2003 Ford Explorer
Problems, recalls and owner-reported issues
Structure is the leading concern among 1,313 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Explorer model years with reports.
Of the 2003 reports, 69 involved a crash and 19 involved a fire. 66 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Representative owner complaints
1,313 reports, newest first.
Structure, Jul 19, 2011
I BOUGHT 2003 FORD EXPLORER IN 2008, USED, AND IN 2011 I OPENED MY BACK GLASS AND THE HINGE SNAPPED ON THE LEFT SIDE AND THE GLASS STARTED FALLING, AND THE ONLY THING THAT SAVED THE GLASS FROM BREAKING WAS THE RIGHT SIDE HINGE HELD. I CALLED THE FORD COMPANY AND THEY SAID THAT I COULD TAKE IT TO A DEALER AND HAVE IT INSPECTED, BUT THERE WAS NO SAFTEY RECALL ON MY VEHICLE. I LOOKED ONLINE AND IN 2004 THE 2003 FORD EXPLORER WAS RECALLED FOR THIS VERY PROBLEM. *KB
Power train, Jul 18, 2011
MY 2003 FORD EXPLORER HAD A "THUNK" NOISE FROM DAY ONE. FORD DEALERSHIP "COULD NOT DUPLICATE" THE COMPLAINT EVEN THOUGH I TOOK IT BACK MULTIPLE TIMES. HAD TO REPLACE THE TORQUE CONVERTER AT 70K MILES AND NOW AT 135K MILES THE WHOLE TRANSMISSION AND ANOTHER TORQUE CONVERTER FOR RATTLING AGAIN. OD/OFF BLINKING LIGHT AND CHECK TRANSMISSION NOTICE CAME ON WITH ERRATIC SHIFTING AND LOSS OF 2ND AND 5TH GEARS. REPLACEMENT OF TRANS ELIMINATED "THUNK" AND MY $4600. SIMILAR COMPLAINTS WITHOUT ANY ACKNOWLEDGEMENT OF FAULTY MATERIALS OR ENGINEERING BY FORD HAS PLAGUED HUNDREDS IF NOT THOUSANDS OF EXPLORER OWNERS. WHERE IS THE EXPECTED INVESTIGATION OF THESE PROBLEMS? WHY DO WE HAVE TO WAIT UNTIL ACCIDENTS OR INJURY TO HAVE FAULTY AUTOS RECALLED? WHY ARE SPARK PLUGS EJECTED MORE OF A SAFETY CONCERN THAN TRANSMISSIONS THAT LEAVE DRIVERS WITHOUT PROPER MOVING CAPABILITY ON THE HIGHWAY? WHERE IS THE RECALL FOR THESE UNITS? *KB
Structure, Jul 14, 2011
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS A CRACK ON THE REAR LIFTGATE, EXTENDING UP TO THE WINDOW. THE CONTACT EXPRESSED CONCERN OVER THE POSSIBILITY OF THE WINDOW SEPARATING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE FAILURE WAS COSMETIC AND THEY WOULD BE UNABLE TO ASSIST WITH REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 74,000 AND THE CURRENT MILEAGE WAS 77,130.
