2016 Kia Optima
Problems, recalls and owner-reported issues
Engine is the leading concern among 756 owner complaints filed for this model year. This is the 4th highest complaint count among 20 Optima model years with reports.
Of the 2016 reports, 27 involved a crash and 19 involved a fire. 21 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Latches/locks/linkages, trunk lid, latchAug 24, 2023
Kia America, Inc. (Kia) is recalling certain 2016-2017 Rio, 2016-2018 Optima, 2017-2018 Optima Hybrid and Optima Plug-in Hybrid vehicles. The trunk latch base may crack, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."
A person inside the trunk compartment may become trapped, increasing their risk of injury.
Dealers will replace the trunk latch base subassembly, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC278.
Campaign 23V594000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleJan 6, 2017
Kia Motors America (Kia) has recalled one 2016 Optima vehicle. In this vehicle, the end seal for the driver's frontal air bag inflator may not have been properly installed, possibly resulting in reduced inflation of the frontal air bag in the event of a crash.
In the event of a crash, an air bag that does not inflate fully increases the risk of injury.
The affected vehicle was remedied on January 10, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC143.
Campaign 17V007000 on NHTSA.gov
Power train, axle assembly, axle shaftOct 3, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 13, 2015, to April 23, 2016 and equipped with a 2.4l engine. The right front axle driveshaft may crack and fail.
If the driveshaft cracks and separates from the vehicle, it will not be able to move forward. Additionally, if the parking brake is not applied upon exiting the vehicle, the vehicle may roll. Either scenario can increase the risk of a crash.
Kia will notify owners, and dealers will replace the front axle driveshaft, free of charge. The recall began November 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC139.
Campaign 16V705000 on NHTSA.gov
Air bags, frontalApr 21, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 10, 2015, to February 12, 2016. In these vehicles, a chemical enhancer required for the for the second stage deployment of the driver's frontal air bag was not loaded, resulting in the second stage not deploying in necessitating crashes.
If the second stage air bag does not deploy it increases the risk of injury or death.
Kia will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began on May 6, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC131.
Campaign 16V231000 on NHTSA.gov
Representative owner complaints
756 reports, newest first.
Other or unspecified, Jul 25, 2025
While driving at approximately 45/50 mph, the right rear window suddenly dropped into the door panel without warning. This unexpected failure startled me and created a distraction while driving, as well as compromised my ability to hear and concentrate safely. My left rear window has also slipped into the door panel and is now being held up by shims and I have now discovered that the issue is due to a failed window regulator. This is a known issue in similar vehicles and poses a potential safety hazard, especially during adverse weather or high-speed driving. The Manufacturer has not issued a recall only a bulletin and the cost that was quoted to me from Hendrick Kia of Concord was over $900 dollars a regulator.
Power train, Electrical system, Engine, Jul 23, 2025
Complaint Message – 2016 Kia Optima Engine Failure Without Oil Light Warning I am the owner of a 2016 Kia Optima (VIN: [XXX] ). My vehicle suffered complete engine failure due to oil starvation — without any prior oil warning light or indication. The engine died while driving, and it was only afterward that I discovered the engine oil was extremely low. The oil pressure light never illuminated at any point to warn me. I am aware that Kia previously recalled earlier model years (2011–2014) for similar engine issues under Recall SC147 and others, related to the Theta II engine and oil pressure-related failures. Many owners reported the exact same symptom — catastrophic engine failure without oil light warnings — that I am now experiencing in my 2016 Optima. Although my model year is not included in the existing recall, the failure pattern appears identical. I believe this presents a significant safety issue that should be investigated. A critical warning system (oil pressure light) failed to function properly, which directly led to engine damage. I am requesting that this issue be reviewed and investigated by NHTSA and Kia for potential expansion of the recall or warranty coverage to include the 2016 Optima. I have already contacted Kia and am pursuing further review through the dealership and customer support. Please note that other 2016 Optima owners have reported similar complaints online and in forums, and this issue may affect a broader number of vehicles than currently acknowledged. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Jul 22, 2025
I’m experiencing severe oil consumption and spark plug fouling, which are known problems with the GDI engine. This is affecting driveability and may indicate piston ring or valve seal failure.
Electrical system, Jul 21, 2025
Odometer Fraud. The contact purchased a 2016 Kia Optima. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 56,276. and at the time of registration, it was discovered that the mileage was 114,000.
Engine, Jul 18, 2025
Engine issue, it’s knocking loud and misfires. Engine light flashing and Car went into limp mode , will not go over 60 mph . I have changed the spark plugs, knock sensor, and had an oil change nothing has fixed my issue.
