2003 Ford Explorer
Problems, recalls and owner-reported issues
Structure is the leading concern among 1,313 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Explorer model years with reports.
Of the 2003 reports, 69 involved a crash and 19 involved a fire. 66 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Representative owner complaints
1,313 reports, newest first.
Structure, Dec 16, 2010
CRACK DEVELOPED IN THE PANEL BELOW THE REAR HATCH WINDOW. *TR
Suspension, Dec 14, 2010
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT NOTICED THAT THE PASSENGER SIDE REAR COIL SPRING WAS ABNORMALLY COVERED BY AN UNKNOWN PLASTIC SHEET. THE DEALER WAS NOTIFIED AND INFORMED THE CONTACT THAT THERE WERE NO RECALLS FOR THE VEHICLE. THE CONTACT DID NOT INFORM THE MANUFACTURER OF THE FAILURE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO ADVISED THE CONTACT THAT THE REAR COIL SPRING WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 80,000 AND THE FAILURE MILEAGE WAS 78,000. UPDATED 02/03/11*LJ UPDATED 02/04/11*JB
Power train, Dec 8, 2010
O/D OFF LIGHT BLINKS ON DASHBOARD AND VEHICLE SHIFTS HARD. WAS ADVISED THAT TRANSMISSION REBUILD WAS NECESSARY. *TR
Power train, Dec 5, 2010
2003 FORD EXPLORER 5R55-W TRANSMISSION FAILURE WHEREIN THE INTERNAL LINKAGES, SERVO VALVE AND BEARINGS FAILED AT STARTUP, RENDERING THE VEHICLE UNMOVABLE UNDER IT'S OWN POWER AND STRANDING THE DRIVER. *TR
Visibility, Dec 1, 2010
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 40 MPH THE HEATER STOPPED WORKING. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE TEMPERATURE BLEND DOOR NEEDED REPLACING. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000 AND THE CURRENT MILEAGE WAS 150,000.
Structure, Nov 30, 2010
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR HATCH DOOR HAS FRACTURED UNDER THE GLASS. SHE NOTICED THE FRACTURE ONCE THE TEMPERATURE BECAME COOLER. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 75,500.
Visibility, Nov 22, 2010
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE AIR CONDITIONER FUNCTIONED BUT THE HEAT DID NOT. THE CONTACT REPLACED THE THERMOSTAT AND STATED THAT THERE WERE NO LEAKS IN THE HEATING COIL. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THE REACTOR COULD HAVE BEEN THE CAUSE OF FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 133,700.
Wheels, Nov 21, 2010
AT 110000 MILES WAS DRIVING AT HIGHWAY SPEED AND HEARD "BUMPING, RUMBLING SOUND", CAR WAS NOT HANDLING WELL, GOT OFF AT NEXT EXIT 1 MILE DOWN THE ROAD AND AS I WAS SLOWING DOWN RIGHT REAR WHEEL FELL OFF VEHICLE. HAD IT TOWED TO DEALERSHIP AND THEY NOTED THAT THE WHEEL STUDS WERE BAD AND THE WHEEL BEARING WAS BAD, REPLACED BOTH. AT 140000 MILES WAS DRIVING AT 50 MPH AND HEARD SAME SOUND, STOPPED IMMEDIATELY AND FOUND THAT LEFT FRONT WHEEL WAS LOOSE. HAD IT TOWED TO DEALERSHIP, THEY STATED THAT THEY FOUND RUST ON THE ROTORS/LUGS/WHEEL, CLEANED IT AND RETORQUED WHEELS TO 130 FT LBS, STATED THEY HAVE HAD THIS PROBLEM WITH OTHER VEHICLES!! AT 151000 HEARD SAME SOUND, I WAS DRIVING ON A SIDE ROAD AT 30 MPH, STOPPED IMMEDIATELY AND THE LEFT FRONT WHEEL WAS LOOSE AGAIN (TIRES HAD BEEN ROTATED, SO THIS IS NOT THE SAME WHEEL AS PREVIOUSLY). DEALERSHIP AGAIN CLEANED THE ROTORS/LUGS/WHEEL AND RETORQUED WHEELS TO 125 FT LBS THIS TIME AND STATED THAT WITH SOME OF THE PREVIOUS PROBLEMS THEY WERE ATTRIBUTING IT TO DELAMINATION OF A COATING ON THE ALUMINUM WHEELS, BUT THAT WE DON'T HAVE THAT KIND OF WHEEL. BY LUCK AND CAREFUL MONITORING WE HAVE NOT BEEN IN A SERIOUS ACCIDENT WITH THIS ISSUE - YET! A FRONT WHEEL FALLING OFF AT HIGHWAY SPEEDS COULD LIKELY BE DEADLY. THERE ARE REPEATED REPORTS ON THIS PROBLEM, IT IS NOT AN ISOLATED INCIDENCE. THE ONLY TIME THE WHEEL STUDS WERE SHEARED AND BEARINGS WERE BAD IS WHEN I DID NOT CATCH IT IN TIME AND THE WHEEL ACTUALLY CAME OFF, I FIRMLY BELIEVE THE ISSUE IS THE SAME THOUGH, THE WHEEL FALLING OFF IS CAUSING THE STUDS TO SHEAR AND BEARINGS TO GO.