Power train, Jul 13, 2011
SUDDENLY THE TRANSFER CASE STARTED JERKING AND THE SUV WAS SHAKING BADLY THAT I ALMOST COULDN'T DRIVE IT HOME. I WAS LUCKY TO HAVE THIS HAPPENING AT 1/2 MILE FROM MY HOUSE AND AT ABOUT 20-25 MILES PER HOUR! IT WAS NO CODE TO INDICATE WHERE THE FAILURE OCCURRED WITHIN THE POWER TRAIN. I TOOK A PART THE REAR END, I FOUND NOTHING WRONG WITH IT. I STARTED TO TROUBLESHOOT THE TRANSFER CASE AND I NOTICED THAT THE ELECTRICAL MOTOR WITH ACTUATOR DOES NOT SPIN THE SHAFT FROM TRANSFER CASE, REASON THAT THE TRANSFER CASE CAN'T SELECT FIRMLY THE POSITION OF HI, LOW OR 4WD!!!!. OBSERVING THAT THE MOTOR OF THE TRANSFER CASE SIFTER DOES NOT SPIN, I PURCHASED A NEW MOTOR FROM FORD,. AFTER REPLACEMENT, THE PROBLEM PERSISTED; SO, I REPLACED THE TRANSFER CASE MODULE, BEHIND THE GLOVE BOX; NO RESULT. TO BE ABLE TO MOVE THE CAR AROUND I UNPLUGGED THE TRANSFER CASE MOTOR SHIFT FROM THE MAIN HARNESS AND THE SUV STAYS NOW IN 4WD WITH BLINKING LIGHTS ON MY DASH FOR ABS AND 4X4 WD!!! I AM STILL WANDERING WHAT COULD HAPPENED TO ME IF THE JUMPING AND GRINDING WAS TO HAPPEND WHEN I WAS DRIVING THE CAR WITH 65-70 MILES PER HOUR AND THE POWER TRAIN COULD SNAP AND THE DRIVESHAFT COULD FLY OUT... WHO SHALL BE RESPONSIBLE FOR MY LIFE OR SOMEBODY ELSE'S THAT I COULD HIT? I CONSIDER THAT THE MANUFACTURER SHALL RECALL THE EXPLORER'S AFFECTED AND ADDRESS THE TRANSFER CASE ISSUES. THE OLD PARTS THAT I HAVE REPLACED ARE AVAILABLE, THEY ARE FUNCTIONAL. I STILL DON'T KNOW WHAT IS WRONG BECAUSE I COULDN'T FIND ANY ADVISE FROM ANY FORD SITES\, NEITHER FROM A QUALIFIED DIAGNOSTIC SPECIALIST. IF I GO TO FORD DEALERSHIP THEY WILL BE CHARGING TONS OF $$$ UNTIL THE CAR RUNS AGAIN; THEY DON'T CARE HOW MANY PARTS WILL REPLACE AND I WILL HAVE TO PAY FORD'S MISTAKES FROM MY POCKET; THIS IS NOT RIGHT! *TR
Structure, Jul 13, 2011
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED WHILE OPENING THE REAR HATCH THE LIFT GATE HINGE FAILED OFF CAUSING THE LIFT GATE TO HANG ON BY ONE HINGE. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THE HINGE NEEDED TO BE REPLACED. THE CONTACT DID NOT HAVE THE HINGE REPLACED. THE CONTACT STATED THE LIFT GATE COULD HAVE FALLEN OFF WHILE DRIVING. THE FAILURE MILEAGE WAS 123,000.
Air bags, Jul 8, 2011
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE HORN WAS DEFECTIVE AND THE AIRBAG LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. A LOCAL MECHANIC DIAGNOSED A DEFECT WITHIN THE STEERING COLUMN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT DID NOT OFFER ASSISTANCE. THE FAILURE MILEAGE WAS 95,000 AND THE CURRENT MILEAGE WAS 100,000. UPDATED 08/10/11
Structure, Jul 5, 2011
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE HATCH BACK HAD A CRACK FROM THE END OF IT TO THE WINDOW. THE VEHICLE WAS INSPECTED BY A DEALER WHO ADVISED HER THAT IT WAS CAUSED BY STRESS FROM OPENING AND CLOSING OF THE DOOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.
Engine and engine cooling, Jul 2, 2011, crash
CAR STARTED TO ACCELERATE IN REVERSE AND STRUCK ANOTHER VEHICLE WHILE BRAKE WAS APPLIED TO NO AVAIL. *TR
Structure, Jun 30, 2011
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR LIFT GATE FRACTURED DIRECTLY UNDERNEATH THE WINDOW SEAL. SHE NOTICED WHEN THE DOOR WAS AJAR THE WARNING LIGHT WOULD ILLUMINATE AS IF SHE HAD OPENED THE DOORS. THE DEALER ADVISED HER THAT THEY WERE AWARE OF THE FAILURE, BUT THERE WAS NO RECALL. THE VEHICLE WAS NOT INSPECTED NOR WAS IT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 125,000.
