2003 Ford Explorer
Problems, recalls and owner-reported issues
Structure is the leading concern among 1,313 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Explorer model years with reports.
Of the 2003 reports, 69 involved a crash and 19 involved a fire. 66 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Representative owner complaints
1,313 reports, newest first.
Air bags, Aug 19, 2016, crash
TL* THE CONTACT OWNED A 2003 FORD EXPLORER. WHILE DRIVING AT AN UNKNOWN RATE OF SPEED ON A HIGHWAY, THE CONTACT WAS INVOLVED IN A HEAD ON COLLISION WITH ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE OTHER VEHICLE ROLLED OVER AND THE CONTACT'S VEHICLE STOPPED AT THE MEDIAN. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED A MILD CONCUSSION, A BRUISED STERNUM, BACK AND NECK PAINS. THE CONTACT RECEIVED MEDICAL TREATMENT. THE VEHICLE WAS TOWED TO A YARD AND DESTROYED. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER OR MECHANIC. THE APPROXIMATE FAILURE MILEAGE WAS 319,000.
Power train, Air bags, Other or unspecified, Aug 14, 2016
"TAKATA RECALL"I BROUGHT THE TRUCK AND THE AIRBAG LIGHT WAS FLASHING 4X4 LIGHTS FLASHING ALSO, SMELLING OIL COMING FROM THE DEFERENTIAL ON THE BACK AXLE. NOW, THE TRANSMISSION STARTED SLIPPING AND HE CHANGED A PART . THEN, THE TRANSMISSION STARTED TO SLIP AGAIN. ALSO,I WANTED TO SWITCH TO ANOTHER VEHICLE BUT HE DECLINED IT . HE SAID " HE PUT TO MUCH WORK INTO THE TRUCK AND ALL THE PARTS ARE NEW IN WHICH ONLY THE TIRES AND MUFFLER WAS REVOLVED ".
Structure, Jul 25, 2016
THE REAR LIFT-GATE HAS A CRACKED PANEL.
Visibility, Structure, Jul 20, 2016
TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. WHILE DRIVING APPROXIMATELY 25 MPH, A NOISE EMERGED FROM THE REAR HATCH WINDOW. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND NOTICED THAT THE PIECE THAT HELD THE WINDOW IN PLACE WAS FRACTURED. THE VEHICLE WAS REPAIRED FOR THE SAME FAILURE IN MARCH OF 2015. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 159,149.
Power train, Electrical system, Electronic stability control (ESC), Jul 19, 2016
MY TRANSMISSION LIGHT HAS BEEN COMING ON. I WAS ONLY AT 117K MILES WHEN IT HAPPENED. THAT'S TO SOON FOR A TRANSMISSION TO BE ACTING UP ESPECIALLY SINCE IT'S ANEW ONE ACCORDING TO CARFAX THIS IS THE SECOND TRANSMISSION FOR MY EXPLORER. THE FIRST ONE WAS PUT IN ONLY AT 3 YEARS OLD. IT WILL SOMETIMES JERK INTO REVERSE OR TAKE A SECOND TO GO INTO DRIVE WHEN I SWITCH GEARS. MY OVERDRIVE LIGHT ALSO FLASHES WHICH I ASSUME MEANS MY OVERDRIVE NO LONGER WORKS. THE LIGHT ONLY COMES ON AFTER DRIVING OVER 40 MPH. SO IF I'M ON THE HIGHWAY I CAN'T GO THE SPEED LIMIT BECAUSE I DON'T WANT THIS LIGHT COMING ON. I TOOK IT TO A TRANSMISSION SHOP IT NEEDS A TORQUE CONVERTER AND A REBUILD. I CONTACTED FORD AND THEY WON'T DO ANYTHING ABOUT IT. THEY TOLD ME TO BUY A NEW CAR. WHEN I GO UP HILLS MY EXPLORER ALSO HAS TROUBLE EVEN THOUGH IT SHOULDN'T. I ALSO NEED A NEW SOLENOID PACK.
