2003 Ford Explorer
Problems, recalls and owner-reported issues
Structure is the leading concern among 1,313 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Explorer model years with reports.
Of the 2003 reports, 69 involved a crash and 19 involved a fire. 66 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Representative owner complaints: power train
356 reports, newest first. Show all
Power train, Sep 30, 2008
I CAN'T SEEM TO GET THE FRONT DIFFERENTIAL TO STOP LEAKING - NEITHER CAN MY MECHANIC. MY MECHANIC HAS REPLACED THE "CRUSH WASHER" (WHERE THE DRIVELINE CONNECTS TO THE DIFFERENTIAL) A COUPLE OF TIMES. I WAS TOLD THE DIFFERENTIAL WAS MANUFACTURED BY DANA. I DON'T WANT TO REPLACE THE DIFFERENTIAL BECAUSE MY DRIVER'S SIDE FRONT HALF-SHAFT WILL PROBABLY HAVE TO BE REPLACED ALSO... THE THREADS ON THE END OF THE SPINDLE HAVE RUSTED OFF. I'LL PROBABLY ALSO HAVE TO REPLACE THE (LF) WHEEL BEARING. (I THINK I'LL HAVE TO BECAUSE I HAD TO HAVE THE FORD DEALERSHIP REPLACE BOTH REAR WHEEL BEARINGS BACK WHEN THE VEHICLE ONLY HAD 36,000 MILES ON IT) NOT CRITICAL STUFF HERE - JUST A NUISANCE. THANKS. *TR
Service brakes, Hydraulic, Engine and engine cooling, Power train, Electrical system, Sep 16, 2008
I PURCHASED A 2003 EXPLORER IN AUGUST 2006; MILEAGE WAS APPROXIMATELY 45,000. BY OCTOBER THE CAR WOULD NOT START AND THE ALTERNATOR WAS REPLACED. A FEW WEEKS LATER, I WAS BACK BECAUSE MY CAR WAS JERKING. NOTHING SHOWED UP ON THE DIAGNOSTIC TOOL AT THAT TIME. HOWEVER, I WAS TOLD THE STARTER WOULD HAVE TO BE REPLACED AS WOULD THE RECENTLY INSTALLED ALTERNATOR. I RETURNED LESS THAN A MONTH LATER WITH THE SAME JERKING ISSUE, ONLY THIS TIME I NOTIFIED THE REPAIR SHOP THAT THE O/D LIGHT HAD BEEN COMING ON. FURTHERMORE, MY CAR HAD ACTUALLY STALLED IN THE MIDDLE OF TRAFFIC. AGAIN, NOTHING WAS FOUND. BY EARLY DECEMBER, I WAS BACK. MY CAR HAD STALLED ON A FEW MORE OCCASIONS AND WOULD NOT "PICK UP". THAT IS, EVEN THOUGH THE RPM'S WOULD REACH ANYWHERE FROM 2500 - 4000, MY CAR COULD NOT ACCELERATE ABOVE 25 - 30 MPH. SEVERAL DAYS LATER I WAS TOLD THAT THE TRANSMISSION NEEDED WORK. I GOT MY CAR BACK A FEW DAYS BEFORE CHRISTMAS AND DECIDED LAST MINUTE TO HEAD TO THE MOUNTAINS. AS SOON AS I REACH A SLIGHT ELEVATION, THE CAR CEASED TO ACCELERATE AND WHAT'S MORE, A THICK HEAVY CLOUD OF BLACK SMOKE CAME OUT OF THE REAR AND PERSISTED FOR AT LEAST TWO MILES. I HEADED BACK DOWN THE MOUNTAIN FOR HOME. I TOOK THE CAR BACK AND THEY KEPT IT FOR AT LEAST A WEEK AND A HALF TO REPAIR THE TORQUE CONVERTER AND OTHER TRANSMISSION RELATED ISSUE. IN EARLY FALL 2007, I TOOK THE CAR TO MY LOCAL FORD DEALER FOR SOME STRANGE NOISE COMING FROM THE ENGINE. IT ENDED UP COSTING $2500.00 TO REPAIR. I RETURNED IN NOVEMBER FOR MORE WORK, THIS TIME FOR THE SAME TORQUE CONVERTER AND SOLENOID ISSUE AS A YEAR AGO. DURING THIS TWO YEAR PERIOD, MY VEHICLE WAS UNDER EXTENDED WARRANTY. THE TOTAL REPAIR COST FOR THE FIRST YEAR OF OWNERSHIP IS ANYWHERE FROM $5000 - $9000, OF WHICH I PAID AT LEAST $2500 OUT OF POCKET. MY WARRANTY HAS SINCE EXPIRED AND I AM WORRIED THAT THESE SAME ISSUES WILL RECUR, AS I HAVE READ THEY HAVE. THIS IS NOT AN ISOLATED INCIDENT AND SHOULD BE INVESTIGATED AND A RECALL ISSUED. *TR