Power train, Jun 16, 2011
THE TRANSMISSION ON OUR 2003 FORD EXPLORER HAD TO BE REPLACED. IT COULD HAVE LEFT US STRANDED ON THE ROAD. FORD KNEW OF THIS PROBLEM WITH THE TRANSMISSIONS ON THE 2003-2004 EXPLORERS. I THINK THEY SHOULD MAKE AN ADJUSTMENT ON THE COST OF THE REPAIRS. TRANSMISSION ARE SUPPOSED TO LAST LONGER THAN 71,000 MILES. WE DID NOT MISTREAT THIS VEHICLE IN ANY WAY. *TR
Structure, Jun 13, 2011
THE BACK PANEL ON MY EXPLORER CRACKED BY JUST CLOSING THE GLASS. THE TEMPERATURE WAS ONLY 65 SO CONSIDERING THE MORE EXTREME TEMPERATURES WE HAVE SEEN IN NORTH CAROLINA WAS DID IT CRACK ON THAT DAY? *TR
Structure, Jun 13, 2011
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT WAS CLOSING THE REAR LIFTGATE WHEN THE REAR GLASS DETACHED FROM THE VEHICLE. THE CONTACT WAS ABLE TO GRAB HOLD OF THE GLASS TO PREVENT IT FROM SHATTERING. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTICS OR REPAIRS. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 04V442000 (STRUCTURE:BODY:HATCHBACK/LIFTGATE: HINGE AND ATTACHMENTS) THAT COULD HAVE BEEN BE RELATED TO THE FAILURE BUT THE MANUFACTURER STATED THAT THE CONTACT'S VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.
Structure, Latches/locks/linkages, Jun 10, 2011
THE TAILGATE CRACKS DOWN THE CENTER. *TR
Air bags, Jun 7, 2011
I OWN A 2003 FORD EXPLORER XLT. I STARTED MY CAR UP THIS MOURNING TO GO TO WORK. I STEPPED OUT OF THE CAR TO REMOVE AN EMPTY CUP WHEN I HEARD A POP FROM INSIDE MY CAR. AS I TURNED AN LOOKED I SAW MY CAR FILLED WITH SMOKE. AS I WENT BACK TO THE CAR THE PASSENGER SIDE AIR BAG WAS DEPLOYED. THERE WAS NO WARNING WHAT SO EVER. IF THIS WOULD HAVE HAPPENED WHEN I WAS DRIVING THERE IS NO TELLING WHAT WOULD HAVE HAPPENED. THIS CAR IS IN VERY GOOD SHAPE. IT HAS 130000 MILES ON IT. I AM AFRAID OF THIS HAPPENING TO THE DRIVERS SIDE BAG NOW AS I HAVE SEEN THAT THIS HAS HAPPENED BEFORE TO THIS MODEL. *TR
Power train, May 18, 2011
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH THE OVER DRIVE LIGHT BEGAN ILLUMINATING ON THE INSTRUMENT PANEL AND THE VEHICLE BEGAN TO SHIFT INTO A HIGHER GEAR. THE CONTACT TURNED THE VEHICLE OFF AND UPON RESTARTING IT, THE VEHICLE BEGAN TO FUNCTION NORMALLY. AFTER DRIVING FOR A FEW MILES, THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 111,000.
Power train, Interior lighting, May 16, 2011
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE DOOR AJAR LIGHT ILLUMINATED FREQUENTLY AND THE DOME LIGHT STAYED ILLUMINATED EVEN WHEN THE DOORS WERE CLOSED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A MANUFACTURERS RECALL AND THE DEALER STATED THAT THE REPAIR HAD PREVIOUSLY BEEN PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VEHICLE HESITATED INTERMITTENTLY. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS APPROXIMATELY 72,000. THE FAILURE MILEAGE WAS APPROXIMATELY 49,000.
Power train, Electrical system, May 11, 2011
FIRST I MUST SAY I LOVE THIS TRUCK. ITS MY SECOND ONE AND BOTH HAD SAME PROBLEMS. WHILE DRIVING HOME FROM WORK ALL OF A SUDDEN TRUCH LURCHED FORWARD THEN O/D OFF LITE STARTED FLASHING THEN CHECK ENGINE LITE FLASHING.TOOK IT TO MY MECHANIC AND IT CAME UP WITH A PO775 CODE, HE SAID ITS VERY COMMON AND NOT THE FIRST ONE HES SEEN DO THIS. PRESSURE CONTROL SOLENOID B NEEDS REPLACING FOR ABOUT $400.00 THEN AFTER REMOVING PAN WHOLE TRANSMISSION NEEDED OVERHAUL NOW $2200.00 LATER. I THINK FORD KNOWS OF THIS PROBLEM AND SHOULD STAND BEHIND IT. ALSO BLEND DOOR STOPPED WORKING AND ALL 4 CALIPERS SEIZED UP. DONT KNOW IF ILL EVER BUY ANOTHER FORD.ALSO POWER WINDOWS QUIT WORKING, BROKEN WIRE IN DOOR. NOTHING BUT TROUBLE WITH THIS VEHICLE.I THINK A CLASS ACTION SUIT SHOULD BE STARTED AGAINST FORD FOR REPAIRS ON THESE TRANSMISSIONS.I CANT AFFORD TO DUMP HUNDREDS OF DOLLARS INTO THIS TRUCK AFTER PAYING THOUSANDS OF DOLLARS FOR IT.