Air bags, Jul 13, 2016, crash
TL* THE CONTACT OWNED A 2003 FORD EXPLORER. WHILE DRIVING 35 MPH, ANOTHER VEHICLE CRASHED INTO THE FRONT END OF THE CONTACT'S VEHICLE. THE FRONT DRIVER SIDE AIR BAG FAILED TO DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE HEAD, BACK, AND KNEES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 95,404. UPDATED 09/27/16*LJ *JS
Service brakes, Engine, Jun 22, 2016
2003 FORD EXPLORER, WHILE DRIVING THROUGH TOWN I STARTED TO SLOW DOWN FOR A GROUP OF KIDS WAITING TO USE A CROSS WALK WHEN THE EXPLORER SHUT DOWN & LOST ALL POWER TO CONTROL BRAKES AND STEERING ALMOST HITTING THE KIDS.. I HAVE TAKEN TO A SHOP & WAS TOLD THEY COULD NOT DUPLICATE THE ISSUES I HAVE BEEN HAVING FOR 5 YEARS. THE REASON I AM NOW REPORTING THIS IS BECAUSE THE CLOSE CALL I JUST HAD WITH THE CROSS WALK. THIS PROBLEM STARTS AFTER ABOUT 5 OR 10 MINUTES OF RUN TIME THEN CLEARS UP NOT RETURNING UNTIL NEXT RUN OR SOME TIME LATER...
Air bags, Jun 15, 2016, crash
I LOST CONTROL AROUND A BEN GOING 35MPH AFTER IT GOT DONE RAINING AND GOT IN AN ACCIDENT HIT A TELEPHONE POLE AND FARM POST AFTER SPINNING ABOUT 4XS CAR IS TOTALED AIR BAGS NEVER WENT OFF
Visibility, May 23, 2016
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE HINGES ON THE REAR WINDSHIELD WERE LOOSE AND THE REAR WINDOW WAS NOT PROPERLY SECURED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Visibility/wiper, May 20, 2016
I HAD JUST PUT A BAG OF GROCERIES IN THE BACK, WAS CLOSING THE REAR GLASS HATCH WHEN IT EXPLODED ABOUT 1/3 OF THE WAY DOWN. VERY LOUD NOISE, AND TINY GLASS PIECES SHATTERED ACROSS 3 PARKING SPOTS, INTO AND ALL AROUND OUR VEHICLE, INCLUDING THE GROCERIES WHICH I DISCARDED. THIS CAR IS NOT INCLUDED IN THE RECALL.
Structure, May 13, 2016
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR LIFT GATE HINGE FRACTURED WHICH CAUSED THE LIFT GATE TO REMAIN UNLOCKED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.
Structure, Apr 14, 2016
I HAVE OWNED THIS 2003 FORD EXPLORER SINCE IT WAS BRAND NEW IN 2003. IT CURRENTLY HAS 70,009 MILES AND HAS BEEN KEPT IN A GARAGE AND NOT DRIVEN OFTEN OVER 13 YEARS. WITHIN TWO YEARS OF PURCHASING THIS VEHICLE I NOTICED A CRACK IN THE MIDDLE OF THE LIFT GATE UNDER THE GLASS. I TALKED TO TWO FORD DEALERSHIPS THAT ADVISED IT WAS NOT A DEFECT BUT MY FAULT FOR GLIDING THE GLASS TO HARSHLY. I HAD NOT USED THE GLASS OFTEN AND HAD NEVER SLAMMED IT.M SINCE THAT TIME I'VE SEEN HUNDREDS OF FORD EXPLORERS FROM THE EARLY TO MID 2000S WITH THE SAME CRACK IN THE SAME LOCATION. TODAY I WAS BEHIND FOUR DIFFERENT EXPLORERS FROM THE SAME TIME PERIOD AND ALL HAD THE SAME CRACK. I CHECKED ONLINE AND REALIZED THERE ARE THOUSANDS OF COMPLAINTS ABOUT THIS DEFECT WITH SOME DRIVERS STATING THE BACK GLASS BURSTS WHILE THEY WERE DRIVING. IT IS UNBELIEVABLE THAT WITH SO MANY OF THESE VEHICLES HAVING THE EXACT SAME ISSUE THAT FORD HAS NOT OWNED UP TO THE DEFECT AND REPAIRED IT. ALL ONE NEEDS TO DO IS SEARCH THROUGH ONLINE IMAGES TO SEE IT US A HUGE PROBLEM AND A DEFINITE MANUFACTURER DEFECT AND WITH THE BACK GLASS BLOWING OUT IT IS A MAJOR SAFETY CONCERN.
