2007 Toyota RAV4
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,003 owner complaints filed for this model year. This is the highest complaint count among 26 RAV4 model years with reports.
Of the 2007 reports, 53 involved a crash and 37 involved a fire. 41 people were injured.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Air bagsApr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V245000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints
1,003 reports, newest first.
Engine, Jan 25, 2017
OIL CONSUMPTION PROBLEM.
Suspension, Jan 19, 2017
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION) AND STATED THAT THE PART WAS NOT AVAILABLE. THE DEALER DID NOT GIVE A TIME FRAME OF WHEN THE PARTS WOULD BECOME AVAILABLE TO COMPLETE THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Electrical system, Jan 12, 2017
MY VEHICLE WAS PARKED IN A PARKING LOT BUT WHEN I WANTED TO OPEN THE DOOR, THE FOB WOULDN'T WORK. THE BATTERY HAD BEEN DEPLETED AND WHEN I REPLACED THE BATTERY, BY AAA, THE DASHBOARD LIGHTS STAYED ON EVEN AFTER I TOOK OUT THE KEYS FROM THE IGNITION. THIS CAN CAUSE THE BATTERY TO DIE AGAIN. I HAVE TO DISCONNECT THE BATTERY SO THAT THE LIGHT THAT STAYS ON WILL NOT DEPLETE THE BATTERY. THE CAR SHAKES BECAUSE THE POWER ISN'T GETTING TO THE RECEIVER VERY WELL. THIS IS A PROBLEM INSIDE THE ELECTRIC HUB. AT ANY MOMENT MY CAR CAN SHUT OFF BECAUSE THE ELECTRIC CURRENT ISN'T STABLE WHEN THE CAR IS ON. ONE OF THE FUSES OR SOMETHING ISN'T DISCONNECTING PROPERLY, CAUSING THE DASHBOARD LIGHTS TO STAY ON.
Suspension, Jan 3, 2017
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Engine, Dec 22, 2016
MY OIL KEEPS BURNING EVERY 500 MILES
Service brakes, Fuel/propulsion system, Dec 16, 2016, crash
WHILE DRIVING ON AN EXPRESSWAY I ATTEMPTED TO SLOW MY VEHICLE. THE BRAKES BEGAN TO ENGAGE BUT THEN I FELT THE CAR ACCELERATE AND THE CAR "STUTTERED". IT MAY HAVE BEEN THE BRAKE ASSIST KICKING IN. IT ACCELERATED. AFTER A FEW SECONDS, THE BRAKES FINALLY ENGAGED. ABOUT 2 MILES DOWN THE ROAD, THE SAME THING HAPPENED EXCEPT THAT THE BRAKES DID NOT ENGAGE UNTIL A FEW SECONDS LATER AND I REAR-ENDED SOMEONE. THANKFULLY THERE WERE NO INJURIES.
Engine, Dec 16, 2016
EXCESSIVE OIL CONSUMPTION. NOTICES MY VEHICLE USED 1/2 A QUART OF OIL IN 480 MILE. TOOK IT IN FOR EXCESSIVE OIL CONSUMPTION TEST. DEALER INDICATED I MAY HAVE TO DO $170-$1200 IN GASKET REPLACEMENT TO QUALIFY FOR WARRANTY REPAIRS. FIRST I COULD NOT SEE WHAT THEY WERE TALKING ABOUT, I.E. NOT LEAKS VISIBLE/APPARENT TO ME. ALSO THIS DID NOT MAKE SENSE ESPECIALLY SINCE THE REPAIRS THEY INDICATED I MAY NEED TO DO, WILL HAVE TO BE REDONE DURING THE WARRANTY REPAIRS. WHEN ASKED WHY, THEY SAID THEY HAD TO REQUIRE THEM TO BE DONE BECAUSE TOYOTA HQ WOULD STICK THEM WITH THE WARRANTY REPAIR BILL IF THEY DISAGREED WITH THEM AS TO WHETHER TO AUTHORIZE THE WARRANTY REPAIRS. TOYOTA HAS ADMITTED THEY HAVE A DESIGN FLAW IN THIS ENGINE IN THIS VEHICLE. WHY WON'T THEY FIX IT WITHOUT SUCH A HASSLE. THIS NEEDS TO BE MADE A FORMAL RECALL SO THEY ARE FORCED TO STOP TAKING ADVANTAGE OF THEIR CUSTOMERS.