Power train, Sep 7, 2008
THIS VEHICLE IS A 2003 FORD EXPLORER LIMITED WITH A SEVERE ROAR COMING FROM THE REAR END. THERE IS A TECHNICAL BULLETIN OUT AT REPAIR SHOPS BUT NO RECALL. IT COULD RESULT IN THE GEARS LOCKING DOWN AND LOSING CONTROL WHILE DRIVING. IT IS A DEFECT OF THE FORD MOTOR CO AND SHOULD BE UNDER RECALL. THE COST OF REPAIR IS AROUND $1400.00. THE NOISE IS SO LOUD THAT IT COULD BLOCK THE ABILITY TO HEAR ONCOMING TRAFFIC AND EMERGENCY VEHICLES. YOU DON'T HAVE TO WORRY ABOUT USING A CELL PHONE WHILE DRIVING IN THIS VEHICLE BECAUSE YOU WOULD NOT BE ABLE TO HEAR THE OTHER PERSON. I UNDERSTAND THAT ALL FORD,LINCOLN, AND MERCURY SUV'S ARE A PART OF THIS TECH-BULLETIN. THE YEARS THAT ARE AFFECTED ARE 2002-2006. PLEASE CONSIDER ISSUING A RECALL SOON. *TR
Power train, Sep 2, 2008
I OWN A 2003 FORD EXPLORER. I HAVE OWNED IT SINCE BUYING IT FROM VOGLER FORD IN CARBONDALE, ILLINOIS. A FEW MONTHS AGO THE OVERDRIVE LIGHT BEGAN TO FLASH ALL THE TIME AND IT SHIFTS HARD GOING FROM 2ND TO 3RD GEAR. I SEARCHED THIS PROBLEM ON THE INTERNET TO SEE IF I COULD REPLACE A PART ON IT. I HAVE READ NUMEROUS COMPLAINTS ABOUT THESE TRANSMISSIONS. HAVE THEY RECALLED ANY FAULTY TRANSMISSIONS FROM FORD VEHICLES. *TR
Power train, Aug 24, 2008
SEVERE REAR END NOISE HAS BEEN HAPPENING FOR OVER A YEAR NOW. REAR DIFFERENTIAL NOW NEEDS TO BE CHANGED. ALTHOUGH THERE ARE TECHNICAL SERVICE BULLETINS THE DEALERSHIP WILL NOT WORK WITH ME ON THE COST OF THESE REPAIRS. I HAVE ALSO HAD A SENSOR REPLACED TWICE AND IT IS NOW BROKEN AGAIN. *TR
Power train, Structure, Equipment, Aug 5, 2008
FACTORY REAREND WAS REPLACED IN MY 03 FORD EXPLORER. SINCE THEN THE PROBLEM OF GRADUAL REAREND DETERIORATION HAS NOT BEEN FIXED. IF THE REAREND FAILS CATASTROPHICALLY THEN A SERIOUS ACCIDENT COULD OCCUR. FORD MOTORS DOES NOT CONSIDER THIS TO BE A SAFETY CONCERN, BUT IT DEFINITELY IS. FORD SHOULD RECALL ALL VEHICLES WITH THE DEFECTIVE REARENDS AND FIX THEIR PROBLEM. *TR
Power train, Jul 18, 2008
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE TRANSMISSION FREQUENTLY MALFUNCTIONED. WHEN HE WOULD SHIFT INTO REVERSE OR DRIVE, THE VEHICLE WOULD NOT RESPOND. HE WOULD HAVE TO WAIT TEN MINUTES FOR THE TRANSMISSION TO ENGAGE OR EVEN SHUT OFF THE VEHICLE AND TRY AGAIN. EVERYTIME THE VEHICLE WAS TAKEN TO THE DEALER, THEY COULD NEVER DUPLICATE THE FAILURE. AFTER A DIAGNOSTIC WAS PERFORMED, THE DEALER COULD NOT FIND ANY FAILURES. THE CONTACT TOOK THE VEHICLE TO THE DEALER AT LEAST 5-6 TIMES FOR THE FAILURE, BUT WAS NOT GIVEN ANY EXPLANATION. THE CURRENT MILEAGE WAS APPROXIMATELY 62,000 AND FAILURE MILEAGE WAS APPROXIMATELY 20,000.
