2003 Ford Explorer
Problems, recalls and owner-reported issues
Structure is the leading concern among 1,313 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Explorer model years with reports.
Of the 2003 reports, 69 involved a crash and 19 involved a fire. 66 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Representative owner complaints
1,313 reports, newest first.
Power train, Feb 19, 2011
I WAS DRIVING MY 2003 FORD EXPLORER XLT V6 4.0L ON I40W, WHEN ALL OF A SUDDEN THE VEHICLE BEGAN TO DECELERATE WHILE THE RPMS WERE CONSTANTLY GOING UP. THIS PUT ME IN THE INTERSTATE WITH NO POWER AS THE GEARS WEREN'T SHIFTING. I TOOK IT TO MY LOCAL FORD DEALERSHIP AND THEY PUT IT ON THE DIAGNOSTIC MACHINE AND TOLD ME THEY REALLY DIDN'T KNOW WHAT WAS WRONG WITH IT AND THAT THEY WOULD HAVE TO BREAK THE TRANSMISSION DOWN IN ORDER TO KNOW FOR SURE. I SEARCHED ONLINE FOR ANY COMMON TRANSMISSION PROBLEMS AND CAME ACROSS A SITE WHERE PEOPLE WITH VEHICLES JUST LIKE MINE HAVING THE SAME EXACT PROBLEM. AS OF NOW I'M STILL WAITING ON FORD TO LET ME KNOW WHAT'S GOING ON WITH MY TRUCK, BUT WITH HUNDREDS OF OTHER PEOPLE HAVING THE SAME PROBLEM I SEE NO REASON FOR THEM NOT KNOW WHAT THE PROBLEM IS AS WELL AS HAVE A RECALL ON THE VEHICLE TO FIX THE PROBLEM. *TR
Power train, Feb 12, 2011
NO SECOND GEAR. *TR
Visibility, Feb 8, 2011
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACTED STATED THAT THE REAR WINDOW PANEL WAS FRACTURED NEAR THE BOTTOM. THE CONTACT WAS CONCERNED THAT THE WINDOW WOULD FRACTURE FROM THE VEHICLE AND BREAK. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THERE WERE NO A RECALLS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
Power train, Feb 4, 2011
LIKE EVERY OTHER DAY, I STARTED THE SUV A FEW MINUTES BEFORE I HAD TO LEAVE TO LET IT WARM UP BECAUSE NY IS COLD, AND THEN LEFT TO RUN SOME ERRANDS. I REALIZED RIGHT AWAY THAT THE TRUCK SOUNDED A LITTLE FUNNY WHEN ACCELERATING, SO THE RADIO WENT OFF SO I COULD LISTEN. I FOUND THAT WHEN SHIFTING FROM FIRST TO SECOND, IN THIS AUTOMATIC VEHICLE, THE OVERDRIVE WAS KICKING ON PREMATURELY. THEN THE O/D LIGHT STARTED FLASHING. I CAME HOME AND STARTED RESEARCHING IT AND FOUND HUNDREDS OF COMPLAINTS, SO HERE I AM, IN THE SAME BOAT AS EVERYONE ELSE, ABOUT TO LOOK UP NUMBERS TO TRANSMISSION SPECIALISTS BECAUSE THE DEALER IS DEFINITELY NOT GOING TO MAKE ANY MONEY OFF OF MY WITH THIS ONE. *TR
Structure, Feb 2, 2011
REAR HATCH CRACKED NEAR THE FORD LOGO. *TR