Engine, Dec 12, 2016
EXCESSIVE OIL CONSUMPTION - AFTER FULL OIL CHANGE AND DRIVING 4,000 - BEFORE THE NEXT SCHEDULED OIL SERVICE - NO OIL LEFT. *TR
Engine, Dec 8, 2016
OIL CONSUMPTION ISSUE - DEALER CONDUCTED A TEST AND PASSED THE VEHICLE DESPITE IT BURNING A QUART OF OIL AT 1100 MILES - WHICH POINTS IT A 0.009 QUARTS PER MILE - THIS MEANS AND 5000 MILES (THE RECOMMENDED MILEAGE BETWEEN OIL CHANGES) THE CAR HAS BURNED THROUGH 4.54 QUARTS WHEN IT ONLY HOLDS 4.5 QUARTS - IT CONSUMES ALL THE OIL BETWEEN OIL CHANGES. HOW CAN THIS CAR PASS THE TEST?
Service brakes, Engine, Dec 2, 2016
OIL INDICATOR LIT UP. I CHECKED THE DIP STICK AND OIL WAS WELL BELOW MINIMUM LEVEL. I ADDED 2 QUARTS OF OIL. MY RAV4 HAS MORE THAN 1000 MILES LEFT BEFORE THE SCHEDULED 5K OIL CHANGE AND NEITHER HAS IT BEEN 6MOS YET. BROUGHT THE CAR TO THE DEALER AND THEY PERFORMED OIL CONSUMPTION TEST. CAR MILEAGE WAS 87000. I BROUGHT THE CAR BACK AFTER 1000MILES AS INSTRUCTED TO DO SO. THE TEST TURNED OUT NEGATIVE. COUDN'T DO ANYTHING ELSE AS THE CAR IS OUT OF WARRANTY. I LOOKED ONLINE AND THERE WERE A NUMBER OF COMPLAINTS BUT NO ASSOCIATED RECALLS REGARDING THIS PROBLEM. ANOTHER PROBLEM IN MY RAV4 IS WHEN STEPPING ON THE BRAKES, IT ACCELERATES FIRST BEFORE STOPPING. AGAIN THERE WERE NO RECALLS ABOUT IT.
Suspension, Nov 18, 2016
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION). THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Electrical system, Nov 18, 2016
DROVE FOR OVER AN HOUR IN DRY, STABLE WEATHER CONDITIONS. UPON SLOWING TO MAKE A LEFT TURN INTO A PARKING GARAGE ON SURFACE STREETS THE STEERING COMPLETELY STALLED WITH MULTIPLE ALARM LIGHTS FLASHING, INCLUDING BATTERY. VEHICLE WAS STILL ON AND ABLE TO DRIVE BUT WITH VERY POOR ACCELERATION. THIS CAUSED ME TO BLOCK TRAFFIC ONCOMING TRAFFIC FOR OVER 10 MINUTES AS I LABORED (WITH A LOT OF STRENGTH) WITH THE STALLED POWER STEERING BACK AND FORTH UNTIL INLINE WITH THE GARAGE. CALLED TRIPLE A IMMEDIATELY AND HAD BATTERY CHANGED. DESPITE THE CAR WORKING AGAIN WITH STABLE STEERING, STILL CONCERNED ABOUT STALLING AGAIN, PARTICULARLY IN CITY STREETS (INCLUDING THE SF HILLS) AND FREEWAYS. THERE NEEDS TO BE SOME FIX FOR POWER-STEERING BEING THE FIRST THING TO FAIL WITH THE BATTERY/ALTERNATORS.
Power train, Nov 16, 2016
TRANSMISSION SLIPS OR JERKS AFTER VEHICLE SLOWS DOWN AND SPEEDS UP. THIS IS UNSAFE IN TRAFFIC DUE TO VEHICLES FOLLOWING BEHIND AND STOPS WHICH COULD CAUSE A REAR END COLLISION DUE TO HESITATION WHEN VEHICLE SHOULD BE EXCELERATED BUT IT SLOWS THEN JERKS BACK WHICH CAN BE FELT WHEN DRIVING. EVEN FELT DURING EXCELARATION IN NORMAL DRIVING CONDITIONS. THIS HAPPENS DURING PRESSING DOWN ON GAS PETAL WHEN THE TRANSMISSION GEARS SHOULD CHANGE SMOOTHER, IT SLIPS OR JERKS INTO PLACE, THEN SLOWS BACK DOWN AGAIN AFTER ACCELERATION.