Fuel system, Gasoline, Nov 20, 2010
I HAVE A 2003 FORD EXPLORER AND RECENTLY THE CHECK FUEL CAP LIGHT WENT ON, I HAVE CHANGE THE CAP 3 TIMES, RESET THE COMPUTER, CHECK THE CHARCOAL CANISTER, THE FUEL LINES AND ALL THE RECOMMENDATIONS ON THE USERS MANUAL BUT NOTHING SEEMS TO WORK, NOW THE SERVICE ENGINE SOON LIGHT ALSO WENT ON, I CHECKED ONLINE AND THERE IS THOUSANDS OF PEOPLE WITH THE SAME PROBLEM... NO SOLUTION FROM THE DEALER OR ONLINE YET. *TR
Suspension, Wheels, Nov 16, 2010, fire
IT STARTED WITH HUMMING VIBRATING NOISE IN THE FRONT END LEFT TIRE ENDING WITH FRONT WHEEL BEARING FAILURE AND SMALL FIRE TO THE WHEEL BEARING RUBBER BOOT AND HARD PULLING TO THE LEFT TOO DANGEROUS TO DRIVE THIS IS A MAJOR MECHANICAL FAILURE AFTER INSPECTING I FOUNT THAT ONLY THE ONE NUT WAS HOLDING TIRE ON. *TR
Power train, Nov 12, 2010
I SENT A LETTER OF COMPLAINT TO FORD REGARDING MY SITUATION WITH MY TRANSMISSION FAILING ON ME AND THE LOCAL FORD DEALER CHARGING ME $4,300 SINCE MY CAR IS NO LONGER UNDER WARRANTY. I TRULY HOPE THAT FORD GETS THEIR ACT TOGETHER AND ADDRESSES THIS ISSUES AS I'M SEEING MORE AND MORE COMPLAINTS POP-UP EVERYWHERE REGARDING THIS. POOR EXCUSE!!! DEAR VALUED CUSTOMER, THANK YOU FOR CONTACTING THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER INQUIRING FOR ANY RECALLS ON YOUR 2003 FORD EXPLORER. I SINCERELY UNDERSTAND THE FRUSTRATION THAT THIS TRANSMISSION CONCERN ON YOUR VEHICLE HAS BROUGHT YOU. PLEASE BE INFORMED THAT FORD MOTOR COMPANY IS WORKING WITH THE NATIONAL HIGHWAY TRAFFIC AND SAFETY ADMINISTRATION (NHTSA) TO PROACTIVELY IDENTIFY AREAS OF CONCERN THROUGH INVESTIGATION OF CONSUMER AND DEALERSHIP FEEDBACK. IF A CONCERN IS NOTED, A RECALL IS CONDUCTED TO REMEDY A SAFETY OR EMISSIONS CONCERN IN THE INTEREST OF CUSTOMER SATISFACTION AND ENVIRONMENTAL RESPONSIBILITY. THUS, I HAVE REVIEWED IF ANY AVAILABLE COVERAGES OR PROGRAMS MAY PROVIDE ASSISTANCE TOWARDS YOUR VEHICLE REPAIR. AFTER EXTENSIVELY REVIEWING YOUR SITUATION, I REGRET TO INFORM YOU THAT THERE ARE NO RECALLS, WARRANTIES OR OTHER COVERAGES AVAILABLE THAT MAY COVER THE REPAIR ON YOUR VEHICLE. WHILE THIS IS SO, I WOULD LIKE TO THANK YOU FOR TAKING THE TIME TO BRING YOUR CONCERN INTO OUR ATTENTION AS THIS IS DEFINITELY SOMETHING WE CAN BUILD ON. IF A PROGRAM IS ANNOUNCED ON A SPECIFIC COMPONENT AND/OR FOR THE TRANSMISSION CONCERN ON YOUR VEHICLE, FORD WILL NOTIFY YOU BY MAIL. I APPRECIATE THE FACT THAT YOU ARE A LOYAL FORD CUSTOMER AND HOPE THAT WE MIGHT HAVE THE OPPORTUNITY IN THE FUTURE TO ASSIST YOU WITH A MORE FAVORABLE RESOLUTION TO KEEP YOUR CONFIDENCE IN OUR PRODUCTS AND SERVICES. IF YOU HAVE ANY OTHER INQUIRIES AND/OR CONCERNS THAT NEED TO BE ADDRESSED, PLEASE FEEL FREE TO CONTACT US AND WE WILL BE HAPPY TO ASSIST A VALUED CUSTOMER LIKE YOURSELF. SINCERELY, CUSTOMER RELATIONSHIP CENTER *TR
Structure, Nov 9, 2010
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS A CRACK ON THE REAR LIFT GATE THAT EXTENDED ACROSS. THERE WERE ALSO THREE OTHER SMALLER CRACKS. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CONTACT STATED THAT THE REAR WINDOW LOOKED AS IF IT WOULD EXPLODE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 83,000.