Power train, Feb 1, 2011
I OWN A 2003 FORD EXPLORER AND HAVE NEVER HAD ANY PROBLEM WITH MY VEHICLE. I DO NOT DRIVE IT HARD AND MAKE SURE THAT IT GETS THE PROPER UPKEEP. AS I WAS DRIVING DOWN THE ROAD ONE DAY MY CHECK ENGINE LIGHT CAME ON. THE NEXT DAY ON MY WAY TO WORK I NOTICED THAT THE TRANSMISSION WAS HAVING TROUBLE SHIFTING AND THE TIME I GOT HOME THAT EVENING THE TRANSMISSION WAS SHIFTING VERY HARD IF IT WOULD EVEN SHIFT AT ALL. MY O/D OFF LIGHT ALSO STARTED FLASHING. I THOUGHT THAT IT WAS JUST A FLUKE WITH MY TRANSMISSION UNTIL I CHECKED ONLINE TO FIND THAT THERE IS ALOT OF OTHER PEOPLE HAVING THE SAME PROBLEM AND THAT FORD IS DOING NOTHING TO FIX THE PROBLEM. MY CAR IS CURRENTLY IN THE SHOP AND THEY HAVE SAID THAT IT WILL COST ATLEAST 3200 OR MORE TO FIX THE TRANSMISSION. I HAVE CONTACTED MY FORD DEALERSHIP AND THEY WERE WELL AWARE OF THE PROBLEMS WITH THIS TRANSMISSION BUT STATED THERE WAS NOTHING THEY COULD DO AND FORD HASN'T ACCEPTED RESPONSIBILITY FOR THE PROBLEM. THEY ALSO STATED THAT THERE WAS AN OBVIOUS DEFECT WITH THE TRANSMISSION. I WOULD LIKE TO KNOW IF THERE IS OR WAS A DEFECT INVESTIGATION SEEING THAT THERE ARE SO MANY PEOPLE WITH THE SAME PROBLEM AND IF ANYONE CAN TELL ME IF THERE IS A CLASS ACTION LAWSUIT FOR THIS MATTER. *LN
Power train, Jan 25, 2011
ENGINE REVS TO NEARLY 5000 RPM BEFORE SLAMMING INTO 2ND GEAR. HAD SEVERAL MECHANICS TELL ME THAT THESE TRANSMISSIONS ARE JUNK.
Power train, Jan 24, 2011
I WAS DRIVING MY 2003 FORD EXPLORER, AND ALL OF A SUDDEN WHEN MERGING ONTO THE HIGHWAY, MY OVERDRIVE LIGHT STARTED FLASHING, AND THE TRANSMISSION WON'T SHIFT OUT OF 1ST GEAR. ABSOLUTELY UNACCEPTABLE! AN 03?! PLEASE! *TR
Power train, Jan 21, 2011
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE VEHICLE EXPERIENCED DIFFICULTY CHANGING GEARS WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE TRANSMISSION WAS REBUILT. APPROXIMATELY 3 YEARS LATER THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE TRANSMISSION WAS REBUILT. THE FAILURE MILEAGE WAS 54,655 AND THE CURRENT MILEAGE WAS 111,260.
Power train, Jan 17, 2011
SOME SORT OF TRANSMISSION FAILURE DEALING WITH THE SHIFTING SOLENOID. THIS LEADS TO SPORADIC SHIFTING BETWEEN THE LOWER GEARS. THIS LEAD TO VERY HARD DRIVING IN SLOW AND ICY CONDITIONS. THE CAR WOULD BE AT SUCH HIGH RPMS AT SLOW SPEEDS SUCH AS 20-30 MPH THAT THE CAR WOULD LOOSE TRACTION, SO FAR I HAVE HAD NO ACCIDENTS WITH THIS PROBLEM BUT THE POTENTIAL IS VERY APPARENT. *TR