Engine, Nov 14, 2016
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 30 MPH, THE OIL INDICATOR ILLUMINATED. THE CONTACT CHECKED THE OIL AND NOTICED THAT THE OIL TANK WAS EMPTY. THE CONTACT ADDED FOUR QUARTS OF OIL AND TOOK THE VEHICLE TO THE DEALER WHO PERFORMED AN OIL CHANGE. THE CONTACT WAS ADVISED TO DRIVE THE VEHICLE AND TO BRING IT BACK AFTER 1,100 MILES. THE VEHICLE WAS TAKEN BACK TO THE DEALER AT 1,100 MILES. THE DEALER STATED THAT THE VEHICLE DID NOT QUALIFY FOR AN OIL CONSUMPTION SERVICE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000. UPDATED 01/05/2017*CT UPDATED 10/2/2017*JS
Wheels, Nov 13, 2016
THE WHEELS WERE DESIGNED WITH A LIP THAT DOES NOT DRAIN, CAUSING THEM TO RUST OVER TIME AS WATER AND ROAD WASTE SITS IN THE LIP. I ONLY LEARNED ABOUT THE RUST, WHICH IS NOT VISIBLE, WHEN I RECENTLY PURCHASED A NEW SET OF TIRES. SURPRISINGLY, MY NEW TIRES IMMEDIATELY STARTED LOSING AIR. AFTER CHECKING THE TIRES AND REPLACING THE VALVE STEMS, MY MECHANIC USED THE SOAPY WATER TEST TO DETERMINE THAT THE WHEELS THEMSELVES ARE SO RUSTED THAT THEY ARE LETTING AIR ESCAPE. THE LIP OF ALL FOUR WHEELS ARE RUSTED TO THE POINT WHERE THE RUST IS FLAKING OFF. GIVEN THE DETERIORATION OF THE WHEELS, I AM CONCERNED FOR MY SAFETY. MY INITIAL CONTACT WITH TOYOTA RESULTED IN NO ACTION BY THEM. I AM WRITING TO THE VP OF MARKETING TO MAKE HIM AWARE OF MY CONCERNS.
Suspension, Nov 12, 2016
NHTSA RECALL NO. 16V-596. WHAT IS THE PARTS STATUS? MY LOCAL DEALERSHIP STATES PARTS NOT AVAILABLE FOR COMPLETION OF RECALL 16V-596. THIS FEELS ME WITH DREAD, IN THAT I DO NOT DARE DRIVE MORE THAN 5 TO 10 MILES FROM MY RESIDENCE WHICH I DO WITH GREAT TREPIDATION AND I DO NOT DARE TAKE MY GRANDCHILDREN WITH ME. I NEED TO DRIVE FOR DAILY CONVENIENCES, IE FOOD AND MEDICAL APPTS. TO NAME A FEW. WHAT IS THE STATUS OF THESE PARTS FOR THIS SAFETY RECALL. MY RAV-4 WAS LAST SERVICED AT PECHELES OF WASHINGTON NC ON 10 25 2016- INVOICE NO. TOCS233900-CUSTOMER 28903. CURIOUS? ARE WE WAITING ON SOME ONE TO SUFFER AN UNTIMELY DEMISE BEFORE WE GET AFTER TOYOTA INC. THIS LACK OF PROGRESS OR AN UPDATE AS TO THE STATUS OF THE PARTS IS TROUBLESOME.
Suspension, Nov 10, 2016
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 16V598000 (SUSPENSION). THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Engine, Nov 3, 2016
STARTING IN MARCH 2016 IT BECAME EVIDENT THE VEHICLE IS CONSUMING A LOT OF OIL, IT IS NOT MAKING IT BETWEEN OIL CHANGES. NOW BETWEEN OIL CHANGES AT LEAST 2 QTS OF OIL HAS TO BE ADDED.
Steering, Power train, Nov 1, 2016
WHEN I BACK UP ON ANY KIND OF AN INCLINE, THE CAR JERKS AND THE STEERING WHEEL SHAKES. IT FEELS LIKE I HAVE "HIT" SOMETHING IT JERKS SO BADLY. IF I LET OFF THE GAS PEDAL, IT STOPS THE JERKING BUT THE MINUTE I PRESS THE GAS PEDAL AGAIN, IT JERKS AGAIN AND MAKES A TERRIBLE NOISE. I CAN STILL BACK UP BUT IT FEELS LIKE THE UNDERSIDE OF MY CAR IS FALLING OUT. IT'S BEEN GOING ON SINCE I PURCHASED IT USED 2 YEARS AGO. I KEPT THINKING IT WAS ME UNTIL I GOOGLED IT TODAY AND SAW SEVERAL OTHER PEOPLE HAVE THE SAME ISSUE. I FEEL IT'S UNSAFE AND TOYOTA NEEDS TO TAKE CARE OF IT. MY VEHICLE ALREADY QUALIFIED FOR THE OIL CONSUMPTION ISSUE AND WAS REPAIRED EARLIER THIS YEAR. NEEDS TO BE A NATIONAL RECALL AND FIXED PROPERLY.