Suspension, Power train, Jul 8, 2008
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT HEARD A LOUD WHINING SOUND COMING FROM THE REAR OF THE VEHICLE WHILE ACCELERATING AND DECELERATING. THE SERVICE MANAGER STATED THAT HE COULD NOT FIND ANYTHING IN HIS COMPUTER THAT WAS RELATED TO THE FAILURE. THERE ARE CURRENTLY TEN NHTSA SERVICE BULLETINS RELATED TO THE FAILURE. THE CURRENT MILEAGE WAS 76,000 AND FAILURE MILEAGE WAS 55,000. UPDATE 09/10/08 *CW THE CONSUMER WAS TOLD THE REAR AXLE MAY HAVE TO BE REPLACED. UPDATED 09/11/08. *JB
Power train, Jun 29, 2008
APRIL 2008, O/D LIGHT STARTED BLINKING & VEHICLE STARTED SHIFTING HARD; TOOK TO FORD DEALERSHIP THE NEXT WEEK; AFTER COMPUTER DIAGNOSTIC SAID I NEEDED TO REPLACE TRANSMISSION ON 2003 EXPLORER WITH 80,000 MILES; WITHIN 2 MONTHS THE VEHICLE WAS PARKED BECAUSE THE TRANSMISSION WAS NOT WANTING TO SHIFT INTO REVERSE REGARDLESS OF WEATHER CONDITIONS. *TR
Power train, May 2, 2008
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING 25 MPH, THE TRANSMISSION CAUSED THE RPM'S TO INCREASE FROM 1,000 TO 4,000, FOLLOWED BY A LOUD THUMPING NOISE. THE OVERDRIVE LIGHT WOULD ALSO REMAIN ILLUMINATED AFTER THE MALFUNCTION. THE VEHICLE HAS BEEN DIAGNOSED BY THE DEALER, BUT STILL CONTINUES TO FAIL. THE FAILURE MILEAGE WAS 44,000.
Power train, Apr 24, 2008
O/D LIGHT FLASHES TRANSMISSION HAS TROUBLE SHIFTING OUT OF 1ST GEAR. *TR
Power train, Apr 7, 2008
DRIVING TO WORK FROM HOME, O/D OFF LIGHT BEGAN FLASHING AND GOING FROM 1ST TO 2ND GEAR LAGGED. RETURNING HOME THAT NIGHT, O/D OFF LIGHT BEGAN FLASHING AND SERVICE ENGINE SOON LIGHT CAME ON ALONG WITH LAGGING IN SHIFTING. TOOK TO MECHANIC WHO PERFORMED TRANSMISSION MAINTENANCE AND REPLACED SOLENOID. THIS CORRECTED SERVICE ENGINE LIGHT, BUT O/D LIGHT STILL FLASHED. FOUND FILINGS IN TRANSMISSION FLUID WHICH LED TO REPLACING TRANSMISSION. FOUND FORUMS THAT RELATED SIMILAR PROBLEMS WITH TRANSMISSION. AT LEAST I GOT 90,000 MILES BEFORE THIS HAPPENED. *TR
Power train, Mar 29, 2008
EXCESSIVE WHINE/NOISE COMING FROM THE REAR END OF THE VEHICLE, AT HIGHWAY SPEEDS. *TR
Power train, Mar 28, 2008