Power train, Electrical system, Mar 30, 2016
WHILE DRIVING HOME FROM WORK THIS EVENING THE O/D OFF LIGHT BEGAN STEADILY BLINKING AND THE TRANSMISSION TOOK WAY TOO LONG TO SHIFT (RPM ALMOST RED LINE) AND WOULDN'T SHIFT INTO 5TH GEAR. I WAS DRIVING ON A CITY STREET AND FIRST NOTICED THE TRUCK NOT SHIFTING AND WITHIN 3 MINUTES OF DRIVING THE O/D OFF LIGHT BEGAN FLASHING. IF YOU TURN THE TRUCK OFF THEN BACK ON THE O/D OFF LIGHT TURNS OFF BUT THE TRUCK STILL WON'T SHIFT CORRECTLY AND THE LIGHT STARTS TO BLINK AGAIN. MY TRUCK ONLY HAS 133,000 MILES. I GOOGLED THIS PROBLEM AND DISCOVERED THAT THE VAST MAJORITY OF 2003 FORD EXPLORER OWNERS HAVE THIS SAME PROBLEM.
Tires, Feb 26, 2016
CONTINENTAL CONTITRAC P235/70R16 DOT A308 46KW 311 NOTICED VIBRATION WHILE DRIVING, TIRE TREAD WAS SEPARATING; INSTALLED SPARE. HAD VIBRATION AGAIN A MONTH LATER. BOTH TIRES HAD TREAD SEPARATION. INSTALLED IN 2013; APPROX 20K MILES. REPLACED ALL 4 TIRES; HAVE OLD TIRES.
Power train, Feb 24, 2016
WHILE DRIVING HOME FROM WORK THIS EVENING THE O/D OFF LIGHT BEGAN STEADILY BLINKING AND THE TRANSMISSION TOOK WAY TOO LONG TO SHIFT (RPM ALMOST RED LINE) AND WOULDN'T SHIFT INTO 5TH GEAR. I WAS DRIVING ON A CITY STREET AND FIRST NOTICED THE TRUCK NOT SHIFTING AND WITHIN 3 MINUTES OF DRIVING THE O/D OFF LIGHT BEGAN FLASHING. IF YOU TURN THE TRUCK OFF THEN BACK ON THE O/D OFF LIGHT TURNS OFF BUT THE TRUCK STILL WON'T SHIFT CORRECTLY AND THE LIGHT STARTS TO BLINK AGAIN. MY TRUCK ONLY HAS 133,000 MILES. I GOOGLED THIS PROBLEM AND DISCOVERED THAT THE VAST MAJORITY OF 2003 FORD EXPLORER OWNERS HAVE THIS SAME PROBLEM.
Electrical system, Structure, Feb 24, 2016
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE DOOR AJAR WARNING LIGHT ILLUMINATED, WHICH CAUSED THE DOME LIGHT TO REMAIN ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 188,000.
Air bags, Other or unspecified, Service brakes, Feb 15, 2016
I WAS DRIVING IN MINUS 20 DEGREE CELSIUS TO TAKE HIGHWAY 15 NORTH FROM JUST AFTER PANAMA BUS STATION. IN THE ENTRANCE, MY CAR START TO SLOW DOWN TO THE 5 KMPH. IN THE BACK OF MY CARS WERE ALL ON THEIR HAZARD LIGHT AND BEING MAD AT ME. SO I DRIVE BACK TO MY HOME TAKING THE NEXT EXIT. I WISH SOMEBODY COULD TAKE THE VIDEOS AND SENT TO THE FORD COMPANY TO LET THEM KNOW MY SITUATION.
Other or unspecified, Feb 12, 2016
2003 FORD EXPLORER SHUTS DOWN WHILE DRIVING. I LOSE BRAKING AND STEERING ABILITY. IT CAN HAPPEN AT ANY TIME. IT HAS HAPPENED SEVERAL TIMES . TODAY 12 FEB. 2016 IS THE LATEST DATE.
Power train, Engine, Jan 19, 2016
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING ON AN INCLINE AT AN UNKNOWN SPEED, THE VEHICLE FAILED TO ACCELERATE AND THE OVERDRIVE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO ANOTHER INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SOLENOID PACK AND THE OXYGEN SENSORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT ALSO MENTIONED THAT THE CHECK TRANSMISSION AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000. THE VIN WAS NOT AVAILABLE.