Power train, Nov 3, 2010
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 30 MPH WHEN THE RPMS INCREASED UP TO 405 AND THE OVER DRIVE LIGHT ILLUMINATED AS WELL. THE CONTACT DROVE ONTO THE EMERGENCY LANE AND WAS ABLE TO RESTART THE VEHICLE IT RECURRED. THE DEALER WAS INFORMED ABOUT THE FAILURE AND THEY STATED THAT THE BANDS IN THE TRANSMISSION ARE SHOT AND WILL HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 62000 AND THE CURRENT MILEAGE WAS 62010.
Power train, Nov 3, 2010
TL*THE CONTACT OWNS A 2003 FORD FOCUS. THE VEHICLE WOULD NOT SHIFT INTO REVERSE FROM THE PARK POSITION. IN ORDER SHIFT INTO REVERSE HE HAD TO SHIFT THE VEHICLE INTO NEUTRAL AND ALLOW IT TO SLOWLY ROLL BACKWARDS. UPON DRIVING THE VEHICLE HE ALSO NOTICED THE VEHICLE WOULD NOT SHIFT INTO 6TH GEAR. A DIAGNOSTIC TEST WAS NOT PERFORMED. THE FAILURE AND CURRENT MILEAGES WERE 50,000.
Power train, Oct 25, 2010
TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING 35 MPH, THE VEHICLE SUDDENLY LOST POWER, THE CHECK ENGINE LIGHT ILLUMINATED AND THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO A TRANSMISSION SPECIALIST WHO STATED THAT THE GEAR SOLENOID NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 110,000.
Structure, Oct 23, 2010
THE BACK HATCH CRACKED ON MY 2003 FORD EXPLORER. I HEAR THIS IS A COMMON PROBLEM WITH THIS SUV. *TR
Suspension, Oct 19, 2010
MY 2003 FORD EXPLORER HAS ONLY 70,000 MILES ON IT AND THREE OUT OF THE FOUR WHEEL BEARINGS HAVE HAD TO BE REPLACED, AT A TOTAL COST OF OVER $1,100. THE MECHANIC TOLD ME THAT THIS COULD CAUSE A DANGEROUS SITUATION SUCH AS ABNORMAL TIRE WEAR OR THE WHEEL COMING OFF DURING DRIVING. THIS POTENTIALLY UNSAFE SITUATION WARRANTS A RECALL BY FORD. *TR
Wheels, Oct 19, 2010
BOTH FRONT WHEEL BEARINGS. *TR
Wheels, Oct 13, 2010
WHEEL BEARING FAILURE. *TR
Visibility, Structure, Oct 7, 2010
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED A CRACK IN THE PANEL ATTACHED TO THE GLASS OF THE REAR LIFTGAGE. THE CRACK WAS SMALL AT FIRST BUT BECAME LARGER OVER TIME. THE VEHICLE HAD NOT BEEN TAKEN TO BE INSPECTED FOR THE PROBLEM. ALSO, THE HEATED STOPPED BLOWING HEAT AND WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE BLEND DOOR ACTUATOR NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 46,000.