WHEN SHIFTED INTO REVERSE THE VEHICLE WILL INTERMITTENTLY SLAM INTO THE GEAR AFTER SOME TIME HAS LAPSED, OR OTHER TIMES IT WON'T MOVE INTO ANY GEAR AND FREEZES IN A NEUTRAL STATE, EVEN WHEN THE SHIFT LEVER IS MOVED INTO DRIVE OR ANY OTHER GEAR, FOR THAT MATTER. THESE EVENTS HAVE OCCURRED AT LEAST SEVERAL TIMES IN THE 1 MONTH PERIOD WE HAVE OWNED IT. PURCHASED IT FROM A DEALER ON 2/24/08 WITH 53,000K MILES ON IT. IT IS CURRENTLY IN A FORD DEALER (1 WEEK SO FAR) FOR SERVICE, BUT THEY SAY THEY CAN NOT REPLICATE THE PROBLEM WITH THE TRANSMISSION. IF I PICK UP THE VEHICLE NOW THE USED VEHICLE WARRANTY THAT CAME WITH THE VEHICLE WILL EXPIRE AND WILL NOT COVER THE PROBLEM WHEN IT DOES COMPLETELY FAIL. AFTER READING ALL THE PROBLEMS THESE TRANSMISSIONS HAVE, IT IS INEVITABLE IT WON'T BE LONG BEFORE THAT HAPPENS. HOPEFULLY, IT WON'T BE IN THE MIDDLE OF TRAFFIC OR WORSE YET, WHEN DRIVING WITH MY GRANDKIDS SOMEWHERE. THIS IS DEFINITELY A SAFETY ISSUE, AS THE TOTAL FAILURE OFTEN HAPPEN WITH NO WARNING. THE VEHICLE OTHERWISE DRIVES GREAT. *TR
Suspension, Power train, Mar 27, 2008
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING 30 MPH, THE CONTACT HEARD A WHINING NOISE COMING FROM THE VEHICLE. THE NOISE BECOMES LOUDER AS THE VEHICLE TRAVELS FASTER. THE WHINING APPEARS TO BE COMING FROM THE REAR SUSPENSION. THE FAILURE MILEAGE WAS 120,000 AND CURRENT MILEAGE WAS 144,800. UPDATED 04/14/08. *LJ THE CONSUMER STATED THE TRANSMISSION WAS REPLACED AT NO CHARGE BY FORD AT 55,000 MILES DUE TO A DEFECT. THE 4-WHEEL DRIVE MAKES EXCESSIVE NOISE WHEN IN GEAR. UPDATED
Power train, Mar 18, 2008
WITH NO ADVANCE WARNING, THE O/D OFF LIGHT BEGAN FLASHING AND THE TRANSMISSION BEGAN TO SLIP. MECHANIC SAID THE TRANSMISSION IS SHOT. I HAVE NOT DONE ANY OF THE WORK YET, AS I CAN NOT AFFORD $3000 IN REPAIRS. I HAVE SINCE FOUND OUT THAT THIS PROBLEM OCCURS ON A LARGE NUMBER OF FORD EXPLORERS. *TR
Power train, Mar 10, 2008
REAR AXLE LOUD NOISE. FRONT LEFT WHEEL BEARING BECAME EXTREMELY NOISY. AUTOMATIC 4WD CONTROL ENGAGED UNEXPECTEDLY DURING LOW SPEED TURNS AND PARKING. SEVERAL VISITS TO THE FORD REPAIR SHOP, ALMOST $2.5K IN REPAIRS, "ERRONEOUSLY" DIAGNOSED. RESULTS: FINALLY, FAILURES STILL IN PLACE. WHAT A SHAME!!! *TR
Power train, Wheels, Mar 3, 2008
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING 10 MPH, THE CONTACT HEARD A NOISE SIMILAR TO A TIRE BLOWOUT. SHE PULLED THE VEHICLE OFF THE ROAD AND DISCOVERED THAT THE LUG STUDS FOR THE DRIVER AND PASSENGER SIDE REAR WHEELS HAD SHEARED OFF. THE VEHICLE WAS TOWED TO THE DEALER AND THE STUDS WERE REPLACED. THE FAILURE OCCURRED TWICE. THE CONTACT ATTEMPTED TO SHIFT INTO PARK, BUT THE GEAR BECAME STUCK. SHE JIGGLED THE GEAR UNTIL IT WENT INTO PARK. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000 AND CURRENT MILEAGE WAS 60,000.