Structure, Jan 11, 2011
I HAVE 2003 FORD EXPLORER AND AFTER 7YEARS A CRACK HAS FORMED FROM THE REAR WINDOW DOWN TO THE FORD LOGO ON THE REAR PANEL OR TRUNK DOOR. *TR
Power train, Jan 11, 2011
SERVICE ENGINE LIGHT APPEARED, THEN THE OD (OVERDRIVE) LIGHT BEGAN FLASHING. THEN THE EXPLORER HAD DIFFICULTY ACCELERATING. THE ENGINE WAS RUNNING HIGHER RPMS THAN USUAL, ESPECIALLY WHEN ACCELERATING FROM 0 TO 30MPH. I TOOK THE EXPLORER TO THE FORD DEALER WHERE THE EXPLORER WAS PURCHASED AND EXCLUSIVELY SERVICED SINCE WHEN I BOUGHT IT NEW IN JULY 2003. THEY WOULD NOT ACKNOWLEDGE THAT THIS IS A PERSISTENT PROBLEM WITH 2003 EXPLORERS. THEY TOLD ME THAT I HAVE NO 2ND OR 5TH GEARS, INT. SERVO FAILED AND CASE BORE DAMAGED. THEY WANT OVER $3,600 TO REPAIR (AND THAT, THEY SAY IS A DISCOUNT!). I THEN TOOK IT TO A TRANSMISSION SHOP, WHO WAS WELL AWARE OF THIS PROBLEM AND THERE WERE 2 OTHER EXPLORERS CURRENTLY THERE BEING REPAIRED FOR THE SAME THING. AN INVESTIGATION NEEDS TO BE DONE FOR A RECALL. THIS IS A SAFETY ISSUE AND A CONSUMER RIP-OFF! *TR
Power train, Jan 9, 2011
MY 2003 FORD EXPLORER XLT ONLY HAS 70000K AND THE TRANSMISSION IS COMPLETELY IN NEED OF REBUILD. IT DOESN'T DRIVE IN REVERSE AND DOESN'T GO FASTER THAN 25MPH WITHOUT SOUNDING AS IF THE ENGINE IS GOING TO FALL OFF. IT KICKS BACK WHILE ATTEMPTING TO CHANGE GEARS AND THE RPM IS WORKING HARD WITH THE TRUCK GOING NOWHERE FAST. I CANT AFFORD TO REPAIR THE PROBLEM AS IM STILL MAKING MONTHLY PAYMENTS ON IT. THIS SHOULD NOT BE HAPPENING WITH AN EIGHT YEAR OLD VEHICLE. THIS LITTLE BIT OF INFORMATION ON HOW THERE IS NO DIPSTICK TO CHECK THE TRANSMISSION FLUID SHOULD HAVE BEEN REVEALED AT TIME OF PURCHASE I THINK. *TR
Power train, Jan 5, 2011
"OD (OVERDRIVE)" LIGHT BLINKING IN DASH. THEN "SERVICE ENGINE SOON" LIGHT ON 12-31-10. HIGHER RPM'S IN ENGINE THEN USUAL, TO SHIFT GEARS IN AUTOMATIC TRANSMISSION. TRANS HAVING THUMPING SOUNDING WHEN PLACED INTO PARK, DRIVE OR REVERSE. BROKEN SERVO SIDEARM INSIDE TRANSMISSION.. VEHICLE ONLY HAS 62,000 MILES ON IT. TAKEN TO LOCAL TRANSMISSION SHOP. ESTIMATE OF $1,475 TO FIX. *TR
Structure, Jan 5, 2011
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE VEHICLE WAS PARKED WHEN THE CONTACT NOTICED THAT THERE WAS A LARGE CRACK IN THE REAR LIFT GATE PANEL. THE CRACK WAS LOCATED UNDER THE TAIL GATE WINDOW. THE FAILURE WAS DIAGNOSED OR REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 120,000.