Wheels, May 10, 2011
THE DRIVERS SIDE REAR HUB BROKE WITHOUT ANY WARNING OR INDICATION OF ANY PROBLEM WHATSOEVER. IT DESTROYED THE KNUCKLE AND THE WHEEL NEARLY FELL OFF.
Engine and engine cooling, Structure, May 10, 2011
MY 2003 FORD EXPLORER LIMITED BLEW A SPARK PLUG RIGHT OUT OF THE ENGINE. VERY SCARY & VERY LOUD WHILE GOING TO THE GROCERY STORE. I THOUGHT FOR SURE THE ENGINE BLEW. *TR
Wheels, May 10, 2011
A 2003 FORD EXPLORER REAR WHEEL DRIVE WITH 82K MILES. THE WHEEL HUB BEARINGS HAVE FAILED ON BOTH REAR WHEELS. *TR
Structure, May 9, 2011
CRACK IN REAR PANEL OF MY 2003 FORD EXPLORER. *TR
Power train, Latches/locks/linkages, May 6, 2011, crash
MY 2003 FORD EXPLORER WAS PARKED IN MY DRIVEWAY AND IT SOMEHOW ROLLED DOWN APPROX 150 FEET AND SMASHED INTO A TREE. THERE WAS NO ONE IN THE VEHICLE IT WAS PARKED AND THE KEYS WERE IN THE HOUSE. I IMMEDIATELY CALLED MY INSURANCE (STATE FARM) AND THEY HAD ME CALL A COLLISION GARAGE TO COME OUT AND THEY CAME WITHIN THE HOUR. THEY HAVE STATED THAT THE VEHICLE IS A TOTAL LOSS. THE NEXT MORNING I CALLED FORD AND THEY DISREGARDED ANYTHING I SAID AND SAID MY INSURANCE SHOULD TAKE CARE OF IT. I AM STILL PAYING ON A LOAN FOR THIS CAR AND I DO HAVE FULL COVERAGE BUT I AM NOW WITHOUT A VEHICLE AND I AM SCARED TO THINK OF WHAT MIGHT OF HAPPENED IF MY DAUGHTERS WOULD OF BEEN PLAYING IN THE BACKYARD. *TR
Power train, Apr 27, 2011
VEHICLE TRANSMISSION SLIPS OUT OF GEAR AND SOMETIMES WONT ENGAGE. FREQUENTLY OCCURS AT STOP/START MOVEMENTS. OCURRS IN FORWARD AND REVERSE. "O/D OFF" LIGHT IS FREQUENTLY DISPLAYED. UNSAFE TO DRIVE ANYWHERE!!! *TR
Power train, Apr 27, 2011
TRANSMISSION PROBLEMS STARTED AROUND 100K MILES; HIGH RPM SHIFTING BETWEEN 1ST AND 2ND GEAR WITH SUBSEQUENT FLASHING O/D LIGHT. MANY TIMES TRANSMISSION WILL "CLUNK" INTO GEAR EITHER FROM GOING INTO REVERSE, STOPPING COMPLETELY, THEN SHIFTING INTO DRIVE AND/OR WHEN PUTTING IN REVERSE OR DRIVE. APPEARS THIS IS A COMMON PROBLEM FOR MY MODEL YEAR EXPLORER (03) AND SAME CODE MANY OTHERS RECEIVE (P0775) WHICH REALLY DOES NOT DESCRIBE THE PROBLEM OR LEAD A NOT SO MECHANICAL INCLINED PERSON TO TRY AND TROUBLESHOOT/BUY PARTS TO FIX. I'M CAREER MILITARY MAN W/FAMILY AND MY TRUCK IS PAID OFF NEXT MONTH--OWNED 5 YEARS AND REALLY SUCKS TO HAVE TO POSSIBLY DUMP $3K INTO A TRUCK THAT FORD HAS KNOWN CONTAINED ISSUES WITH THE 5R55W TRANSMISSION. *TR
Visibility, Apr 19, 2011
BLEND DOOR ACTUATOR NOT WORKING. NOT ABLE TO DEFROST WINDOWS EASILY.