Power train, Feb 28, 2008
TRANSMISSION WAS FINE AND THEN IT STARTED HAVING TROUBLE SWITCHING FROM 1ST TO 2ND GEAR. NEXT THING THE OD LIGHT STARTED FLASHING SO I DECIDED TO TAKE IT TO THE DEALER. BY THE TIME I GOT THERE THE SERVICE ENGINE SOON LIGHT CAME ON. THEY DID A COMPUTER CHECK ($90 COST) ON IT AND RECOMMENDED TO INSTALL A REMANUFACTURED UNIT FOR $3829. AFTER SOME MORE RESEARCH, I DECIDED TO TAKE IT TO AAMCO. THEY WENT BEYOND THE COMPUTER CHECK AND DISCOVERED THAT THE 2ND SERVO PISTON WAS BROKEN AND THE OD SERVO PISTON ALSO RECOMMENDED TO BE REPLACED ALONG WITH THE TORQUE CONVERTER BECAUSE THERE HAVE BEEN SO MANY PROBLEMS WITH THEM. IN THE END, THE COST WILL BE $2043. *TR
Power train, Feb 11, 2008
THE TRANSFER CASE FAILED ON OUR 2003 FORD EXPLORER. THIS IS A KNOWN PROBLEM AT FORD AND DUE TO A DESIGN FLAW WITH THE EXPLORER. IT COST $2,000 TO FIX. OUR MECHANIC REFERRED US TO A TRANSMISSION/TRANSFER CASE SPECIALIST WHO HAD SEEN MULTIPLE EXPLORERS WITH THIS PROBLEM. FORD SHOULD ISSUE A RECALL FOR THIS KNOWN DEFECT. THE CONSEQUENCES OF A FAILURE IN THE TRANSFER CASE CAN BE A COMPLETE SHREDDING OF THE GEARS AND SUDDEN LOSS OF POWER, WHICH COULD BE EXTREMELY DANGEROUS. *TR
Power train, Feb 10, 2008
AT 40,000 MILES 4000 OUT OF WARRANTY, THE TRANSMISSION ON MY 2003 FORD EXPLORER CATASTROPHICALLY FAILED. NO WARNING AT ALL. DRIVING DOWN THE HIGHWAY, THE O/D LIGHT STARTED TO FLASH AND THE CAR STARTED TO SHIFT IN AND OUT OF GEAR. MY WIFE NURSED THE CAR HOME. THE CAR HAD NO FIRST GEAR AND WOULD SLAM FROM SECOND TO THIRD. FORD CONFIRMED THIS, AND SAID THE ONLY FIX WAS A COMPLETE TRANSMISSION. 6,000 MILES LATER, THE SAME THING. SINCE THIS WAS UNDER WARRANTY, FORD SAID THAT THEY COULD REPLACE SOME SOLENOIDS AND THAT WOULD FIX IT....NOT!! THREE MORE TRIPS AND FINALLY A TRANSMISSION THAT DOESN'T ACT UP ALL THE TIME. IT STILL SHIFTS FUNNY AND SOMETIMES FAILS TO GO INTO GEAR. MY WIFE HAS COME CLOSE TO BEING REAR-ENDED NUMEROUS TIMES, I.E. BACKING INTO THE STREET. THIS IS A SAFETY ISSUE THAT FORD HAS BEEN IGNORING, READ THE FORUMS. I HAVE MANY OTHER NUMEROUS COMPLAINTS ABOUT THIS VEHICLE. READ DIFFERENTIAL CLUTCHES GOING BAD, KEYLESS ENTRY FAILING, DOOR LOCKS FAILING, AND A WINDOW THAT WORKS PART-TIME....KINDA LIKE FORD ENGINEERS. *TR
Engine and engine cooling, Power train, Jan 19, 2008
BRAND NEW 2003 FORD EXPLORER. REPLACED ENGINE AT 115 K MILES AND NOW THE TRANS IS GOING; SPECIFICALLY, THE O/D LIGHT KEEPS FLASHING AND IT SHIFTS BADLY. I'VE SEEN NUMEROUS COMPLAINTS ABOUT THE SAME THING ONLINE, WHILE FORD IGNORES THIS FAULTY TRANS. *TR
Power train, Jan 4, 2008
TYPICAL FORD EXPLORER TRANMISSION PROBLEM HAVING TO DO WITH THE TORQUE CONVERTER. OD LIGHT FLASHING. NOTHING DONE TO ENVOKE THIS PROBLEM AND NO EVENTS LEADING UP TO THE FAILURE. JUST DRIVING ON THE HIGHWAY. *CN
Power train, Dec 21, 2007
2003 FORD EXPLORER TRANSMISSION FAILURE AT 62,000 MILES. *TR
Power train, Dec 18, 2007, fire
WHILE DRIVING IN A NICE ASPHALTED ROAD UP A HILL, I FELT LIKE THE TRANSMISSION SUDDENLY STARTED TO SLIP. THE VEHICLE LOST FORWARD MOMENTUM SO I LOOKED FOR A SAFE PLACE TO MAKE AN EMERGENCY STOP. I ENDED UP AT A SERVICE STATION WHERE THE VEHICLE CAUGHT FIRE QUICKLY. THE VEHICLE WAS COMPLETELY LOST AND THE SERVICE STATION SUFFERED CONSIDERABLE DAMAGE. *TR