Structure, Jan 5, 2011
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE THE VEHICLE WAS PARKED THE CONTACT NOTICED THAT THE REAR TAILGATE WAS CRACKED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIANS STATED THAT THE CONTACT WOULD HAVE TO PAY TO HAVE THE TAILGATE REPLACED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THEY WOULD PAY FOR R HALF OF THE REPAIR COST. THE CONTACT STATED THAT HE SHOULD NOT HAVE TO PAY ANY PORTION OF THE REPAIR COST. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. UPDATED 2/23/11 *CN UPDATED 04/25/11
Visibility, Dec 30, 2010
THE FRONT WINDSHIELD ON MY 2003 FORD EXPLORER REACHES EXCESSIVE TEMPERATURES. IN MILD WEATHER ON A SUNNY DAY THE INTERIOR OF THE WINDSHIELD CAN BECOME SO HOT IT CAN EASILY MELT ITEMS PLACED AGAINST IT. ADDITIONALLY, IT APPEARS THIS IS THE ORIGINAL WINDSHIELD FROM THE MANUFACTURER. *TR
Power train, Structure, Dec 29, 2010
PROBLEMS WITH THE REAR PANEL CRACKING UP, BEING REPLACED TWICE, STILL CRACKED AGAIN, ALSO THE TRANSMISSION NOT ABLE TO CHECK IT DURING A TRIP UNLESS YOU GO UNDER THE TRUCK, LAST THING THE BRAKE LIGHT SWITCH STICKING CAUSING TO DRAIN BATTERY AND NOT ABLE TO ORDER PART BECAUSE THE MANUAL ARE WRONG. *TR
Wheels, Dec 29, 2010
AS I WAS DRIVING TO WORK THE OTHER DAY, I WAS SITTING IN A LINE OF CARS WAITING FOR MY TURN TO GO THROUGH A 4-WAY STOP WHEN MY 2003 FORD EXPLORER SUDDENLY STOPPED RUNNING. I HAD PLENTY OF FUEL AND THE ELECTRICAL WORKED. THE ENGINE SIMPLY WOULDN'T TURN OVER. I CALLED A TOW TRUCK AND HAD THE VEHICLE TOWED TO MY LOCAL REPAIR SHOP. AFTER SOME INSPECTION, THE REPAIRMAN DETERMINED THAT I HAD BLOWN A FUSE. THE CAUSE WAS MY ABS SENSOR CONTINUALLY SENDING OUT AN PROBLEM SIGNAL. THE CAUSE OF THAT WAS MY WHEEL BEARINGS GOING BAD. FURTHER INSPECTION SHOWED THAT AT LEAST THREE OF MY WHEELS HAVE BAD BEARINGS. THE REPAIRS ARE INCREDIBLY COSTLY (WELL OVER $1,000). AND THE MECHANICAL FAILURE IS DANGEROUS, INCLUDING WHEEL SEPARATION, WHEEL SEIZING UP AND BRAKE FAILURE. I WAS LUCKY TO HAVE BEEN STOPPED AT AN INTERSECTION. I DRIVE ON THE INTERSTATE DAILY AND IF THE CAR HAD FAILED THERE, IT COULD HAVE BEEN INCREDIBLY BAD. WHILE WHEEL BEARINGS TO FAIL, THE MECHANIC SAID IT IS INCREDIBLY RARE TO SEE MULTIPLE BEARINGS GO OUT AT THE SAME TIME. WELL, EXCEPT FOR FORDS. HE SAID THE EXPLORER AND FOCUS (ESPECIALLY THE '02 & '03 MODELS) HAVE A REPUTATION FOR WEARING OUT. SOMETIMES, MULTIPLE TIMES FOR THE SAME WHEEL. A QUICK GOOGLE SEARCH PROVED HIM RIGHT. THERE ARE HUNDREDS OF COMPLAINTS FOR THIS PROBLEM ON THE '02 & '03 FORD EXPLORERS. I REALIZE WE'RE GOING ON 8 OR 9 YEARS SINCE THESE VEHICLES WERE PRODUCED, BUT HOW COULD THE SAME ISSUE ON HUNDREDS OF CARS NOT HAVE BEEN ADDRESSED YET? THE PROBLEM SEEMS TO OBVIOUSLY NOT BE DUE TO USER ERROR OR POOR MECHANICAL MAINTENANCE. I IMPLORE YOU TO INVESTIGATE THIS FURTHER FOR THE SAKE OF THE THOUSANDS OF PEOPLE STILL DRIVING THESE CARS EVERY DAY. *TR
Structure, Dec 29, 2010
METAL CRACKED INTO FROM LIFTGATE WINDOW TO BOTTOM OF LIFTGATE. JUST WENT TO WORK ONE DAY AND CAME HOME TO FIND THIS HUGE CRACK IN THE LIFTGATE DOOR. I HAD NOT OPENED THE LIFTGATE THAT DAY. AFTER DOING RESEARCH AND PERSONALLY WITNESSING OTHER EXPLORERS WITH THIS PROBLEM, I FOUND THERE ARE HUNDREDS OF FORD EXPLORER OWNERS WITH SAME PROBLEM. *TR
Structure, Dec 28, 2010
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR HATCHBACK WINDOW HINGE WAS FRACTURED. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 04V442000 (STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS) YET THE FAILURE RECURRED. BOTH THE DEALER AND MANUFACTURER WAS INFORMED OF THE FAILURE WHO ADVISED THE CONTACT THAT ANY FURTHER REPAIRS WOULD BE AT THE CONTACTS EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 139,634 AND THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.