Steering, Suspension, Oct 26, 2016
NHTSA RECALL NO 16V 596. ATTEMPTED TO HAVE RECALL COMPLETED AT WASHINGTON NC PECHELES TOYOTA. PARTS ARE NOT AVAILABLE AS OF 10 25 2016. WHAT IS THE HOLD UP? FAILURE OF RLSA WILL RESULT IN LOSS OF VEHICLE CONTROL- SERIOUS SAFETY ISSUE.
Engine, Fuel/propulsion system, Oct 25, 2016
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT'S VEHICLE RECEIVED A RECALL REPAIR THAT INVOLVED REBUILDING THE ENGINE. A MONTH AFTER RECEIVING THE REPAIR, SMOKE APPEARED UNDER THE HOOD WHEN ACCELERATING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE BLEW OUT BECAUSE FUEL FROM THE FUEL INJECTOR LEAKED ONTO THE ENGINE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE NHTSA CAMPAIGN NUMBER AND FAILURE MILEAGE WERE UNKNOWN.
Seat belts, Oct 19, 2016
TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SEAT BELTS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Engine, Oct 10, 2016
EXCESSIVE OIL CONSUMPTION. ENGINE LOCKED. AFTER CONTACTING TOYOTA MAIN HOTLINE TO ALERT THEM OF THE PROBLEM. THEY PROVIDED ME WITH INFORMATION TO TEST THE OLI CONSUMPTION AND TO TAKE THE RESULTS TO THE LOCAL DEALERSHIP. AFTER COMPLETING INITIAL TESTING, THE DEALERHSHIP INFORMED ME THAT IT WAS NOT BURNING OIL. THE VEHICLE STILL WAS BURNING OLL. TOYOTA SUBSEQUENTLY ISSUED A NOTICE THAT THE VEHICLES WERE BURNING OIL AND THAT THEY WOULD SEND A PART TO THE DEALERSHIPS TO REPAIR THE PROBLEM. THE DEALERSHIP THEN INFORMED ME THAT THEY WERE WAITING ON THE PARTS TO CORRECT THE PROBLEM. THE PARTS NEVER ARRIVED AND NOW MY ENGINE HAS LOCKED DUE TO INSUFFICIENT OIL. I WANT TO BE MADE WHOLE.
Engine, Oct 5, 2016
TOOK VEHICLE IN FOR AN UNRELATED RECALL AND WAS TOLD WE NEEDED TO HAVE AN OIL CONSUMPTION TEST, VEHICLE FAILED - HAD ENGINE REBUILD WORK PERFORMED AT TOYOTA DEALERSHIP (AS RECOMMENDED BY TOYOTA TO REMEDY THE OIL CONSUMPTION FAILURE) FREE OF CHARGE WITH THE EXCEPTION OF THE DEALERSHIPS RECOMMENDATION OF REPLACING THE WATER PUMP AND GASKETS WE PAID FOR. LESS THAN 10K MILES LATER THE MOTOR IS BLOWN - CAUSE GIVEN: OIL STARVATION. WE HAD THE OIL CHANGED EVERY 3000 MILES AND THE OIL WAS CHECKED ONCE A MONTH AND NEVER SHOWED LOW ON THE DIP STICK. THE DEALERSHIP AND AN ENGINEER DEEMED THE PROBLEM IS OURS AND TAKE NO RESPONSIBILITY. WE AS CONSUMERS WERE NEVER REPRESENTED AT THE TIME THE DETERMINATION WAS MADE. I HAVE REQUESTED THE ENGINEER'S REPORT IN WRITING. TO BE CLEAR, THE VEHICLE WAS PERFECTLY FINE WHEN ORIGINALLY TAKEN IN FOR THE UNRELATED RECALL, IT DIDN'T EVEN REQUIRE ADDITIONAL OIL BETWEEN OIL CHANGES.
Engine, Sep 13, 2016
I STARTED AN EXCESSIVE OIL CONSUMPTION TEST WITH WESTCHESTER TOYOTA ON 2-27-15 AND FAILED ON 4-7-15. SINCE THEN I HAVE BEEN REPEATEDLY TOLD THAT I AM A WAITING LIST AND IT IS UNKNOWN WHEN MY ENGINE WILL B OVERHAULED. MY CURRENT RATE OF OIL CONSUMPTION IS 10 QUARTS OF OIL FOR 3000 MILES AND THIS HAS STEADILY INCREASED. MY EXHAUST IS COATED IN BURNT OIL AND I FEAR THE ENGINE WILL SEIZE AT SOME POINT. YET I AM ON A WAITING LIST FOR OVER A YEAR WITH NO REPAIR DATE IN SITE.