Other or unspecified, Jan 19, 2016
CRACKED PANEL BELOW THE REAR WINDOW
Power train, Electrical system, Dec 5, 2015
I BOUGHT MY FORD EXPLORER XLT BACK IN JUNE OF 2015. SINCE THEN I REPLACED MY OXYGEN SENSOR DO TO A FAULT IN THE SYSTEM AND MELTING BACK IN AUG. 20015. THE SUV WOULDN'T START BECAUSE OF IT AND HAD TO BE TOWED. SINCE I PURCHASED AND HAD REPLACED THE OXYGEN SENSOR BY A FORD DEALER, I NOTICED THE SUV HAVING POWER FAILURE EVEN FROM A COMPLETE STOP AND NOW THE OVER DRIVE OFF LIGHT FLASHES; THIS STARTED IN THE BEGINNING OF NOV. 2015 I NOTICED THAT THERE IS OVER 2755 COMPLAINTS OF TRANSMISSION PROBLEMS AND FAILURES EXACTLY THE SAME AS MINE, BUT NOT ONE RECALL. THIS IS A ISSUE WITH THE SUV THEMSELVES AND NOT OWNER ERROR. I HAVE CHILDREN AND DON'T WANT TO END UP STRANDED IN THE STREET OR SIDE OF THE HIGHWAY DUE TO TRANSMISSION FAILURE. THERE HAS TO BE SOMETHING CAUSING THE TRANSMISSION TO BREAK DOWN OR FAIL AND I REFUSE TO BE THE THE BLAME NOR PAY THOUSANDS TO FORD DEALERSHIP TO FIX A FLAW IN THERE OWN SUV. A RECALL NEEDS TO BE MADE FOR THIS PROBLEM AND IT IS CLEARLY A MANUFACTURE FLAW.
Other or unspecified, Nov 27, 2015, fire
VEHICLE WAS PARKED(ENGINE COLD) ON RESIDENTIAL STREET,ALARM SOUNDED,UPON OPENING HOOD DISCOVERED FLAMES, PUT OUT IMMEDIATELY WITH EXTINGUISHER, CAR WILL NOT RUN AND THERE APPEARS TO BE EXTENSIVE DAMAGE ESPECIALLY ON RIGHT SIDE.
Air bags, Nov 18, 2015, crash
TL* THE CONTACT OWNED A 2003 FORD EXPLORER. WHILE DRIVING AT 50 MPH, THE FRONT AND REAR DRIVER SIDE TIRES BLEW OUT, WHICH CAUSED THE VEHICLE TO FLIP OVER SEVERAL TIMES. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUFFERED INJURIES TO THE LOWER BACK, ARM, AND KNEES. THE PASSENGER SUFFERED AN INFLAMMATION OF THE LOWER BACK. THE DRIVER AND PASSENGER BOTH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT FACILITY. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Power train, Structure, Electronic stability control (ESC), Nov 18, 2015
1. TRANSMISSION DOES NOT LET YOU ACCELARATE. PRESSURE BUILDS UP WHILE YOU ARE PRESSING ON THE GAS PEDAL AND IT DOESN'T INCREASE YOUR SPEED UNTIL 10 SECONDS OR SO OF PRESSING THE GAS PEDAL, AND THAN IT EXPLODES AND YOU ARE THRUST BACK WITH THE ACCELERATION. VERY DANGEROUS WHEN YOU ARE TRYING TO CHANGE LANES OR ARE ENTERING THE HIGHWAY. LACK OF ACCELERATION HAS ALMOST GOT US INTO A FEW ACCIDENTS. 2. SENSORS ARE NOT FUNCTIONING, CONSTANTLY TELLING ME THAT THE DOORS ARE OPEN. I DON'T KNOW WHEN A DOOR IS ACTUALLY OPEN OR NOT. 3. THE REAR HATCH IS CRACKED AND I'M AFRAID IT DOESN'T PROVIDE ENOUGH STABLE PRORECTECTION FOR THE REAR GLASS TO BE HELD IN PLACE PROPERPLY.
Service brakes, Nov 13, 2015
THE REAR AIR CONDITIONER LINE RUBBED AGAINST THE BRAKE LINE CAUSING BRAKE LINE FAILURE. THE RUPTURE OCCURRED DURING AN ATTEMPT TO SUDDENLY STOP. THERE WERE NO SIGNS OF RUST EITHER INSIDE OR OUTSIDE THE BRAKE LINE. THE FAILURE OCCURRED AT ABOUT 156,000 MILES ON THE VEHICLE. ODDLY ENOUGH, THE MECHANIC SPECIFICALLY NOTED THAT RUST WAS NOT A FACTOR IN THIS CASE AS IS COMMON ON MANY NEWER VEHICLES. I HAVE OWNED THE VEHICLE SINCE 3/7/2006. NO COLLISION WORK HAS BEEN PERFORMED ON THE VEHICLE SINCE TAKING OWNERSHIP.