Electrical system, Vehicle speed control, Jul 13, 2025
1) Rear passenger window failed a couple months ago. I believe it was regulator, not 100% sure. Cost me a couple hundred to fix. Now, few months later, the driver side rear window has failed. I rarely use the windows so I believe the failing parts are Kia known manufacturing defect. The dealer acknowledged that it’s a known problem with the vehicles like mine and even suggested the other one is going to fail soon. Now it has. If the dealership is aware then it’s likely a Kia flaw. If it’s a know manufacturing flaw, shouldn’t Kia should be fixing them instead of making customers spend upwards of $1k+ to fix both windows? 2) cruise control cuts off or doesn’t set and menus won’t go back to speedometer. While trying to set cruise control, it gets into the menu and won’t go back to the speedometer. Sometimes I have to pull over and stop to get the cruise control to work again. It gets stuck in the menu and can’t see the speedometer. Might get stuck on the trip screen, or the range. This has been happening since about 75k miles. It also doesn’t work with the pedal to set sometimes. Messing with it while driving can be a real hazard and sometimes I need to have cruise control to work. It’s deforming more than just inconvenient
Power train, Electrical system, Engine, Jul 9, 2025
Several safety-critical systems failed on this vehicle. The engine (Theta II 2.4L GDI) failed due to rod bearing wear, causing sudden power loss on the highway. The vehicle entered limp mode, once at 50 mph in 2018 and again at 70 mph in 2025, and had to be pulled over quickly to avoid collision. Additional issues: all four windows failed at different times, leaving them stuck open and creating safety risks in weather or emergencies. The trunk latch failed, causing unsecured cargo risk. ABS, TPMS, and traction control warning lights illuminated repeatedly, indicating possible loss of critical safety systems. A loose wiring harness caused the turn signal bulb to burn out repeatedly, reducing visibility and signaling. The dealership performed the KSDS software update after I reported engine trouble but did not resolve the issue. The engine soon failed completely while driving. Other issues, such as the fuse box blowing fuses from a standard USB charger have also been documented by a Kia dealership but not always fully repaired. The most recent engine failure and electrical defects are being inspected by a Kia dealership, and Kia Consumer Affairs is reviewing the warranty claim. Prior to the engine failure, I smelled burning oil and topped it off monthly due to excessive consumption. The oil level light and check engine light only appeared during limp mode right before the failure. These repeated safety-critical defects, particularly sudden engine failure at highway speed, created a significant safety hazard for myself and others on the road. At the time of this report, I am in the process of seeking warranty coverage for the catastrophic engine failure through Kia. The failure behavior (limp mode, flashing check engine light, and rod knock) is consistent with the safety defect described in the Theta II engine settlement. I am concerned that despite this being a known issue, there may be delays or denials in honoring the safety-related warranty repair.
Other or unspecified, Jul 9, 2025
I own a 2016 Kia Optima EX with VIN [XXX] . The engine failed at 85,763 miles due to a rod bearing seizure. This matches the known defect in Kia’s 2.4L GDI engines, which has been the subject of recalls and service campaigns in the past. Despite being covered under Kia’s extended engine warranty, Kia America denied my engine replacement claim. They cited "vehicle reconditioning" and "multiple ownership" as reasons — neither of which are valid grounds to void warranty coverage, especially for a known defect. A certified Kia dealership (Mark Kia in Scottsdale, AZ) approved my vehicle for warranty replacement, and submitted the request. Kia corporate denied it. This creates a serious safety concern and shows that Kia may be wrongfully avoiding responsibility for this defect. Please investigate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Jun 29, 2025
The vehicle went into limp power mode while driving
Electrical system, Visibility, Jun 27, 2025
The contact owns a 2016 Kia Optima. The contact stated that while driving in inclement weather on several occasions, all four windows of the vehicle became intermittently inoperable. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure. The failure mileage was approximately 130,000.
Electrical system, Jun 20, 2025
3 of windows do not roll up.
Structure, Jun 10, 2025
My paint has begun bubbling up and feeling out of nowhere. I’ve always taken good care of my car yet spots are beginning to pop up along the passanger side. The paint continues to peel more as time goes on. I’ve found many complaints online of people saying they’ve had the same issue with their kia in the Snow White Pearl color I have, but there’s no recall and kia refuses to pay for it.
Electrical system, Other or unspecified, Engine, Jun 10, 2025
A month in after purchasing the check engine light came on. My car did not want to accelerate, started shaking and having jerking movement while driving on the freeway with my newborn and 3 other children in the car with me. Got stranded 3 hours away from home. Car has been in the shop going on 30 days. Spark plugs changed, coolant thermostat changed and now the engine was reported that it has failed. Still in the shop currently.
Steering, May 28, 2025
MDPS failing when driving randomly. Steering locks up and vehicle is uncontrollable, while the vehicle is moving. This has occurred at varying speeds, while turning and while driving straight. Dealer has unsuccessfully got the issue to replicate, but independent service center was able to replicate it and found the extended warranty and recommended dealership visit since issue is covered. Vehicle has been inspected by dealership and the first recommended battery replacement, but this did not remedy the issue. EPS warning light is illuminated while issue is occurring but due to safety, car needs to be restarted to gain control of the vehicle and light turns off.
