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE AND WAS REFERRED TO NHTSA FOR ASSISTANCE. THE FAILURE MILEAGE WAS 20,000. THE VIN WAS NOT AVAILABLE.
Power train, Other or unspecified, Engine, Jan 30, 2020
PRIOR TO RECALL NOTICE; ON 12-20-19 HUSBAND NOTICED COOLANT L LEVEL DOWN AT APPROXIMATELY 7,000 MILES. WENT TO LOCAL FORD DEALER TO PURCHASE COOLANT. WHILE THERE DEALER ASKED SEVERAL QUESTIONS CONCERNING SPECIFICS; LIKE, IS COOLANT LEAKING FROM YOUR ENGINE AND IS IT VISIBLE ON THE GROUND; HUSBAND SAID NO. RETUNED HOME WITH COOLANT AND FILLED THE RESERVOIR. JANUARY 18TH, 2020, RECEIVE RECALL NOTICE FROM FORD ADVISING COOLANT MAY BE INTRUDING INTO THE CYLINDERS; ADVISING TO CONTACT LOCAL DEALER FOR SERVICE. JANUARY 21ST, CAR INTO SERVICE TO REPROGRAM POWER TRAIN /CLEARED ALL CODES. JANUARY 22ST, 2020 TOOK AN 81 MILE TRIP TO LAKE AND BACK; HOURS LATER CHECKED THE COOLANT AND IT WAS DOWN AGAIN 5/8 'S INCH FROM MAX. JANUARY 23RD CALLED THE SCHEDULED ANOTHER APPT FOR JANUARY 29TH. JANUARY 29TH 2020, MCSPADDEN FORD HAD VEHICLE FOR 4.5 HOURS TO CONTINUE INVESTIGATION INTO EXCESSIVE COOLANT USE. UPON PICK UP OF VEHICLE, SERVICE MANAGER ADVISED THEY PUT CAR UP ON LIFT TO LOOK FOR LEAKS, NEGATIVE. HOOKED UP COMPUTER AND RAN CAR FOR 20 MINUTES LOOKING FOR ANYTHING UNUSUAL, NO PROBLEMS FOUND. REMOVE VALVE COVERS, INSPECTED BLOCK, PISTONS & CYLINDERS. IN PROCESS BOKE A SPARK PLUG THAT WAS REPLACED AT NO CHARGE. SERVICE MANAGER ADVISED THEY DID NOT FIND ANYTHING TO FIX; WE SHOULD JUST DRIVE IT LIKE NORMAL. DRIVING HOME AT 1.3 MILES (4 MIN) CAR SPUTTERS. ANOTHER .3 MILES (1 MIN) CAR SPUTTERS, BUCKS, STEERING VIBRATES, CAR SHAKES. ANOTHER .6 MILES (1 MIN) , CAR SPUTTERS & BUCKS, STEERING VIBRATES, CARE SHAKES, RPM GAUGE BOUNCING, CHECK ENGINE LITE COMES ON. ANOTHER .5 MILES (1 MIN) I PULL OFF THE HIGHWAY INTO RESIDENTIAL NEIGHBORHOOD AND CALL MCSPADDEN SERVICE WHO ADVISE TO IMMEDIATELY RETURN THE CAR TO THEM IF I AM ABLE. CAR LEFT AGAIN AT THE SHOP AT 1-29-2020 5:45.
Other or unspecified, Sep 17, 2019
BOUGHT THE CAR LESS THAN 30 DAYS AGO. WASHING THE FRONT WINDSHIELD AND NOTICED A HAIRLINE CRACK ON THE OUTSIDE ABOUT 4-5 INCHES LONG. NO DAMAGES OF A ROCK HITTING THE WINDSHIELD.
Other or unspecified, Aug 1, 2019
3 WEEKS AFTER I LEASED THE VEHICLE NEW, THE WINDSHIELD SHATTERED WITHOUT ANYTHING HITTING IT. IT IS NOW 3 MONTHS LATER AND I ABOVE 7500 MILES ON THE CAR AND WHILE SITTING IN STOPPED TRAFFIC THE BACK GLASS EXPLODED ON ITS OWN. FORD CORPORATE ONLY ACCEPTED PHOTOS TAKEN AND SUBMITTED BY THE DEALERSHIP TO REVIEW THE CLAIM AFTER TELLING ME A 'TECHNICIAN WILL DETERMINE' WHAT HAPPENED. FORD SAID GLASS IS NOT COVERED UNDER WARRANTY. I EXPLAINED TO THEM THAT I UNDERSTAND BUT I AM MODE CONCERNED OF THE OVERALL SAFETY OF THE CAR AFTER THIS HAPPENED. 2 PHONE REPS AND THEIR SUPERVISOR REPEATEDLY SAID THERE IS NOTHING THEY CAN DO, TOLD ME IT IS NORMAL WEAR AND TEAR, AND THERE IS NO OTHER PHONE NUMBER OR DEPARTMENT I CAN CONTACT TO FURTHER PURSUE THIS ISSUE.
Other or unspecified, May 2, 2019
I WAS DRIVING A AVIS RENTAL CAR - FORD FUSION 2019 IN AN INTERSTATE FROM CHATTANOOGA, TENNESSEE TO DALTON, GEORGIA. I SAW AN ERROR MESSAGE ON THE SCREEN ALL OF A SUDDEN (LIKE COMMUNICATION ERROR) AND THE ENGINE JUST SHUT OFF, ALL LIGHTS TURNED OFF AND SEAT STARTED MOVING BACK. IT WAS ALMOST 15 - 20 SECONDS AND I WAS TERRIFIED TO JUST KEEP THE CAR ON MIDDLE LANE AND NOT TO BE HIT BY SOMEONE FROM BEHIND. THE GUY WHO WAS IN THE PASSENGER SEAT PUSHED THE START BUTTON AND IT STARTED AND I MANAGED TO DRIVE LAST 5 MILES TO REACH HOTEL. I CALLED AVIS ROADSIDE ASSISTANCE IMMEDIATELY ON RETURN TO HOTEL AND ASKED THEM TO RECORD THIS ISSUE. I ALSO INFORMED THE RETURN CAR ATTENDANT WHEN I RETURNED TODAY AT AVIS ATLANTA AIRPORT.
Other or unspecified, May 2, 2019
I WAS DRIVING A AVIS RENTAL CAR - FORD FUSION 2019 IN AN INTERSTATE FROM CHATTANOOGA, TENNESSEE TO DALTON, GEORGIA ON 5/1/2019 WEDNESDAY. I SAW AN ERROR MESSAGE ON THE SCREEN ALL OF A SUDDEN (LIKE COMMUNICATION ERROR) AND THE ENGINE JUST SHUT OFF, ALL LIGHTS TURNED OFF AND SEAT STARTED MOVING BACK. IT WAS ALMOST 15 - 20 SECONDS AND I WAS TERRIFIED TO JUST KEEP THE CAR ON MIDDLE LANE AND NOT TO BE HIT BY SOMEONE FROM BEHIND. THE GUY WHO WAS IN THE PASSENGER SEAT PUSHED THE START BUTTON AND IT STARTED AND I MANAGED TO DRIVE LAST 5 MILES TO REACH HOTEL. I CALLED AVIS ROADSIDE ASSISTANCE AND ASK D THEM TO REGISTER A COMPLAINT .I ALSO INFORMED THE ATTENDANT WHEN I RETURNED THE CAR AT ATLANTA AIRPORT TODAY.