Structure, Latches/locks/linkages, Oct 6, 2010
IN TRYING TO DETERMINE WHERE A NEW RATTLE WAS COMING I HEARD ON THE WAY HOME, I NOTICED THE REAR GATE GLASS HINGE HAD BROKEN OR BECAME DISLODGED. WHEN TRYING TO SECURE IT TO TAKE IT TO THE DEALERSHIP FOR REPAIR, THE GLASS SLIPPED AND CUT DEEP GASHES INTO THE BODY. I HAD JUST RETURNED HOME AND HAD IT FALLEN OFF ON THE HIGHWAY IT GOOD HAVE CAUSED AN ACCIDENT. THE DEALERSHIP ATTRIBUTED IT TO WEAR AND TEAR EVEN THOUGH I HAD PREVIOUSLY ONLY OPENED THE GLASS LIFT GATE TWICE DURING THE LIFE OF THE CAR. I WAS CHARGED A FEE JUST TO REPLACE THE HINGE. I DID NOT GET HE BODY WORK REPAIRED. THERE WERE RECALLS FOR THIS PROBLEM ON OTHER EXPLORER'S MADE DURING THE SAME PERIOD MINE WAS MADE, BUT I WAS TOLD MY VIN WAS NOT INVOLVED IN THE RECALL. (FORD RECALL NO. 04S20 AND A CAMPAIGN NUMBER 04V442000 AND SAFETY REPORT #10266375 AND #10266836). *TR
Structure, Oct 4, 2010
PLEASE BE ADVISED THAT THE HATCH BACK OF THE 2003 FORD EXPLORER DEVELOPED A CRACK DIRECTLY IN THE MIDDLE. THIS DEFECT CAN BE SEEN AROUND MANY OTHER 2003 FORDS. PLEASE BE ADVISED THAT THE HATCHBACK PIECE IS RATTLING AND SEEMS LIKE IT WILL COME OFF. *TR
Power train, Sep 28, 2010
TL* THE CONTACT OWNS A 2003 FORD EXPLORER XLT (N/A). WHILE DRIVING THE OVER DRIVE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE THE MECHANIC LOCATED THE FAILURE AT THE TRANSMISSION SOLENOID. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED THAT THERE WERE NO RELATED RECALLS. THE CONTACT PLANNED TO HAVE THE VEHICLE REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 153,000 THE CURRENT MILEAGE WAS APPROXIMATELY 153,300.
Engine and engine cooling, Power train, Electrical system, Latches/locks/linkages, Other or unspecified, Sep 27, 2010
THERE HAVE BEEN MULTIPLE PROBLEMS WITH MY 2003 FORD EXPLORER SINCE I BOUGHT IT BRAND NEW IN AUGUST OF 2003. BUT IRONICALLY THEY HAVE ALL APPEARED AFTER THE WARRANTY HAD EXPIRED. IN SEPTEMBER 2007 THE AIR CONDITIONING UNIT NO LONGER WORKED. IT COST ME $2000 AND A WEEK WITHOUT A CAR, TO GET IT FIXED. IN AUGUST 2009 THE PASSENGER DOOR WINDOW WOULD NO LONGER WORK. IN SEPTEMBER 2009 MY SUV STARTED MAKING A CLICKING SOUND WHEN TURNING ON THE HEATER. SINCE WE LIVED IN A WARM CLIMATE THIS DID NOT CONCERN US MUCH, AS THE HEAT HAD WORKED EVEN WITH THE CLICKING SOUND. BUT WE MOVED TO A COLDER CLIMATE AND THE HEATER WENT OUT IN MARCH 2010. IN APRIL 2010 THE SERVICE ENGINE LIGHT CAME ON. AFTER SPEAKING WITH THE MECHANIC, HE SAID IT WAS A TRANSMISSION PROBLEM THAT OCCURRED WHEN THE CAR SHIFTED FROM 1ST TO 2ND GEAR AND FROM 4TH TO 5TH GEAR. HE COULD NOT GIVE ME ANY MORE INFORMATION AND WAS NOT WILLING TO FIX MY TRANSMISSION PROBLEM (HE SUGGESTED I GO ELSEWHERE BECAUSE HE WAS NOT AN EXPERT IN TRANSMISSIONS). IN MAY 2010 THE O/D LIGHT STARTED FLASHING OFF. AFTER SPEAKING TO MECHANIC AGAIN, HE SAID IT WAS RELATED TO THE TRANSMISSION PROBLEM. IN AUGUST 2010 THE DOOR AJAR LIGHT STARTED COMING ON RANDOMLY, EVEN WHEN THE DOOR IS NOT OPEN. AND IN SEPTEMBER 2010, I NOTICED MY ABS LIGHT WILL COME ON RANDOMLY. IT DOES NOT APPEAR TO BE TRIGGERED BY ANY SPECIFIC REASON, AND DOES NOT ALWAYS COME ON. *TR
Wheels, Sep 26, 2010
ABS LIGHT ON,SECOND WHEEL BEARING NEEDS REPLACED. *TR