Electrical system, Other or unspecified, May 28, 2025
All 4 of the window regulator motors blew in my windows at the same time, only about 9 years into the vehicle's life. The little plastic pulleys that move the cables degrade over time and then ruin the rest of the window motor when they break, and since they decided not to make this an easily repairable part it requires the entire window regulator assembly which is half of the door to be replaced, not just this plastic part. I had to replace all 4 of them out of my own money, KIA REFUSED to replace something that is completely 100% their fault and it cost me over $3,500 to repair all four windows that went out pretty much at the same time. It's insane silly that anyone's windows can just break at anytime and be stuck in the down position. I can't just put up trash bags and then not be able to see a thing while I wait to get it fixed if it happens again. I was lucky enough to be in a position to get it looked at quickly, but it is absolutely insane that KIA would refuse to cover such a defect. There is already a class-action lawsuit over this I believe but they haven't even attempted to remedy the situation. Not everyone has time to wait for a lawsuit to settle. There should absolutely be some kind of recall/extended warranty on their windows. My engine blew at 57,400 miles only a few months later which is separate and was replaced but it's just insane that I was promised a car but got a piece of trash that consistently breaks while all I can get is a replacement engine with the same exact problem and no confirmation that the same thing won't just happen again while they continue to use the same defective engine over 10 model years. I want them to fix their issues not slap a band-aid over them and hope for the best. This company has been knowingly selling cars built to end up in a landfill within 10 years and they don't care.
Power train, Engine, May 19, 2025
Engine failed at 52.350 miles due to excessive oil consumption confirmed by a Kia dealership. Car was driving fine on 5/1/25, on 5/2/25, car started to stall with loud clicking noise, and wouldn't move fast, which then activated the check engine light.
Steering, Power train, May 16, 2025
While driving vechile shakes violently between 35-45 mph. I was informed the right axle needed replacement. There is a recall for 2016 optima axle replacement but Kia says my car doesn’t fall under it even though is the exact issue as the recall.
Power train, Engine, May 16, 2025
I went to the Garden Grove Kia to get my new 2016 kia optima repaired for their knock sensor settlement repair. By their own terms of the agreement all original and subsequent ow ers can get vehicles repaired. They took my vehicle information, I gave them all details of my ownership of the vehicle and they said they would fix it. The next day I rented a trailer to take the vehicle to get repaired (vehicle still runs but don't think it's safe to drive like that) and upon arriving, a worker comes out and tells me that they will not repir the vehicle because I just purchased the vehicle. Craig, the manager, also refused to see ownership documents but gave me 2 things; legal advice saying that I should sue where I bought the vehicle from and a paper that said they will not fix cars owned by dealers and auctions. I am neither am neither nor. Craig, also stated that Kia wont cover the repairs.
Engine, May 15, 2025
The check engine light came on in the car. Upon having it checked at a local automotive shop, we discovered that the thermostat assembly is malfunctioning. This can cause the engine to overheat and shut off at any time which of course would be a severe danger. Additionally, a bad thermostat assembly in Kia vehicles can lead to engine overheating or overcooling, potentially causing engine damage and even a fire risk. Upon searching, this appears to be a common issue with the 2016 Kia Optima.
Other or unspecified, May 4, 2025
Have a shake during accelerating 35-40 mph and then again at 70 mph. There is an axle, recall on 2016 kia optima. for certain months, my is not included. how is the recall determined. Have not had it checked out yet. It seems to be getting worst, will check soon.
Engine, Apr 28, 2025
Valve 3 does not have compression sent to private mechanic. Sent to KIA was told this is not covered under warranty for new engines went to say that intrest rates are down for new used cars. After some research this could be caused by engine recall.
Engine, Apr 23, 2025
Car has been consuming way more oil than usual which caused engine failed and I’ve filed several complaints with Kia America few years before engine failure with concerns of how much money I was spending in oil
Other or unspecified, Service brakes, Engine, Apr 14, 2025, fire
The car caught on fire while I was driving. No warning lights came on and the car didn't show it was running hot. I tried to engage the brakes, and they malfunctioned. I coasted the car to the side of the highway, where the fire and smoke plumed from under the car. I immediately exited the car and ran. As I was running from the car the grass was on fire. The car was totally destroyed by fire. The car has not been inspected by my insurance or Kia. Kia has a class action settlement for car fires the year, make, and model of mine.
Engine, Apr 14, 2025
The contact owned a 2016 Kia Optima. The contact stated while coming to a stop, the vehicle leaned forward as if the engine had moved abnormally too far forward out of position. The contact stated that her boyfriend attempted to roll down the passenger’s side window; however, the window failed to open as intended. No warning light was illuminated. In addition, the contact attempted to take the vehicle to the local independent dealer where it was purchased; however, the vehicle experienced a loss of automotive power. The vehicle was towed to the local independent mechanic, where it was diagnosed that the engine was blown and there was a hole in the engine. The contact was informed that the engine needed to be replaced. In addition, the contact diagnosed the failure and related the failure to the motor mount, alternator bracket, and in need of an intake manifold replacement. The local dealer was not contacted. The vehicle was not diagnosed or repaired by the local dealer. The vehicle was given back to the local independent dealer and the vehicle was repaired and put up for sale. The manufacturer was not made aware of the failure. The failure mileage was approximately 68,086. The VIN was not available.
Exterior lighting, Seats, Other or unspecified, Apr 8, 2025
Unknown