Structure, Dec 20, 2010
CRACK IN PANEL BELOW REAR GLASS OF 2003 FORD EXPLORER. PANEL JUST CRACKED FROM ONE DAY TO THE NEXT. WENT TO TRADE IN FOR NEW EXPLORER AND DEALER EVEN COMPLAINED ABOUT DAMAGE. *TR
Structure, Dec 20, 2010
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE THE VEHICLE WAS PARKED THE CONTACT NOTICED THAT THERE WAS A CRACKED PANEL BELOW THE REAR WINDOW. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN STATED THAT THE PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 105,000. UPDATED 02/23/11 *BF THE CONSUMER STATED THE PANEL HAS SINCE BEEN REPLACED. UPDATED 04/28/11 UPDATED 06/13/11 *BF UPDATED 01/04/12 *LN
Visibility, Dec 17, 2010
WHILE PULLING OUT OF A PARKING LOT AT A SLOW SPEED THE BACK WINDOW ON MY FORD EXPLORER SPORT SHATTERED. THE GLASS WAS COMPLETELY GONE AND NUMEROUS PIECES ENDED UP INSIDE AND OUTSIDE OF THE VEHICLE. THERE WAS ABSOLUTELY NO OBJECT FROM THE OUTSIDE THAT WOULD HAVE CAUSED THIS INCIDENT. THE LIFT GATE HAD NOT BEEN OPENED PRIOR TO THIS EVENT. I BELIEVE IT WAS CAUSED BY THE HINGES AND THE MANNER IN WHICH THEY WERE DESIGNED TO ATTACH TO THE GLASS THAT TRIGGERED THIS EXPLOSION OF THE REAR WINDOW.
Power train, Wheels, Dec 16, 2010
2003 FORD EXPLORER XLS 4X4, FRONT AND REAR HUB BEARINGS GOING OUT ON A VEHICLE ESPECIALLY THE FRONT HUB BEARINGS. THE LEFT FRONT HUB BEARING WENT BAD AND LUCKILY WE WAS NOT GOING DOWN THE HIGHWAY AT 55 MPH OR HIGHER, WE WAS ONLY GOING ABOUT 25-30 MPH. THE LEFT FRONT HUB BEARING FROZE UP AND WE DID A "U" TURN AND NO ONE WAS HURT. I HAD IT TOWED TO A SERVICE SHOP AND THEY TOLD ME WHAT THE PROBLEM WAS,AND THEY TOLD ME THAT THIS IS A MAJOR PROBLEM WITH THIS TRUCK. I CONTACTED FORD ON THIS MATTER AND THEY TOLD ME I HAD TO PAY FOR THE REPAIR BY MYSELF,BUT IF THE SAME PROBLEM IS ON MANY,MANY TRUCKS THIS IS BAD AND NOT SAFE. DO YOU HAVE ANY IDEAS? THE REPAIR SHOP CALLED ME AND TOLD ME WE SHOULD REPLACE THE TWO FRONT HUBS AND THE REAR AXLE BEARINGS ALSO,AND LOOKED AT THEM AFTER THE REPAIR AND THE OTHER ONES WERE WORN EXCESSIVE ALSO. THE REPAIR WORK FOR PARTS AND LABOR WAS $1488.00 WITH A LIMITED LIFE WARRANTY ON THE PARTS. *TR